On several occasions I have unintentionally pressed the accelerator pedal in addition to pressing the brake pedal. The brake pedal is 2 inches "higher" (closer to the driver) than the accelerator pedal in its full up position. When attempting to quickly place my foot on top of the brake pedal from the accelerator pedal, my foot …
Read full complaint
On several occasions I have unintentionally pressed the accelerator pedal in addition to pressing the brake pedal. The brake pedal is 2 inches "higher" (closer to the driver) than the accelerator pedal in its full up position. When attempting to quickly place my foot on top of the brake pedal from the accelerator pedal, my foot hits the side of the brake pedal. This issue has resulted in several near-hit accidents with a vehicle in front of me. The rapid acceleration of the Ford Lightning reduces response time to correct the braking disruption. The brake pedal may be placed higher to prevent the driver from also depressing the accelerator when depressing the brake. Other vehicles also have a higher brake pedal, but it feels like an unusually high foot lift is required in the Lightning. There is definitely something unusual about the brake and accelerator geometry in my Ford Lightning.
NHTSA ODI #11565294
Mileage unknown · Jul 24, 2023
Electrical SystemService BrakesVehicle Speed Control
Unintended acceleration / rolling may occur when vehicle is remote started through Fordpass mobile application. The 1 pedal-drive vehicle setting is NOT preserved when using remote start. Vehicle may roll down hill upon entry. Default driver profile has 1 pedal drive OFF while all device profiles linked to Fordpass and Phone-as-…
Read full complaint
Unintended acceleration / rolling may occur when vehicle is remote started through Fordpass mobile application. The 1 pedal-drive vehicle setting is NOT preserved when using remote start. Vehicle may roll down hill upon entry. Default driver profile has 1 pedal drive OFF while all device profiles linked to Fordpass and Phone-as-a-Key have 1 pedal drive ON. Fordpass mobile app remote start needs to preserve 1 pedal drive setting due to potential unintended acceleration when on flat surfaces or unintended reverse acceleration rolling down hills.
Ford Motor Company (Ford) is recalling certain 2022-2026 F-150 Lightning BEV, 2024-2026 Mustang Mach-E, and 2025-2026 Maverick vehicles. The integrated park module may fail to lock into the park position when the driver shifts into park. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: A loss of park function can allow the vehicle to rollaway, increasing the risk of a crash.
Remedy: The park module software will be updated over-the-air (OTA) or by a dealer, free of charge. Owner notification letters were mailed February 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C69. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning January 26, 2026.
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning BEV vehicles previously repaired under recall number 23V418. The rear lightbar may have microcracks in the outer lens that allows moisture to accumulate, which can result in inoperative or flickering reverse lights.
Consequence & remedy
Consequence: Inoperative or flickering reverse lights may not alert other driver's that the vehicle is reversing, increasing the risk of injury or crash.
Remedy: Dealers will inspect and replace the rear lightbar and fasteners as necessary, free of charge. Owner notification letters were mailed June 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB6. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 29, 2025.
Ford Motor Company (Ford) is recalling certain 2022 F-150 Lightning BEV vehicles equipped with 20" or 22" all season tires that were repaired incorrectly under recall 22V-453. The tire pressure monitoring system (TPMS) light may not illuminate as intended, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: Low tire pressure can lead to poor vehicle handling and a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will update the body control module (BCM) software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C20.
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning vehicles previously repaired incorrectly under recall number 23V801. The SYNC software may fail to activate the electronic stability control (ESC) system at the beginning of each ignition cycle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Failure to reset the ESC to active may result in the driver unknowingly operating the vehicle without electronic stability control, increasing the risk of a crash.
Remedy: Dealers will update the Accessory Protocol Interface Module (APIM) software, free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C15.
Ford Motor Company (Ford) is recalling certain 2023 F-150 Lightning vehicles. The fasteners that secure the junction box bus bars inside the high-voltage battery pack may not have been tightened securely, which can cause electrical arcing at the busbars.
Consequence & remedy
Consequence: Electrical arcing increases the risk of a fire. In addition, a loss of drive power may occur, which can increase the risk of a crash.
Remedy: Dealers will inspect and repair the busbar fasteners and replace any damaged components as necessary, free of charge. Owner notification letters were mailed on May 21, 2025. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 24S11. This recall expands previous recall number 24V-144.
Ford Motor Company (Ford) is recalling certain 2022-2024 F-150 Lightning battery electric vehicles. A manufacturing defect in the high voltage battery cells may result in an internal short circuit.
Consequence & remedy
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Owners are advised to only charge their vehicles to a maximum of 80% battery capacity until the repair has been completed. Dealers will inspect and replace the high voltage battery array as necessary, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S18.
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 Lightning vehicles. The SYNC software may fail to activate the electronic stability control (ESC) system at the beginning of each ignition cycle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 126, "Electronic Stability Control Systems."
Consequence & remedy
Consequence: Failure to reset the ESC to active may result in the driver unknowingly operating the vehicle without electronic stability control, increasing the risk of a crash.
Remedy: The Accessory Protocol Interface Module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed December 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C38.
Ford Motor Company (Ford) is recalling certain 2022-2023 F-150 BEV vehicles. The rear lightbar may have microcracks in the outer lens that allows moisture to accumulate, which can result in inoperative or flickering reverse lights.
Consequence & remedy
Consequence: Inoperative or flickering reverse lights may not alert other driver's that the vehicle is reversing, increasing the risk of injury or crash.
Remedy: Dealers will replace the rear lightbar, free of charge. Owner notification letters were mailed October 9, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S30.
Ford Motor Company (Ford) is recalling certain 2022 F-150 BEV vehicles equipped with 20" or 22" all season tires. The tire pressure monitoring system (TPMS) light may not illuminate as intended, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: Low tire pressure can lead to poor vehicle handling and a loss of vehicle control, increasing the risk of a crash.
Remedy: The body control module (BCM) software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed July 20, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C15.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2022 Ford F-150 Lightning Bev Problems, Complaints & Recalls | Skip That Year
Illustration