2022 Ford F-150 Lightning Bev

Extreme corrosion on connector for headlamp assembly and front camera. Also, extreme corrosion on connector that powers lightbar. Ford denied warranty claim by considering it a lamp issue even though lamp was good. The lightbar and connector w/ corrosion are one single part. Corrosion was so bad multiple pins had rusted off. This could cause electrical short and potential fire risk.

VIN: [XXX] NHTSA recall number: 23V41800 Manufacturer recall number: 23S30 My car has a current NHTSA, I have scheduled over 5 appointments to have Ford address the reverse lightbar replaced. And all 5 appointments have been unsuccessful at replacing the light since [XXX]. It is now October 2024, over 17 months since the NHTSA recall from June 2023. As of the date of this letter, my next appointment is schedule for [XXX], once again I called Colonial Ford dealership in Plymouth, Massachusetts to confirm my lightbar is available and the service advisor told me it is not in stock, and rescheduled me to [XXX]. This letter pursues, after several failed appointment and long wait times waiting to hear the part is on backorder for the last year. I am attaching proof all appointments and phone calls, and email notices of scheduled appointments, but were unsuccessful since the part is not in at the dealership. Over the course of the last year, I have called monthly and after receiving email and recall notices, and to no avail, each time I am told the part is on backorder and to call back. I continue to have problems with my taillight flickering, and problems with my reverse light for the last six months, recently a few weeks ago, I was given a warning by Plymouth Police Department in Massachusetts. I explained and showed proof of the recall. I have patiently waited since I keep thinking it will be here next month, well it is now almost 1.5 years later and the part is still on “backorder”. Patiently waiting is now a safety issue. I have explained to the service advisor that my car detects an accident collision because of the faulty light and Ford has failed to promptly address and replace the tail light. Please see Ford attached invoices addressing the Collision Detection malfunctioning from November 2023. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V418000 (Exterior Lighting) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the tailgate light bar had failed to illuminate. The dealer was contacted. The manufacturer was made aware of the issue. The failure mileage was 28,000. Parts distribution disconnect.

Campaign/NHTSA# 23S30/23V418 Issue Date 2023-06-09 Description On your vehicle, it may be possible that your reversing lamps may not function due to microscopic cracks that can develop in the vehicles rear lightbar. If a microscopic crack is present, condensation can potentially enter the reversing lamp lens through these cracks and cause electrical failure to the reverse lamps. Safety Risk This may result in inoperative reverse lamps which can reduce the awareness of other motorists or road users of the drivers intention to operate the vehicle in reverse gear, increasing the risk of injury or crash. Remedy Ford Motor Company has authorized your dealer to replace the rear lightbar free of charge parts and labor. Campaign/NHTSA# 23C38/23V801 Issue Date 2023-11-28 Description Affected vehicles may have software logic that does not reset the electronic stability control esc system to default operation at the initiation of each ignition cycle. Section 5.4.1 of fmvss no. 126 requires that the vehicles esc system return to the manufacturers original default esc mode at the initiation of each ignition cycle Safety Risk The vehicle operator may not notice that the vehicle operates differently after receiving the ota update 6.3.0 and now remains in off-road mode with a reduced esc state after cycling the ignition. If the vehicle operator does not notice the esc off telltale in the cluster, they may not know the vehicle is in a reduced esc state. For these vehicles, failing to revert back to a normal esc-on state after being in off-road mode makes the vehicles noncompliant to fmvss no. 126, increasing the risk of crash. Remedy The remedy for this program is a software update to accessory protocol interface module apim. Ford began Ford power-up over-the-air deployments to update the apim software for affected vehicles in November 2023. Alternatively, owners will have the option to take their vehicle to a Ford or Lincoln dealer to complete the software update. Campaign# 23B1

Front driver side turn signal fails to signal randomly. From the instrument panel, I see the turn signal flashing 2x as fast like the bulb is out and it appears the amber light isn't flashing in the headlight. This continues for the entire duration of the drive, but the next several drive it works OK. Drivers can't see which way I'm turning when it's failed.