2022 Ford F-150 Lightning Bev

This is a problem from an old recall. The rear tail gate light was recalled and replace because it was leaking in Jan 2024. The exact same problem has happened again in March 2025. Ford refuses to replace the defective part. After research in forums online I have noticed many other people having the same issue. This is a safety issue as it is part of the exterior lighitng system. It is either completely off or will be flashing making it difficult for other drivers to see me. Another safety issue, it made the backup camera inoperable I did have to have the light replace at considerable cost so it is no longer available. I did ask the dealer to save the light for me and they did not. There was no warning messages on the vehicle computer system

The rear light bar and reversing lamp assembly, which was part of a safety recall, is filled with water and the lights are malfunctioning again. Ford is telling me that the replacement part has a 1 year warranty so that I would have to pay over $1600 for a replacement. This is a widespread issue with many of these trucks. Ford admitted that it was a manufacturing defect with the original part. However, the replacement part has the same issue so it is my belief that Ford has not fulfilled their duty to adequately repair an obvious safety issue and should be held responsible for the replacement of this part at no cost to the vehicle owner.

This letter serves as formal notification of a persistent and unresolvable defect in my 2022 Ford F-150 Lightning. The defect concerns the tailgate light, which continues to leak water despite multiple repair attempts. I purchased/leased this vehicle on [XXX] from Galpin Ford on 15505 Roscoe Blvd, North Hills, CA 91343. The vehicle is currently under the original manufacturer's warranty. The tailgate light has exhibited a recurring issue of water intrusion, leading to condensation, malfunction, potential for electrical damage. This problem significantly impairs the vehicle's safety due to Inoperative reverse lamps. This may reduce the awareness of other motorists or road users of the driver’s intention to operate the vehicle in reverse gear, increasing the risk of injury or crash. It has also in the past caused electrical shorting that caused other lamps to fail, potentially resulting in the risk of injury or crash due to failed communication with other drivers. The following repair attempts have been made to address this defect, once under the recall: 1. March 14, 2023: Autonation Ford performed the repair for the first time. 2. March 18, 2024: Autonation Ford performed the repair for the second time. 3. March 24, 2025: Autonation Ford performed the repair for the third time. Despite these attempts, the defect persists. I have also become aware that numerous other Ford F-150 Lightning owners across the country are experiencing the same or a similar tailgate light issue. This is evidenced by discussions on the Ford Lightning Owners Forum, reports on social media platforms such as Facebook. This widespread problem indicates a potential design or manufacturing defect that Ford has failed to adequately address. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Rear tail light/bar was recalled a couple of years ago for small micro cracks that water got in. My truck tail light had water in it and was replaced under recall. Less than 2 years later it has happened again. Ford denied covering it under warranty per the dealer who replaced it originally. . Others have posted that their tail light has failed and the leds stay on. Mine as far as I know, has not failed yet. No warning lamps. I feel ford should replace it again since they have had it recalled previously.

Under recall 23S30 in 2023 my rear light bar assembly which included brake light, back up camera, and white reverse lights for illumination the area behind the vehicle when backing up. There was a new rear lightbar part issued as part of that recall. After almost 2 years the same issue has occurred again to my vehicle. I'm concerned the new part # has not resolved this original issue and a new recall needs to be put in place.

My truck was "repaired" for recall 23S30. The light bar gets microcracks that leet water in and short out the lights. The "repair" was to replace the light bar with another light bar that does the exact same thing. It lasted just over a year before it went out. It didn't even last as long as the original that was recalled and replaced

The contact owns a 2022 Ford F-150. The contact stated that while driving at an undisclosed speed, the rear light bar was flickering intermittently. The vehicle was taken to the dealer; however, the failure could not be duplicated. The contact stated that the failure persisted. The contact stated that the failure had occurred increasingly, and the vehicle was taken back to the dealer, where it was diagnosed that microscopic cracks in the light bar had caused water intrusion, causing the rear light bar to fail. The dealer determined that the rear light bar needed to be replaced. The dealer informed the contact that the light bar needed to be replaced prior to performing an unknown recall repair. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under Ford Campaign Number: 23S30. The failure mileage was 12,550.

The rear light bar was replace a year or so ago by a recall from Ford due to manufacturing defect that cause water to be trapped within the light bar and LEDs will short out. A few months back, the water has returned within the light bar and causing the LED's to short out just like before. Since the lightbar holds the back up light, with LED shorting out the other drivers will not be able to notice the truck is in Reverse mode which I get a few near misses. The factory recall did not fix the water in the light bar issue.

Moisture entered the rear light bar and caused the reverse / back-up lights to fail. Reverse / back-up lights do not work and thus do not illuminate the area behind the truck when backing up. The rear camera does not provide a usable image when the reverse / back-up lights do not illuminate the area behind the truck. The rear light bar was previously replaced about 9/15/2023 under Ford Recall 23S30 for the same issue. The replacement light bar suffers from the same moisture intrusion issue as the original light bar, so the original safety issue has not been resolved.