COMPONENT SPOTLIGHT

Ford Explorer electrical problems

2,242 distinct owner reports with an electrical-system component in this snapshot.

Includes the electrical-system component and its detailed subcategories. Related recalls and investigations must also name this component; they are not linked by narrative keyword alone.

44 crash reports312 fire reports36 injury reports

Reports by model year

Recall and investigation columns show each year’s full history. A report naming several years can appear in more than one row.

When problems were reported

Mileage at the reported incident

246

0–25K

179

25–50K

194

50–75K

154

75–100K

198

100–150K

123

150K+

1,094 reports with mileage · 1,148 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What owners actually said

2,242 reports

1999 model year · Mileage unknown · Dec 1, 2003

Electrical SystemEngine And Engine CoolingSuspension

Read full complaint

SEVERAL PROBLEMS WITH 1999 FORD EXPLORER EDDIE BAUER EDITION. *MR WHEN THE VEHICLE WAS TURNED RIGHT, THE WINDSHIELD WIPERS WOULD COME ON, THE RIGHT REAR TIRE HAD BLOWN, THERE WAS A WHINE NOISE, A LEAKING ON THE GARAGE FLOOR ALONG WITH A BURNING SMELL WHEN THE VEHICLE WAS SHUTOFF, IT WAS DISCOVERED THE FRONT AXLE SEAL NEEDED TO BE REPLACED. CHECK ENGINE LIGHT HAD COME ON AND THE HEAT GAUGE SHOWED HOT, THE DEALER DETERMINED IT WAS THE THERMOSTAT. THE ENGINE SURGED, THE LIGHT EMITTING THE DISPLAY HAD GONE OUT, THERE WAS A PROBLEM WITH THE RIGHT FRONT HUB ASSEMBLY/AXLE SEAL. *SCC *JB

NHTSA ODI #10049869

1991 model year · 100,000 miles · Nov 7, 2003

Electrical SystemFire

AFTER FILLING THE FUEL TANK VEHICLE CAUGHT ON FIRE FROM UNDER THE HOOD WHILE DRIVING 40 MPH. *AK

NHTSA ODI #10046613

1991 model year · 141,000 miles · Oct 29, 2003

Electrical SystemFire

ELECTRICAL WIRING HARNESS INSIDE THE DASHBOARD IGNITED, AND VEHICLE CAUGHT ON FIRE. THIS OCCURRED WHILE VEHICLE WAS PARKED IN THE DRIVEWAY. *AK

NHTSA ODI #10044955

1994 model year · Mileage unknown · Oct 17, 2003

Electrical SystemFire

1994 FORD EXPLORER CAUGHT ON FIRE, JUST AFTER WIFE AND BABY GOT OUT OF VEHICLE. IT BURNED THE DRIVER SIDE DOOR, AND PART OF THE DASH. NHTSA CAMPAIGN #97V083000, I THINK IS RELEVANT, AND RESPONSIBLE FOR THIS ACCIDENT. I NOTIFED FORD OVER 3 WEEKS AGO, AND THEY KEEP TELLING ME CONSUMER AFFAIRS WILL CALL, BUT THEY NEVER HAVE YET.…

Read full complaint

NHTSA ODI #10043075

2001 model year · 38,730 miles · Oct 12, 2003

Electrical SystemVisibility

Read full complaint

THERE WAS A WARNING INDICATOR THAT WAS ORIGINALLY ILLUMINATED GREEN. WHEN THE INDICATOR TURNED BLUE THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS. THE INDICATOR WAS FOR THE LIGHTING SYSTEM, AND THE DEALER MADE SOME REPAIRS, BUT DID NOT INFORM THE CONSUMER OF WHAT WAS DONE. CURRENTLY, THE INDICATOR IS NOT ON AT ALL, AND THE DEALER CANNOT DETERMINE WHY IT IS NOT WORKING. ALSO, THE REAR WINDOW WINDSHIELD WIPER WAS NOT OPERATING. DEALER STATED MOTOR HAD TO BE REPLACED. *AK *PH *NLM

NHTSA ODI #10038193

1997 model year · 52,100 miles · Oct 12, 2003

Electrical System

THE VEHICLE AUTOMATICALLY POPPED INTO 4X4 MODE WITHOUT WARNING. WHEN THAT HAPPENED THE VEHICLE MADE A LOUD GRINDING NOISE AND STOPPED IN THE MIDDLE OF TRAFFIC. *NLM THE VEHICLES WIPERS ALSO BECAME INOPERABLE. THE WINDOWS COULD NOT BE OPENED. THE INTERIOR LIGHTS FAILED. IT WAS LATER DETERMINED THAT ALL THESE FAIL…

Read full complaint

NHTSA ODI #10040176

2000 model year · 47,845 miles · Oct 12, 2003

Electrical System

I HAVE A 2000 FORD EXPLORER IN THE LAST YEAR I HAD TO CHANGE MY SPARK PLUGS TWICE BECAUSE COIL KEEPS BURNING OUT, I PURCHASED THE VEHICLE 5/03 AND THE AIRBAG LIGHT STAYS ON. *LA

NHTSA ODI #10041673

2002 model year · 17,500 miles · Oct 9, 2003

Electrical System

Read full complaint

TRAILER TOWING WIRING IS FUSED AT 40 AMPS TO THE TRAILER PLUG. A SHORT IN THE SIGNAL WIRING CAUSED THE TRAILER WIRING INSULATION TO MELT OFF BEFORE THE FUSE BLEW. I WAS FORTUNATE TO HAVE IT HAPPEN WITH MY BOAT TRAILER WHERE THE WIRING IS ENCLOSED IN THE IRON CHANNEL OF THE TRAILER. HAD THIS BEEN A CAMPER, IT COULD HAVE CAUSED A FIRE. THE WIRES GOING TO THE TRAILER PLUG SHOULD BE FUSED AT 7.5 AMPS AS IN PREVIOUS MODEL EXPLORERS. SEE THE EMAIL I RECENTLY COPIED YOUR DEPARTMENT FOR FULL EXPLANATION OF THIS INCIDENT. THIS PROBLEM EXISTS IN THE 2002 AND 2003 EXPLORERS AND POSSIBLE OTHER FORD PRODUCTS. *LA

NHTSA ODI #10041531

1992 model year · 80,000 miles · Oct 6, 2003

Electrical SystemFire

WHILE DRIVING 30 MPH SMOKE STARTED TO COME FROM THE DASHBOARD. CONSUMER CONTINUED TO DRIVE. AFTER THE VEHICLE WAS PARKED FOR 5 MINUTES VEHICLE CAUGHT ON FIRE.*AK

NHTSA ODI #10042342

1991 model year · Mileage unknown · Oct 2, 2003

Electrical System

GENERATOR FAILED PREMATURELY, CAUSING VEHICLE TO STALL WHILE DRIVING.*AK

NHTSA ODI #10042162

Related Official recalls

26V165000 · Back Over Prevention:software; Electrical System:adas

Mar 18, 2026

Ford Motor Company (Ford) is recalling certain 2022-2025 Lincoln Navigator, 2024-2025 Lincoln Nautilus, 2025 Lincoln Aviator and Explorer vehicles. The Image Processing Module A (IPMA) may experience multiple unexpected resets, resulting in loss of the rearview camera image and advanced driver assistance (ADAS) features, including pre-collision assist, lane-keeping assist, and blind-spot monitoring.

Consequence & remedy

Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.

Remedy: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.

Additional source detail variants (2)

Back Over Prevention:software

Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.

Remedy: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.

Electrical System:adas

Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.

24V685000 · Electrical SYSTEM:12V/24V/48V Battery:cables; Hybrid Propulsion System

Sep 13, 2024

Ford Motor Company (Ford) is recalling certain 2024 Ford Explorer vehicles equipped with 3.3L Hybrid engines. The 12-Volt battery cable may chafe against the Belt-integrated Starter Generat (BiSG) and short circuit.

Consequence & remedy

Consequence: A short circuit increases the risk of a fire.

Remedy: Dealers will install a tie strap between the battery cable and high voltage cable, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S61.

Additional source detail variants (2)

Hybrid Propulsion System

Consequence: A short circuit increases the risk of a fire.

Remedy: Dealers will install a tie strap between the battery cable and high voltage cable, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S61.

Electrical SYSTEM:12V/24V/48V Battery:cables

Consequence: A short circuit increases the risk of a fire.

23V686000 · Back Over Prevention:display Function; Electrical System:wiring

Oct 13, 2023

Ford Motor Company (Ford) is recalling certain 2023 Explorer vehicles equipped with a standard rearview camera. Due to a manufacturing error in the wire harness, the rearview camera may display a blue image on the SYNC screen when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Consequence & remedy

Consequence: A rearview camera that does not properly display an image can reduce the driver's rear view, increasing the risk of a crash.

Remedy: Dealers will inspect the rearview camera wire harness and repair any loose splices, free of charge. Owner notification letters were mailed November 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C31.

Additional source detail variants (2)

Back Over Prevention:display Function

Consequence: A rearview camera that does not properly display an image can reduce the driver's rear view, increasing the risk of a crash.

Remedy: Dealers will inspect the rearview camera wire harness and repair any loose splices, free of charge. Owner notification letters were mailed November 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C31.

Electrical System:wiring

Consequence: A rearview camera that does not properly display an image can reduce the driver's rear view, increasing the risk of a crash.

23V626000 · Electrical System:propulsion System:traction Battery

Sep 8, 2023

Ford Motor Company (Ford) is recalling certain 2020-2022 Lincoln Aviator and Ford Explorer vehicles equipped with 3.0L PHEV engines. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.

Consequence & remedy

Consequence: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.

Remedy: Dealers will perform a Battery Energy Control Module (BECM) diagnostic test and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on April 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford Motor Company's number for this recall is 23S53.

19V687000 · Electrical System:wiring

Sep 30, 2019

Ford Motor Company (Ford) is recalling certain 2020 Ford Explorer vehicles equipped with 2.3L or 3.3L engines. The wiring harness may not have been properly secured and may contact the air conditioner compressor (A/C) pulley, potentially damaging the harness or the A/C belt.

Consequence & remedy

Consequence: The A/C pulley may rub through the wiring harness insulation and contact the unfused battery positive wire, resulting in a short circuit, increasing the risk of a fire.

Remedy: Ford will notify owners, and dealers will install a tie strap to the wiring harness at the hand shock tower clip, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S32.

19V575000 · Electrical System: Instrument Cluster/panel; Parking Brake; Power Train:automatic Transmission:gear Position Indication (prndl)

Aug 5, 2019

Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. The Manual Park Release (MPR) cover may not be installed. In addition, the vehicles may be in Factory Mode, which disables warning alerts and does not display the transmission gear selected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Prevention" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."

Consequence & remedy

Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

Additional source detail variants (3)

Parking Brake

Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

Electrical System: Instrument Cluster/panel

Power Train:automatic Transmission:gear Position Indication (prndl)

00V072000 · Electrical System:wiring:fuses And Circuit Breakers

Mar 7, 2000

VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES EQUIPPED WITH 4.0L ENGINES AND ALL-TIME 4-WHEEL DRIVE (A4WD) POWERTRAINS. THE GENERIC ELECTRONIC MODULE (GEM) COULD EXPERIENCE A CONDITION REFERRED TO AS "LOCK-UP" IN WHICH THE GEM CONTROLLED ELECTRONIC FUNCTIONS (E.G., FRONT WINDSHIELD WIPERS, INTERIOR LIGHTS, 4X4 SYSTEM, ETC.) COULD NOT BE TURNED ON OR, IN SOME CASES IF THE FUNCTION IS ON, COULD NOT BE TURNED OFF.

Consequence & remedy

Consequence: AN INOPERATIVE WINDSHIELD WIPER SYSTEM COULD AFFECT DRIVER VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A RESISTOR IN THE GEM CIRCUIT.

97V215000 · Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module

Nov 24, 1997

VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES, EDDIE BAUER AND LIMITED EDITIONS. THE KEY-IN-IGNITION/DOOR OPEN WARNING CHIME MAY NOT FUNCTION WHEN THE DOOR IS OPENED. THIS DOES NOT FULLY COMPLY WITH FMVSS NO. 114, "THEFT PROTECTION."

Consequence & remedy

Consequence: THE STANDARD SPECIFIED THAT A WARNING TO THE DRIVER SHALL BE ACTUATED WHENEVER THE KEY HAS BEEN LEFT IN THE LOCKING SYSTEM AND THE DRIVER'S DOOR IS OPENED.

Remedy: DEALERS WILL INSTALL A JUMPER WIRE TO PROVIDE THE NECESSARY GROUND CIRCUIT IN THESE VEHICLES.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

Related NHTSA investigations

EA05005 · Engine Compartment Fires

Opened Mar 22, 2005 · Closed Aug 2, 2006

Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Vehicle Speed Control:cruise Control

EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.

Additional source detail variants (21)

Electrical System

Electrical System:wiring:front Underhood

Vehicle Speed Control:cruise Control

PE97010 · Electrical Fire In Center Console

Opened Mar 13, 1997 · Closed Sep 4, 1997

Status: closed (inferred from source dates) · Electrical System

THIS INVESTIGATION REVEALED THAT CONSOLE FIRES IN THE SUBJECT VEHICLES MOST OFTEN OCCURRED WHILE VEHICLES EQUIPPED WITH THE LAMP OUTAGE MODULE (LOM), WHICH IS PART OF THE MESSAGE CENTER, WERE TOWING A TRAILER AND WHICH HAD BEEN MODIFIED BY ADDING AN AFTERMARKET TRAILER WIRING HARNESS INTO THE VEHICLE'S TAILLIGHT CIRCUITS.THE OWNER'S MANUAL STATES NEVER AND MORE THAN OTHER TRAILER LIGHT BULB TO ONE CIRCUIT HOWEVER TRAILERS FREQUENTLY CONTAIN SEVERAL BULBS.THE RESULTING EXCESS CURRENT PASSING THROUGH THE LOM COULD CAUSE IT TO OVERHEAT RESULTING IN A FIRE.PROPER AFTERMARKET INSTALLATION OF TRAILER WIRING REQUIRES THE USE OF A BYPASS MODULE, WHICH OBTAINS POWER FOR THE TRAILER LIGHTS DIRECTLY FROM THE BATTERY RATHER THAN FROM THE VEHICLE'S TAIL LIGHT AND STOP LAMP CIRCUITS, OR THE USE OF THE MANUFACTURER'S WIRING HARNESS.IN A LETTER DATED SEPTEMBER 2, 1997, FORD NOTIFIED ODI THAT IT INTENDS TO TAKE ACTION TO PRECLUDE FURTHER INCIDENTS INCLUDING ISSUING A TECHNICAL SERVICE BULLETIN TO ITS DEALERS, NOTIFYING TRAILER RENTAL ASSOCIATIONS AND AGENCIES WHERE KNOWN, AND ADVISING OWNERS BY LETTER OF THE PROPER METHOD FOR CONNECTION OF TRAILER TOW WIRING ON THE SUBJECT VEHICLES.THERE WAS NO DEFECT TREND IN THE SUBJECT VEHICLES IDENTIFIED AS A RESULT OF THIS INVESTIGATION, AND FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT WARRANTED TO CONTINUE THE INVESTIGATION.

PE96066 · Driver Door Electrical Fire

Opened Nov 22, 1996 · Closed May 15, 1997

Status: closed (inferred from source dates) · Electrical System

THE CONTACT ASSEMBLY FOR THE REMOTE POWER MIRROR CONTROL SWITCH MAY DEVELOP A SHORT CIRCUIT BETWEEN THE SWITCH POSITIVE PAD AND CHASSIS GROUND PAD AS A RESULT OF WATER INTRUSION.EXCESS CURRENT FLOW RESULTING FROM THE SHORT CIRCUIT CONDITION MAY OVERHEAT THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AND CAUSE A FIRE IN THE DRIVER'S DOOR.FORD HAS INDICATED THAT CURRENT IN EXCESS OF 15 AMPS CAN OVERHEAT THE CIRCUIT BOARD ENOUGH TO CAUSE A FIRE.CIRCUIT PROTECTION IS PROVIDED BY A 30 AMP FUSE.FORD IS RECALLING ALL 1993-94 4-DOOR EXPLORER VEHICLES EQUIPPED WITH THE SUBJECT ELECTRONIC OPTION COMBINATION TO INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.NO 2-DOOR EXPLORER VEHICLES WERE BUILT WITH THE SUBJECT COMPONENTS.ACCORDING TO FORD, VEHICLES BUILT PRIOR TO THE RECALL PRODUCTION RANGE WERE EQUIPPED WITH LOWER CAPACITY CIRCUIT BOARDS FOR THE SUBJECT SWITCH ASSEMBLY THAT WOULD FAIL FROM AN OPEN CIRCUIT IF A SIMILAR SHORT OCCURRED.A NEW SWITCH ASSEMBLY WITH 10 AMP FUSE PROTECTION WAS INTRODUCED BEGINNING WITH THE 1995 MODEL YEAR EXPLORER.MAZDA WILL CONDUCT A PARALLEL COMPAIGN (97V-083.002) TO REMEDY THE SUBJECT CONDITION IN APPROXIMATELY 14,000 NAVAJO VEHICLES.THE NAVAJO VEHICLES WERE AVAILABLE IN ONLY THE 2-DOOR VERSION WHICH, UNLIKE THE EXPLORER VEHICLES, DID USE THE SUBJECT OPTION COMBINATION IN THAT BODY STYLE.