COMPONENT SPOTLIGHT

Ford Explorer electrical problems

2,242 distinct owner reports with an electrical-system component in this snapshot.

Includes the electrical-system component and its detailed subcategories. Related recalls and investigations must also name this component; they are not linked by narrative keyword alone.

44 crash reports312 fire reports36 injury reports

Reports by model year

Recall and investigation columns show each year’s full history. A report naming several years can appear in more than one row.

When problems were reported

Mileage at the reported incident

246

0–25K

179

25–50K

194

50–75K

154

75–100K

198

100–150K

123

150K+

1,094 reports with mileage · 1,148 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What owners actually said

2,242 reports

2004 model year · Mileage unknown · Oct 6, 2008

Electrical SystemStructure

I HAVE 2 ISSUES THAT I WOULD LIKE ADDRESSED. 1. I BELIEVE THAT I HAVE AN ELECTRICAL SHORT OR SOMETHING BECAUSE MY RADIO KEEPS GOING OUT ON THE DRIVERS SIDE. THIS HAS BEEN HAPPENING FOR ABOUT A YEAR OR SO NOW. NOT SURE HOW TO GO ABOUT CORRECTING THE ISSUE BECAUSE I DON'T KNOW IF IT IS COVERED UNDER WARRANTY OR NOT. 2. MY HATCHBA…

Read full complaint

NHTSA ODI #10244463

1999 model year · 99,589 miles · Oct 3, 2008

Electrical System

Read full complaint

TL*THE CONTACT OWNS A 1999 FORD EXPLORER. THE CONTACT STATED THAT THE GEM CONTROLLED ELECTRONIC FUNCTION FAILED, WHICH CAUSED THE WINDSHIELD WIPERS TO STOP WORKING. THE DEALER STATED THAT THEY DIDN'T KNOW ANYTHING ABOUT IN NHTSA CAMPAIGN ID NUMBER 00V072000 (ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS), ALTHOUGH THE FAILURES WERE IDENTICAL. THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COSTS. AS OF OCTOBER 3, 2008, THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 99,589. UPDATED 05/08/09. *LJ UPDATED 05/11/09.*JB

NHTSA ODI #10244308

2003 model year · 50,000 miles · Sep 16, 2008

Electrical SystemEngine And Engine CoolingPower Train

Read full complaint

I PURCHASED A 2003 EXPLORER IN AUGUST 2006; MILEAGE WAS APPROXIMATELY 45,000. BY OCTOBER THE CAR WOULD NOT START AND THE ALTERNATOR WAS REPLACED. A FEW WEEKS LATER, I WAS BACK BECAUSE MY CAR WAS JERKING. NOTHING SHOWED UP ON THE DIAGNOSTIC TOOL AT THAT TIME. HOWEVER, I WAS TOLD THE STARTER WOULD HAVE TO BE REPLACED AS WOULD THE RECENTLY INSTALLED ALTERNATOR. I RETURNED LESS THAN A MONTH LATER WITH THE SAME JERKING ISSUE, ONLY THIS TIME I NOTIFIED THE REPAIR SHOP THAT THE O/D LIGHT HAD BEEN COMING ON. FURTHERMORE, MY CAR HAD ACTUALLY STALLED IN THE MIDDLE OF TRAFFIC. AGAIN, NOTHING WAS FOUND. BY EARLY DECEMBER, I WAS BACK. MY CAR HAD STALLED ON A FEW MORE OCCASIONS AND WOULD NOT "PICK UP". THAT IS, EVEN THOUGH THE RPM'S WOULD REACH ANYWHERE FROM 2500 - 4000, MY CAR COULD NOT ACCELERATE ABOVE 25 - 30 MPH. SEVERAL DAYS LATER I WAS TOLD THAT THE TRANSMISSION NEEDED WORK. I GOT MY CAR BACK A FEW DAYS BEFORE CHRISTMAS AND DECIDED LAST MINUTE TO HEAD TO THE MOUNTAINS. AS SOON AS I REACH A SLIGHT ELEVATION, THE CAR CEASED TO ACCELERATE AND WHAT'S MORE, A THICK HEAVY CLOUD OF BLACK SMOKE CAME OUT OF THE REAR AND PERSISTED FOR AT LEAST TWO MILES. I HEADED BACK DOWN THE MOUNTAIN FOR HOME. I TOOK THE CAR BACK AND THEY KEPT IT FOR AT LEAST A WEEK AND A HALF TO REPAIR THE TORQUE CONVERTER AND OTHER TRANSMISSION RELATED ISSUE. IN EARLY FALL 2007, I TOOK THE CAR TO MY LOCAL FORD DEALER FOR SOME STRANGE NOISE COMING FROM THE ENGINE. IT ENDED UP COSTING $2500.00 TO REPAIR. I RETURNED IN NOVEMBER FOR MORE WORK, THIS TIME FOR THE SAME TORQUE CONVERTER AND SOLENOID ISSUE AS A YEAR AGO. DURING THIS TWO YEAR PERIOD, MY VEHICLE WAS UNDER EXTENDED WARRANTY. THE TOTAL REPAIR COST FOR THE FIRST YEAR OF OWNERSHIP IS ANYWHERE FROM $5000 - $9000, OF WHICH I PAID AT LEAST $2500 OUT OF POCKET. MY WARRANTY HAS SINCE EXPIRED AND I AM WORRIED THAT THESE SAME ISSUES WILL RECUR, AS I HAVE READ THEY HAVE. THIS IS NOT AN ISOLATED INCIDENT AND SHOULD BE INVESTIGATED AND A RECALL ISSUED. *TR

NHTSA ODI #10242371

2004 model year · Mileage unknown · Sep 10, 2008

Electrical SystemPower TrainSuspension

Read full complaint

I HAVE HAD MANY, MANY PROBLEMS WITH MY 2004 FORD EXPLORER. PROBABLY THE MOST DANGEROUS ONE IS THE RECURRING FAILURE OF THE TRANSMISSION. THIS LAST TIME THAT THIS OCCURRED I WAS ON INTERSTATE-85, IN MORNING RUSH-HOUR TRAFFIC, AND ALL OF A SUDDEN MY RPM'S ARE FLYING TO THE RED DANGER AREA AND I HAVE NO ACCELERATION POWER AND AM LOSING SPEED. THERE IS AN 18-WHEELER ON MY REAR AND I CAN'T PICK UP SPEED! LUCKILY, I WAS APPROACHING AN EXIT AND MANAGED TO GET THE VEHICLE OFF OF THE INTERSTATE AND ONTO A LESS TRAVELED ROAD. THIS IS THE SECOND TIME THAT I HAVE ENDURED THIS SCENARIO. ONCE AGAIN THE SOLENOID IS GONE, WITH REPAIRS ESTIMATED AT $1255.00. I HAVE HAD THIS PROBLEM REPAIRED LESS THAN A YEAR AFTER PURCHASE. I HAVE HAD THIS PROBLEM REPAIRED AT 32,567 MILES, AND I NOW HAVE THIS PROBLEM AGAIN AT 76,725 MILES. I HAVE HAD THE CLUTCH PACK REPLACED AT 24,940 MILES AS WELL AS THE RING GEAR, PINION, AND ALL BEARINGS REPLACED AT 24,940 MILES. AT 35,558 MILES THE LOWER BALL JOINT HAD TO BE REPLACED. AT 64,335 I HAD TO HAVE THE PATS TRANSPONDER(SECURITY SYSTEM) REPLACED. IN SHORT I HAVE HAD THE TRANSMISSION REPAIRED THREE TIMES THE FRONT END REBUILT , THE BACK END REDONE. I HONESTLY CAN SAY I DO NOT FEEL VERY SAFE IN THIS VEHICLE, ESPECIALLY SINCE I HAVE TO USE THIS TO TRANSPORT MY CHILDREN. THESE PROBLEMS SEEM TO BE THE NORM FOR THIS PARTICULAR VEHICLE, AS I HAVE DONE RESEARCH ON THIS. I DON'T UNDERSTAND WHY FORD IS NOT MADE TO RESOLVE THESE ISSUES. I HAVE ALSO HAD TO HAVE MY HEATING AND AIR REPLACED. THIS OCCURRED IN THE WINTER OF 2007 AND WAS A SAFETY ISSUE, AS I COULD NOT DEFROST MY WINDOWS. *TR

NHTSA ODI #10241780

1991 model year · 100,000 miles · Sep 8, 2008

Electrical SystemFire

TL*THE CONTACT OWNED A 1991 FORD EXPLORER. WHILE DRIVING 40 MPH, THE CONTACT NOTICED SMOKE COMING FROM THE INSTRUMENT PANEL. THE VEHICLE FAILED TO RESTART. SHE MANAGED TO MANEUVER THE VEHICLE TO THE SHOULDER AND LEFT TO CALL FOR HELP. UPON RETURNING TO THE VEHICLE, IT WAS CONSUMED IN FLAMES. THE VEHICLE WAS DESTROYED AND A …

Read full complaint

NHTSA ODI #10241375

2002 model year · 110,000 miles · Sep 1, 2008

Electrical System

Read full complaint

READING THE FORUMS AND MANY PEOPLE HAVE BEEN HAVING PROBLEMS WITH THEIR EXPLORERS 4X4. I HAVE THE SAME PROBLEM. SEEMS LIKE IF YOU DISCONNECT THE BATTERY OR YOUR BATTERY DIES SO DOES YOUR CONTROL MODULE FOR THE 4X4. MINE STOPPED WORKING WHEN THAT HAPPENED. THAT IS WHEN MY 4X4 SELECTOR SWITCH LIGHTS STOPPED WORKING AND MY 4X4 WAS NOT ENGAGING. SEEMS LIKE FORD NEEDS TO RECALL THIS PART. I GOT A NEW CONTROL MODULE AND IT STARTED WORKING AGAIN. COULD BE DANGEROUS IN WINTER TIME FOR THIS TYPE OF VEHICLE TO HAVE NO 4X4. *TR

NHTSA ODI #10240501

2002 model year · 955,000 miles · Aug 19, 2008

Electrical SystemCrash

Read full complaint

DOOR AJAR CONSTANTLY ON. INTERIOR DOME LIGHT FRONT AND CARGO COME ON AND OFF FOR MINUTES AT A TIME. BEEPS AND CHIMES SPORADICALLY FOR NO GIVEN TIME OR REASON WHILE DRIVING, STOPPING, TURNING OR ANY OTHER ACTION. A DISTRACTION TO DRIVING; ESPECIALLY DOME LIGHTS AT NIGHT AND BEEPS/CHIMES WHICH CAN ALSO INTERFERE WITH RADIO SOUND OUTPUT AND ATTENTION. HAS BEEN IN AND OUT OF DEALER WITH NO RESULT. HAVE PROVIDED OTHER ONLINE COMPLAINTS TO SERVICE MANAGER REGARDING SAME ISSUE WITH NO RESULT. *TR

NHTSA ODI #10238835

2002 model year · 35,000 miles · Aug 8, 2008

Electrical SystemPower TrainStructure

Read full complaint

PURCHASED A 2002 FORD EXP EDDIE BAUER ED USED WITH 35,000 MILES. TRANSMISSION HAD TO BE REPAIRED WITHIN 3 WEEKS DUE TO 4WD MALFUNCTION COVERED BY WARRANTY. PASSENGER SIDE WINDOW MOTOR ASSEMBLY HAS BEEN REPLACED ONCE, AND WINDOW REGULATOR HAS BEEN REPLACED ONCE, AND IS IN NEED OF A SECOND REPLACEMENT. TOOK TO LOCAL DEALERSHIP AND WAS TOLD WINDOW WAS NOT MEANT TO BE LOWERED HALFWAY. THE REAR HATCH HAS ALSO CRACKED COMPLETELY DOWN FROM WINDOW TO LOWER PANEL. DEALERSHIP WILL NOT ACKNOWLEDGE ISSUES WITH THIS OCCURRING, BUT UPON FURTHER RESEARCH HAVE FOUND THIS TO BE A COMMON PROBLEM WITH THIS VEHICLE MAKE AND MODEL. OVERDRIVE LIGHT BLINKS CONTINUOUSLY AND DEALERSHIP REPORTS IT TO BE A MALFUNCTIONING ELECTRICAL SWITCH REPAIR COST AT AROUND $400. HAVE CONTINUED TO DRIVE VEHICLE, BUT WILL NO LONGER DRIVE VEHICLE AFTER DISCOVERING THAT THIS IS A PRECURSOR TO TRANSMISSION FAILURE. MAY POSSIBLY TRADE-IN THIS VEHICLE AND LOSE MONETARY VALUE FOR PRIVATE SALE. WILL NOT BE RESPONSIBLE FOR SELLING THIS VEHICLE TO A PRIVATE PARTY AND RISK INJURY TO NEXT OWNER. SHAME ON FORD FOR NOT TAKING CARE OF THEIR CUSTOMERS. *TR

NHTSA ODI #10237454

2006 model year · 28,000 miles · Jul 22, 2008

Electrical System

MY 2006 FORD EXPLORER WILL JUST SHUT OFF WHEN YOU ARE RUNNING 55-60 MPH. THIS SEEMS TO HAPPEN USUALLY AFTER IT RAINS. MY ALARM GOES OFF PERIODICALLY WHEN NOBODY IS AROUND IT. FORD CANNOT SEEM TO DUPLICATE THE PROBLEM. *TR

NHTSA ODI #10235311

2002 model year · Mileage unknown · Jul 18, 2008

Electrical System

MY DASHBOARD HAS DIGITAL MILEAGE/ TEMP AND TRIP....HOWEVER, SINCE I GOT THE SUV IN DECEMBER OF 2007, THE CLUSTER THAT SHOWS THAT INFORMATION HAS NOT BEEN UP. THE DEALERSHIP I BOUGHT THE SUV FROM REFUSED TO HAVE IT FIXED AND I NEED TO KNOW WHAT I CAN DO WITHOUT SPENDING ALOT OF MONEY. *TR

NHTSA ODI #10234749

Related Official recalls

26V165000 · Back Over Prevention:software; Electrical System:adas

Mar 18, 2026

Ford Motor Company (Ford) is recalling certain 2022-2025 Lincoln Navigator, 2024-2025 Lincoln Nautilus, 2025 Lincoln Aviator and Explorer vehicles. The Image Processing Module A (IPMA) may experience multiple unexpected resets, resulting in loss of the rearview camera image and advanced driver assistance (ADAS) features, including pre-collision assist, lane-keeping assist, and blind-spot monitoring.

Consequence & remedy

Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.

Remedy: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.

Additional source detail variants (2)

Back Over Prevention:software

Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.

Remedy: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.

Electrical System:adas

Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.

24V685000 · Electrical SYSTEM:12V/24V/48V Battery:cables; Hybrid Propulsion System

Sep 13, 2024

Ford Motor Company (Ford) is recalling certain 2024 Ford Explorer vehicles equipped with 3.3L Hybrid engines. The 12-Volt battery cable may chafe against the Belt-integrated Starter Generat (BiSG) and short circuit.

Consequence & remedy

Consequence: A short circuit increases the risk of a fire.

Remedy: Dealers will install a tie strap between the battery cable and high voltage cable, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S61.

Additional source detail variants (2)

Hybrid Propulsion System

Consequence: A short circuit increases the risk of a fire.

Remedy: Dealers will install a tie strap between the battery cable and high voltage cable, free of charge. Owner notification letters were mailed November 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S61.

Electrical SYSTEM:12V/24V/48V Battery:cables

Consequence: A short circuit increases the risk of a fire.

23V686000 · Back Over Prevention:display Function; Electrical System:wiring

Oct 13, 2023

Ford Motor Company (Ford) is recalling certain 2023 Explorer vehicles equipped with a standard rearview camera. Due to a manufacturing error in the wire harness, the rearview camera may display a blue image on the SYNC screen when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Consequence & remedy

Consequence: A rearview camera that does not properly display an image can reduce the driver's rear view, increasing the risk of a crash.

Remedy: Dealers will inspect the rearview camera wire harness and repair any loose splices, free of charge. Owner notification letters were mailed November 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C31.

Additional source detail variants (2)

Back Over Prevention:display Function

Consequence: A rearview camera that does not properly display an image can reduce the driver's rear view, increasing the risk of a crash.

Remedy: Dealers will inspect the rearview camera wire harness and repair any loose splices, free of charge. Owner notification letters were mailed November 2, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C31.

Electrical System:wiring

Consequence: A rearview camera that does not properly display an image can reduce the driver's rear view, increasing the risk of a crash.

23V626000 · Electrical System:propulsion System:traction Battery

Sep 8, 2023

Ford Motor Company (Ford) is recalling certain 2020-2022 Lincoln Aviator and Ford Explorer vehicles equipped with 3.0L PHEV engines. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.

Consequence & remedy

Consequence: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.

Remedy: Dealers will perform a Battery Energy Control Module (BECM) diagnostic test and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on April 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford Motor Company's number for this recall is 23S53.

19V687000 · Electrical System:wiring

Sep 30, 2019

Ford Motor Company (Ford) is recalling certain 2020 Ford Explorer vehicles equipped with 2.3L or 3.3L engines. The wiring harness may not have been properly secured and may contact the air conditioner compressor (A/C) pulley, potentially damaging the harness or the A/C belt.

Consequence & remedy

Consequence: The A/C pulley may rub through the wiring harness insulation and contact the unfused battery positive wire, resulting in a short circuit, increasing the risk of a fire.

Remedy: Ford will notify owners, and dealers will install a tie strap to the wiring harness at the hand shock tower clip, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S32.

19V575000 · Electrical System: Instrument Cluster/panel; Parking Brake; Power Train:automatic Transmission:gear Position Indication (prndl)

Aug 5, 2019

Ford Motor Company (Ford) is recalling certain 2020 Explorer and Lincoln Aviator vehicles. The Manual Park Release (MPR) cover may not be installed. In addition, the vehicles may be in Factory Mode, which disables warning alerts and does not display the transmission gear selected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Prevention" and 102, "Trans Shift Lever Seq/Starter Interlock/Trans Braking Effect."

Consequence & remedy

Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

Additional source detail variants (3)

Parking Brake

Consequence: Without the cover, the MPR lever may be unintentionally moved, allowing the vehicle to roll away. Being in Factory Mode, the vehicle will not display warnings and/or gear selection on the instrument cluster. Both conditions increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, install a MPR cover. Dealers will verify the instrument cluster is not in Factory Mode and clear any fault codes, free of charge. The recall began August 23, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C06.

Electrical System: Instrument Cluster/panel

Power Train:automatic Transmission:gear Position Indication (prndl)

00V072000 · Electrical System:wiring:fuses And Circuit Breakers

Mar 7, 2000

VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES EQUIPPED WITH 4.0L ENGINES AND ALL-TIME 4-WHEEL DRIVE (A4WD) POWERTRAINS. THE GENERIC ELECTRONIC MODULE (GEM) COULD EXPERIENCE A CONDITION REFERRED TO AS "LOCK-UP" IN WHICH THE GEM CONTROLLED ELECTRONIC FUNCTIONS (E.G., FRONT WINDSHIELD WIPERS, INTERIOR LIGHTS, 4X4 SYSTEM, ETC.) COULD NOT BE TURNED ON OR, IN SOME CASES IF THE FUNCTION IS ON, COULD NOT BE TURNED OFF.

Consequence & remedy

Consequence: AN INOPERATIVE WINDSHIELD WIPER SYSTEM COULD AFFECT DRIVER VISIBILITY, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A RESISTOR IN THE GEM CIRCUIT.

97V215000 · Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module

Nov 24, 1997

VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES, EDDIE BAUER AND LIMITED EDITIONS. THE KEY-IN-IGNITION/DOOR OPEN WARNING CHIME MAY NOT FUNCTION WHEN THE DOOR IS OPENED. THIS DOES NOT FULLY COMPLY WITH FMVSS NO. 114, "THEFT PROTECTION."

Consequence & remedy

Consequence: THE STANDARD SPECIFIED THAT A WARNING TO THE DRIVER SHALL BE ACTUATED WHENEVER THE KEY HAS BEEN LEFT IN THE LOCKING SYSTEM AND THE DRIVER'S DOOR IS OPENED.

Remedy: DEALERS WILL INSTALL A JUMPER WIRE TO PROVIDE THE NECESSARY GROUND CIRCUIT IN THESE VEHICLES.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

Related NHTSA investigations

EA05005 · Engine Compartment Fires

Opened Mar 22, 2005 · Closed Aug 2, 2006

Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Vehicle Speed Control:cruise Control

EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.

Additional source detail variants (21)

Electrical System

Electrical System:wiring:front Underhood

Vehicle Speed Control:cruise Control

PE97010 · Electrical Fire In Center Console

Opened Mar 13, 1997 · Closed Sep 4, 1997

Status: closed (inferred from source dates) · Electrical System

THIS INVESTIGATION REVEALED THAT CONSOLE FIRES IN THE SUBJECT VEHICLES MOST OFTEN OCCURRED WHILE VEHICLES EQUIPPED WITH THE LAMP OUTAGE MODULE (LOM), WHICH IS PART OF THE MESSAGE CENTER, WERE TOWING A TRAILER AND WHICH HAD BEEN MODIFIED BY ADDING AN AFTERMARKET TRAILER WIRING HARNESS INTO THE VEHICLE'S TAILLIGHT CIRCUITS.THE OWNER'S MANUAL STATES NEVER AND MORE THAN OTHER TRAILER LIGHT BULB TO ONE CIRCUIT HOWEVER TRAILERS FREQUENTLY CONTAIN SEVERAL BULBS.THE RESULTING EXCESS CURRENT PASSING THROUGH THE LOM COULD CAUSE IT TO OVERHEAT RESULTING IN A FIRE.PROPER AFTERMARKET INSTALLATION OF TRAILER WIRING REQUIRES THE USE OF A BYPASS MODULE, WHICH OBTAINS POWER FOR THE TRAILER LIGHTS DIRECTLY FROM THE BATTERY RATHER THAN FROM THE VEHICLE'S TAIL LIGHT AND STOP LAMP CIRCUITS, OR THE USE OF THE MANUFACTURER'S WIRING HARNESS.IN A LETTER DATED SEPTEMBER 2, 1997, FORD NOTIFIED ODI THAT IT INTENDS TO TAKE ACTION TO PRECLUDE FURTHER INCIDENTS INCLUDING ISSUING A TECHNICAL SERVICE BULLETIN TO ITS DEALERS, NOTIFYING TRAILER RENTAL ASSOCIATIONS AND AGENCIES WHERE KNOWN, AND ADVISING OWNERS BY LETTER OF THE PROPER METHOD FOR CONNECTION OF TRAILER TOW WIRING ON THE SUBJECT VEHICLES.THERE WAS NO DEFECT TREND IN THE SUBJECT VEHICLES IDENTIFIED AS A RESULT OF THIS INVESTIGATION, AND FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT WARRANTED TO CONTINUE THE INVESTIGATION.

PE96066 · Driver Door Electrical Fire

Opened Nov 22, 1996 · Closed May 15, 1997

Status: closed (inferred from source dates) · Electrical System

THE CONTACT ASSEMBLY FOR THE REMOTE POWER MIRROR CONTROL SWITCH MAY DEVELOP A SHORT CIRCUIT BETWEEN THE SWITCH POSITIVE PAD AND CHASSIS GROUND PAD AS A RESULT OF WATER INTRUSION.EXCESS CURRENT FLOW RESULTING FROM THE SHORT CIRCUIT CONDITION MAY OVERHEAT THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AND CAUSE A FIRE IN THE DRIVER'S DOOR.FORD HAS INDICATED THAT CURRENT IN EXCESS OF 15 AMPS CAN OVERHEAT THE CIRCUIT BOARD ENOUGH TO CAUSE A FIRE.CIRCUIT PROTECTION IS PROVIDED BY A 30 AMP FUSE.FORD IS RECALLING ALL 1993-94 4-DOOR EXPLORER VEHICLES EQUIPPED WITH THE SUBJECT ELECTRONIC OPTION COMBINATION TO INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.NO 2-DOOR EXPLORER VEHICLES WERE BUILT WITH THE SUBJECT COMPONENTS.ACCORDING TO FORD, VEHICLES BUILT PRIOR TO THE RECALL PRODUCTION RANGE WERE EQUIPPED WITH LOWER CAPACITY CIRCUIT BOARDS FOR THE SUBJECT SWITCH ASSEMBLY THAT WOULD FAIL FROM AN OPEN CIRCUIT IF A SIMILAR SHORT OCCURRED.A NEW SWITCH ASSEMBLY WITH 10 AMP FUSE PROTECTION WAS INTRODUCED BEGINNING WITH THE 1995 MODEL YEAR EXPLORER.MAZDA WILL CONDUCT A PARALLEL COMPAIGN (97V-083.002) TO REMEDY THE SUBJECT CONDITION IN APPROXIMATELY 14,000 NAVAJO VEHICLES.THE NAVAJO VEHICLES WERE AVAILABLE IN ONLY THE 2-DOOR VERSION WHICH, UNLIKE THE EXPLORER VEHICLES, DID USE THE SUBJECT OPTION COMBINATION IN THAT BODY STYLE.