NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
17 reportsClear category filterMileage unknown · Aug 13, 2026
Electrical SystemUnknown Or Other
On XXX, my 2025 Ford Explorer Platinum experienced a complete unexplained no-start failure while approximately six hours from home. The vehicle had less than 1/4 tank of fuel but was not empty and was parked on a slight decline. It remote-started normally and ran for approximately 10 minutes before automatically shutting off. Af…
Read full complaint
On XXX, my 2025 Ford Explorer Platinum experienced a complete unexplained no-start failure while approximately six hours from home. The vehicle had less than 1/4 tank of fuel but was not empty and was parked on a slight decline. It remote-started normally and ran for approximately 10 minutes before automatically shutting off. Afterward, it would not restart, repeatedly displayed "Accessory Power Only," and later displayed and audibly announced "System Failure, Contact Dealer." Multiple jump-start attempts failed and the vehicle required towing to Lugoff Ford in [XXX]. Lugoff Ford documented fuel and transmission-related codes and initially advised that the vehicle appeared to need a transmission replacement. That explanation later changed, and the vehicle was returned without an identified cause or repair. I subsequently took the vehicle to Cleveland Ford in [XXX] for a second evaluation. Their repair order specifically states that Ford connected data showed a fuel-pressure code on the day of the failure, but they found no active DTCs and could not duplicate the condition. The vehicle was again returned without diagnosis or repair. I am concerned that an intermittent defect involving the fuel system, transmission controls, electrical system, software, or related components could cause another sudden disabling event. Two Ford dealers have evaluated the vehicle, evidence of the original failure exists, and the underlying cause remains unidentified and unrepaired. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11756812
Mileage unknown · Aug 8, 2026
SeatsStructureUnknown Or Other
This vehicle was a rental car. The rear door opens and closes at random times. On multiple occasions even after locking the car, we would come out to the door being open. The door came down on its own and smacked my wife as well as hitting my [XXX] daughter in the head. While driving down the highway that rear door decided to op…
Read full complaint
This vehicle was a rental car. The rear door opens and closes at random times. On multiple occasions even after locking the car, we would come out to the door being open. The door came down on its own and smacked my wife as well as hitting my [XXX] daughter in the head. While driving down the highway that rear door decided to open on its own putting my family in immediate grave danger. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11755681
Mileage unknown · May 8, 2026
Unknown Or Other
The gear shifter gets tight to put it from park to drive and drive to park, but doesnt stay constant. Brought it in and was told that I am spinning it to fast to spin it slower. I told the dealer I do spin it slow with the same issue. They told me they will not do anything until it gets stuck. Upon doing research, I have found s…
Read full complaint
The gear shifter gets tight to put it from park to drive and drive to park, but doesnt stay constant. Brought it in and was told that I am spinning it to fast to spin it slower. I told the dealer I do spin it slow with the same issue. They told me they will not do anything until it gets stuck. Upon doing research, I have found several others have had the same issue.
NHTSA ODI #11736707
Mileage unknown · Apr 29, 2026
Unknown Or OtherInjury
I was driving on the Highway and all the sudden for absolutely no apparent reason the Passenger side door window completely shattered into small bits of glass. I check the vehicle for any damage other than the window not a scratch on the door at all I have no idea what caused the window to shatter.
NHTSA ODI #11734686
Mileage unknown · Feb 9, 2026
Back Over PreventionForward Collision AvoidanceUnknown Or Other
The vehicle failed the inspection related to Recall 25C42. Since owning the vehicle, I have experienced repeated intermittent failures of multiple safety and driver-assistance systems, which raise serious safety concerns. The Pre-Collision Assist system has activated without any apparent reason on four separate occasions, inclu…
Read full complaint
The vehicle failed the inspection related to Recall 25C42. Since owning the vehicle, I have experienced repeated intermittent failures of multiple safety and driver-assistance systems, which raise serious safety concerns. The Pre-Collision Assist system has activated without any apparent reason on four separate occasions, including situations where there were no vehicles, pedestrians, or obstacles present. These unexpected activations are alarming and could increase the risk of a collision. I fear for my safety when driving the vehicle due to these unpredictable safety system activations. Additionally, the Rear Cross Traffic Alert system functions intermittently and does not activate consistently when vehicles are present, further reducing confidence in the vehicle’s safety systems. While driving, the vehicle’s phone connectivity system has disconnected unexpectedly, and during these events the GPS/navigation system became unavailable, preventing the use of turn-by-turn directions. These failures occur while the vehicle is in motion and contribute to driver distraction and safety concerns. The vehicle was inspected for Recall 25C42, and I was informed that the required repair cannot be completed because the replacement part is on backorder until June. As a result, the vehicle continues to be operated with known and unresolved safety-related defects for an extended period of time. These issues occur intermittently and without warning, making them difficult to reproduce or diagnose. Due to the ongoing malfunction of critical safety systems and the delay in recall repairs, I fear for my safety while driving this vehicle.
NHTSA ODI #11716635
Mileage unknown · Dec 6, 2025
Unknown Or OtherVisibility/wiper
There is a large black box on the interior windshield surrounding the rearview mirror. This box blocks the defrost on the windshield, causing ice buildup on the windshield in this area thus causing ice buildup on the windshield wipers. This causes the windshield wipers to be ineffective at removing water, snow, slush, - whatever…
Read full complaint
There is a large black box on the interior windshield surrounding the rearview mirror. This box blocks the defrost on the windshield, causing ice buildup on the windshield in this area thus causing ice buildup on the windshield wipers. This causes the windshield wipers to be ineffective at removing water, snow, slush, - whatever debris is on the windshield from being removed greatly decreasing visibility in freezing temperatures. I first noticed this when it started to get cold and my windshield wipers were making a strange noise. I got out of the car to see what was going on with the windshield and noticed the ice building up at the top middle of the windshield. As I drove, and the temperatures dropped, the top half of my windshield where this black box is iced up causing my windshield wipers to be ineffective on about the top half of my windshield. This greatly reduced visibility in already reduced visibility driving conditions. This was not just ice on the windshield. It was very obviously accumulating where this box is, due to ineffective defrost of the windshield.
NHTSA ODI #11703488
Mileage unknown · Dec 5, 2025
EngineUnknown Or Other
12 V Battery continues to die and I've had the car less than a year. On [XXX] the battery was dead. Our neighbor put it on his supercharger. On [XXX] the 12V battery low light came on while I was driving 30 miles away. It went off the next day and reappeared on Thursday [XXX] disappeared on Friday and back on Saturday. I called…
Read full complaint
12 V Battery continues to die and I've had the car less than a year. On [XXX] the battery was dead. Our neighbor put it on his supercharger. On [XXX] the 12V battery low light came on while I was driving 30 miles away. It went off the next day and reappeared on Thursday [XXX] disappeared on Friday and back on Saturday. I called the Future Ford on Monday and technician [XXX] said it only showed 15% charge. I took it in to the dealership and it was kept over night and the next day he said it was charged to 90%. I was not happy with the "you can come and get it". I told him I'm a [XXX] and bought this car so I wouldn't breakdown and now I don't feel safe with it. He checked the charge again while we were on the phone and he said it dropped to 80%. He said thats not good it will probably need a new battery. That evening he text and said it is fully charged and I can come get it without a new battery. I was not happy as I've received no reason for why it was losing charge. So I did some research on my on and text him back that evening. I told him about my research and found this was an ongoing problem and that they need to find out what is causing the draining issue. I'm sure the dealership had to know as there was a recall for this issue. I suggested a Parasitic test, or software glitch issues to check. He said they would run the parasitic test.. He said it would take several days. I checked back on 12/4/25 and he said No Progress today. I told him I want a copy of all the test run. Wouldn't you know it he gets right back to me saying a handful of modules need updated software. That they will attend them this morning. I think they were trying to get out of the fix as my warranty runs out this month. Why are only certain vehicles being recalled (mine not one of them), when they all should be recalled. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11703309
Mileage unknown · Nov 8, 2025
Unknown Or Other
Ever since the last recall got resolved the car has failed to go into the gear it’s set to. Such as it fails to go in park when you shift it into park. This is a serious issue as I have now almost rear ended cars in parking lots a few times because of this issue.
NHTSA ODI #11698333
Mileage unknown · Oct 12, 2025
Unknown Or OtherWheels
The carpet on the wheel wells is not functional. We live out on a ranch on a dirt road and when it rains the mud gets stuck on the carpet and weighs is down. This can cause more damage to the vehicle. We took it in to a dealership and they said there was nothing they could do until the carpet gets ripped off. When we bought an e…
Read full complaint
The carpet on the wheel wells is not functional. We live out on a ranch on a dirt road and when it rains the mud gets stuck on the carpet and weighs is down. This can cause more damage to the vehicle. We took it in to a dealership and they said there was nothing they could do until the carpet gets ripped off. When we bought an expensive 4x4 vehicle we expected it to be sturdy enough to not have to worry about mud (especially when the car has a built in mud feature).
NHTSA ODI #11692908
Mileage unknown · Sep 7, 2025
Unknown Or Other
The expansive and overly complicated electronic display has moving menu buttons. By that I mean when you use a feature such as the heated seats or radio source and make a choice, the next time you go there to change something the buttons are in a different order with the previous choice showing first. The radio source actually m…
Read full complaint
The expansive and overly complicated electronic display has moving menu buttons. By that I mean when you use a feature such as the heated seats or radio source and make a choice, the next time you go there to change something the buttons are in a different order with the previous choice showing first. The radio source actually moves the entire menu to another part of the screen. You have to take your attention off the road for far too long to find what you are looking for. The 2025 Explorer has a very dangerous electronic display that requires far too much attention. As stated, some buttons change location, others are too small to see. The cruise control display is minuscule and mixed in with other display components when there is far more than enough unused space on the screen for larger graphics. I'm sure Ford will use the excuse to use voice controls, but the system is slow and gets it wrong half of the time. In my opinion Ford should be forced to change all of this and send software updates to all affected vehicles.
NHTSA ODI #11685537
Official recalls
20Jul 21, 2026
Ford Motor Company (Ford) is recalling certain 2025-2027 Explorer and Lincoln Aviator vehicles. An unoccupied driver's seat may recline unintentionally during certain scenarios, such as remote unlock or remote start.
Consequence & remedy
Consequence: Unexpected movement of the driver’s seat back may trap a second-row occupant, increasing the risk of injury.
Remedy: Dealers will disable the driver seat module (DSM) feature until parts are available. Once available, the motor will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S53.
Jul 14, 2026
Ford Motor Company (Ford) is recalling certain 2020-2027 Aviator and 2020-2026 Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, tipping, or sliding unexpectedly.
Consequence & remedy
Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the bezel around the switch as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters explaining the safety risk were mailed August 19, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Lincoln Aviator owner notification letters were mailed August 21, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S52. This recall expands Recall 25V393. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
May 27, 2026
Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer, Ranger, and Bronco vehicles. The engine may fail, which can result in a loss of drive power.
Consequence & remedy
Consequence: A sudden loss of drive power can increase the risk of a crash.
Remedy: Dealers will replace the engine long block, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2026. Additional letters will be sent once the remedy is available, anticipated in November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S35. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 28, 2026.
Mar 18, 2026
Ford Motor Company (Ford) is recalling certain 2022-2025 Lincoln Navigator, 2024-2025 Lincoln Nautilus, 2025 Lincoln Aviator and Explorer vehicles. The Image Processing Module A (IPMA) may experience multiple unexpected resets, resulting in loss of the rearview camera image and advanced driver assistance (ADAS) features, including pre-collision assist, lane-keeping assist, and blind-spot monitoring.
Consequence & remedy
Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.
Remedy: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.
Additional source detail variants (2)
Back Over Prevention:software
Ford Motor Company (Ford) is recalling certain 2022-2025 Lincoln Navigator, 2024-2025 Lincoln Nautilus, 2025 Lincoln Aviator and Explorer vehicles. The Image Processing Module A (IPMA) may experience multiple unexpected resets, resulting in loss of the rearview camera image and advanced driver assistance (ADAS) features, including pre-collision assist, lane-keeping assist, and blind-spot monitoring.
Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.
Remedy: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.
Electrical System:adas
Ford Motor Company (Ford) is recalling certain 2022-2025 Lincoln Navigator, 2024-2025 Lincoln Nautilus, 2025 Lincoln Aviator and Explorer vehicles. The Image Processing Module A (IPMA) may experience multiple unexpected resets, resulting in loss of the rearview camera image and advanced driver assistance (ADAS) features, including pre-collision assist, lane-keeping assist, and blind-spot monitoring.
Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.
Remedy: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.
Mar 17, 2026
Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.
Consequence & remedy
Consequence: A loose seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C18. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer vehicles. The Dynamic Bending Light (DBL) system software may cause the passenger-side headlight to turn in the wrong direction when driving through curves in the road. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A headlight that turns incorrectly can result in increased glare to other road users, increasing the risk of a crash.
Remedy: The headlight control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C12. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2025 Ranger, Lincoln Nautilus, Mustang, Maverick, Explorer, Escape, Lincoln Corsair, Bronco Sport, and Bronco vehicles. The exhaust gas recirculation (EGR) valve may fail, resulting in an unexpected loss of drive power.
Consequence & remedy
Consequence: An unexpected loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the EGR valves, free of charge. Owner notification letters were mailed July 31, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S10. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.
Oct 24, 2025
Ford Motor Company (Ford) is recalling certain 2025-2026 Lincoln Corsair, Lincoln Aviator, and Explorer vehicles. The windshield glass may have visible air bubbles, which can obscure the driver's visibility. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 205, "Glazing Materials."
Consequence & remedy
Consequence: Reduced visibility while driving can increase the risk of a crash.
Remedy: Dealers will inspect and replace the windshield as necessary, free of charge. Owner notification letters were mailed November 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C60. Vehicle Identification Numbers (VINs) involved in this recall become searchable on NHTSA.gov beginning October 27, 2025.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2024-2026 Explorer and 2024-2026 Lincoln Aviator vehicles. The trailer hitch assembly bolts may be loose.
Consequence & remedy
Consequence: While towing a trailer, loose trailer hitch bolts can cause a loss of vehicle handling and control, or cause the trailer to detach. Either of these conditions can increase the risk of a crash.
Remedy: Dealers will inspect and tighten the trailer hitch bolts, or replace them as necessary, free of charge. Owner notification letters were mailed October 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA3. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Aug 22, 2025
Ford Motor Company (Ford) is recalling certain 2025 Explorer and Aviator vehicles. When towing a trailer, the tail lights on the trailer may fail to illuminate due to an improperly manufactured body control module. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer tail lights that do not illuminate as intended can reduce visibility to other drivers, increasing the risk of a crash.
Remedy: Dealers will replace the body control module C on vehicles with less than 9,000 miles. For vehicles over 9,000 miles, dealers will perform a functional check on the body control module C and replace it as necessary. Repairs will be performed free of charge. Aviator 2025 owner notification letters were mailed October 13, 2025. Explorer 2025 owner letters were mailed November 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C42.
Jun 13, 2025
Ford Motor Company (Ford) is recalling certain 2025 Transit, F-150, and Explorer vehicles. The connecting rod and rod bearing components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: A damaged engine can result in engine failure and a stall, increasing the risk of a crash.
Remedy: Dealers will inspect the connecting rods and replace the engine long block assembly as necessary, free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S55.
Jun 13, 2025
Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator, and Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, folding, or sliding unexpectedly while driving.
Consequence & remedy
Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing their risk of injury.
Remedy: Dealers will inspect the second-row seat switch, and replace the bezel around the switch as necessary, free of charge. Owner notification letters were mailed August 7, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S67.
Jun 3, 2025
Ford Motor Company (Ford) is recalling certain 2025 Explorer vehicles. The bolts securing the front brake caliper may not be tightened properly, which can result in a loss of front brake function and possible wheel damage.
Consequence & remedy
Consequence: Loss of brake function and wheel damage can increase the risk of a crash.
Remedy: Dealers will inspect and tighten the bolts as necessary. If bolts are missing, the brake caliper and pads will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed June 19, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S60.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2025 Explorer and Aviator vehicles. A mounting bolt for the front subframe may have been tightened improperly.
Consequence & remedy
Consequence: A loose subframe bolt may reduce the vehicle's performance in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and tighten the subframe bolts as necessary, free of charge. Owners may contact Ford Customer Service at 1-866-436-7332. Owner notification letters were mailed May 21, 2025. Ford's number for this recall is 25S43.
Apr 11, 2025
Ford Motor Company (Ford) is recalling certain 2025 Explorer vehicles. The powertrain control module (PCM) may reset while driving, which can damage the park system or cause an engine stall.
Consequence & remedy
Consequence: A damaged park system can result in a vehicle rollaway when the vehicle is placed in park without the parking brake applied. An engine stall while driving can result in a sudden loss of drive power. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S35.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Bronco, 2024 Ranger, 2025 Mustang, Explorer, and Aviator vehicles. The transmission valve body may have been machined incorrectly, which can cause reverse gear failure, or unexpected forward movement in reverse or neutral gear.
Consequence & remedy
Consequence: Unexpected vehicle movement increases the risk of a crash.
Remedy: Dealers will replace the transmission main control valve body, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S19.
Jan 17, 2025
Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.
Consequence & remedy
Consequence: An improperly secured transmission can result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the transmission cross member bolts as necessary, free of charge. If the cross member bolts are missing, dealers will replace the cross member and install new bolts, free of charge. Owner notification letters were mailed January 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S03.
Additional source detail variants (2)
Structure:frame And Members
Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.
Consequence: An improperly secured transmission can result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the transmission cross member bolts as necessary, free of charge. If the cross member bolts are missing, dealers will replace the cross member and install new bolts, free of charge. Owner notification letters were mailed January 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S03.
Power Train:automatic Transmission
Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.
Consequence: An improperly secured transmission can result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the transmission cross member bolts as necessary, free of charge. If the cross member bolts are missing, dealers will replace the cross member and install new bolts, free of charge. Owner notification letters were mailed January 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S03.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Oct 25, 2024
Ford Motor Company (Ford) is recalling certain 2025 Explorer and Lincoln Aviator vehicles. The rearview camera image may fail when the vehicle speed reaches 10 MPH or greater. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: The loss of the rearview camera image while in reverse can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed on March 28, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C34.
Aug 23, 2024
Ford Motor Company (Ford) is recalling certain 2023 Lincoln Corsair, 2023-2024 Escape, 2024 Mustang, and 2025 Explorer vehicles. The fuel injectors may have been assembled without O-ring support discs, which can result in a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will install new fuel injector O-rings and O-ring support discs, free of charge. Owner notification letters were mailed on October 7, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S54.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration