NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
7 reportsClear category filterMileage unknown · Jun 24, 2026
Electrical SystemEngineFuel/propulsion System
I am reporting a severe safety hazard regarding an immediate, drastic increase in fuel consumption and erratic fuel range calculations following a manufacturer recall repair. My 2025 Ford Explorer ST-Line was operating perfectly until a Ford Mobile Service technician performed safety recall 26S21 (IPMA Reset). According to off…
Read full complaint
I am reporting a severe safety hazard regarding an immediate, drastic increase in fuel consumption and erratic fuel range calculations following a manufacturer recall repair. My 2025 Ford Explorer ST-Line was operating perfectly until a Ford Mobile Service technician performed safety recall 26S21 (IPMA Reset). According to official Ford manufacturer specifications, this SUV has an expected driving range of up to 501 miles on a full 17.9-gallon tank of fuel. However, immediately following this software update, the vehicle's total driving range drastically dropped. On a 100% full tank of gasoline, the dashboard's "Distance to Empty" (DTE) display now only reads 316 miles left to empty—nearly 200 miles below the manufacturer's expected capability. Furthermore, during a subsequent continuous, short 1.8-mile drive near my residence with no stop-and-go traffic, the DTE display rapidly plummeted from 15 miles down to 5 miles remaining, dropping visibly every two seconds. The vehicle is physically burning through gasoline at an accelerated, unsafe rate. This creates an immediate safety risk. If the vehicle is suffering from an uncalibrated software glitch in the powertrain/fuel modules due to the recall update, or if the procedure triggered a mechanical fault, the vehicle is at high risk of a sudden highway stall or leaving the driver stranded in live traffic due to inaccurate fuel signaling. I request that NHTSA look into whether the software installation process for recall 26S21 can corrupt engine/fuel management maps or trigger fuel delivery faults on the 2.3L EcoBoost platform.
NHTSA ODI #11746206
9,000 miles · Mar 5, 2026
Engine
The contact owns a 2025 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle started shaking violently. The check engine warning light came on, and the vehicle lost motive power and stalled. The contact used a scanner to identify an error code. The contact was able to restart the vehicle and …
Read full complaint
The contact owns a 2025 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle started shaking violently. The check engine warning light came on, and the vehicle lost motive power and stalled. The contact used a scanner to identify an error code. The contact was able to restart the vehicle and drove to the residence while driving 20 MPH with the vehicle shaking abnormally. Upon arriving at the residence, the vehicle lost power. The contact called Ford Customer Service and spoke with a Ford Roadside Assistance representative to retrieve the vehicle from the residence. An appointment was scheduled for the dealer to pick up the vehicle at the residence. The vehicle was taken to Ciocco Ford, but was not diagnosed or repaired; however, the spark plugs were replaced but the failure persisted. The manufacturer was made aware of the issue. The approximate failure mileage was 9,000.
NHTSA ODI #11722319
Mileage unknown · Feb 11, 2026
Electrical SystemEngineService Brakes
I am writing to formally report a series of catastrophic and life-threatening mechanical and electronic failures in my 2025 Ford Explorer Active (VIN: [XXX] ]), purchased in Bogotá, Colombia. Despite immediately notifying the Ford Post-Sales Support Line after the first incident, the technical response was insufficient, leading…
Read full complaint
I am writing to formally report a series of catastrophic and life-threatening mechanical and electronic failures in my 2025 Ford Explorer Active (VIN: [XXX] ]), purchased in Bogotá, Colombia. Despite immediately notifying the Ford Post-Sales Support Line after the first incident, the technical response was insufficient, leading to a second, more severe event that nearly resulted in a fatal high-speed collision on February 9, 2026. Incidents Summary: 1. Total Power Loss: Engine and all electrical systems shut down while in motion (40 km/h), losing steering and braking assistance. 2. Brake System Failure: At 70 km/h, The vehicle presented a multi-system failure of sensors, audible alarm and illumination of warning lights (ABS, Traction Control, Pre-collision Assistant, hill start assist not available, check brake system, BRAKE, ESC check, driving modes not available). the vehicle experienced a total loss of brake pedal response followed by a sudden, uncontrolled autonomous "hard braking" event. This happened on a high-traffic highway (Autopista Norte). Global Safety Concern: I am formally requesting a Global Technical Investigation into this unit and the 2025 Explorer Active series. The failure of the electronic brake booster and the total system shutdown represent a "Product Liability" risk that could lead to mass-casualty events. I demand: • Direct intervention from Ford Global to Ford Colombia. • A formal safety alert or recall investigation for similar units. Sincerely, [XXX] MAIL [XXX] bogota colombia phone [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11717439
Mileage unknown · Dec 5, 2025
EngineUnknown Or Other
12 V Battery continues to die and I've had the car less than a year. On [XXX] the battery was dead. Our neighbor put it on his supercharger. On [XXX] the 12V battery low light came on while I was driving 30 miles away. It went off the next day and reappeared on Thursday [XXX] disappeared on Friday and back on Saturday. I called…
Read full complaint
12 V Battery continues to die and I've had the car less than a year. On [XXX] the battery was dead. Our neighbor put it on his supercharger. On [XXX] the 12V battery low light came on while I was driving 30 miles away. It went off the next day and reappeared on Thursday [XXX] disappeared on Friday and back on Saturday. I called the Future Ford on Monday and technician [XXX] said it only showed 15% charge. I took it in to the dealership and it was kept over night and the next day he said it was charged to 90%. I was not happy with the "you can come and get it". I told him I'm a [XXX] and bought this car so I wouldn't breakdown and now I don't feel safe with it. He checked the charge again while we were on the phone and he said it dropped to 80%. He said thats not good it will probably need a new battery. That evening he text and said it is fully charged and I can come get it without a new battery. I was not happy as I've received no reason for why it was losing charge. So I did some research on my on and text him back that evening. I told him about my research and found this was an ongoing problem and that they need to find out what is causing the draining issue. I'm sure the dealership had to know as there was a recall for this issue. I suggested a Parasitic test, or software glitch issues to check. He said they would run the parasitic test.. He said it would take several days. I checked back on 12/4/25 and he said No Progress today. I told him I want a copy of all the test run. Wouldn't you know it he gets right back to me saying a handful of modules need updated software. That they will attend them this morning. I think they were trying to get out of the fix as my warranty runs out this month. Why are only certain vehicles being recalled (mine not one of them), when they all should be recalled. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11703309
Mileage unknown · Oct 14, 2025
EnginePower Train
My 2025 Ford Explorer ST-Line is up to date on recalls as of October 7, 2025. However, I am still experiencing engine "shudder" and hesitation at low RPMs (between idle and 1500 RPM) when accelerating. The 10 speed transmission is also continuing to shift harshly at times. I am very concerned that the hesitation and shudder c…
Read full complaint
My 2025 Ford Explorer ST-Line is up to date on recalls as of October 7, 2025. However, I am still experiencing engine "shudder" and hesitation at low RPMs (between idle and 1500 RPM) when accelerating. The 10 speed transmission is also continuing to shift harshly at times. I am very concerned that the hesitation and shudder could be an issue when pulling out into traffic. By comparison, my previous 2017 Explorer did not exhibit this behavior, whichh I consider disconcerting. Also, this car (and all 2025 Explorer models ) injects Fake Engine Noise into the audio speakers to make the 2.5L engine sound more powerful. These fake "bass tones" are disturbing to some passengers with hearing aides, and per Ford's website there is no way to disable the fake noise. Thus, some people with a hearing disability cannot ride in my car without removing their hearing aides. It should be unacceptable to not be able to disable that feature. Note updated form dated 8/1/25 states Fake Noise cannot be turned off.
NHTSA ODI #11693380
Mileage unknown · Jun 9, 2025
Electrical SystemEngineService Brakes
6/2/25 tried to start vehicle, codes coming up and car would not start 6/6/25 car was in park running, starting chiming with alarms, the same alarms that came up a few days before.
NHTSA ODI #11665745
Mileage unknown · Feb 27, 2025
Electrical SystemEngineForward Collision Avoidance
While driving on an interstate with my children, my automatic braking system decided their was something in front of my car when there wasn't and slammed on the brakes. There was a semi truck behind us and it almost hit us. Took it to the dealer and all they did was shut the feature off for automatic braking. The interior screen…
Read full complaint
While driving on an interstate with my children, my automatic braking system decided their was something in front of my car when there wasn't and slammed on the brakes. There was a semi truck behind us and it almost hit us. Took it to the dealer and all they did was shut the feature off for automatic braking. The interior screens have been reprogrammed twice to fix glitches. the rear hatch has been reprogrammed. The windows continue to randomly roll up and down on their own. My engine decided to not start for an hr before randomly turning on for no reason. And to top it all off the windshield washer fluid no longer wants to work.
NHTSA ODI #11645436
Official recalls
20Jul 21, 2026
Ford Motor Company (Ford) is recalling certain 2025-2027 Explorer and Lincoln Aviator vehicles. An unoccupied driver's seat may recline unintentionally during certain scenarios, such as remote unlock or remote start.
Consequence & remedy
Consequence: Unexpected movement of the driver’s seat back may trap a second-row occupant, increasing the risk of injury.
Remedy: Dealers will disable the driver seat module (DSM) feature until parts are available. Once available, the motor will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S53.
Jul 14, 2026
Ford Motor Company (Ford) is recalling certain 2020-2027 Aviator and 2020-2026 Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, tipping, or sliding unexpectedly.
Consequence & remedy
Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the bezel around the switch as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters explaining the safety risk were mailed August 19, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Lincoln Aviator owner notification letters were mailed August 21, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S52. This recall expands Recall 25V393. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
May 27, 2026
Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer, Ranger, and Bronco vehicles. The engine may fail, which can result in a loss of drive power.
Consequence & remedy
Consequence: A sudden loss of drive power can increase the risk of a crash.
Remedy: Dealers will replace the engine long block, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2026. Additional letters will be sent once the remedy is available, anticipated in November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S35. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 28, 2026.
Mar 18, 2026
Ford Motor Company (Ford) is recalling certain 2022-2025 Lincoln Navigator, 2024-2025 Lincoln Nautilus, 2025 Lincoln Aviator and Explorer vehicles. The Image Processing Module A (IPMA) may experience multiple unexpected resets, resulting in loss of the rearview camera image and advanced driver assistance (ADAS) features, including pre-collision assist, lane-keeping assist, and blind-spot monitoring.
Consequence & remedy
Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.
Remedy: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.
Additional source detail variants (2)
Back Over Prevention:software
Ford Motor Company (Ford) is recalling certain 2022-2025 Lincoln Navigator, 2024-2025 Lincoln Nautilus, 2025 Lincoln Aviator and Explorer vehicles. The Image Processing Module A (IPMA) may experience multiple unexpected resets, resulting in loss of the rearview camera image and advanced driver assistance (ADAS) features, including pre-collision assist, lane-keeping assist, and blind-spot monitoring.
Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.
Remedy: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.
Electrical System:adas
Ford Motor Company (Ford) is recalling certain 2022-2025 Lincoln Navigator, 2024-2025 Lincoln Nautilus, 2025 Lincoln Aviator and Explorer vehicles. The Image Processing Module A (IPMA) may experience multiple unexpected resets, resulting in loss of the rearview camera image and advanced driver assistance (ADAS) features, including pre-collision assist, lane-keeping assist, and blind-spot monitoring.
Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.
Remedy: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.
Mar 17, 2026
Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.
Consequence & remedy
Consequence: A loose seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C18. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer vehicles. The Dynamic Bending Light (DBL) system software may cause the passenger-side headlight to turn in the wrong direction when driving through curves in the road. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A headlight that turns incorrectly can result in increased glare to other road users, increasing the risk of a crash.
Remedy: The headlight control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C12. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2025 Ranger, Lincoln Nautilus, Mustang, Maverick, Explorer, Escape, Lincoln Corsair, Bronco Sport, and Bronco vehicles. The exhaust gas recirculation (EGR) valve may fail, resulting in an unexpected loss of drive power.
Consequence & remedy
Consequence: An unexpected loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the EGR valves, free of charge. Owner notification letters were mailed July 31, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S10. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.
Oct 24, 2025
Ford Motor Company (Ford) is recalling certain 2025-2026 Lincoln Corsair, Lincoln Aviator, and Explorer vehicles. The windshield glass may have visible air bubbles, which can obscure the driver's visibility. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 205, "Glazing Materials."
Consequence & remedy
Consequence: Reduced visibility while driving can increase the risk of a crash.
Remedy: Dealers will inspect and replace the windshield as necessary, free of charge. Owner notification letters were mailed November 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C60. Vehicle Identification Numbers (VINs) involved in this recall become searchable on NHTSA.gov beginning October 27, 2025.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2024-2026 Explorer and 2024-2026 Lincoln Aviator vehicles. The trailer hitch assembly bolts may be loose.
Consequence & remedy
Consequence: While towing a trailer, loose trailer hitch bolts can cause a loss of vehicle handling and control, or cause the trailer to detach. Either of these conditions can increase the risk of a crash.
Remedy: Dealers will inspect and tighten the trailer hitch bolts, or replace them as necessary, free of charge. Owner notification letters were mailed October 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA3. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Aug 22, 2025
Ford Motor Company (Ford) is recalling certain 2025 Explorer and Aviator vehicles. When towing a trailer, the tail lights on the trailer may fail to illuminate due to an improperly manufactured body control module. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer tail lights that do not illuminate as intended can reduce visibility to other drivers, increasing the risk of a crash.
Remedy: Dealers will replace the body control module C on vehicles with less than 9,000 miles. For vehicles over 9,000 miles, dealers will perform a functional check on the body control module C and replace it as necessary. Repairs will be performed free of charge. Aviator 2025 owner notification letters were mailed October 13, 2025. Explorer 2025 owner letters were mailed November 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C42.
Jun 13, 2025
Ford Motor Company (Ford) is recalling certain 2025 Transit, F-150, and Explorer vehicles. The connecting rod and rod bearing components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: A damaged engine can result in engine failure and a stall, increasing the risk of a crash.
Remedy: Dealers will inspect the connecting rods and replace the engine long block assembly as necessary, free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S55.
Jun 13, 2025
Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator, and Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, folding, or sliding unexpectedly while driving.
Consequence & remedy
Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing their risk of injury.
Remedy: Dealers will inspect the second-row seat switch, and replace the bezel around the switch as necessary, free of charge. Owner notification letters were mailed August 7, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S67.
Jun 3, 2025
Ford Motor Company (Ford) is recalling certain 2025 Explorer vehicles. The bolts securing the front brake caliper may not be tightened properly, which can result in a loss of front brake function and possible wheel damage.
Consequence & remedy
Consequence: Loss of brake function and wheel damage can increase the risk of a crash.
Remedy: Dealers will inspect and tighten the bolts as necessary. If bolts are missing, the brake caliper and pads will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed June 19, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S60.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2025 Explorer and Aviator vehicles. A mounting bolt for the front subframe may have been tightened improperly.
Consequence & remedy
Consequence: A loose subframe bolt may reduce the vehicle's performance in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and tighten the subframe bolts as necessary, free of charge. Owners may contact Ford Customer Service at 1-866-436-7332. Owner notification letters were mailed May 21, 2025. Ford's number for this recall is 25S43.
Apr 11, 2025
Ford Motor Company (Ford) is recalling certain 2025 Explorer vehicles. The powertrain control module (PCM) may reset while driving, which can damage the park system or cause an engine stall.
Consequence & remedy
Consequence: A damaged park system can result in a vehicle rollaway when the vehicle is placed in park without the parking brake applied. An engine stall while driving can result in a sudden loss of drive power. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S35.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Bronco, 2024 Ranger, 2025 Mustang, Explorer, and Aviator vehicles. The transmission valve body may have been machined incorrectly, which can cause reverse gear failure, or unexpected forward movement in reverse or neutral gear.
Consequence & remedy
Consequence: Unexpected vehicle movement increases the risk of a crash.
Remedy: Dealers will replace the transmission main control valve body, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S19.
Jan 17, 2025
Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.
Consequence & remedy
Consequence: An improperly secured transmission can result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the transmission cross member bolts as necessary, free of charge. If the cross member bolts are missing, dealers will replace the cross member and install new bolts, free of charge. Owner notification letters were mailed January 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S03.
Additional source detail variants (2)
Structure:frame And Members
Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.
Consequence: An improperly secured transmission can result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the transmission cross member bolts as necessary, free of charge. If the cross member bolts are missing, dealers will replace the cross member and install new bolts, free of charge. Owner notification letters were mailed January 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S03.
Power Train:automatic Transmission
Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.
Consequence: An improperly secured transmission can result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the transmission cross member bolts as necessary, free of charge. If the cross member bolts are missing, dealers will replace the cross member and install new bolts, free of charge. Owner notification letters were mailed January 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S03.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Oct 25, 2024
Ford Motor Company (Ford) is recalling certain 2025 Explorer and Lincoln Aviator vehicles. The rearview camera image may fail when the vehicle speed reaches 10 MPH or greater. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: The loss of the rearview camera image while in reverse can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed on March 28, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C34.
Aug 23, 2024
Ford Motor Company (Ford) is recalling certain 2023 Lincoln Corsair, 2023-2024 Escape, 2024 Mustang, and 2025 Explorer vehicles. The fuel injectors may have been assembled without O-ring support discs, which can result in a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will install new fuel injector O-rings and O-ring support discs, free of charge. Owner notification letters were mailed on October 7, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S54.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration