IllustrationDashboard separation concerned with airbag. Every day driving you run the risk of more damage. Have spoken to Koons Ford who states cannot help due to warranty. No one has looked at it except for pictures. This should not be the owners responsibility since I am not alone with issues of this problem
2021 Ford Explorer
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2021 Ford Explorer do not stand out strongly from the model-year median of 609.
About this comparison →How this year compares
Owner complaints by model year
Compare all Explorer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 101 of 422 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 120 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 47 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports5 fire reports14 injury reports
Structure complaints
23 reportsThe top of dashboard is lifting up and coming apart on drivers side.
I am reporting a safety incident involving a 2021 Ford Explorer. While driving at normal speed, the hood unexpectedly flew open and struck the windshield, completely obstructing visibility and causing damage. I did not open the hood prior to driving, and there were no prior warnings or indications of failure. The incident sugge…
Read full complaint
I am reporting a safety incident involving a 2021 Ford Explorer. While driving at normal speed, the hood unexpectedly flew open and struck the windshield, completely obstructing visibility and causing damage. I did not open the hood prior to driving, and there were no prior warnings or indications of failure. The incident suggests a possible hood latch or secondary safety latch malfunction. I am submitting this report due to a serious safety concern involving sudden loss of driver visibility.
Recently purchased a vehicle that had just previously got a recall 23S55 3 weeks prior. Upon receiving the vehicle there was a slight clicking noise when going into gear. i took the vehicle to a ford dealer and they investigated the recall remedy was installed improper from the dealership and the vehicle was unsafe to drive the …
Read full complaint
Recently purchased a vehicle that had just previously got a recall 23S55 3 weeks prior. Upon receiving the vehicle there was a slight clicking noise when going into gear. i took the vehicle to a ford dealer and they investigated the recall remedy was installed improper from the dealership and the vehicle was unsafe to drive the rear subframe of the car moves and has free play which made is very unsafe to drive . . While calling the dealership back that did the recall work they refused to take responsibility . i then put in a repair order through ford and they denied repairs for the recall mishap . I am being stuck with a $3500 bill for a recall that was installed improper.
Dashboard not attached to frame. Clips intended to attach dashboard to frame are defective (cracked in half). Air bags may be affected (either won't deploy or will deploy on their own). Service Dept. at Ford dealership says this is the first case they've seen and repairing it would cost $$$. This vehicle has been regularly m…
Read full complaint
Dashboard not attached to frame. Clips intended to attach dashboard to frame are defective (cracked in half). Air bags may be affected (either won't deploy or will deploy on their own). Service Dept. at Ford dealership says this is the first case they've seen and repairing it would cost $$$. This vehicle has been regularly maintained and has 0 history of accidents. It is unknown if this defect has existed from the date the car was purchase(or earlier).
Roof window cover/headliner has come loose and is impeding full vision to the rear of the car while the headliner is retracted.
The contact owns a 2021 Ford Explorer. The contact stated that there was a 15x3/4-inch strip on the B-pillar trim of the driver's side rear door that was detaching from the vehicle. The vehicle was taken to the dealer, who attempted to use adhesive to secure the trim piece; however, the temporary repair failed to fix the vehicle…
Read full complaint
The contact owns a 2021 Ford Explorer. The contact stated that there was a 15x3/4-inch strip on the B-pillar trim of the driver's side rear door that was detaching from the vehicle. The vehicle was taken to the dealer, who attempted to use adhesive to secure the trim piece; however, the temporary repair failed to fix the vehicle. The dealer determined that the entire B-pillar trim needed to be replaced. The vehicle was not repaired. Additionally, the contact became aware that the B-pillar trim on the passenger's side rear door had started to detach. The contact informed the manufacturer of the failure. The contact was informed that the VIN was not included in NHTSA Campaign Number: 25V347000 (Structure). The manufacturer advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 65,000.
The contact owns a 2021 Ford Explorer. The contact stated that upon inspecting the vehicle, the contact noticed that there was a gap between the body and the frame on the passenger's side of the vehicle. The vehicle was not diagnosed or repaired by a dealer or an independent mechanic. The manufacturer was notified of the failure…
Read full complaint
The contact owns a 2021 Ford Explorer. The contact stated that upon inspecting the vehicle, the contact noticed that there was a gap between the body and the frame on the passenger's side of the vehicle. The vehicle was not diagnosed or repaired by a dealer or an independent mechanic. The manufacturer was notified of the failure, and a case was filed. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 74,000.
The chrome on the window switch on the passenger side is peeling and cut my finger while using it.
I was backing out of my driveway and a whoosh of water came pouring into my trunk from my roof of my car. When I took it to the Ford dealership they took the headliner down and found that the drains for my sunroof were clogged and caused the leak. They found that the headliner had mold growing on it. This is currently not a reca…
Read full complaint
I was backing out of my driveway and a whoosh of water came pouring into my trunk from my roof of my car. When I took it to the Ford dealership they took the headliner down and found that the drains for my sunroof were clogged and caused the leak. They found that the headliner had mold growing on it. This is currently not a recall issue yet but I believe it should be or should be considered a default from Ford, (my warranty expired a couple months earlier). After speaking with the maintenance manager at Ford, I have been informed that it is not uncommon that the sunroof drains get clogged and this is something that should be checked or cleaned out periodically. With that being said- my 3 year old vehicle has only been maintained at a Ford dealership during its life. I go every 3-4 months and this has never been checked or cleaned out. My vehicle has been at the dealership for 3 months now because the parts are on back order. When I spoke with the dealership on 12/18 I was told there were 16 headliners on order, but when I checked back in January (a month later) there were 437 on order. This seems to be an issue with more and more of these vehicles. This is a dangerous situation because I do not know how long the mold has been growing in my vehicle and could cause health issues with me or my kids.
Official recalls
2626V451000 · Seats:mid/rear Assembly
Jul 14, 2026
Ford Motor Company (Ford) is recalling certain 2020-2027 Aviator and 2020-2026 Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, tipping, or sliding unexpectedly.
Consequence & remedy
Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the bezel around the switch as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters explaining the safety risk were mailed August 19, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Lincoln Aviator owner notification letters were mailed August 21, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S52. This recall expands Recall 25V393. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
26V402000 · Power Train:automatic Transmission
Jun 24, 2026
Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.
Consequence & remedy
Consequence: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.
26V159000 · Seat Belts
Mar 17, 2026
Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.
Consequence & remedy
Consequence: A loose seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C18. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.
26V117000 · Visibility:windshield Wiper/washer:motor
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer, Escape, Lincoln Aviator, and Lincoln Corsair vehicles. The windshield wiper motor may fail and prevent the windshield wipers from operating properly.
Consequence & remedy
Consequence: Windshield wipers that fail to operate properly can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the front wiper motors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed April 2, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S14. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.
26V123000 · Back Over Prevention:software
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An incorrectly displayed rearview image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the accessory protocol interface module (APIM) software, free of charge. Owner notification letters were mailed June 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
25V685000 · Equipment:electrical:engine Block Heater
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
25V455000 · Fuel System, Gasoline:delivery:fuel Pump
Jul 7, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
25V442000 · Back Over Prevention:software
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
25V393000 · Seats:mid/rear Assembly
Jun 13, 2025
Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator, and Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, folding, or sliding unexpectedly while driving.
Consequence & remedy
Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing their risk of injury.
Remedy: Dealers will inspect the second-row seat switch, and replace the bezel around the switch as necessary, free of charge. Owner notification letters were mailed August 7, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S67.
25V159000 · Back Over Prevention:software
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 23V-342. The video output may fail, preventing the rearview camera image from displaying.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the Image Processing Module software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S27.
25V166000 · Power Train:driveline:driveshaft
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles previously repaired incorrectly under recall numbers 23V-199 or 22V-255. The rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Consequence & remedy
Consequence: A disconnected driveshaft can result in vehicle rollaway when the vehicle is placed in park without the parking brake applied. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S22.
25V093000 · Seat Belts
Feb 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer and Aviator vehicles. The seat belt buckle anchor bolts at one or more seating positions may be improperly secured. Additionally, vehicles may have an improperly secured seat belt retractor anchor bolt and/or seat belt anchor bolt at the second-row center seating position, if equipped.
Consequence & remedy
Consequence: A loose seat belt or seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect seat belt buckle anchor bolts in all seating positions. Additionally, dealers will inspect the seat belt retractor anchor bolt and seat belt anchor bolt at the second-row center seating position, if equipped. If loose anchor bolts are found, the affected seat components will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed on June 5, 2025. Owners may contact Ford customer service at 866-436-7332. Ford's number for this recall is 25S09.
24V852000 · Equipment:other:labels
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
24V635000 · Engine And Engine Cooling:engine:hard Parts Internal/mechanical
Aug 23, 2024
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.
24V598000 · Engine
Aug 9, 2024
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with the Police Interceptor Utility Package. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as promptly as possible upon hearing unexpected engine noises, or after experiencing an unexpected engine power reduction, or seeing smoke from the engine compartment. Dealers will update the Powertrain Control Module (PCM) software. In addition, dealers will inspect for connecting rod bearing failure and if necessary, replace the engine long block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S52.
23V675000 · Power Train:driveline:driveshaft
Oct 6, 2023
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles. The rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Consequence & remedy
Consequence: A disconnected driveshaft can result in a loss of drive power or a vehicle rollaway if the parking brake is not applied. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will replace the subframe bushing and rear axle bolt. They will also inspect the rear axle cover for damage near the bolt hole location and replace with a new cover if any damage is found. Repairs will be performed free of charge. Owner notification letters were mailed January 19, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S55.
23V626000 · Electrical System:propulsion System:traction Battery
Sep 8, 2023
Ford Motor Company (Ford) is recalling certain 2020-2022 Lincoln Aviator and Ford Explorer vehicles equipped with 3.0L PHEV engines. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Consequence & remedy
Consequence: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.
Remedy: Dealers will perform a Battery Energy Control Module (BECM) diagnostic test and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on April 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford Motor Company's number for this recall is 23S53.
23V342000 · Back Over Prevention: Sensing System: Camera
May 12, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will replace the 360-degree camera, free of charge. Owner notification letters were mailed November 10, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S23. This recall expands and replaces NHTSA recall number 23V-022. Vehicles previously repaired under 23V-022 will need to have the new remedy performed.
23V305000 · Back Over Prevention:display Function
Apr 28, 2023
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer Police Interceptor Utility vehicles equipped with a 12.1-inch Integrated Computer Screen (ICS). When the Display On/Off Button is used to turn the display to "Off" prior to placing the vehicle in reverse, the backup camera rearview image will not appear on the display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera that does not display an image can reduce the driver's rear view, increasing the risk of a crash or injury.
Remedy: Dealers will update the ICS software, free of charge. Owner notification letters were mailed July 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C14.
23V199000 · Parking Brake:electrical; Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Mar 24, 2023
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Consequence & remedy
Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.
Additional source detail variants (2)
Parking Brake:electrical
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.
Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L RWD, 3.3L GAS, 3.3L FHEV, or 3.0L ST powertrain. The previous powertrain control module (PCM) update completed under recall 22V-255 did not include the automatic electronic parking brake feature when the vehicle is shifted to park, as intended. In addition, the rear axle horizontal mounting bolt may fracture and cause the driveshaft to disconnect.
Consequence: Without the electronic parking brake applied, the vehicle could rollaway if the driveshaft disconnects. A disconnected driveshaft can also result in a loss of drive power. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will update the PCM software, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S16.
23V069000 · Power Train:automatic Transmission:control Module (tcm/pcm/tecm)
Feb 10, 2023
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer vehicles equipped with a 2.3L engine and 10R60 automatic transmission. An unintentional powertrain control module (PCM) reset may occur while the vehicle is in motion and result in park system damage.
Consequence & remedy
Consequence: A park system that is damaged may not shift into "PARK," resulting in a vehicle rollaway and increasing the risk of injury or crash.
Remedy: Dealers will inspect the park system for damage and repair as necessary, free of charge. Owner notification letters were mailed March 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S05.
23V022000 · Back Over Prevention: Sensing System: Camera
Jan 23, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.
Consequence & remedy
Consequence: Loss of the rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will update the image processing module (IPMB) software, free of charge. Interim owner notification letters informing owners of the safety risk were mailed April 25, 2023. Owner notification letters were mailed February 13, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S02. This recall expands and replaces NHTSA recall number 21V-735. Vehicles previously repaired under 21V-735 will need to have the new remedy performed.
21V870000 · Suspension:rear
Nov 10, 2021
Ford Motor Company (Ford) is recalling certain 2021 Explorer and Lincoln Aviator vehicles. Incorrect rear suspension module components may have been installed due to a labeling error.
Consequence & remedy
Consequence: A rear suspension module with incorrect components may affect vehicle handling, ride height, and braking characteristics, increasing the risk of a crash.
Remedy: Dealers will inspect the rear suspension module, and replace any incorrect parts, as necessary, free of charge. Owner notification letters were mailed December 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S47.
21V735000 · Back Over Prevention: Sensing System: Camera; Back Over Prevention:software
Sep 22, 2021
Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer, Lincoln Corsair, and Lincoln Aviator vehicles equipped with 360-degree cameras. The video output may fail, preventing the rearview camera image from displaying.
Consequence & remedy
Consequence: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will update the Image Processing Module (IPMB) software, free of charge. Owner notification letters were mailed November 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S44.
Additional source detail variants (2)
Back Over Prevention:software
Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer, Lincoln Corsair, and Lincoln Aviator vehicles equipped with 360-degree cameras. The video output may fail, preventing the rearview camera image from displaying.
Consequence: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will update the Image Processing Module (IPMB) software, free of charge. Owner notification letters were mailed November 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S44.
Back Over Prevention: Sensing System: Camera
Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer, Lincoln Corsair, and Lincoln Aviator vehicles equipped with 360-degree cameras. The video output may fail, preventing the rearview camera image from displaying.
Consequence: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will update the Image Processing Module (IPMB) software, free of charge. Owner notification letters were mailed November 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S44.
21V652000 · Air Bags:critical Fasteners; Air Bags:side/window:curtain
Aug 23, 2021
Ford Motor Company (Ford) is recalling certain 2021 Explorer and Lincoln Aviator vehicles. The side air bag attachment weld studs could detach during the deployment of the side air bag, resulting in an improper deployment. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard 214, "Side Impact Protection".
Consequence & remedy
Consequence: Improper deployment of a side air bag increases the risk of injury during a crash.
Remedy: Dealers will replace the side air bag assemblies, free of charge. Owner notification letters were mailed September 10, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C19.
Additional source detail variants (2)
Air Bags:side/window:curtain
Ford Motor Company (Ford) is recalling certain 2021 Explorer and Lincoln Aviator vehicles. The side air bag attachment weld studs could detach during the deployment of the side air bag, resulting in an improper deployment. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard 214, "Side Impact Protection".
Consequence: Improper deployment of a side air bag increases the risk of injury during a crash.
Remedy: Dealers will replace the side air bag assemblies, free of charge. Owner notification letters were mailed September 10, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C19.
Air Bags:critical Fasteners
Ford Motor Company (Ford) is recalling certain 2021 Explorer and Lincoln Aviator vehicles. The side air bag attachment weld studs could detach during the deployment of the side air bag, resulting in an improper deployment. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard 214, "Side Impact Protection".
Consequence: Improper deployment of a side air bag increases the risk of injury during a crash.
Remedy: Dealers will replace the side air bag assemblies, free of charge. Owner notification letters were mailed September 10, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C19.
20V788000 · Engine
Dec 17, 2020
Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer and Lincoln Aviator vehicles. The right hand motor mount fasteners may have been incorrectly tightened, and may loosen over time.
Consequence & remedy
Consequence: With a loose motor mount, motor vibration may cause the axle to disconnect from the engine and could result in loss of power, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will remove and replace the right hand motor mount fasteners, free of charge. The recall began February 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S72.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA23002 · Loss Of Motive Power
Opened Sep 29, 2023 · Closed Oct 31, 2024
Status: closed (inferred from source dates) · Engine
On July 22, 2022, the Office of Defects Investigation (ODI) granted a Defect Petition (DP22001) and opened a Preliminary Evaluation (PE22007) to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco vehicles equipped with 2.7L EcoBoost engines. Complainants were reporting sudden engine failure while driving resulting in a loss of motive power, often without the ability to restart. During PE22007, the cause of engine failure and loss of motive power in the subject vehicles was determined to be intake valve fracture, and the full scope of vehicles affected by the subject defect was identified as all MY 2021-2022 Ford and Lincoln models equipped with either the 2.7L or 3.0L EcoBoost engines, referred to as the “Nano” engine family. If an intake valve fractures in the subject engines, it may drop into the cylinder and contact the piston, often resulting in catastrophic engine damage. On September 29, 2023, PE22007 was upgraded to an Engineering Analysis (EA23002) to further investigate the subject defect across the full scope of affected vehicles. During EA23002, ODI visited Ford facilities to review technical information related to intake valve fracture in “Nano” engines, coordinated with NHTSA’s Vehicle Research and Testing Center (VRTC), and analyzed updated field data relating the subject defect. Forensic analysis of fractured intake valves demonstrated that the defective components exhibited “grinding burn” or out of specification hardness in the area of the keeper grooves. The presence of grinding burn is evidence that during the groove grinding phase of production, the temperature of the valve became sufficiently high to alter the microstructure of the material and is indicative that the valve supplier’s manufacturing processes were not within control specifications. Grinding burn results in a hard, brittle microstructure and high residual stresses toward the surface of the valve. Through normal engine loading, a valve with grinding burn will likely fracture at the area of highest vulnerability, which is the third keeper groove. In its response to the EA23002 Information Request (IR) letter, Ford provided evidence of 396 customer complaints (including field reports), 825 warranty claims, and 936 engine exchanges. When considering both ODI and manufacturer failure report data, there have been reports representing 1066 unique vehicles within the subject vehicle population. Analysis of the failure report data demonstrates that vehicles equipped with potentially defective intake valves were built within a production “spike period” of May 2021 – October 2021. The beginning of the spike period corresponds to a ramp up in production at the valve supplier manufacturing facility, and the end of the spike period aligns with the implementation of several mid-production process improvements and the decision to change the metal alloy used to produce intake valves from “Silchrome Lite” to “Silchrome 1”. Ford began investigating the subject defect in July 2021, determined the root cause, and took corrective measures for the new production vehicles. Analysis of the failure report data demonstrates that these corrective actions were successful in eliminating the risk of intake valve fracture for subject vehicles produced after October 2021. However, Ford did not take any field action to address vehicles produced during the spike period, and in the several months following the implementation of the production changes, a significant number of field failures continued to occur. It is Ford’s assessment that not all valves produced during the spike period are defective, and that failures associated with the subject defect occur at low time in service. Analysis of the failure report data demonstrates that the vast majority of failures have occurred before 20,000 miles with over half of all reported failures occurring before 5,000 miles. The rate of reported failures related to the subject defect has steadily decreased since November 2021. ODI coordinated with NHTSA’s National Center for Statistics and Analysis (NCSA) to conduct statistical analysis and predict the number of future failures associated with the subject defect. The results of this analysis, and the trends identified through the failure report data are generally consistent with Ford’s assessment that defective intake valves will likely fail at a low time in service and indicate that the majority of subject vehicles equipped with defective valves have already experienced a failure. On August 23, 2024, Ford submitted recall 24V635 for subject vehicles equipped with “Nano” engines and built within the production spike period identified above (total population 90,736 vehicles). The remedy includes an inspection at a Ford/Lincoln dealership where the lifetime engine cycles of the vehicle will be determined. If a vehicle does not meet a threshold for lifetime engine cycles, the dealership will conduct a high RPM engine cycle accumulation procedure, which aims to identify if the vehicle is equipped with defective intake valves. Any vehicle that fails the accumulation procedure will receive an engine replacement under the recall. In addition to recall 24V635, Ford has stated that it will launch customer satisfaction campaign 24N12, which will provide extended warranty coverage to the subject vehicles through the earlier of 10 years or 150,000 miles. In view of the recall action being taken by Ford, ODI is closing this Engineering Analysis. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ23002 · Rear Axle Bolt Failure
Opened Jun 20, 2023 · Closed Feb 15, 2024
Status: closed (inferred from source dates) · Power Train:axle Assembly; Power Train:driveline:differential Unit
On July 17, 2023, the Office of Defect Investigation (ODI) opened this Recall Query (RQ) after receiving 2 consumer complaints alleging loss of vehicle forward power and/or loss of transmission torque of the rear wheels in model year (MY) 2020-2022 Ford Explorer vehicles (subject vehicles). The RQ was opened to focus on the effectiveness of the remedies of Recalls 22V-255 and 23V-199 related to the alleged problem. Recall 22V-255 involved replacing the bushing and axle cover in the following subject vehicles: 3.3L FHEV Police built before October 14, 2020, and 3.3L Gas Police vehicle built before January 31, 2021. For 2.3L RWD, 3.0L PHEV, 3.3LFHEV, and 3.0LST retail (non-police) vehicles, the recall provided an PCM software update to engage the Electronic Park Brake (EPB) when Park is commanded. The recall addressed a breakage of the rear axle bolt that can cause the driveshaft/half shafts to disconnect, resulting in a loss of transmission torque to the rear wheels necessary to hold park. If the parking brake is not applied, the loss of the primary park torque will allow the vehicle to roll in park increasing the risk of crash and injury. Recall 23V-199 addressed 674 of the subject vehicles produced from February 2, 2019 to April 4, 2022, which received an incorrect remedy under Recall 22V-255. The affected vehicles had received a previous Powertrain Control Module (PCM) update which did not include an automatic EPB engagement when vehicle is shifted to park. On October 17, 2023, Ford filed a new safety recall (Recall 23V-675) covering 238,364 MY 2020-2022 Explorer vehicles with the following powertrains: 3.3L FHEV Police, 3.3L Gas Police, 3.0L Gas Police, 2.3L RWD, 3.0L PHEV, 3.3L FHEV, 3.0L RWD and 3.0L AWD, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. Ford stated that the cause of the bolt fracture is due to joint design not robust to peak axle input torques and manufacturing variability. The primary contributor is insufficient bearings for maximum joint loads. This can result in bearing deformation, increasing bending stress on the bolt, which may lead to fatigue failure. On January 19, 2023, Ford amended Recall 23V-675 to add 1,942 MY 2020-2022 Explorer vehicles with the following powertrain: 3.0L RWD Platinum and King Ranch variant, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. In addition to the safety recall, Ford will conduct a customer satisfaction program for the following MY 2020-2022 Explorer vehicles with the following powertrains: 2.3L AWD, 3.3L Gas Retail, 3.0L Gas AWD Platinum and King Ranch, produced from October 22, 2018 to July 6, 2022. Ford stated that the Explorer powerpack variants not covered under Recalled 23V-675 do not present an unreasonable risk to motor vehicle safety due to the combination of lower peak torque levels and torque management strategies to share inputs between front and rear axles, reducing occurrence of higher torque. According to Ford, this is also evidenced by the lower current and projected failure rates. In view of the recall action being taken by Ford, ODI is closing this RQ. NHTSA will continue to monitor complaints from the customer satisfaction program vehicles and reopen this issue, if necessary. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Power Train:axle Assembly
On July 17, 2023, the Office of Defect Investigation (ODI) opened this Recall Query (RQ) after receiving 2 consumer complaints alleging loss of vehicle forward power and/or loss of transmission torque of the rear wheels in model year (MY) 2020-2022 Ford Explorer vehicles (subject vehicles). The RQ was opened to focus on the effectiveness of the remedies of Recalls 22V-255 and 23V-199 related to the alleged problem. Recall 22V-255 involved replacing the bushing and axle cover in the following subject vehicles: 3.3L FHEV Police built before October 14, 2020, and 3.3L Gas Police vehicle built before January 31, 2021. For 2.3L RWD, 3.0L PHEV, 3.3LFHEV, and 3.0LST retail (non-police) vehicles, the recall provided an PCM software update to engage the Electronic Park Brake (EPB) when Park is commanded. The recall addressed a breakage of the rear axle bolt that can cause the driveshaft/half shafts to disconnect, resulting in a loss of transmission torque to the rear wheels necessary to hold park. If the parking brake is not applied, the loss of the primary park torque will allow the vehicle to roll in park increasing the risk of crash and injury. Recall 23V-199 addressed 674 of the subject vehicles produced from February 2, 2019 to April 4, 2022, which received an incorrect remedy under Recall 22V-255. The affected vehicles had received a previous Powertrain Control Module (PCM) update which did not include an automatic EPB engagement when vehicle is shifted to park. On October 17, 2023, Ford filed a new safety recall (Recall 23V-675) covering 238,364 MY 2020-2022 Explorer vehicles with the following powertrains: 3.3L FHEV Police, 3.3L Gas Police, 3.0L Gas Police, 2.3L RWD, 3.0L PHEV, 3.3L FHEV, 3.0L RWD and 3.0L AWD, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. Ford stated that the cause of the bolt fracture is due to joint design not robust to peak axle input torques and manufacturing variability. The primary contributor is insufficient bearings for maximum joint loads. This can result in bearing deformation, increasing bending stress on the bolt, which may lead to fatigue failure. On January 19, 2023, Ford amended Recall 23V-675 to add 1,942 MY 2020-2022 Explorer vehicles with the following powertrain: 3.0L RWD Platinum and King Ranch variant, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. In addition to the safety recall, Ford will conduct a customer satisfaction program for the following MY 2020-2022 Explorer vehicles with the following powertrains: 2.3L AWD, 3.3L Gas Retail, 3.0L Gas AWD Platinum and King Ranch, produced from October 22, 2018 to July 6, 2022. Ford stated that the Explorer powerpack variants not covered under Recalled 23V-675 do not present an unreasonable risk to motor vehicle safety due to the combination of lower peak torque levels and torque management strategies to share inputs between front and rear axles, reducing occurrence of higher torque. According to Ford, this is also evidenced by the lower current and projected failure rates. In view of the recall action being taken by Ford, ODI is closing this RQ. NHTSA will continue to monitor complaints from the customer satisfaction program vehicles and reopen this issue, if necessary. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Power Train:driveline:differential Unit
On July 17, 2023, the Office of Defect Investigation (ODI) opened this Recall Query (RQ) after receiving 2 consumer complaints alleging loss of vehicle forward power and/or loss of transmission torque of the rear wheels in model year (MY) 2020-2022 Ford Explorer vehicles (subject vehicles). The RQ was opened to focus on the effectiveness of the remedies of Recalls 22V-255 and 23V-199 related to the alleged problem. Recall 22V-255 involved replacing the bushing and axle cover in the following subject vehicles: 3.3L FHEV Police built before October 14, 2020, and 3.3L Gas Police vehicle built before January 31, 2021. For 2.3L RWD, 3.0L PHEV, 3.3LFHEV, and 3.0LST retail (non-police) vehicles, the recall provided an PCM software update to engage the Electronic Park Brake (EPB) when Park is commanded. The recall addressed a breakage of the rear axle bolt that can cause the driveshaft/half shafts to disconnect, resulting in a loss of transmission torque to the rear wheels necessary to hold park. If the parking brake is not applied, the loss of the primary park torque will allow the vehicle to roll in park increasing the risk of crash and injury. Recall 23V-199 addressed 674 of the subject vehicles produced from February 2, 2019 to April 4, 2022, which received an incorrect remedy under Recall 22V-255. The affected vehicles had received a previous Powertrain Control Module (PCM) update which did not include an automatic EPB engagement when vehicle is shifted to park. On October 17, 2023, Ford filed a new safety recall (Recall 23V-675) covering 238,364 MY 2020-2022 Explorer vehicles with the following powertrains: 3.3L FHEV Police, 3.3L Gas Police, 3.0L Gas Police, 2.3L RWD, 3.0L PHEV, 3.3L FHEV, 3.0L RWD and 3.0L AWD, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. Ford stated that the cause of the bolt fracture is due to joint design not robust to peak axle input torques and manufacturing variability. The primary contributor is insufficient bearings for maximum joint loads. This can result in bearing deformation, increasing bending stress on the bolt, which may lead to fatigue failure. On January 19, 2023, Ford amended Recall 23V-675 to add 1,942 MY 2020-2022 Explorer vehicles with the following powertrain: 3.0L RWD Platinum and King Ranch variant, produced from October 22, 2018 to July 6, 2022, equipped with a 3-point mounted axle design. In addition to the safety recall, Ford will conduct a customer satisfaction program for the following MY 2020-2022 Explorer vehicles with the following powertrains: 2.3L AWD, 3.3L Gas Retail, 3.0L Gas AWD Platinum and King Ranch, produced from October 22, 2018 to July 6, 2022. Ford stated that the Explorer powerpack variants not covered under Recalled 23V-675 do not present an unreasonable risk to motor vehicle safety due to the combination of lower peak torque levels and torque management strategies to share inputs between front and rear axles, reducing occurrence of higher torque. According to Ford, this is also evidenced by the lower current and projected failure rates. In view of the recall action being taken by Ford, ODI is closing this RQ. NHTSA will continue to monitor complaints from the customer satisfaction program vehicles and reopen this issue, if necessary. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.