IllustrationDrivers door will not lock. It will only lock if you push it down but doesn’t lock when taking off like it’s supposed to for safety.
2019 Ford Explorer
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2019 Ford Explorer do not stand out strongly from the model-year median of 609.
About this comparison →How this year compares
Owner complaints by model year
Compare all Explorer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
270–25K
2425–50K
2750–75K
2775–100K
8100–150K
2150K+
115 reports with mileage · 179 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 148 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports5 injury reports
What owners actually said
294 reportsNeeds a full transmission replacement and only have 80,000 miles on it. Bought new from dealership in 2019.
The A-pillar passenger side flank flew off while driving.
Operator law enforcement was idling for an extended time in this vehicle. He was found unconscious in the vehicle and diagnosed with acute carbon monoxide poisoning. He was hospitalised for 4 days, and suffers continuing neurological deficits. Post-incident testing by engineer instructed by operator indicated two improper or in…
Read full complaint
Operator law enforcement was idling for an extended time in this vehicle. He was found unconscious in the vehicle and diagnosed with acute carbon monoxide poisoning. He was hospitalised for 4 days, and suffers continuing neurological deficits. Post-incident testing by engineer instructed by operator indicated two improper or incomplete welds on exhaust system, allowing exhaust to pool under vehicle and enter passenger compartment through HVAC fresh air intake. Post-incident testing recreated rising CO levels in passenger compartment. Vehicle has also been inspected by manufacturer. There were no warning lamps or messages.
VEHICLE SHIFTS ROUGH. I WAS TOLD BY FORD THAT I NEED TO REPLACE MY BATTERY EXCEPT I DO NOT HAVE ANY BATTERY ISSUES AT ALL. ALSO WHEN I PUT MY VEHICLE IN PARK IT ROLLS FORWARD A LITTLE.
The contact owns a 2019 Ford Explorer. The contact stated that the front windshield was slightly detached from the vehicle. While driving at various speeds there was a whistling sound coming from the windshield. The vehicle was taken to an auto body shop where it was diagnosed that there was mold along the sides of the windshiel…
Read full complaint
The contact owns a 2019 Ford Explorer. The contact stated that the front windshield was slightly detached from the vehicle. While driving at various speeds there was a whistling sound coming from the windshield. The vehicle was taken to an auto body shop where it was diagnosed that there was mold along the sides of the windshield panel causing the windshield to detach. The vehicle was not repaired. The manufacturer was made aware of the failure, and it was confirmed that there was no recall on the VIN for the failure. The contact was referred to the NHTSA Hotline for assistance. The approximate failure mileage was 50,000.
My 2019 Ford Explore XLT wouldn’t shift right, kinda hesitated to lock. My RPM were jumping like crazy. My mechanic replaced my torque converter and throttle body. Now my vehicle drives fine but when you stop at a stop light it shakes you to death. Then it sputters when trying to accelerate. So back to the shop it went because t…
Read full complaint
My 2019 Ford Explore XLT wouldn’t shift right, kinda hesitated to lock. My RPM were jumping like crazy. My mechanic replaced my torque converter and throttle body. Now my vehicle drives fine but when you stop at a stop light it shakes you to death. Then it sputters when trying to accelerate. So back to the shop it went because that can cause an accident. Not to mention if it stalks while driving. My mechanic says my torque converter is [XXX] again. After paying $4000 to have my transmission basically rebuilt a year later I’m back in the same boat. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The trim that is on either side of the front windshield has come loose. The one on the driver side came loose while I was on the interstate and struck the vehicle behind me. It caused the driver to lose control and spin out. Fortunately, it did not cause a collision, but it could have caused a loss of life, we were travelling…
Read full complaint
The trim that is on either side of the front windshield has come loose. The one on the driver side came loose while I was on the interstate and struck the vehicle behind me. It caused the driver to lose control and spin out. Fortunately, it did not cause a collision, but it could have caused a loss of life, we were travelling at highway speeds. The trim on the passenger side was still on the vehicle, but it had popped loose and was sticking up at an odd angle. I removed it to prevent the same thing from happening.
I purchased a Ford certified 2019 Ford Explorer recently. It is my 20th Ford. I could barely hear the horn and thought there was a problem with one of the horns. I researched it and found that the 2019 model year only came with one horn. The horn is at the front of the hood and when I checked there was a bracket for 2 horns …
Read full complaint
I purchased a Ford certified 2019 Ford Explorer recently. It is my 20th Ford. I could barely hear the horn and thought there was a problem with one of the horns. I researched it and found that the 2019 model year only came with one horn. The horn is at the front of the hood and when I checked there was a bracket for 2 horns but there was only one. You almost can not hear it when inside of the car and it makes me think that others may not hear it if there is an emergency. I have owned close to 70 cars and I have never had a car with one horn. A moped has a louder horn. In my opinion Ford should not have tried to save $5 that could cause an accident. I had to order Ford part number GB5Z-13832-A which are the dual horns found on the other model years. My safety and the safety of other 2019 Ford Explorer owners is at risk because of this.
coolant leaking into engine 2.3l eco boost
Official recalls
626V448000 · Structure:body
Jul 14, 2026
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
26V101000 · Suspension:rear
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2017-2019 Explorer vehicles. The rear suspension toe links may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the toe links, free of charge. Owner notification letters were mailed on March 16, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S08. This recall is an expansion of previous NHTSA recall number 21V537. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 25, 2026.
26V012000 · Equipment:electrical:engine Block Heater
Jan 15, 2026
Ford Motor Company (Ford) is recalling certain 2016-2018 Focus, 2019 Explorer, and 2024 Explorer vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed February 13, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on January 16, 2026. This recall expands previous recall number 25V685.
24V031000 · Structure:body:roof And Pillars
Jan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence & remedy
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
21V316000 · Structure:body
May 5, 2021
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
19V633000 · Seats:front Assembly:recliner; Seats:mid/rear Assembly
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.