Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
920–25K
5125–50K
5550–75K
4475–100K
40100–150K
6150K+
288 reports with mileage · 440 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 287 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports7 fire reports13 injury reports
What owners actually said
728 reports
Mileage unknown · Jul 3, 2022
Unknown Or Other
Driving on freeway the driver side windshield A-Pillar trim came almost all of the way off and was flapping. We pulled it off by the one remaining attachment and drove home. Also noticed the passenger side A-Pillar trim was loose. Took to dealer. There was not a recall so we payed to have them replaced. The total cost was $655.9…
Read full complaint
Driving on freeway the driver side windshield A-Pillar trim came almost all of the way off and was flapping. We pulled it off by the one remaining attachment and drove home. Also noticed the passenger side A-Pillar trim was loose. Took to dealer. There was not a recall so we payed to have them replaced. The total cost was $655.96. These could have flown off of the vehicle and caused an accident.
NHTSA ODI #11472207
Mileage unknown · Jun 12, 2022
Air BagsVehicle Speed ControlCrashInjury
When driving the car I corrected to move further to the left on the road. In doing so it felt like I ran over something and all of a sudden the car accelerated (initially I was driving around 20-25 mph) and I struck a tree. I sustained a T Spine fracture and was hospitalized for 5 days. I just have a case number with Ford but …
Read full complaint
When driving the car I corrected to move further to the left on the road. In doing so it felt like I ran over something and all of a sudden the car accelerated (initially I was driving around 20-25 mph) and I struck a tree. I sustained a T Spine fracture and was hospitalized for 5 days. I just have a case number with Ford but they seem disinterested. When the car accelerated I felt it was going a 2x the speed.
NHTSA ODI #11468893
Mileage unknown · Jun 9, 2022
Back Over PreventionForward Collision Avoidance
Within weeks of vehicle being out of warranty apim module failed. Vehicle completely lost all gps, intermitment screen failure that prevents seeing backup camera. Forward collison lights come on for no apparent reason. All lane assist functions intermittently work
NHTSA ODI #11468370
Mileage unknown · May 27, 2022
Tires
i notice that my car is sliding in somewhat wet terrain situations. I did notice it last year but didn't think at 24k miles my tire treads were bad. I had my car serviced and they are telling me at 32K miles I need new tires and they are bad. These tires are warranted for 50K miles. There are rubber tears at the tread and w…
Read full complaint
i notice that my car is sliding in somewhat wet terrain situations. I did notice it last year but didn't think at 24k miles my tire treads were bad. I had my car serviced and they are telling me at 32K miles I need new tires and they are bad. These tires are warranted for 50K miles. There are rubber tears at the tread and well as complete baldness. Terrible! Had I been driving much this winter there would no doubt be a incident. These are a issue on all 4 tires. I see there are many complaints with these Hankook Ventus Noble tires. Something needs to be done or recalled. We are the consumer. Protect us!
NHTSA ODI #11466345
470,000 miles · May 20, 2022
Steering
The contact owns a 2018 Ford Explorer. The contact stated that while his wife was operating the vehicle, the hill assists and traction control warning lights illuminated. The power steering failed to cause the steering wheel to become extremely difficult to turn in either direction. The vehicle was towed to the local dealer who…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated that while his wife was operating the vehicle, the hill assists and traction control warning lights illuminated. The power steering failed to cause the steering wheel to become extremely difficult to turn in either direction. The vehicle was towed to the local dealer who diagnosed that the steering column was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 47,000.
NHTSA ODI #11465383
50,000 miles · May 19, 2022
Steering
The contact owns a 2018 Ford Explorer. The contact stated that while parked in a parking lot and attempting to start the vehicle, the power steering assist warning light illuminated. The contact stated that the failure was intermittent. The vehicle was towed to a dealer to be diagnosed. The contact was informed that the steering…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated that while parked in a parking lot and attempting to start the vehicle, the power steering assist warning light illuminated. The contact stated that the failure was intermittent. The vehicle was towed to a dealer to be diagnosed. The contact was informed that the steering column needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 50,000. The vehicle has since been repaired.
NHTSA ODI #11465332
79,000 miles · May 6, 2022
Engine And Engine Cooling
The contact owns a 2018 Ford Explorer. The contact stated the water pump was leaking. While driving, the vehicle overheated and stalled. The overheating message was displayed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure m…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated the water pump was leaking. While driving, the vehicle overheated and stalled. The overheating message was displayed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 79,000.
NHTSA ODI #11463623
31,000 miles · May 3, 2022
Structure
The contact owns a 2018 Ford Explorer. The contact stated that upon inspection it was discovered that approximately three quarters of the driver’s side roof rail covers had fractured and dislodged from the vehicle. The cause of the failure was unknown. The local dealer and manufacturer were notified of the failure and the contac…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated that upon inspection it was discovered that approximately three quarters of the driver’s side roof rail covers had fractured and dislodged from the vehicle. The cause of the failure was unknown. The local dealer and manufacturer were notified of the failure and the contact was informed that the vehicle was not included in the NHTSA Campaign Number: 21V316000 (Structure). The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 31,000.
NHTSA ODI #11463161
Mileage unknown · Apr 12, 2022
Fuel/propulsion System
THE FUEL PRESSURE SENSOR ALARM
NHTSA ODI #11460557
50,000 miles · Apr 7, 2022
Structure
The contact owns a 2018 Ford Explorer. The contact stated while driving at 70 MPH on a windy day, the driver's side windshield A-Pillar trim bracket fractured inadvertently and continually struck the windshield. The contact veered to the side of the road and the remove the broken windshield A-Pillar trim bracket. The contact the…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated while driving at 70 MPH on a windy day, the driver's side windshield A-Pillar trim bracket fractured inadvertently and continually struck the windshield. The contact veered to the side of the road and the remove the broken windshield A-Pillar trim bracket. The contact then continued to drive to his residence. The vehicle was taken to the dealer who inspected the vehicle and diagnosed that the trim bracket needed to be replaced. The manufacturer was notified of the failure and informed the contact that they could not assist as the VIN was not included a recall associated to the failure. The failure mileage was approximately 50,000.
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Ford Motor Company (Ford) is recalling certain 2017-2019 Explorer vehicles. The rear suspension toe links may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the toe links, free of charge. Owner notification letters were mailed on March 16, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S08. This recall is an expansion of previous NHTSA recall number 21V537. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 25, 2026.
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence & remedy
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Ford Motor Company (Ford) is recalling certain 2018 Ford Explorer vehicles equipped with 2.3L or 3.5L GTDI engine. Due to an assembly error, the fuel pressure sensor may leak fuel.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel line assembly, free of charge. The recall began December 7, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S35.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
AQ22003 · Hertz/vehicles Rented With Open Recalls
Opened Dec 16, 2022 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages:hood:latch
NHTSA is opening this audit query to investigate whether The Hertz Corporation (Hertz) has complied with the requirements of the National Traffic and Motor Vehicle Safety Act (Safety Act). The Safety Act requires, among other things, that a rental company shall not rent a vehicle subject to a safety recall unless the recall remedy has been performed. 49 U.S.C. § 30120(i).NHTSA is in receipt of information that indicates Hertz rented vehicles to customers without having performed required recall repairs. Accordingly, we are opening this audit query to seek additional information concerning this issue.
Illustration