2018 Ford Explorer

The contact owns a 2018 Ford Explorer. The contact stated that while reversing, the Back Over Prevention camera image froze and intermittently failed to display an image. An unknown warning light was illuminated, and a camera sensor message was displayed. The vehicle was taken to a local dealer, where it was diagnosed that the rearview camera needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was unknown.

The contact called in for a client who owns a 2018 Ford Explorer. The contact works at an independently owned auto body shop. The contact stated that the vehicle was towed into the body shop for inspection. While inspecting the vehicle, the contact became aware that the driver’s rear toe link had fractured. The contact stated that while the owner of the vehicle was driving at an undisclosed speed, he lost control of the vehicle and spun out, and ran off the road causing damage to the vehicle. The contact stated that he was called by the State Police to tow the vehicle. The contact was unaware of any injuries being sustained during the failure. A police report was filed. The vehicle was not yet repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was 59,004.

Driving about 50mph on dry country road, good visibility, when suddenly car pulled hard right. We went onto a grass embankment, I managed to pull left back onto the road, but car fish-tailed uncontrollably, we hit crash barrier, and finally came to a stop. Badly shaken but no injuries. Examining car, besides body damage, most notably rear drivers side wheel was mis-aligned with car by about 15 degrees. Photo of suspension I took shows broken toe-link, subsequently confirmed by body shop and loss adjuster. The car had new rear struts 2 days earlier, but at that time no report of a broken toe-link. I have subsequently learnt there is a recall for broken toe-link for Ford Explorers 2013-2017, but mine is 2018. But I suspect the recall should have been broader - my toe-link looks like one subject to recall.

2018 Ford Explorer developed a shudder and rough idle, sluggish vehicle operation, slow acceleration during launch. No warning lamps. Researched issues online and found a bulletin from Ford Motor Company dated October 9, 2020 that identified the issue as a torque converter defect. My vehicle was manufactured during the identified time period and at the identified assembly plant but I did not receive a notice from Ford for the repair program. My vehicle has exhibited all of the known issues as well as a total loss of power while reversing leaving me sideways in the middle of the road while I had my family on a road trip risking collision and injury. Dealership confirms there was an issue but refuses to repair because my VIN was not listed in their system as affected. Feel the issue may extend to more vehicles than Ford previously figured.

As I was driving the car slowed down and jerked a little. ( no lights came on ) It happened again getting on the freeway, on another day. Still no lights on the dash. It did it another time and the light that indicate it's the power train. All while I was going through this I took it to a shop that said nothing was wrong with my vehicle. I only had my vehicle 5 months before the first slow down. I tried to take it to Pat Millenkin Ford they MEVER looked at the powertrain after me telling them I thought it was the transmission, but I was told it has no issues because it wasn't a light on. Two day's after getting my car back same problem happened, I called then was giving the run around then after my warranty expired they said bring it in which now they want me to pay over $4000 but they never did a diagnostic test on my powertrain. There also was a manufacturer customer satisfaction program from Ford on the transmission #20N07 before I purchased.

The contact owns a 2018 Ford Explorer. The contact stated while his wife was driving at an undisclosed speed, the rear windshield trim separated from the vehicle. The vehicle was taken to the dealer where it was diagnosed that the rear windshield trim needed to be replaced. The dealer informed the contact that he needed to pay for the repair because the VIN was not under recall. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was approximately 57,000.

The contact owns a 2018 Ford Explorer. The contact stated that the weather stripping around the windshield and the rubber seal around all doors had started to deteriorate on the passenger’s and driver’s side rear doors. The contact had taken the vehicle to the dealer who diagnosed that the windshield molding and the rubber stripping on the doors needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and opened a case. The approximate failure mileage was 27,632.

The entire main console screen/information center went black one day. It was unable to be manually reset. Occasionally, on very hot days, the screen would work for the first start up. There are major safety issues associated with this: 1- inability to enable calling for help/911. There is a remote on the steering wheel to make phone calls, however, when the carplay is active and the phone is connected, you must only use the screen, the steering wheel feature is automatically disabled 2- The backup camera system is inoperable when the screen is black. This is dangerous as you cannot see hazards behind you including children, other vehicles, etc. When I contacted Ford's IT department to first report it, they said this has been an ongoing issue with updates that they were aware of, but unable to fix. Skalnek Ford in Lake Orion attempted to diagnose the safety issue for weeks and ultimately the APIM needed replacement.

My car produces a sulfer/burning smell at hard acceleration. When I am merging into traffic at 3500-4000 and over RMP, an awful smell enters the cabin. I am very concerned that this is unsafe for my family and children in the vehicle, as well as the environment. I have had this vehicle looked by Ford and they claim everything looks normal. It is not normal to have this smell while accelerating.

In mid-July 2022, I attempted to fix the exhaust issue when accelerating in my 2018 Explorer. Ford dealership found there was a crack in the exhaust. Ford Corporate paid for the repairs. The problems persisted but were not as quick to notice, but still faintly smell it. Since July, I feel the dealership never fix the issue, and since the heat has worsened, the exhaust also has. Ford Corp, in a statement, has stated that it's "normal" to smell exhausted when accelerating. The Ford Dealership has also echoed this statement. Our Ford Fusion 2015 has never smelled like exhaust. My Mercedes never, either. From my understanding, 2017 Explorer had this recall, l and it seems they never fixed the issue. I feel it's not safe, as my family, my 1 yr old granddaughter, and myself are being poisoned. Today, I ordered carbon monoxide to record this data and will find out what is legally allowed.