NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
67 reportsClear category filter111,000 miles · Aug 5, 2022
Engine And Engine Cooling
The contact owns a 2013 Ford Explorer. The contact stated while driving approximately 45 MPH, the check engine warning light illuminated. The contact stated that on multiple occasions she noticed that the coolant level was low. The vehicle was taken to the dealer where it was diagnosed that the internal water pump needed to be r…
Read full complaint
The contact owns a 2013 Ford Explorer. The contact stated while driving approximately 45 MPH, the check engine warning light illuminated. The contact stated that on multiple occasions she noticed that the coolant level was low. The vehicle was taken to the dealer where it was diagnosed that the internal water pump needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and advised the contact to call the NHTSA hotline. The approximate failure mileage was 111,000.
NHTSA ODI #11477747
72,000 miles · Apr 21, 2022
Engine And Engine CoolingUnknown Or Other
The contact owns a 2013 Ford explore. The contact stated while driving 65 MPH the vehicle engine stop warning lights turned on. The engine started overheating and the contact pulled over and added water. The contact drove the vehicle to the dealer. The vehicle was not repaired. The manufacture was notified. The failure mileage w…
Read full complaint
The contact owns a 2013 Ford explore. The contact stated while driving 65 MPH the vehicle engine stop warning lights turned on. The engine started overheating and the contact pulled over and added water. The contact drove the vehicle to the dealer. The vehicle was not repaired. The manufacture was notified. The failure mileage was 72,000
NHTSA ODI #11461676
150,000 miles · Apr 12, 2022
Engine And Engine Cooling
The contact owns a 2013 Ford Explorer. The contact stated that while operating the vehicle, the check engine warning light would remain illuminated and the vehicle would sputter and fail to properly accelerate while depressing the accelerator pedal. The vehicle was taken to an independent mechanic who diagnosed that the water pu…
Read full complaint
The contact owns a 2013 Ford Explorer. The contact stated that while operating the vehicle, the check engine warning light would remain illuminated and the vehicle would sputter and fail to properly accelerate while depressing the accelerator pedal. The vehicle was taken to an independent mechanic who diagnosed that the water pump was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure. The failure mileage was 150,000.
NHTSA ODI #11460498
130,000 miles · Mar 17, 2022
Engine And Engine Cooling
The contact owns a 2013 Ford Explorer. The contact stated that while driving at an undisclosed speed, the high engine temperature warning light illuminated. The contact pulled over to inspect the vehicle and became aware that all the coolant had leaked out of the radiator. The vehicle was towed to an independent mechanic to be d…
Read full complaint
The contact owns a 2013 Ford Explorer. The contact stated that while driving at an undisclosed speed, the high engine temperature warning light illuminated. The contact pulled over to inspect the vehicle and became aware that all the coolant had leaked out of the radiator. The vehicle was towed to an independent mechanic to be diagnosed and the contact was informed that the water pump needed to be replaced. The vehicle was not repaired. Neither the dealer nor the manufacturer had been notified of the failure. The approximate failure mileage was 130,000.
NHTSA ODI #11457147
183,460 miles · Feb 23, 2022
Engine And Engine Cooling
The contact owns a 2013 Ford Explorer. The contact stated while her son was driving 45 MPH, the engine overheated. There was no warning light illuminated. The vehicle was driven home and the contact added antifreeze to the engine however, the liquid poured out. The contact had the vehicle towed to an independent mechanic to be d…
Read full complaint
The contact owns a 2013 Ford Explorer. The contact stated while her son was driving 45 MPH, the engine overheated. There was no warning light illuminated. The vehicle was driven home and the contact added antifreeze to the engine however, the liquid poured out. The contact had the vehicle towed to an independent mechanic to be diagnosed. The contact was provided a service date in May 2022. The contact was informed that the water pump, timing chain, and other unnamed parts needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 183,460.
NHTSA ODI #11453640
129,000 miles · Dec 16, 2021
Engine And Engine CoolingFire
The contact owns a 2013 Ford Explorer. The contact stated they had taken their vehicle to a local dealer for a crack in the water pump which the dealer repaired, After the repair, the contact noticed a burning abnormal odor when turning on their heat from their a/c unit, which caused the contact and his passenger to become light…
Read full complaint
The contact owns a 2013 Ford Explorer. The contact stated they had taken their vehicle to a local dealer for a crack in the water pump which the dealer repaired, After the repair, the contact noticed a burning abnormal odor when turning on their heat from their a/c unit, which caused the contact and his passenger to become light-headed and dizzy. The contact drove to a local hospital where it was confirmed that the reason for the symptoms was due to high level of carbon monoxide levels. The contact called the local dealer about the abnormal odor but the dealer informed the contact they would not be able to fix the issue and inform the contact to reach out to the manufacturer for the failure. The contact decided to take the vehicle's independent mechanic who diagnosed the failure as small oil leaks around the engine that contribute to the odor coming into the interior of the vehicle. The vehicle was not repaired. The manufacturer was made of failure. The failure mileage was approximately 129,000.
NHTSA ODI #11444001
169,234 miles · Jun 2, 2021
Engine And Engine Cooling
The contact owns a 2013 Ford Explorer. The contact stated while driving 30 mph, he started to smell exhaust fumes inside of the cabin of the vehicle. The contact stated no warning light was illuminated. The contact stated while inspecting the vehicle, he noticed the exhaust manifold was faulty and leaking. The vehicle was not di…
Read full complaint
The contact owns a 2013 Ford Explorer. The contact stated while driving 30 mph, he started to smell exhaust fumes inside of the cabin of the vehicle. The contact stated no warning light was illuminated. The contact stated while inspecting the vehicle, he noticed the exhaust manifold was faulty and leaking. The vehicle was not diagnosed nor repaired. A dealer was not contacted. The manufacturer had been informed of the failure. The failure mileage was approximately 169,234.
NHTSA ODI #11419381
125,200 miles · Jan 31, 2018
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2013 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT WAS OVERCOME BY EXHAUST FUMES ENTERING THE VEHICLE. THE CONTACT BECAME EXHAUSTED AND HAD SEVERE HEADACHES. THE CONTACT UNDERWENT MEDICAL TESTS AT CARY MEDICAL GROUP (530 NEW WAVERLY PL #200, CARY, NC 27518, (919) 859-5955) FOR CARBON MONOXIDE PO…
Read full complaint
TL* THE CONTACT OWNS A 2013 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT WAS OVERCOME BY EXHAUST FUMES ENTERING THE VEHICLE. THE CONTACT BECAME EXHAUSTED AND HAD SEVERE HEADACHES. THE CONTACT UNDERWENT MEDICAL TESTS AT CARY MEDICAL GROUP (530 NEW WAVERLY PL #200, CARY, NC 27518, (919) 859-5955) FOR CARBON MONOXIDE POISONING. THE CONTACT WAS INFORMED THAT THE TESTS SHOWED ELEVATED LEVELS OF CARBON MONOXIDE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR INSPECTED. THE CONTACT STATED THAT AN APPOINTMENT WAS MADE WITH AN INDEPENDENT FACILITY TO PERFORM A CARBON MONOXIDE TEST ON THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 125,200.
NHTSA ODI #11066011
5,800 miles · Aug 9, 2017
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2013 FORD EXPLORER. THE CONTACT NOTICED AN ABNORMAL CARBON MONOXIDE ODOR INSIDE THE VEHICLE WHILE USING THE AIR CONDITIONER. THE ODOR WAS ALSO PRESENT WHEN THE CONTACT ACCELERATED TO PASS OTHER VEHICLES OR WHILE DRIVING HIGH SPEEDS. IN JUNE OF 2013, THE VEHICLE WAS TAKEN TO LEIF JOHNSON FORD (501 E KOENIG …
Read full complaint
TL* THE CONTACT OWNS A 2013 FORD EXPLORER. THE CONTACT NOTICED AN ABNORMAL CARBON MONOXIDE ODOR INSIDE THE VEHICLE WHILE USING THE AIR CONDITIONER. THE ODOR WAS ALSO PRESENT WHEN THE CONTACT ACCELERATED TO PASS OTHER VEHICLES OR WHILE DRIVING HIGH SPEEDS. IN JUNE OF 2013, THE VEHICLE WAS TAKEN TO LEIF JOHNSON FORD (501 E KOENIG LN, AUSTIN, TX 78751) WHERE THEY VERIFIED THE PROPER SEAL OF SEALED MECHANIC JOINTS. THE CONTACT TOOK THE VEHICLE BACK TO THE SAME DEALER IN AUGUST OF 2013 DUE TO THE ODOR. THE DEALER CHECKED THE MOULDING, ADHESIVE GRILL, INLET VALVE, ASSEMBLY AUTO DRAIN, UNDER COAT, AND PERFORMED TSB 121204 WHERE THEY REPLACED THE CO-SEAMS AND INSTALLED BOTH NEW VENTS. IN SEPTEMBER OF 2013, THE CONTACT TOOK THE VEHICLE TO A SECOND DEALER (COVERT FORD LINCOLN, 11514 RESEARCH BLVD, AUSTIN, TX, 78758,) IN REFERENCE TO THE CARBON MONOXIDE ODOR DUE TO ACCELERATION. THE DEALER CHECKED THE CABIN AIR FILTER AND EXHAUST FOR LEAKS/DAMAGE, ALONG WITH REGULAR ROUTINE MAINTENANCE; HOWEVER, NO DIAGNOSIS WAS PROVIDED. THE CONTACT SENT A LETTER TO THE SECOND DEALER IN OCTOBER OF 2013 ABOUT THE ODOR IN REFERENCE TO FINDINGS FROM THE INTERNET. THE CONTACT ASKED THE DEALER TO COMPARE THE FAILURES AND INFORM HER OF FORD'S OUTCOME. THE CONTACT TOOK THE VEHICLE TO TOW OTHER MECHANICS WHERE THE EXHAUST WAS ADJUSTED; HOWEVER, THE REMEDY FAILED. THE FAILURE CONTINUED THROUGHOUT THE YEARS AND THE FORD DEALERS COULD NOT PROVIDE A SOLUTION THROUGH JUNE OF 2015. THE CONTACT STOPPED ATTEMPTING TO REPAIR THE VEHICLE DUE TO FRUSTRATION, TIME, AND MONEY. THE MANUFACTURER WAS NOT CONTACTED OR MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 5,800.
NHTSA ODI #11013917
10 miles · Aug 7, 2017
Engine And Engine CoolingFuel/propulsion System
TL* THE CONTACT OWNS A 2013 FORD EXPLORER. WHILE THE VEHICLE WAS ON AN INCLINE WITH THE ACCELERATOR PEDAL DEPRESSED, THE ODOR OF CARBON MONOXIDE ENTERED THROUGH THE CABIN WITHOUT WARNING. WHILE THE AIR CONDITIONER WAS IN RECIRCULATION MODE, THE CONTACT ATTEMPTED TO ACCELERATE PAST OTHER VEHICLES AND THE ABNORMAL ODOR WAS NOTICED…
Read full complaint
TL* THE CONTACT OWNS A 2013 FORD EXPLORER. WHILE THE VEHICLE WAS ON AN INCLINE WITH THE ACCELERATOR PEDAL DEPRESSED, THE ODOR OF CARBON MONOXIDE ENTERED THROUGH THE CABIN WITHOUT WARNING. WHILE THE AIR CONDITIONER WAS IN RECIRCULATION MODE, THE CONTACT ATTEMPTED TO ACCELERATE PAST OTHER VEHICLES AND THE ABNORMAL ODOR WAS NOTICED. THE DEALER (ED SHULTS FORD-LINCOLN, 2258 WASHINGTON ST, JAMESTOWN, NY, 14701 716-484-0121) WAS CONTACTED FOUR YEARS AGO (ONE YEAR AFTER PURCHASING THE VEHICLE) IN REFERENCE TO THE ABNORMAL ODOR. THE CONTACT WAS INFORMED THAT THERE WAS NO OPEN RECALL. THE VEHICLE WAS NOT TAKEN TO A DEALER OR MADE AWARE OF THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 10...UPDATED 09/28/17 * UPDATED 10/27/2017*JS
NHTSA ODI #11013476
Official recalls
11Jan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence & remedy
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Sep 22, 2021
Ford Motor Company (Ford) is recalling certain 2011-2013 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. These vehicles may be equipped with a cross-axis ball joint (CABJ) replacement part that could seize, and result in a fracture of the outboard section of the rear suspension toe link.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealer will inspect for the presence of a CABJ. If a CABJ of any design is found, the dealer will inspect the tightness of the CABJ, and replace the CABJ, knuckle, and/or toe link as necessary, free of charge. Interim notification letters were mailed November 10, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S43.
Jul 15, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.
Consequence & remedy
Consequence: A rear toe-link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will inspect and replace as necessary, the cross-axis ball joint (CABJ) knuckle, and replace the rear suspension toe links, free of charge. This recall is an expansion of previous NHTSA recall numbers 16V-245, 19V-435, and 20V-675. Certain vehicles previously repaired will need to return for the new remedy. An interim notification letter notifying owners of the safety risk were mailed on September 10, 2021. Owner notification letters were mailed on March 16, 2022. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 21S32.
Mar 12, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the cross-axis ball joint (CABJ) knuckle attached to the rear suspension toe link and replace it as necessary, free of charge. The recall began November 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S62.
Jun 10, 2019
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
Consequence & remedy
Consequence: A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
Dec 2, 2015
Ford Motor Company (Ford) is recalling certain model year 2013 Explorer, Explorer Police Utility, Taurus, Taurus Police Interceptor, Flex, Lincoln MKS, and Lincoln MKT vehicles. In the affected vehicles, the fuel delivery module may crack, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel delivery module, free of charge. The recall began on December 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 13S04-S1.
Mar 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Explorer vehicles. In the affected vehicles, the interior door handle return spring may unseat, resulting in interior door handle that does not return to the fully stowed position after actuation.
Consequence & remedy
Consequence: If the interior door handle return spring is unseated, the door may unlatch in the event of a side impact crash, increasing the risk of personal injury.
Remedy: Ford will notify owners, and dealers will inspect all four of the interior door handles and either repair or replace them, free of charge. The recall began on July 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S11.
May 29, 2014
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Ford Explorer vehicles manufactured May 17, 2010, through February 28, 2012. The affected vehicles may experience an intermittent connection in the electric power steering gear, which can cause a loss of the motor position sensor signal resulting in a shut down of the power steering assist.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist it will require extra steering effort at lower speeds, increasing the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will update the Power Steering Control Module (PSCM) software, free of charge. If a vehicle shows a history of a loss of motor position sensor signal when the vehicle is brought in for the recall remedy, its steering rack assembly will be replaced, free of charge. The recall began on July 23, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S06.
Jun 26, 2013
Ford Motor Company (Ford) is recalling certain model year 2013 Ford Explorer, Taurus, and Lincoln MKS vehicles manufactured November 29, 2012, through December 12, 2012. In the affected vehicles, with sufficient door openings and closings, the child safety locks may change from an activated position to a deactivated position without notice.
Consequence & remedy
Consequence: If the child lock is deactivated, the door could be unlocked and opened from the inside which could lead to personal injury to an unrestrained child.
Remedy: Ford will notify owners, and dealers will test the safety locks. If necessary, the locks will be replaced free of charge. The recall began on August 2, 2013. Ford's recall number is 13S07. Owners may contact the Ford customer relationship center at 1-866-436-7332.
May 31, 2013
Ford is recalling certain model year 2013 Explorer, Taurus, Flex, Fusion, Police Interceptor Sedan and Police Interceptor Utility vehicles; and certain model year 2013 Lincoln MKS, MKT, and MKZ vehicles. In the affected vehicles, the fuel delivery module may develop a crack, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel delivery module, free of charge. The recall began on July 20, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332. Ford's recall campaign number is 13S04.
Mar 27, 2013
Ford is recalling certain model year 2012 Taurus, Lincoln MKS, and model year 2013 Explorer vehicles manufactured July 19, 2011, through March 15, 2012. In the affected vehicles, the fuel tanks may have a marginally sealed seam in the side of the tank. As a result, the fuel tanks may not provide the expected strength in the event of an impact. The tanks may also leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Ford will notify owners, and dealers will inspect the fuel tanks and replace them as necessary, free of charge. The recall began on May 9, 2013. Ford's recall campaign number is 13S03. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA17002 · Exhaust Odor In Passenger Cab
Opened Jul 27, 2017 · Closed Jan 17, 2023
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Structure:body
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Structure:body
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
PE16008 · Ford Explorer Exhaust Odor
Opened Jul 1, 2016 · Closed Sep 12, 2017
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System; Structure:body
During the National Highway Traffic Safety Administration?s (NHTSA?s) investigation into the Ford carbon monoxide allegations, the Office of Defects Investigation (ODI) identified additional Vehicle Owner Questionnaire (VOQ) reports with similar exhaust odor claims.Presently, ODI has identified 791 VOQs for Model Year 2011-2017 Ford Explorers pertaining to exhaust odor claims.ODI has identified three crashes and 41 injuries potentially linked this issue.The reported injuries range from unspecified to loss of consciousness, with the majority being nausea, headaches, or dizziness ? all of which can be symptomatic of carbon monoxide exposure.Additionally, Ford provided 2,400 reports including owner complaints, warranty claims, dealer field reports, and legal claims, that involve 2,051 vehicles that may be connected to the exhaust odor issue.NHTSA's Vehicle Test and Research Center tested multiple vehicles, including complaint vehicles, during the investigation.ODI also conducted field inspections of complaint vehicles and crashes involving police units that occurred while the officers were on duty.When possible, data was collected to quantify carbon monoxide levels in the examined vehicles.Based on the information gathered to date, NHTSA upgraded this investigation to an Engineering Analysis (EA17-002).
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System
During the National Highway Traffic Safety Administration?s (NHTSA?s) investigation into the Ford carbon monoxide allegations, the Office of Defects Investigation (ODI) identified additional Vehicle Owner Questionnaire (VOQ) reports with similar exhaust odor claims.Presently, ODI has identified 791 VOQs for Model Year 2011-2017 Ford Explorers pertaining to exhaust odor claims.ODI has identified three crashes and 41 injuries potentially linked this issue.The reported injuries range from unspecified to loss of consciousness, with the majority being nausea, headaches, or dizziness ? all of which can be symptomatic of carbon monoxide exposure.Additionally, Ford provided 2,400 reports including owner complaints, warranty claims, dealer field reports, and legal claims, that involve 2,051 vehicles that may be connected to the exhaust odor issue.NHTSA's Vehicle Test and Research Center tested multiple vehicles, including complaint vehicles, during the investigation.ODI also conducted field inspections of complaint vehicles and crashes involving police units that occurred while the officers were on duty.When possible, data was collected to quantify carbon monoxide levels in the examined vehicles.Based on the information gathered to date, NHTSA upgraded this investigation to an Engineering Analysis (EA17-002).
Structure:body
During the National Highway Traffic Safety Administration?s (NHTSA?s) investigation into the Ford carbon monoxide allegations, the Office of Defects Investigation (ODI) identified additional Vehicle Owner Questionnaire (VOQ) reports with similar exhaust odor claims.Presently, ODI has identified 791 VOQs for Model Year 2011-2017 Ford Explorers pertaining to exhaust odor claims.ODI has identified three crashes and 41 injuries potentially linked this issue.The reported injuries range from unspecified to loss of consciousness, with the majority being nausea, headaches, or dizziness ? all of which can be symptomatic of carbon monoxide exposure.Additionally, Ford provided 2,400 reports including owner complaints, warranty claims, dealer field reports, and legal claims, that involve 2,051 vehicles that may be connected to the exhaust odor issue.NHTSA's Vehicle Test and Research Center tested multiple vehicles, including complaint vehicles, during the investigation.ODI also conducted field inspections of complaint vehicles and crashes involving police units that occurred while the officers were on duty.When possible, data was collected to quantify carbon monoxide levels in the examined vehicles.Based on the information gathered to date, NHTSA upgraded this investigation to an Engineering Analysis (EA17-002).
EA15005 · Front Brake Hose Failure
Opened Sep 28, 2015 · Closed Nov 2, 2018
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On April 29, 2015, the Office of Defects Investigation (ODI) opened PE15-017 to investigate a report alleging incidents of front brake hose failure in model year (MY) 2015 Ford Explorer Police Interceptor vehicles used by the Sacramento Police Department in its pursuit driving training program (VOQ 10705832).On September 28, 2015, ODI upgraded the investigation to an Engineering Analysis (EA15-005) to assess maximum front caliper crimp temperatures under various test conditions, test hose assemblies removed from police interceptor service for any signs of thermal degradation, and further assess field data for evidence of a defect trend related to the alleged defect.The alleged defect results from exposure to extremely high heat at the caliper-side hose crimp. NHTSA?s vehicle testing suggests that the conditions necessary to produce the critical temperatures in the subject components result from drive-soak intervals that can occur during the Sacramento training program.NHTSA's testing of hose assemblies returned from police interceptor service did not identify any evidence of thermal degradation.NHTSA has not confirmed any incidents of caliper crimp failures due to overheating in vehicles not subjected to the Sacramento training course driving.The low number of hose assembly failure reports and the absence of any verified incidents of heat related front brake hose crimp failures since 2015 suggests that the Sacramento PD incidents resulted from conditions unique to the training program.A safety related defect trend has not been identified at this time and further use of Agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The Agency will take further action if warranted by the circumstances.For additional information, see the Closing Report in the document file for EA15-005 on www.nhtsa.gov.
PE14027 · Front Brake Hose Failure
Opened Aug 22, 2014 · Closed Feb 3, 2015
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) opened PE14-027 based on a report of 13 front brake hose (jounce hose) failures in 11 vehicles in the District of Columbia Metropolitan Police Department (DCMPD) fleet of 46 model year (MY) 2013 Ford Explorer Police Interceptor (PI) vehicles (VOQ 10621634).The DCMPD fleet provided Ford with 71 jounce hoses for analysis, including 4 of the 13 failed hoses.Inspection of each of the failed hoses identified a small tear in the outer cover on the body end of the hoses on the outboard side. Ford?s lab analysis of these hoses identified splits in the inner liners 1.5-2.0mm from the end of the nipple (outside of the crimped ferrule joint).Ford conducted pressure testing of 10 randomly selected samples of the remaining 67 hoses that had not experienced leaks and 9 of the samples leaked at 6,000 psi.Ford?s examination of the 9 hoses that leaked in the pressure tests found 4 that failed on the outboard side of the hose (similar to the 4 leaking field parts) and 5 that failed on the body end of the hose on the inboard side.Four additional non-leaking hoses were sent to the hose supplier, Hitachi, for analysis.Broken yarn was observed in scanning electron microscope examinations at both the body side and caliper side hose to ferrule crimps, indicating severe bending stress had occurred at these locations. Hitachi supplied an additional set of non-leaking field return hoses and a brand new set of hoses to an outside laboratory (Element Materials Technology) for analysis.The lab did not identify any manufacturing or material deficiencies in the hoses and concluded that the hose failures were caused by excessive bending stresses.Based on the examinations of the returned jounce hoses, Ford conducted durability testing on new hoses that were the same design as those found on the subject vehicles.Ford first determined the worst case conditions for the hoses; jounce bumpers removed, internal rebound stops fully compressed, and shock absorbers attached. With the jounce hose installed, the steering was rotated to the maximum turn angle while the suspension was translated from full jounce to full rebound.This determined the maximum hose length of 13.0in (331mm) and a minimum hose bending radius of 1.6in (40mm).Using these conditions hoses tested on a Suspension Motion Simulator far surpassed Ford?s performance specifications. Twenty (20) complaints of front brake jounce hose failure were identified on a total of 18 Explorer PI vehicles, including the 13 hose failures in 11 vehicles from the DCMPD fleet that prompted PE14-027.The remaining 7 complaints included 3 from one fleet that reportedly occurred on the banjo block end of the hose assembly and single complaints from 4 other fleets.Only two brake hose assemblies were used in the subject and peer Explorer vehicles, with the BB53 level hose used until June 20, 2012, and an updated DB53 level hose used thereafter.No pattern of failures was observed by hose assembly, with 15 of failures involving the BB53 hose assembly (including the 13 from DCMPD manufactured in March 2012) and 5 the DB53 hose assembly built after June 20, 2012. No root cause was determined for the reported Explorer PI jounce hose failures, but Ford identified improper service repair procedures (e.g., hanging the brake caliper from the brake hose during brake pad replacement) as a possible contributor to higher than expected rate of front brake jounce hose leaks. ODI?s analysis of field data, hose inspection and test data did not identify evidence of any defects in hose material, manufacture or vehicle installation.The closing of this invest
PE12017 · Electric Power Steering Failure
Opened Jun 19, 2012 · Closed Jun 12, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On May 27, 2014 and amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 179,027 model year (MY) 2011 through 2013 Ford Explorer vehicles equipped with electric power assisted steering (EPAS), including 82,328 MY 2011 Explorersthat are the subject of PE12-017.Ford has assigned the recall number 14S06.The NHTSA recall number is 14V-286.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Sudden loss of power steering assist while driving can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe mode, which removes power from the EPAS motor and defaults to manual steering.Ford's DIR indicates that the majority of steering assist failures in the recalled vehicles have been caused by an intermittent electrical connection in the Power Steering Control Module (PSCM) that can lead to a loss of the motor position sensor signal.Ford's remedy instructs dealers to check the PSCM for diagnostic trouble codes (DTC).If upon initial inspection a loss of steering assist DTC is present, dealers will replace the steering gear at no charge to the owner and update the PSCM with revised software.Following detection of a motor position sensor signal fault, the revised software will provide audible and visual warnings to the driver that a power steering system fault has been detected and will maintain steering assist for the remainder of that drive cycle.If no DTC is present, dealers will reprogram the PSCM with the revised software. Analysis of information from all sources identified a total of 969 complaints and 4,059 warranty claims related to loss of power steering assist while driving in the MY 2011 through 2012 Explorer vehicles, resulting in a complaint rate of 5.4 incidents per thousand vehicles and a warranty claim rate of 2.3 percent.ODI identified 15 crashes with evidence indicating loss of power steering assist may have been a factor.All 15 crashes involved low-speed impacts with roadside objects during turning maneuvers, resulting in minor vehicle damage or no damage.In one incident that occurred in a low-speed curve, the driver attempted to brake in response to the sudden increase in steering effort and inadvertently applied the accelerator pedal instead.This caused the vehicle to run off the side of the road and strike a wooden pole at approximately 15 mph.Another incident occurred when the driver was unable to to negotiate a left-turn at an intersection and ran off the road into a shallow ditch, resulting in moderate front-end damage to the vehicle and minor injuries to the driver that did not require medical treatment. This investigation is closed.All ODI complaints associated with this closing resume are listed in the Attachment 1.
Illustration