NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
8 reportsClear category filter125,000 miles · Jul 28, 2012
Service Brakes, HydraulicVehicle Speed Control
I WAS COASTING UP TO A STOP LIGHT AND BEGAN APPLYING THE BRAKES. THE BRAKES DID NOT SEEM TO BE STOPPING THE CAR AND I REALIZED THAT THE ENGINE WAS RUNNING AT 3000 RPMS WHILE MY RIGHT FOOT WAS APPLYING THE BRAKES. SO THE ACCELERATION OCCURRED AFTER APPLYING THE BRAKES. I WAS ABLE TO GET THE CAR TO A STOP AND PUT IT INTO PARK W…
Read full complaint
I WAS COASTING UP TO A STOP LIGHT AND BEGAN APPLYING THE BRAKES. THE BRAKES DID NOT SEEM TO BE STOPPING THE CAR AND I REALIZED THAT THE ENGINE WAS RUNNING AT 3000 RPMS WHILE MY RIGHT FOOT WAS APPLYING THE BRAKES. SO THE ACCELERATION OCCURRED AFTER APPLYING THE BRAKES. I WAS ABLE TO GET THE CAR TO A STOP AND PUT IT INTO PARK WITHOUT HITTING THE CAR IN FRONT OF ME. I TURNED OFF THE IGNITION IMMEDIATELY AFTER STOPPING AND HAD THE CAR TOWED TO THE DEALERSHIP. I WILL NOT HAVE AN ANSWER FROM THEM BEFORE MONDAY. *TR
NHTSA ODI #10468108
101,840 miles · Jul 25, 2011
Service Brakes, Hydraulic
WAS APPROACHING A RED LIGHT AND APPLIED PRESSURE TO BRAKE PEDAL. THE BRAKE PEDAL HAS HARD AND WOULDN'T DEPRESS. THE ABS AND TRACTION CONTROL LIGHTS CAME ON AND THE VEHICLE CONTINUED THROUGH THE RED LIGHT. FORTUNATELY THERE WAS NO ONE IN FRONT OF ME OR ANY CROSS TRAFFIC. RELEASING THE BRAKE PEDAL AND REAPPLYING WITH THE ABS AND T…
Read full complaint
WAS APPROACHING A RED LIGHT AND APPLIED PRESSURE TO BRAKE PEDAL. THE BRAKE PEDAL HAS HARD AND WOULDN'T DEPRESS. THE ABS AND TRACTION CONTROL LIGHTS CAME ON AND THE VEHICLE CONTINUED THROUGH THE RED LIGHT. FORTUNATELY THERE WAS NO ONE IN FRONT OF ME OR ANY CROSS TRAFFIC. RELEASING THE BRAKE PEDAL AND REAPPLYING WITH THE ABS AND TRACTION CONTROL LIGHTS ON THE VEHICLE WAS FINALLY ABLE TO STOP. CAREFULLY DROVE THE VEHICLE HOME AND HAD IT TOWED TO THE DEALER THE FOLLOWING MORNING. DEALER DIAGNOSED IT AS THE FRONT HUBS BEING DEFECTIVE. THE HUB BEARINGS WERE SO LOOSE THAT THE ABS SENSOR AND SPEED RING WERE NOT IN CLOSE PROXIMITY TO EACH OTHER. DEALER REPLACED HUBS AND VEHICLE IS NOW FUNCTIONING PROPERLY. *TR
NHTSA ODI #10414966
73,000 miles · Oct 27, 2010
Service Brakes, Hydraulic
THE MASTERCYLINDER IS GOING UP ON MY 07 EXPLORE AND IT TAKES ME 2 TIME THE SPACE TO STOP. *TR
NHTSA ODI #10362684
38,000 miles · Mar 10, 2010
Power TrainService Brakes, Hydraulic
ALMOST FROM DAY ONE I THOUGHT THERE WAS A TRANSMISSION PROBLEM. FORD NEVER INFORMED ME, SO I WAITED UNTIL IT WAS NOTICEABLE ENOUGH TO DROP IT OFF AT A FORD DEALERSHIP FOR REPAIR. WHEN COMING TO A STOP THE TRANSMISSION KICKED AS IF SOMEONE HAD RUN INTO THE BACK OF US OR THE TRANSMISSION WOULD UNEXPECTEDLY LUNGE THE SUV FORWAR…
Read full complaint
ALMOST FROM DAY ONE I THOUGHT THERE WAS A TRANSMISSION PROBLEM. FORD NEVER INFORMED ME, SO I WAITED UNTIL IT WAS NOTICEABLE ENOUGH TO DROP IT OFF AT A FORD DEALERSHIP FOR REPAIR. WHEN COMING TO A STOP THE TRANSMISSION KICKED AS IF SOMEONE HAD RUN INTO THE BACK OF US OR THE TRANSMISSION WOULD UNEXPECTEDLY LUNGE THE SUV FORWARD AS IT CAME TO A STOP. THE CONSUMER STATED IN ORDER FOR THE DEALERSHIP TO FIX THE PROBLEM, THEY HAD TO REPROGRAM AND REPLACE THE BAD SOFTWARE PART WITH A NEW SOFTWARE PART. EVEN THOUGH THE TRANSMISSION WAS REPROGRAMMED, THE CONSUMER WAS INFORMED THE PROBLEM MOST LIKELY WOULD RETURN. THE CONSUMER ALSO STATED THERE WAS A PROBLEM WITH THE BRAKES. UPDATED 04/07/10.
NHTSA ODI #10318724
36,000 miles · Dec 9, 2009
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2007 FORD EXPLORER. WHEN HE ATTEMPTED TO ACCELERATE AFTER FUELING THE FUEL TANK, THE VEHICLE CAME TO COMPLETE STOP, WITHOUT BRAKE APPLICATION. THE VEHICLE DID NOT STALL. THE VEHICLE WAS TAKEN TO THE DEALER. HE WAS ADVISED THAT THE ABS BRAKING GEAR HAD FRACTURED. THE VEHICLE WAS SERVICED AT A LOCAL MECH…
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD EXPLORER. WHEN HE ATTEMPTED TO ACCELERATE AFTER FUELING THE FUEL TANK, THE VEHICLE CAME TO COMPLETE STOP, WITHOUT BRAKE APPLICATION. THE VEHICLE DID NOT STALL. THE VEHICLE WAS TAKEN TO THE DEALER. HE WAS ADVISED THAT THE ABS BRAKING GEAR HAD FRACTURED. THE VEHICLE WAS SERVICED AT A LOCAL MECHANIC SHOP. THE CURRENT AND FAILURE MILEAGES WERE 36000.
NHTSA ODI #10295069
20,000 miles · Oct 2, 2008
Power TrainService Brakes, Hydraulic
I AM HAVING PROBLEMS WITH MY BRAKES BLEEDING DOWN IT IS TO GO IN THE SHOP IN A COUPLE OF DAYS..I HAVE ALSO HAD THE SURGING PROBLEM AS OTHERS HAVE HAD. MY CAR WAS TAKEN TO A LOCAL FORD DEALERSHIP WERE THEY KEEP IT FOR A COUPLE OF DAYS. THEY DID HAVE TO RESET THE COMPUTER AND THE SURGING HAS STOPPED AND HAD NO PROBLEMS SINCE THEN.…
Read full complaint
I AM HAVING PROBLEMS WITH MY BRAKES BLEEDING DOWN IT IS TO GO IN THE SHOP IN A COUPLE OF DAYS..I HAVE ALSO HAD THE SURGING PROBLEM AS OTHERS HAVE HAD. MY CAR WAS TAKEN TO A LOCAL FORD DEALERSHIP WERE THEY KEEP IT FOR A COUPLE OF DAYS. THEY DID HAVE TO RESET THE COMPUTER AND THE SURGING HAS STOPPED AND HAD NO PROBLEMS SINCE THEN. *TR
NHTSA ODI #10244248
1,300 miles · Oct 24, 2007
Service Brakes, Hydraulic
NEW VEHICLE PURCHASE IN ORLANDO, FL ON 09-07-07. TOOK TO LOCAL FORD DEALER IN MEMPHIS, TN ON 09-10-07 WITH ISSUE OF VEHICLE PULLING AND STEERING WHEEL VIBRATION WHEN BRAKING, (1300 MILES ON VEHICLE). FORD SAID THE ROTORS WERE GLAZED AND WARPED, (FORD SERVICE EMPLOYEES UNABLE TO EXPLAIN HOW OR WHY THIS OCCURRED WITH ONLY 1300 MIL…
Read full complaint
NEW VEHICLE PURCHASE IN ORLANDO, FL ON 09-07-07. TOOK TO LOCAL FORD DEALER IN MEMPHIS, TN ON 09-10-07 WITH ISSUE OF VEHICLE PULLING AND STEERING WHEEL VIBRATION WHEN BRAKING, (1300 MILES ON VEHICLE). FORD SAID THE ROTORS WERE GLAZED AND WARPED, (FORD SERVICE EMPLOYEES UNABLE TO EXPLAIN HOW OR WHY THIS OCCURRED WITH ONLY 1300 MILE ON VEHICLE). FORD RESURFACED ROTORS,(FORD STATED THEY ARE ONLY REQUIRED TO RESURFACE ROTORS, NOT REPLACE THEM UNDER WARRANTY). FORD DID NOT REPLACE BRAKE PADS OR DO ANY OTHER BRAKE JOB ASSOCIATED REPAIR/REPLACEMENT. ROTORS WERE RESURFACED WITH OVER HALF USABLE BRAKE SURFACE REMOVED. I EXPLAINED TO FORD THAT WITH SO MUCH BRAKE SURFACE GONE THE NEXT TIME THE ROTORS ARE SERVICED, THE ROTORS WILL MOST CERTAINLY NEED TO BE REPLACED AT OWNERS EXPENSE. (THIS REPAIR HAS ELIMINATED THE FIRST RESURFACING OPTION FOR THE CONSUMER). *TR
NHTSA ODI #10206734
Mileage unknown · Jun 20, 2007
Service Brakes, HydraulicVehicle Speed Control
IN ATTEMPTING TO SLOW DOWN OUR COMPANY'S 2007 FORD EXPLORER I INADVERTENTLY PRESSED BOTH THE BRAKE PEDAL AND GAS PEDAL AT THE SAME TIME WITH THE SAME FOOT, CAUSING THE VEHICLE TO SPEED UP INSTEAD. I HAVE PREVIOUSLY EXPERIENCED THIS IN A RENTAL FORD CROWN VICTORIA. THERE WAS NO ACCIDENT, AND THERE WERE NO INJURIES, OTHER THAN A B…
Read full complaint
IN ATTEMPTING TO SLOW DOWN OUR COMPANY'S 2007 FORD EXPLORER I INADVERTENTLY PRESSED BOTH THE BRAKE PEDAL AND GAS PEDAL AT THE SAME TIME WITH THE SAME FOOT, CAUSING THE VEHICLE TO SPEED UP INSTEAD. I HAVE PREVIOUSLY EXPERIENCED THIS IN A RENTAL FORD CROWN VICTORIA. THERE WAS NO ACCIDENT, AND THERE WERE NO INJURIES, OTHER THAN A BRIEF PANIC ATTACK. MY SOLUTION WAS NOT DRIVE THE COMPANY'S VEHICLE, BUT INSTEAD DRIVE MY OWN CHEVROLET. *AK
NHTSA ODI #10193841
NHTSA investigations
1PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
Illustration