NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
44 reportsClear category filter108,673 miles · Mar 12, 2019
Air BagsVehicle Speed ControlCrashInjury
TL* THE CONTACT OWNS A 2005 FORD EXPLORER. WHILE THE CONTACT WAS REVERSING OUT OF THE DRIVEWAY, THE VEHICLE WAS PLACED INTO DRIVE AND ACCELERATED ON ITS OWN. THE ACCELERATOR PEDAL BECAME STUCK AT 60 MPH. THE VEHICLE WENT THROUGH A BACKYARD, DROVE OVER A CURB, DROVE THROUGH A NEIGHBOR'S BACKYARD, AND CRASHED INTO A TREE. THE AIR …
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD EXPLORER. WHILE THE CONTACT WAS REVERSING OUT OF THE DRIVEWAY, THE VEHICLE WAS PLACED INTO DRIVE AND ACCELERATED ON ITS OWN. THE ACCELERATOR PEDAL BECAME STUCK AT 60 MPH. THE VEHICLE WENT THROUGH A BACKYARD, DROVE OVER A CURB, DROVE THROUGH A NEIGHBOR'S BACKYARD, AND CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED TWO BLACK EYES AND A CONCUSSION THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CRASH WAS NOT IN RELATION TO ANY RECALL. THE FAILURE MILEAGE WAS 108,673.
NHTSA ODI #11186174
130,100 miles · Aug 14, 2018
Service BrakesVehicle Speed Control
1) ABS, BRAKE, AND WRENCH FAILURE LIGHTS FLASHED ON FOR ABOUT 3 SECONDS AND TURNED OFF WHEN DECELERATING WITH CRUISE CONTROL FROM 55 MPH TO 45 MPH ZONES AT COURLAND, VA. VEHICLE MANUAL PROVIDES NO GUIDANCE ON THIS FAILURE MODE; ONLY 'WARNING LIGHTS TURN ON AND CONTINUE FLASHING, REDUCE SPEED AND TAKE VEHICLE TO NEAREST SERVICE …
Read full complaint
1) ABS, BRAKE, AND WRENCH FAILURE LIGHTS FLASHED ON FOR ABOUT 3 SECONDS AND TURNED OFF WHEN DECELERATING WITH CRUISE CONTROL FROM 55 MPH TO 45 MPH ZONES AT COURLAND, VA. VEHICLE MANUAL PROVIDES NO GUIDANCE ON THIS FAILURE MODE; ONLY 'WARNING LIGHTS TURN ON AND CONTINUE FLASHING, REDUCE SPEED AND TAKE VEHICLE TO NEAREST SERVICE PROVIDER' AND 'WARNING LIGHTS TURN ON AND STAY ON, STOP DRIVING IMMEDIATELY AND HAVE VEHICLE TOWED TO NEAREST SERVICE PROVIDER.' 2) APPROXIMATELY TEN MINUTES LATER, DRIVER BEGAN APPLYING BRAKES TO DISENGAGE CRUISE CONTROL AND SLOW FROM 60 MPH TO 35 MPH SCHOOL ZONE SPEED ABOUT 50 TO 60 M BEFORE SCHOOL ZONE WARNING SIGN AT CAPRON ELEMENTARY, VA, ON STATE HIGHWAY 58. 3) DRIVER CHECKED SPEED UPON ENTERING SCHOOL ZONE AND FOUND CRUISE CONTROL LIGHT STILL ON AND VEHICLE STILL TRAVELING AT 60 MPH. DEPRESSED BRAKE APPROXIMATELY 1/3 TOTAL BRAKING RANGE (4 CM), WHICH SHOULD HAVE LOCKED THE BRAKES AND BROUGHT THE VEHICLE TO A FULL STOP. NO EFFECT. CRUISE CONTROL LIGHT REMAINED ON AND VEHICLE CONTINUED AT 60 MPH. 4) AT THIS POINT, DRIVER REALIZED THAT HE HAD NO CONTROL OF THE VEHICLE, PANICKED, AND DECIDED HE HAD TO STOP OR CRASH THE VEHICLE. DRIVER JAMMED THE BRAKE PETAL AS HARD AS HE COULD AND HELD. IT TOOK PROBABLY 3 SECONDS FOR THE REAR BRAKES TO FINALLY GO UP A LOGISTIC GROWTH RESISTANCE CURVE, GRAB, AND STOP THE VEHICLE. NO BRAKING BY FRONT WHEELS. ABS DID NOT WORK. CONTRIBUTING PHYSICAL DEFECTS: WORN-OUT FRONT BRAKES, EVEN THOUGH VEHICLE WAS KEPT UNDER RIGOROUS MAINTENANCE AND HAD VALID VIRGINIA STATE INSPECTION STICKER. WARPED FRONT BRAKE ROTORS MOST LIKELY INDUCED INTERMITTENT FALSE SIGNALS TO COMPUTER CONTROL CENTER CAUSING CRUISE CONTROL TO FAIL TO DISENGAGE.
NHTSA ODI #11119977
166,000 miles · Feb 27, 2018
Vehicle Speed Control
WHEN USING THE CRUISE CONTROL AND THE 2005 FORD EXPLORER IS GOING DOWN HILL OR WHEN PRESSING COAST BUTTON, THE 2005 FORD EXPLORER STALL, ENGINE CUTS OUT. STEERING AND BRAKING BECOMES DIFFICULT.
NHTSA ODI #11075313
256,450 miles · Feb 23, 2018
Vehicle Speed Control
I WAS BACKING UP FROM MY DRIVEWAY AND MY CAR ACCELERATED WHEN PUT INTO REVERSE AND IT PEELED OUT AND HAD TO HIT THE BRAKES REALLY HARD.SOMETIMES THE ENGINE SHAKES WHEN GOING FORWARD FOR A FEW SECONDS THEN IT GOES AWAY.
NHTSA ODI #11074582
Mileage unknown · Aug 25, 2017
Electrical SystemExterior LightingVehicle Speed Control
MY GAUGES GO HAYWIRE THE NEEDLES SHAKE WHILE DRIVING AND WHEN CAR IS OFF NO KEY IN IGNITION. THE LIGHTS FLASH AS WELL. CAR WILL STALL IN TRAFFIC AT A STOP, THE RPM WON'T GO ABOVE 2 EVEN WHEN HWY GOING 60 MPH. MECHANIC SAID IT'S ELECTRICAL, THE DEALER TOOK OUT TOP COUNSEL AS A WORK AROUND FOR THIS ELECTRICAL ISSUE CLAIMING IT WAS…
Read full complaint
MY GAUGES GO HAYWIRE THE NEEDLES SHAKE WHILE DRIVING AND WHEN CAR IS OFF NO KEY IN IGNITION. THE LIGHTS FLASH AS WELL. CAR WILL STALL IN TRAFFIC AT A STOP, THE RPM WON'T GO ABOVE 2 EVEN WHEN HWY GOING 60 MPH. MECHANIC SAID IT'S ELECTRICAL, THE DEALER TOOK OUT TOP COUNSEL AS A WORK AROUND FOR THIS ELECTRICAL ISSUE CLAIMING IT WAS NOT A RECALL.
NHTSA ODI #11019486
126,938 miles · Sep 6, 2015
Vehicle Speed Control
THE VEHICLE HAS A HARD TIME ACCELERATING, WHEN IT DOES, A "CLUCK" SOUND CAN BE HEARD, SOMETIMES ACCELERATION FAILS ALL TOGETHER. O/D LIGHT COMES ON AND BLINKS. CHECK TRANSMISSION LIGHT COMES ON.
NHTSA ODI #10761853
124,000 miles · Aug 13, 2015
Electrical SystemPower TrainVehicle Speed Control
THE VEHICLE SHUTS OFF WHILE DRIVING CAUSING LOSS OF POWER STEERING, POWER BRAKES WITH A COMPLETE LOSS OF POWER. THIS IS AN ONGOING PROBLEM AND HAS HAPPEND DURING HIGHWAY HIGH SPEED DRIVING. IT HAPPENS ON CARS BUILT 11/24/04 AND PRIOR. THE CODES ARE P2106 AND P2135. IT'S CAUSED BY A FAULTY THROTTLE POSITION SENSOR AND REQUIRES…
Read full complaint
THE VEHICLE SHUTS OFF WHILE DRIVING CAUSING LOSS OF POWER STEERING, POWER BRAKES WITH A COMPLETE LOSS OF POWER. THIS IS AN ONGOING PROBLEM AND HAS HAPPEND DURING HIGHWAY HIGH SPEED DRIVING. IT HAPPENS ON CARS BUILT 11/24/04 AND PRIOR. THE CODES ARE P2106 AND P2135. IT'S CAUSED BY A FAULTY THROTTLE POSITION SENSOR AND REQUIRES A POWERTRAIN CONTROL MODULE RESET B36.11, B37.2 OR HIGHER. THIS HAS BEEN AN ONGOING PROBLEM THAR FORD READILY ACKOWLEDGES. THEY HAVE UGRADED THE THROTTLE POSITION SENSOR TWICE WITHOUT SOLVING THE PROBLEM.
NHTSA ODI #10748493
160,000 miles · Jul 13, 2015
Vehicle Speed ControlCrash
TL* THE CONTACT OWNS A 2005 FORD EXPLORER. WHILE DRIVING AT 5 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT THE VEHICLE UNEXPECTEDLY ACCELERATED. AS A RESULT, THE VEHICLE CRASHED INTO THE CONTACT'S GARAGE AND OTHER VEHICLE. THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAI…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD EXPLORER. WHILE DRIVING AT 5 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT THE VEHICLE UNEXPECTEDLY ACCELERATED. AS A RESULT, THE VEHICLE CRASHED INTO THE CONTACT'S GARAGE AND OTHER VEHICLE. THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000. UPDATED 09/10/15*LJ
NHTSA ODI #10733768
86,000 miles · Jun 25, 2015
Fuel/propulsion SystemVehicle Speed Control
DRIVING DOWN THE ROAD, SUDDENLY THE WRENCH LIGHT CAME ON AND THE FAIL SAFE LIGHT CAME UP. VEHICLE WOULD BARELY RUN. CLEANED THROTTLE BODY AND IT SEEMED FINE FOR A WHILE. THEN THE SAME THING HAPPENED AGAIN, DRIVING NORMAL, THEN BAM. THIS TIME IT SHUT DOWN AND WOULD BARELY STAY RUNNING...JUST ORDERED A NEW THROTTLE BODY. I WI…
Read full complaint
DRIVING DOWN THE ROAD, SUDDENLY THE WRENCH LIGHT CAME ON AND THE FAIL SAFE LIGHT CAME UP. VEHICLE WOULD BARELY RUN. CLEANED THROTTLE BODY AND IT SEEMED FINE FOR A WHILE. THEN THE SAME THING HAPPENED AGAIN, DRIVING NORMAL, THEN BAM. THIS TIME IT SHUT DOWN AND WOULD BARELY STAY RUNNING...JUST ORDERED A NEW THROTTLE BODY. I WILL NOT OWN ANOTHER FORD.
NHTSA ODI #10730484
69,500 miles · May 25, 2014
Vehicle Speed Control
OUR 2005 EXPLORER WITH V8 ENGINE HAS DEVELOPED A SERIOUS PROBLEM WHEN CRUISE CONTROL IS ENGAGED AND A HILL IS CRESTED (FOR EXAMPLE) AND THE ENGINE GOES TO IDLE IT DROPS BELOW STALL SPEED AND DIES WHILE DRIVING. DRIVER MUST MOVE SHIFTER INTO N AND RESTART, OBVIOUSLY CRITICALLY DANGEROUS PROBLEM. THE CAR HAS NO PROBLEM WITH NORM…
Read full complaint
OUR 2005 EXPLORER WITH V8 ENGINE HAS DEVELOPED A SERIOUS PROBLEM WHEN CRUISE CONTROL IS ENGAGED AND A HILL IS CRESTED (FOR EXAMPLE) AND THE ENGINE GOES TO IDLE IT DROPS BELOW STALL SPEED AND DIES WHILE DRIVING. DRIVER MUST MOVE SHIFTER INTO N AND RESTART, OBVIOUSLY CRITICALLY DANGEROUS PROBLEM. THE CAR HAS NO PROBLEM WITH NORMAL DRIVING OR IDLING WITHOUT CRUISE ON. THIS PROBLEM IS PERSISTENT AND EASY TO REPRODUCE EVEN ON FLAT SURFACES WHEN CRUISE BACKS OFF THE THROTTLE TO SLOW DOWN. A/C CAN BE ON OR OFF. *TR
NHTSA ODI #10593952
NHTSA investigations
2EA09013 · Vehicle Rollaway Allegations
Opened Aug 18, 2009 · Closed Feb 12, 2013
Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:column Shift; Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Additional source detail variants (5)
Power Train:automatic Transmission:gear Position Indication (prndl)
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Power Train:automatic Transmission:lever And Linkage:column Shift
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Steering:column
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Steering:column LOCKING:ANTI-THEFT Device
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Steering
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
PE09020 · Vehicle Rollaway Allegations
Opened Apr 21, 2009 · Closed Aug 19, 2009
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABILITY TO SHIFT THE VEHICLE INTO PARK.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-013) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (3)
Steering:column
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABILITY TO SHIFT THE VEHICLE INTO PARK.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-013) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Steering:column LOCKING:ANTI-THEFT Device
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABILITY TO SHIFT THE VEHICLE INTO PARK.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-013) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Steering
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABILITY TO SHIFT THE VEHICLE INTO PARK.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-013) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Illustration