Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 153 of 1,450 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Tires. Review the 570 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 148 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 120 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
195 crash reports37 fire reports179 injury reports
What owners actually said
1,450 reports
Mileage unknown · Sep 12, 2000
Tires
ALL REAR SETS OF TIRES (3 TO DATE) HAVE BECOME CUPPED ACCOMPANIED BY AUTO VIBRATION. FORD DEALERSHIPS HAVE GIVEN BLAME FOR AUTO VIBRATION AND CUPPING OF TIRES TO TIRE MANUGACTURER. GOODYEAR, ACCORDINGLY, HAS REPLACED 2 TIRES ON TWO SEPARATE OCCASIONS. CUPPING DETECTED ON FIRST TIRE ROTATION WHEN REAR TIRES BROUGHT TO FRONT OF …
Read full complaint
ALL REAR SETS OF TIRES (3 TO DATE) HAVE BECOME CUPPED ACCOMPANIED BY AUTO VIBRATION. FORD DEALERSHIPS HAVE GIVEN BLAME FOR AUTO VIBRATION AND CUPPING OF TIRES TO TIRE MANUGACTURER. GOODYEAR, ACCORDINGLY, HAS REPLACED 2 TIRES ON TWO SEPARATE OCCASIONS. CUPPING DETECTED ON FIRST TIRE ROTATION WHEN REAR TIRES BROUGHT TO FRONT OF VEHICLE...ALONG WITH NOTICABLE DETERIORATION IN STEERING. THIS PROBLEM CONTINUES TO EXIST WITH NO APPARENT SATISFACTION PROVIDED BY LOCAL FORD. *AK( DOT NUMBER: TIRE SIZE: P235/75R15 )
NHTSA ODI #731117
Mileage unknown · Sep 12, 2000
Tires
WHILE DRIVING, FIRESTONE TIRE (NO TIRE INFORMATION) WHEN FLAT AND TREAD SEPARATED, CAUSING VEHICLE TO HIT ANOTHER CAR AND CAUSE DAMAGE. *TT
NHTSA ODI #6901300
Mileage unknown · Sep 12, 2000
TiresInjury
POSSIBLE FAULTY TIRE-TREAD PEELED OFF, DID NOT EXPLODE OR DEFLATE. FIRESTONE ATX P235/75R15. SPOKE TO CR LEO HE INDICATED THAT THEY ALLOWED THE INSUREDS ATTORNEY TO STORE THE TIRE THAT CAUSED THE ACCIDENT KILLING THE INSURED WIFE AND INJURING THE INSURED. INSURED WAS IN A COMA. HE HAS COME OUT OF THE COMA, BUT HE CANNOT BE SPOKE…
Read full complaint
POSSIBLE FAULTY TIRE-TREAD PEELED OFF, DID NOT EXPLODE OR DEFLATE. FIRESTONE ATX P235/75R15. SPOKE TO CR LEO HE INDICATED THAT THEY ALLOWED THE INSUREDS ATTORNEY TO STORE THE TIRE THAT CAUSED THE ACCIDENT KILLING THE INSURED WIFE AND INJURING THE INSURED. INSURED WAS IN A COMA. HE HAS COME OUT OF THE COMA, BUT HE CANNOT BE SPOKEN TO AT THIS TIME. IT IS UNLIKELY THAT HE WILL REMEMBER THE ACCIDENT. POLICE REPORT IS NOT AVAILABLE. WE HAVE AN AGREEMENT WITH INSURED ATTORNEY ABOUT HAVING ACCESS TO TIRE FOR OUR SUB CLAIM. WE ONLY ARE PURSUING SUB FOR PROPERTY. ATTORNEY HAS FILE A LAWSUIT AGAINST FIRESTONE FOR TE INJURIES. (CLAIM# 59-V478-196) *MW
NHTSA ODI #6900279
Mileage unknown · Sep 12, 2000
Tires
INSURED HAD A FIRESTONE RADIAL ATX P235/75/R15 TIRE IN WHICH THE TREAD CAME COMPLETELY OFF TIRE. TREAD SEPARATED FROM TIRE AND DAMAGED REAR FENDER. (CLAIM# 04-1224-987) *MW
NHTSA ODI #6900275
Mileage unknown · Sep 12, 2000
TiresInjury
FIRESTONE TIRE UNRAVELED. ANY MANUFACTURE'S DEFECTS KNOWN FOR POSSIBLE SUB? V1 TRAVELING SOUTHBOUND. REAR LEFT TIRE UNRAVELED. VEH LOST CONTROL AND WENT INTO THE SWAMP/MARSH. (CLAIM# 55-S237-485) *MW
NHTSA ODI #6900273
Mileage unknown · Sep 12, 2000
Tires
THE ORIGINAL FIRESTONE TIRES STILL ON VEHICLE WITH OVER 40,000 MILES ON VEH. THE LEFT REAR TIRE BLEW OUT, THE TIRE DAMAGED THE WHEEL WELL/QTR PANEL. (CLAIM# 43-R498-159) *MW
NHTSA ODI #6900272
Mileage unknown · Sep 12, 2000
Tires
IN MIDDLE OF NOWHERE INSURED HAD A FLAT TIRE AND TREAD SEPARATED AND HIT CAR AND CAUSED DAMAGE. INSURED WANTS CAREST BY SF TO SEE IF OVER DEDUCTIBLE. ADDITIONAL INFO PER CSR: C-SPOKE TO NI, SHE SAW SOMETHING ON THE NEWS RE: FORD RECALL ON HER VEHICLE WITHT HE FACTORY FIRESTONE TIRES, SENT IN CRASH INQUIRY, TOLD NI TO CALL THE NU…
Read full complaint
IN MIDDLE OF NOWHERE INSURED HAD A FLAT TIRE AND TREAD SEPARATED AND HIT CAR AND CAUSED DAMAGE. INSURED WANTS CAREST BY SF TO SEE IF OVER DEDUCTIBLE. ADDITIONAL INFO PER CSR: C-SPOKE TO NI, SHE SAW SOMETHING ON THE NEWS RE: FORD RECALL ON HER VEHICLE WITHT HE FACTORY FIRESTONE TIRES, SENT IN CRASH INQUIRY, TOLD NI TO CALL THE NUMBER SHE SAW & FILE COMPLAINT WITH FORD ALSO. (CLAIM# 59-V522-251) *MW
NHTSA ODI #6900250
Mileage unknown · Sep 12, 2000
TiresInjury
OUR INSURED WAS A PASSENGER IN A VEH OWNED BY: D.F. HER DAUGHTER WAS DRIVING A TIRE BLEW OUT THE VEH ROLLED SEVERAL TIMES. THE DRIVER WAS KILLED.XXXXXHAS SERIOUS INJURIES TO BOTH FEET. CALL AGENTS OFFICE BEFORE CONTACTING ANYONE ON THIS CLAIM. SAFECO CLM (CLAIM# 53-C530-051) *MW
NHTSA ODI #6900220
Mileage unknown · Sep 12, 2000
Tires
F-V1 DRIVING ON 12 0 FIRESTONE TIRE BLEW TREAD-DAMAGED CAR A-390 S-MAYBE POL 10/28/1991 FIRESTONE RADIAL ATX II 23575R15 TUOLPS. (CLAIM# 43-R534-991) *MW
NHTSA ODI #6900113
Mileage unknown · Sep 12, 2000
Tires
FIRESTONE: TREAD SEPARATION OLDER CLAIM NO RECORD OF WHICH TIRE WAS INVOLVED. (CLAIM# 53-C254-357) *MW
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. THE LIFTGATE ASSIST GAS CYLINDER BRACKET ON THE RIGHT HAND BODYSIDE OUTER PANEL WAS INCORRECTLY WELDED.
Consequence & remedy
Consequence: THE GAS CYLINDER BRACKET MAY NOT PROPERLY SUPPORT THE LIFTGATE INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REINFORCE THE BRACKET ATTACHMENT WITH TWO POP RIVETS.
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 5.0L ENGINES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, IDAHO, IOWA, MAINE, MICHIGAN (UPPER PENINSULA ONLY), MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. THESE VEHICLES, WHEN OPERATED FOR EXTENDED PERIODS OF TIME AT HIGHWAY SPEEDS AND TEMPERATURES BELOW -20 DEGREES FARENHEIT, DO NOT RETURN TO IDLE DUE TO ICE IN THE THROTTLE BODY.
Consequence & remedy
Consequence: ALTHOUGH THE VEHICLE CAN BE CONTROLLED BY EITHER APPLYING THE SERVICE BRAKES OR SHIFTING THE TRANSMISSION TO NEUTRAL, INCREASED BRAKE PEDAL EFFORTS OR SOME INCREASE IN STOPPING DISTANCE CAN RESULT.
Remedy: DEALERS WILL INSTALL A REVISED PCV SYSTEM WITH WATER HEATED VACUUM SOURCE.
THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .
Remedy: OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
PE00039 · Front Suspension Stabilizer Bar Link
Opened Sep 20, 2000 · Closed Nov 30, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE99068 · Accelerator Pedal
Opened Nov 1, 1999 · Closed Mar 9, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE97010 · Electrical Fire In Center Console
Opened Mar 13, 1997 · Closed Sep 4, 1997
Status: closed (inferred from source dates) · Electrical System
THIS INVESTIGATION REVEALED THAT CONSOLE FIRES IN THE SUBJECT VEHICLES MOST OFTEN OCCURRED WHILE VEHICLES EQUIPPED WITH THE LAMP OUTAGE MODULE (LOM), WHICH IS PART OF THE MESSAGE CENTER, WERE TOWING A TRAILER AND WHICH HAD BEEN MODIFIED BY ADDING AN AFTERMARKET TRAILER WIRING HARNESS INTO THE VEHICLE'S TAILLIGHT CIRCUITS.THE OWNER'S MANUAL STATES NEVER AND MORE THAN OTHER TRAILER LIGHT BULB TO ONE CIRCUIT HOWEVER TRAILERS FREQUENTLY CONTAIN SEVERAL BULBS.THE RESULTING EXCESS CURRENT PASSING THROUGH THE LOM COULD CAUSE IT TO OVERHEAT RESULTING IN A FIRE.PROPER AFTERMARKET INSTALLATION OF TRAILER WIRING REQUIRES THE USE OF A BYPASS MODULE, WHICH OBTAINS POWER FOR THE TRAILER LIGHTS DIRECTLY FROM THE BATTERY RATHER THAN FROM THE VEHICLE'S TAIL LIGHT AND STOP LAMP CIRCUITS, OR THE USE OF THE MANUFACTURER'S WIRING HARNESS.IN A LETTER DATED SEPTEMBER 2, 1997, FORD NOTIFIED ODI THAT IT INTENDS TO TAKE ACTION TO PRECLUDE FURTHER INCIDENTS INCLUDING ISSUING A TECHNICAL SERVICE BULLETIN TO ITS DEALERS, NOTIFYING TRAILER RENTAL ASSOCIATIONS AND AGENCIES WHERE KNOWN, AND ADVISING OWNERS BY LETTER OF THE PROPER METHOD FOR CONNECTION OF TRAILER TOW WIRING ON THE SUBJECT VEHICLES.THERE WAS NO DEFECT TREND IN THE SUBJECT VEHICLES IDENTIFIED AS A RESULT OF THIS INVESTIGATION, AND FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT WARRANTED TO CONTINUE THE INVESTIGATION.
Illustration