Illustration00 T 005 000/TREAD SEPARATION: DEALER (SUNRISE METRO FORD; NORTH HOLLYWOOD, CA; PHONE # 818/980-9800) REFUSED TO HONOR MANUFACTURER RECALL 00T005 CONCERNING TIRE SIZE P235/75R15, DOT# H4BNDFA478. SEEKING HELP FROM NHTSA IN THIS MATTER. AK *YH
1996 Ford Explorer
Owner reports · Recalls · Investigations
More warning signs than most Explorer years
Owner complaints for the 1996 Ford Explorer are substantially higher than the model-year median of 609.
About this comparison →How this year compares
Owner complaints by model year
Compare all Explorer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 153 of 1,450 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 570 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 148 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 120 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
195 crash reports37 fire reports179 injury reports
What owners actually said
1,450 reportsAFTER I BOUGHT THIS VEHICLE, I HAVE TAKEN IT BACK AT LEAST 6 TIMES DUE TO A VIBRATION. ON FEB.2001, THE TRANSMISSION WAS REPLACED. THIS PROBLEM STILL EXISTED, JUST NOT AS MUCH. I TOOK THE MECHANIC ON A TEST DRIVE 2 TIMES AFTER THE TRANSMISSION WAS REPLACED. UNFORTUNITELY IT DID NOT DO THE VIBRATION. JUST RECENTLY, IT STARTED GET…
Read full complaint
AFTER I BOUGHT THIS VEHICLE, I HAVE TAKEN IT BACK AT LEAST 6 TIMES DUE TO A VIBRATION. ON FEB.2001, THE TRANSMISSION WAS REPLACED. THIS PROBLEM STILL EXISTED, JUST NOT AS MUCH. I TOOK THE MECHANIC ON A TEST DRIVE 2 TIMES AFTER THE TRANSMISSION WAS REPLACED. UNFORTUNITELY IT DID NOT DO THE VIBRATION. JUST RECENTLY, IT STARTED GETTING WORSE. I TOOK IT TO ANOTHER FORD DEALER TODAY, I WAS TOLD THAT IT WAS THE TORQUE CONVERTER. AT THE TIME OF THE TRANSMISSION REPLACEMENT, I ASKED ABOUT THE TORQUE CONVERTER, I WAS TOLD THAT IT WAS REPLACED WITH THE TRANSMISSION. OBVIOUSLY THIS WAS NOT DONE.*AK
WHEN SHUTTING OFF ENGINE AUTOMATIC DOOR LOCKS ENGAGED. DRIVER'S REAR DOOR LOCK WAS REPLACED IN SEPTEMBER 2001, PASSENGER REAR DOOR LOCK WAS REPLACED DECEMBER 19, 2001.
THE CONSUMER WAS TRAVELING WHEN THE VEHICLE WAS STRUCK IN THE REAR BY ANOTHER VEHICLE, CAUSING THE VEHICLE TO SPIN AROUND AND ROLL. DURING THE ACCIDENT, THE DRIVER DOOR CAME OPEN AND THE DRIVER SEAT BELT CAME LOOSE. AS A RESULT, DRIVER WAS THROWN OUT OF THE VEHICLE. THE PASSENGER'S SEAT BELT ALSO BECAME LOOSE. THE DRIVER DIED IN…
Read full complaint
THE CONSUMER WAS TRAVELING WHEN THE VEHICLE WAS STRUCK IN THE REAR BY ANOTHER VEHICLE, CAUSING THE VEHICLE TO SPIN AROUND AND ROLL. DURING THE ACCIDENT, THE DRIVER DOOR CAME OPEN AND THE DRIVER SEAT BELT CAME LOOSE. AS A RESULT, DRIVER WAS THROWN OUT OF THE VEHICLE. THE PASSENGER'S SEAT BELT ALSO BECAME LOOSE. THE DRIVER DIED INSTANTLY. THE PASSENGER SUFFERED SERIOUS INJURIES. THE AIR BAGS ALSO FAILED TO DEPLOY.(SISTER ON BEHALF OF DECEASED BROTHER) *YH
AT LOW SPEED SENSOR SENDS A WRONG SIGNAL TO ABS BRAKE SYSTEM ,RESULTING IN POOR BRAKING. PLEASE PROVIDE FURTHER INFORMATION.*AK
THE DEVICE CAUSED MY 2 YEAR OLD DAUGHTER TO LOSE A PORTION OF HER RIGHT POINTER FINGER AND WE FEEL THIS COULD BE PREVENTED IF THAT PART WAS COVERED UP (AT THE VERY LEAST) IN THE MODELS IT EXISTS IN. IT CAN HAPPEN WHEN THE REAR DOOR IS BEING OPENED AND THE FRONT DOOR IS ALREADY OPEN. MY DAUGHTER WAS STANDING IN THE DOORWAY OF T…
Read full complaint
THE DEVICE CAUSED MY 2 YEAR OLD DAUGHTER TO LOSE A PORTION OF HER RIGHT POINTER FINGER AND WE FEEL THIS COULD BE PREVENTED IF THAT PART WAS COVERED UP (AT THE VERY LEAST) IN THE MODELS IT EXISTS IN. IT CAN HAPPEN WHEN THE REAR DOOR IS BEING OPENED AND THE FRONT DOOR IS ALREADY OPEN. MY DAUGHTER WAS STANDING IN THE DOORWAY OF THE FRONT DOOR AND APPARENTLY TOUCHED THIS ROLLER MECHINISM AS MY HUSBAND WAS OPENING THE REAR DOOR, IT BASCIALLY SUCKED HER FINGER IN AND CUT IT OFF (DUE TO THE PRESSURE - THE ROLLER USES THE CAR BODY TO HOLD THE DOOR OPEN). WE HAVE CHECKED AND SOME VEHICLES HAVE THIS AND OTHER DO NOT AND SOME HAVE IT COVERED UP! IT WOULD ONLY BE APPLICABLE IN 4 DOOR VEHICLES. PLEASE CONTACT ME FOR FURTHER INFORMATION, AS I KNOW IT IS SOMEWHAT CONFUSING. BUT WE WOULD LIKE TO PREVENT ANYONE ELSE FROM GOING THROUGH WHAT WE DID - MY DAUGHTER (2 YEARS OLD) HAD TO HAVE EMERGENCY SURGERY TO REMOVE MORE OF THE BONE/FINGER AND REPAIR THE TIP THE BEST IT COULD BE. SHE STILL HAS DISCOMFORT AT TIMES AND IT HAS BEEN 2 1/2 MONTHS SINCE THE ACCIDENT. WE HAVE CHECKED IT OUT AND SHE COULD HAVE FIT HER WHOLE HAND IN THERE WHICH WOULD OF BEEN EVEN MORE TRAGIC! I HOPE YOU WILL HELP US GET THE WORD OUT ABOUT THIS DANGEROUS PART IN MANY CARS. *AK
WHILE ACCELERATING ON INTERSTATE 17 TO PASS A TRUCK, THE ENTIRE GAS PEDAL ASSEMBLY SEPARATED FROM THE FIREWALL OF VEHICLE, CAUSING A SUDDEN LOSS OF POWER AND A NEAR-COLLISION.*AK
ACCELERATOR STICKS WHILE DRIVING REQUIRES PLACING VEHICLE IN NEUTRAL AND PULLING ACCELERATOR PEDAL TO CORRECT - CAN BE VERY DANGEROUS IN TRAFFIC WITH INEXPERIENCED DRIVER.*AK
THE RIGHT REAR TIRE SIDEWALL BLEW OUT IN ABOUT 7 PLACES ON MY 1996 FORD EXPLORER YESTERDAY ( 11-11-01) ON I-71 ABOUT 30 MILES NORTH OF COLUMBUS OHIO. AT RIGHT AROUND 65 MPH I WAS VERY LUCKY THAT I COULD KEEP CONTROL OF THE VEHICLE AND GET IT PULLED OVER TO THE SIDE OF THE ROAD. AFTER CALLING AAA FOR ASSISTANCE THE MECHANIC THAT …
Read full complaint
THE RIGHT REAR TIRE SIDEWALL BLEW OUT IN ABOUT 7 PLACES ON MY 1996 FORD EXPLORER YESTERDAY ( 11-11-01) ON I-71 ABOUT 30 MILES NORTH OF COLUMBUS OHIO. AT RIGHT AROUND 65 MPH I WAS VERY LUCKY THAT I COULD KEEP CONTROL OF THE VEHICLE AND GET IT PULLED OVER TO THE SIDE OF THE ROAD. AFTER CALLING AAA FOR ASSISTANCE THE MECHANIC THAT CAME OUT TO CHANGE THE TIRE TOLD ME THAT THIS WAS A MAJOR TIRE FAILURE. I WOULD LIKE TO KNOW WHAT OR NOW TO FOLLOW UP ON THIS?*AK (TIRESIZE: P235/75R15)
BRAKES FAILED TO STOP VEHICLE AND THERE WAS EXTENDED STOPPING DISTANCE. HAD TAKEN VEHICLE TO DEALERSHIP, AND WAS INFORMED BY MECHANIC THAT ROTORS NEEDED REPLACING DUE TO BEING CORRODED. DID NOT HAVE ANY EMERGENCY BRAKES.*AK *SLC
Official recalls
609V399000 · Vehicle Speed Control
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
00V402000 · Suspension
Nov 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CONDITIONS, A FRONT SWAY BAR LINK CAN FRACTURE.
Consequence & remedy
Consequence: VEHICLE HANDLING COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH THE LEFT AND RIGHT FRONT SWAY BAR LINKS.
97V137000 · Structure:body:hatchback/liftgate:support Device/strut
Aug 19, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. THE LIFTGATE ASSIST GAS CYLINDER BRACKET ON THE RIGHT HAND BODYSIDE OUTER PANEL WAS INCORRECTLY WELDED.
Consequence & remedy
Consequence: THE GAS CYLINDER BRACKET MAY NOT PROPERLY SUPPORT THE LIFTGATE INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REINFORCE THE BRACKET ATTACHMENT WITH TWO POP RIVETS.
97V074000 · Vehicle Speed Control
Apr 30, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 5.0L ENGINES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, IDAHO, IOWA, MAINE, MICHIGAN (UPPER PENINSULA ONLY), MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. THESE VEHICLES, WHEN OPERATED FOR EXTENDED PERIODS OF TIME AT HIGHWAY SPEEDS AND TEMPERATURES BELOW -20 DEGREES FARENHEIT, DO NOT RETURN TO IDLE DUE TO ICE IN THE THROTTLE BODY.
Consequence & remedy
Consequence: ALTHOUGH THE VEHICLE CAN BE CONTROLLED BY EITHER APPLYING THE SERVICE BRAKES OR SHIFTING THE TRANSMISSION TO NEUTRAL, INCREASED BRAKE PEDAL EFFORTS OR SOME INCREASE IN STOPPING DISTANCE CAN RESULT.
Remedy: DEALERS WILL INSTALL A REVISED PCV SYSTEM WITH WATER HEATED VACUUM SOURCE.
96V161000 · Equipment:other:labels
Aug 29, 1996
THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .
Remedy: OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.
96V070000 · Latches/locks/linkages:doors:latch
Apr 22, 1996
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE00039 · Front Suspension Stabilizer Bar Link
Opened Sep 20, 2000 · Closed Nov 30, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE99068 · Accelerator Pedal
Opened Nov 1, 1999 · Closed Mar 9, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE97010 · Electrical Fire In Center Console
Opened Mar 13, 1997 · Closed Sep 4, 1997
Status: closed (inferred from source dates) · Electrical System
THIS INVESTIGATION REVEALED THAT CONSOLE FIRES IN THE SUBJECT VEHICLES MOST OFTEN OCCURRED WHILE VEHICLES EQUIPPED WITH THE LAMP OUTAGE MODULE (LOM), WHICH IS PART OF THE MESSAGE CENTER, WERE TOWING A TRAILER AND WHICH HAD BEEN MODIFIED BY ADDING AN AFTERMARKET TRAILER WIRING HARNESS INTO THE VEHICLE'S TAILLIGHT CIRCUITS.THE OWNER'S MANUAL STATES NEVER AND MORE THAN OTHER TRAILER LIGHT BULB TO ONE CIRCUIT HOWEVER TRAILERS FREQUENTLY CONTAIN SEVERAL BULBS.THE RESULTING EXCESS CURRENT PASSING THROUGH THE LOM COULD CAUSE IT TO OVERHEAT RESULTING IN A FIRE.PROPER AFTERMARKET INSTALLATION OF TRAILER WIRING REQUIRES THE USE OF A BYPASS MODULE, WHICH OBTAINS POWER FOR THE TRAILER LIGHTS DIRECTLY FROM THE BATTERY RATHER THAN FROM THE VEHICLE'S TAIL LIGHT AND STOP LAMP CIRCUITS, OR THE USE OF THE MANUFACTURER'S WIRING HARNESS.IN A LETTER DATED SEPTEMBER 2, 1997, FORD NOTIFIED ODI THAT IT INTENDS TO TAKE ACTION TO PRECLUDE FURTHER INCIDENTS INCLUDING ISSUING A TECHNICAL SERVICE BULLETIN TO ITS DEALERS, NOTIFYING TRAILER RENTAL ASSOCIATIONS AND AGENCIES WHERE KNOWN, AND ADVISING OWNERS BY LETTER OF THE PROPER METHOD FOR CONNECTION OF TRAILER TOW WIRING ON THE SUBJECT VEHICLES.THERE WAS NO DEFECT TREND IN THE SUBJECT VEHICLES IDENTIFIED AS A RESULT OF THIS INVESTIGATION, AND FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT WARRANTED TO CONTINUE THE INVESTIGATION.