IllustrationACCELERATOR PEDAL FAILED DUE TO A FAULTY WELD. DEALER/ MANUFACTURER NOTIFIED AND REFUSED TO REPAIR UNLESS COST GOES TO CONSUMER. CAN NHTSA PROVIDE ADDITIONAL INFORMATION OR HELP IN THIS MATTER. *AK
1996 Ford Explorer
Owner reports · Recalls · Investigations
More warning signs than most Explorer years
Owner complaints for the 1996 Ford Explorer are substantially higher than the model-year median of 609.
About this comparison →How this year compares
Owner complaints by model year
Compare all Explorer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 153 of 1,450 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 570 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 148 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 120 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
195 crash reports37 fire reports179 injury reports
What owners actually said
1,450 reportsI HAD TREAD SEPARATION ON TWO TIRES WITHIN A WEEK. FIRST INCIDENT WAS REPORTED TO FIRESTONE. REPORT#017116. SECOND INCIDENT WILL BE REPORTED ON MONDAY 6-28-99. I AM NOT TAKING ANY MORE CHANCES. I AM REPLACING REMAING 2 FRONT TIRES AND THE DAMAGED TIRES TODAY. I WANT FIRESTONE TO PAY FOR ALL BAD TIRES. I WANT YOU TO INVESTIGATE, …
Read full complaint
I HAD TREAD SEPARATION ON TWO TIRES WITHIN A WEEK. FIRST INCIDENT WAS REPORTED TO FIRESTONE. REPORT#017116. SECOND INCIDENT WILL BE REPORTED ON MONDAY 6-28-99. I AM NOT TAKING ANY MORE CHANCES. I AM REPLACING REMAING 2 FRONT TIRES AND THE DAMAGED TIRES TODAY. I WANT FIRESTONE TO PAY FOR ALL BAD TIRES. I WANT YOU TO INVESTIGATE, THIS IS SERIOUS. IF YOU NEED ANYMORE INFORMATION LET ME KNOW. THANKS. *AK( DOT NUMBER: VDHL1PM TIRE SIZE: P235/75R15 )
AFTER TAKING FOOT OFF THE ACCELERATOR PEDAL VEHICLE CONTINUES TO ACCELERATE. DEALER CAN NOT IDENTIFY THE PROBLEM. PLEASE GIVE ANY FURTHER DETAILS. *AK
WHILE DRIVING DRIVER'S AIR BAG DEPLOYED WITHOUT ANY WARNING. *AK
CONSUMER WAS DRIVING APPROXIMATELY 55-65 MPH ON TWO OCCASIONS WHEN THE VEHICLE WOULD NOT STOP. HE TOOK VEHICLE IN FOR RECALL #97V-074 FORD, THROTTLE LINKAGES AND CONTROL FAILURE. DEALERSHIP SAID THIS WAS NOT THE PROBLEM. ALSO, WOULD NOT HONOR THE RECALL. *AK
SPEED CONTROL FAILED TO DISENGAGE WHEN BRAKING OR USING OFF BUTTON, THROTTLE CABLE HUNG UP SHIFTED TO NEUTRAL, BUT TRANSMISSION SHIFTED BETWEEN NEUTRAL AND REVERSE AND DESTROYED TRANSMISSION. *AK
THE SEALS THAT ARE BEING REPLACED HAVE BEEN RE-DESIGNED AND ARE NOT COVERED UNDER ANY EXTENDED SERVICE PLAN (EVEN THE "PREMIUMCARE"). *AK
THE REAR RIGHT DOOR WILL NOT OPEN FROM THE INSIDE. DEALER HAS BEEN NOTIFIED. *AK
THE FRONT TIRES HAVE"CUPPED" WITHIN 2000 MILES OF PURCHASING THE VEHICLE. I HAVE BEEN TO THE DEALER AND TO GOODYEAR OVER THIS ISSUE. I HAVE NOTICED THAT BRAKING TAKES LONGER TO ACCOMPLISH BECAUSE OF THE UNEVEN WEAR PATTERN THAT HAS DEVELOPED. I'VE HAD TO REPLACE 2 TIRES AT 46,000 MLES(AS COMPARED WITH 70,000 MILES ON A 1992 EXPL…
Read full complaint
THE FRONT TIRES HAVE"CUPPED" WITHIN 2000 MILES OF PURCHASING THE VEHICLE. I HAVE BEEN TO THE DEALER AND TO GOODYEAR OVER THIS ISSUE. I HAVE NOTICED THAT BRAKING TAKES LONGER TO ACCOMPLISH BECAUSE OF THE UNEVEN WEAR PATTERN THAT HAS DEVELOPED. I'VE HAD TO REPLACE 2 TIRES AT 46,000 MLES(AS COMPARED WITH 70,000 MILES ON A 1992 EXPLORER THAT I OWNED THAT WAS EQUIPPED WITH FIRESTONE TIRES). GOODYEAR HAS TOLD ME THAT I HAVE TO ROTATE MY TIRES EVERY3,000 MILES TO PREVENT THIS WEAR PATTERN. I BELIEVE THIS IS EXCESSIVE MAINTENANCE AND COST TO THE CONSUMER. GOODYEAR HAS ALSO TOLD ME THAT THESE TIRES WERE NOT ENGINEERED FOR THIS VEHICLE, BUT FORD EQUPIPED THESE VEHICLES WITH THESE TIRES AS STANDARD EQUIPMENT IN 1996. I'VE NOTICED THAT SINCE1997, FORD HAS GONE BACK TO FIRESTONE TIRES FOR EXPLORERS. I HAVE CALLED THE FORD CONSUMER HOT LINE. I SPOKE WITH THE PERSON ANSWERING THE CALLS AND EXPLAINED THE PROBLEM. I WAS TOLD I WOULD HEAR FROM A FORD REP, BUT AFTER A YEAR I HAVE HEARD NOTHING. GOODYEAR HAS LOOKED AT ALL MECHANICAL COMPONENTS, INCLUDING SUSPENSION BUSHING AND ALIGNMENT THAT COULD BE CAUSING THIS PROBLEM AND HAS FOUND NOTHING WRONG. I BELIEVE THIS PROBLEM MAY BE INHERENT TO FORD PUTTING TIRES ON THIS AUTMOBILE THAT ARE NOT MATCHED TO THE VEHICAL SUSPENSION. *AK( DOT NUMBER: TIRE SIZE: P235/75R15 )
CROSSED INTERSECTION & APPLIED BRAKES TO SLOW DOWN. VEHICLE FAILED TO SLOW DOWN. USED EMERGENCY BRAKES & VEHICLE KEPT GOING. FINALLY SHIFTED INTO PARK & VEHICLE STOPPED. TOWED VEHICLE TO HOME. NOTICED THICK HEM OF CARPETING HAD MOVED OVER ACCELERATOR PEDAL. *AK
Official recalls
609V399000 · Vehicle Speed Control
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
00V402000 · Suspension
Nov 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CONDITIONS, A FRONT SWAY BAR LINK CAN FRACTURE.
Consequence & remedy
Consequence: VEHICLE HANDLING COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH THE LEFT AND RIGHT FRONT SWAY BAR LINKS.
97V137000 · Structure:body:hatchback/liftgate:support Device/strut
Aug 19, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. THE LIFTGATE ASSIST GAS CYLINDER BRACKET ON THE RIGHT HAND BODYSIDE OUTER PANEL WAS INCORRECTLY WELDED.
Consequence & remedy
Consequence: THE GAS CYLINDER BRACKET MAY NOT PROPERLY SUPPORT THE LIFTGATE INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REINFORCE THE BRACKET ATTACHMENT WITH TWO POP RIVETS.
97V074000 · Vehicle Speed Control
Apr 30, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 5.0L ENGINES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, IDAHO, IOWA, MAINE, MICHIGAN (UPPER PENINSULA ONLY), MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. THESE VEHICLES, WHEN OPERATED FOR EXTENDED PERIODS OF TIME AT HIGHWAY SPEEDS AND TEMPERATURES BELOW -20 DEGREES FARENHEIT, DO NOT RETURN TO IDLE DUE TO ICE IN THE THROTTLE BODY.
Consequence & remedy
Consequence: ALTHOUGH THE VEHICLE CAN BE CONTROLLED BY EITHER APPLYING THE SERVICE BRAKES OR SHIFTING THE TRANSMISSION TO NEUTRAL, INCREASED BRAKE PEDAL EFFORTS OR SOME INCREASE IN STOPPING DISTANCE CAN RESULT.
Remedy: DEALERS WILL INSTALL A REVISED PCV SYSTEM WITH WATER HEATED VACUUM SOURCE.
96V161000 · Equipment:other:labels
Aug 29, 1996
THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .
Remedy: OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.
96V070000 · Latches/locks/linkages:doors:latch
Apr 22, 1996
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE00039 · Front Suspension Stabilizer Bar Link
Opened Sep 20, 2000 · Closed Nov 30, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE99068 · Accelerator Pedal
Opened Nov 1, 1999 · Closed Mar 9, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE97010 · Electrical Fire In Center Console
Opened Mar 13, 1997 · Closed Sep 4, 1997
Status: closed (inferred from source dates) · Electrical System
THIS INVESTIGATION REVEALED THAT CONSOLE FIRES IN THE SUBJECT VEHICLES MOST OFTEN OCCURRED WHILE VEHICLES EQUIPPED WITH THE LAMP OUTAGE MODULE (LOM), WHICH IS PART OF THE MESSAGE CENTER, WERE TOWING A TRAILER AND WHICH HAD BEEN MODIFIED BY ADDING AN AFTERMARKET TRAILER WIRING HARNESS INTO THE VEHICLE'S TAILLIGHT CIRCUITS.THE OWNER'S MANUAL STATES NEVER AND MORE THAN OTHER TRAILER LIGHT BULB TO ONE CIRCUIT HOWEVER TRAILERS FREQUENTLY CONTAIN SEVERAL BULBS.THE RESULTING EXCESS CURRENT PASSING THROUGH THE LOM COULD CAUSE IT TO OVERHEAT RESULTING IN A FIRE.PROPER AFTERMARKET INSTALLATION OF TRAILER WIRING REQUIRES THE USE OF A BYPASS MODULE, WHICH OBTAINS POWER FOR THE TRAILER LIGHTS DIRECTLY FROM THE BATTERY RATHER THAN FROM THE VEHICLE'S TAIL LIGHT AND STOP LAMP CIRCUITS, OR THE USE OF THE MANUFACTURER'S WIRING HARNESS.IN A LETTER DATED SEPTEMBER 2, 1997, FORD NOTIFIED ODI THAT IT INTENDS TO TAKE ACTION TO PRECLUDE FURTHER INCIDENTS INCLUDING ISSUING A TECHNICAL SERVICE BULLETIN TO ITS DEALERS, NOTIFYING TRAILER RENTAL ASSOCIATIONS AND AGENCIES WHERE KNOWN, AND ADVISING OWNERS BY LETTER OF THE PROPER METHOD FOR CONNECTION OF TRAILER TOW WIRING ON THE SUBJECT VEHICLES.THERE WAS NO DEFECT TREND IN THE SUBJECT VEHICLES IDENTIFIED AS A RESULT OF THIS INVESTIGATION, AND FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT WARRANTED TO CONTINUE THE INVESTIGATION.