1996 Ford Explorer

TL* THE CONTACT OWNS A 1996 FORD EXPLORER. THE CONTROLS FOR THE CRUISE CONTROL BECAME DISLODGED AND HE COULD NOT PUT THEM BACK. THE DEALER WAS NOTIFIED, BUT HE DID NOT RECEIVE ANY ASSISTANCE. HE RECEIVED RECALL NOTICE # 09V399000 (VEHICLE SPEED CONTROL). A TECHNICIAN STATED THAT THEY WOULD REPAIR THE PART DESCRIBED UNDER THE RECALL THAT WOULD CAUSE THE FIRE BUT NOT REPAIR THE CONTROLS. THE CONTROLS SHOULD ALSO BE REPAIRED BECAUSE WITHOUT THERE FUNCTIONING, THE CRUISE CONTROL COULD NOT BE ACTIVATED. THE CURRENT MILEAGE WAS APPROXIMATELY 157,000. THE FAILURE MILEAGE WAS APPROXIMATELY 155,000.

TL*THE CONTACT OWNS A 1996 FORD EXPLORER. WHILE PLACING FUEL IN THE VEHICLE, THE CONTACT NOTICED SMOKE UNDERNEATH THE HOOD. HE OPENED THE HOOD AND NOTICED THAT THE VEHICLE WAS ON FIRE. THE FIRE WAS DOUSED WITH A FIRE EXTINGUISHER. THE CONTACT EXAMINED THE DAMAGE AND NOTICED THAT THE WIRING HARNESS FOR THE CRUISE CONTROL HAD MELTED, AS WELL AS THE MASTER CYLINDER. THERE WERE NO WARNING SIGNS PRIOR TO THE FAILURE. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 127,000.

SAFETY RECALL 97V-074000. EVERYTHING MY VEHICLE DID IS DESCRIBED IN THIS RECALL. THE THROTTLE STUCK AT 65 MPH ON TWO DIFFERENT OCCASIONS SO FAR. BOTH TIMES OCCURRED ON DAYS WITH TEMPS AT -13 TO -15 DEGREES. THE VEHICLE SPEEDS UP TO THE "STUCK" SPEED WITH NO GAS PEDAL USE, AND WON'T STOP WITHOUT STANDING ON THE BRAKE PEDAL. UPON SHIFTING TO NEUTRAL OR PARK, THE RPM REVS UP TO ABOUT 5000. I HAVE CONTACTED FORD CUSTOMER SERVICE. THE AGREE THAT IS SOUNDS LIKE THE PROBLEM LISTED IN THE RECALL. HOWEVER, SINCE I LIVE IN COLORADO, THEY WILL NOT FIX IT UNDER THE RECALL. I LIVE LESS THAN 30 MILES FROM WYOMING, WHICH IS INCLUDED, AND FURTHER NORTH THAN PARTS OF NEBRASKA - ALSO INCLUDED. THIS IS A SAFETY PROBLEM WHEN I CAN'T STOP, YET THEY ARE NOT WILLING TO HELP. THE FIRST OCCURRENCE WAS ON JANUARY 2, 2008 - SAME SITUATION. *TR

SPEED CONTROL SWITCH, ALSO KNOWN AS BRAKE PRESSURE SWITCH ON THE 1996 FORD EXPLORER WAS DEFECTIVE. THE THIN MEMBRANE OF THE SWITCH WAS IN CONTACT WITH THE BRAKE FLUID. AS THE SWITCH WAS POWERED ALL THE TIME , HOT, EVEN WHEN THE IGNITION WAS OFF. THIS WAS A FIRE/SAFETY HAZARD. FORD HAS ALREADY RECALLED MILLIONS OF VEHICLES FOR THIS PROBLEM, BUT FORD CUSTOMER SERVICE STATED THERE WAS NO RECALL FOR THIS PARTICULAR VEHICLE, AND I MUST PAY TO HAVE THE RETRO FITTED SWITCH INSTALLED. *AK

TL*THE CONTACT OWNS A 1996 FORD EXPLORER. ON MAY 14, 2007, THE VEHICLE'S ACCELERATOR PEDAL DETACHED WITHOUT WARNING AND THE VEHICLE WAS TOWED OFF THE ROAD. THE CONTACT WAS DRIVING 50 MPH AT THE TIME OF FAILURE. SHE STATED THAT THE VEHICLE HOOD RELEASE ALSO FAILED AND THE TOW DRIVER COULD NOT OPEN THE HOOD. THE VIN, PURCHASE DATE, AND ENGINE SIZE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 163,000.

DT*: THE CONTACT STATED WHILE DRIVING 82 MPH WITH THE CRUISE CONTROL ENGAGED, THE VEHICLE BEGAN TO ACCELERATE CONTINUOUSLY WITHOUT WARNING. THE SPEED OF THE VEHICLE ROSE PAST 97 MPH. THE BRAKES WERE APPLIED AND THE CRUISE CONTROL BUTTON WAS DISENGAGED, WHICH DID NOT CHANGE THE SPEED. THE VEHICLE WAS THEN SHIFTED INTO NEUTRAL, AND THE BRAKES WERE APPLIED WITH EXCESSIVE FORCE WHICH SLOWED THE VEHICLE DOWN. THE VEHICLE WAS NOT TAKEN IN FOR SERVICE FOLLOWING THE INCIDENT.

DT*: THE CONTACT STATED THE VEHICLE ACCELERATED UNCONTROLLABLY TO 80 MPH ON THE HIGHWAY WITHOUT WARNING WHILE TRAVELING 60 MPH. THE VEHICLE WAS NOT CONTROLLABLE BY THE APPLIED BRAKES. THE CRUISE CONTROL WAS NOT ENGAGED. THE CONTACT PUT THE TRANSMISSION INTO NEUTRAL AND REAPPLIED THE BRAKES, WHICH ASSISTED IN STOPPING THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DETERMINED THAT THE SPEED CONTROL COULD HAVE CAUSED THE PROBLEM. THE SAME PROBLEM OCCURRED ON 4 OTHER OCCASIONS. THE VEHICLE ACCELERATED WHILE STOPPED AT A STOP SIGN ON 07/22/06.

DT*: THE CONTACT OWNS A 1996 FORD EXPLORER. IT CAUGHT FIRE WHILE PARKED, DESTROYING THE VEHICLE, THE HOUSE, AND ANOTHER VEHICLE THAT WAS PARKED IN THE DRIVEWAY. THERE IS A NHTSA RECALL, # 05V388000, REGARDING THE VEHICLE SPEED CONTROL. THE VEHICLE HAD THE SAME PROBLEMS AS INDICATED IN THE RECALL, HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN.