NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
120 reportsClear category filter127,000 miles · May 20, 2008
Service Brakes, HydraulicVehicle Speed ControlFire
TL*THE CONTACT OWNS A 1996 FORD EXPLORER. WHILE PLACING FUEL IN THE VEHICLE, THE CONTACT NOTICED SMOKE UNDERNEATH THE HOOD. HE OPENED THE HOOD AND NOTICED THAT THE VEHICLE WAS ON FIRE. THE FIRE WAS DOUSED WITH A FIRE EXTINGUISHER. THE CONTACT EXAMINED THE DAMAGE AND NOTICED THAT THE WIRING HARNESS FOR THE CRUISE CONTROL HAD …
Read full complaint
TL*THE CONTACT OWNS A 1996 FORD EXPLORER. WHILE PLACING FUEL IN THE VEHICLE, THE CONTACT NOTICED SMOKE UNDERNEATH THE HOOD. HE OPENED THE HOOD AND NOTICED THAT THE VEHICLE WAS ON FIRE. THE FIRE WAS DOUSED WITH A FIRE EXTINGUISHER. THE CONTACT EXAMINED THE DAMAGE AND NOTICED THAT THE WIRING HARNESS FOR THE CRUISE CONTROL HAD MELTED, AS WELL AS THE MASTER CYLINDER. THERE WERE NO WARNING SIGNS PRIOR TO THE FAILURE. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 127,000.
NHTSA ODI #10228293
Mileage unknown · Apr 14, 2008
Service Brakes, Hydraulic
1996 FORD EXPLORER WITH BRAKE PROBLEMS. CONSUMER STATES THAT BRAKE PEDAL IS LOCATED TO CLOSE TO THE FLOOR BOARD. AND IS TO CLOSE TO THE ACCELERATOR CAUSING YOU TO HIT THE ACCELERATOR AND THE BRAKE PEDAL AT THE SAME TIME. *KB THE CONSUMER STATED WHEN HE APPLIED THE BRAKE, HIS FOOT ALSO HIT THE ACCELERATOR PEDAL.
NHTSA ODI #10225094
106,000 miles · Sep 18, 2006
Service Brakes, HydraulicCrashInjury
ANTI LOCK BRAKE SYSTEM FAILED CAUSING A NONE TO VERY LITTLE BAKING. 2ND TIME WAS A COMPLETE LOSS OF BRAKES CAUSING A REAR END COLLISION. *NM
NHTSA ODI #10168494
68,781 miles · Jun 21, 2005
Service Brakes, Hydraulic
BRAKE FAILURE - REAR BRAKES FAILED, BRAKE WARNING LIGHT CAME ON. BRAKE LINE RUSTED OUT AT REAR BY AXLE. NEW LINE INSTALLED. GARAGE SAID COMMON PROBLEM ON FORDS.
NHTSA ODI #10126141
116,119 miles · Mar 23, 2005
Service Brakes, HydraulicCrashInjury
WHEN THE CONSUMER APPLIED THE BRAKE, THEY LOCKED UP AND THE VEHICLE SLID AND REAR ENDED ANOTHER VEHICLE AND THEN ROLLED OVER. *AK
NHTSA ODI #10112983
Mileage unknown · Sep 5, 2004
Service Brakes, Hydraulic
ANTI-BRAKE SENSORS REPLACED TWICE SINCE OWNING CAR. *JB
NHTSA ODI #10090465
97,400 miles · Feb 23, 2004
Service Brakes, HydraulicVehicle Speed ControlCrash
MY 1996 EXPLORER IS A 5.0 LITRE AWD EDDIE BAUR PURCHSED USED. AFTER DRIVING USING THE CRUISE CONTROL WITHOUT INCIDENT, I PULLED INTO A PARKING LOT. COASTING SLOWLY INTO A PARKING SLOT APPLYING THE BRAKES, THE ENGINE APPEARED TO INCREASE POWER MAKING IT DIFFICULT TO STOP. THE MORE I PRESSED THE BRAKE PEDAL THE MORE THE ENGINE POW…
Read full complaint
MY 1996 EXPLORER IS A 5.0 LITRE AWD EDDIE BAUR PURCHSED USED. AFTER DRIVING USING THE CRUISE CONTROL WITHOUT INCIDENT, I PULLED INTO A PARKING LOT. COASTING SLOWLY INTO A PARKING SLOT APPLYING THE BRAKES, THE ENGINE APPEARED TO INCREASE POWER MAKING IT DIFFICULT TO STOP. THE MORE I PRESSED THE BRAKE PEDAL THE MORE THE ENGINE POWER INCREASED PREVENTING THE VEHICLE FROM STOPPING UNTIL COLLIDING WITH A VEHICLE IN FRONT. WITH THE BRAKE STILL APPLIED, THE ENGINE RACED WHEN PUT IN NUETRAL UNTIL SWITCHING THE IGNITION OFF. THE BRAKE AND ACCELERATOR OPERATED NORMALLY AFTER RESTARTING. DAMAGE RESULTED TO THE EXPLORER BUMPER. I DID NOT OBSERVE THE GAS PEDAL POSITION DURING THE INCIDENT BUT ASSUMED IT COULD HAVE BEEN DRIVEN BY THE CRUISE CONTROL CABLE UNDER UNCOMMANDED OPERATION AND SEVERED THE CRUISE CABLE BEFORE PROCEDING. A SIMILAR PROBLEM HAD OCCURED DURING A PRIOR STOP THE SAME TRIP BUT ABRUPTLY RETURNED TO NORMAL OPERATION POSSIBLY AFTER HAVING PUMPED THE BRAKES TO CHECK THEM. THE SAME TYPE PROBLEM WITH ENGINE POWER SURGE DURING BRAKING TO A STOP OCCURED ON PRIOR DAYS WHEN THE CRUISE CONTROL HAD NOT BEEN USED AND MAY HAVE CORRECTED AFTER PUMPING THE BRAKE. REVIEWING NHSTA COMPLAINT ODI ID 736277 AND SUBSEQUENT EXPERIMENT ON MY VEHICLE, IT APPEARS THE PROBLEM COULD POTENTIALLY RESULT FROM INADVERTANT PRESSING THE GAS PEDAL DURING BRAKING DUE TO PROXIMITY OF THE PEDALS BUT I CAN'T RULE OUT UNCOMMANDED CRUISE CONTROL OPERATION ACTIVATED BY A BRAKE SIGNAL. PLEASE ADVISE IF INVESTIGATION AND DISCOVERY HAVE RESULTED IN ANY PROBABLE CAUSES AND RECOMMENDATIONS FOR CORRECTIVE MAINTENANCE FOR THIS SAFETY HAZARD. DOES NOT DISPLAY SYMPTOMS CORRECTED BY RECALLS FOR THROTTLE BODY STICKING AND JAMMED CRUISE CONTROL CABLE.*AK
NHTSA ODI #10058793
Mileage unknown · Dec 30, 2003
Service Brakes, Hydraulic
SOMETIMES CAR WILL NOT STOP.
NHTSA ODI #10051384
Mileage unknown · Sep 24, 2003
Engine And Engine CoolingService Brakes, Hydraulic
WHILE VEHICLE IDLED ENGINE STARTED TO RACE. THEN, VEHICLE WAS TRYING TO MOVE WITH BRAKES APPLIED. *AK
NHTSA ODI #10040556
Mileage unknown · Sep 3, 2003
Service Brakes, HydraulicVehicle Speed ControlCrash
TRUCK WAS IN PARK. PUT MY FOOT ON BRAKE, SHIFTED INTO DRIVE, TRUCK IMMEDIATELY MOVED FORWARD WITH FOOT STILL ON BRAKE, AT APPROX 2- 5 MPH. PUSHED CONTINUALLY HARDER ON BRAKE WITH NO RESPONSE. LIFTED FOOT COMPLETELY OFF BRAKE AND PUSHED AGAIN, THEN TRUCK STOPPED. WENT THROUGH A GARAGE DOOR IN THE PROCESS, COULDN'T STOP UNTIL …
Read full complaint
TRUCK WAS IN PARK. PUT MY FOOT ON BRAKE, SHIFTED INTO DRIVE, TRUCK IMMEDIATELY MOVED FORWARD WITH FOOT STILL ON BRAKE, AT APPROX 2- 5 MPH. PUSHED CONTINUALLY HARDER ON BRAKE WITH NO RESPONSE. LIFTED FOOT COMPLETELY OFF BRAKE AND PUSHED AGAIN, THEN TRUCK STOPPED. WENT THROUGH A GARAGE DOOR IN THE PROCESS, COULDN'T STOP UNTIL TRUCK WAS FULLY THROUGH.*AK
NHTSA ODI #10037180
Official recalls
6Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Nov 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CONDITIONS, A FRONT SWAY BAR LINK CAN FRACTURE.
Consequence & remedy
Consequence: VEHICLE HANDLING COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH THE LEFT AND RIGHT FRONT SWAY BAR LINKS.
Aug 19, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. THE LIFTGATE ASSIST GAS CYLINDER BRACKET ON THE RIGHT HAND BODYSIDE OUTER PANEL WAS INCORRECTLY WELDED.
Consequence & remedy
Consequence: THE GAS CYLINDER BRACKET MAY NOT PROPERLY SUPPORT THE LIFTGATE INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REINFORCE THE BRACKET ATTACHMENT WITH TWO POP RIVETS.
Apr 30, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 5.0L ENGINES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, IDAHO, IOWA, MAINE, MICHIGAN (UPPER PENINSULA ONLY), MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. THESE VEHICLES, WHEN OPERATED FOR EXTENDED PERIODS OF TIME AT HIGHWAY SPEEDS AND TEMPERATURES BELOW -20 DEGREES FARENHEIT, DO NOT RETURN TO IDLE DUE TO ICE IN THE THROTTLE BODY.
Consequence & remedy
Consequence: ALTHOUGH THE VEHICLE CAN BE CONTROLLED BY EITHER APPLYING THE SERVICE BRAKES OR SHIFTING THE TRANSMISSION TO NEUTRAL, INCREASED BRAKE PEDAL EFFORTS OR SOME INCREASE IN STOPPING DISTANCE CAN RESULT.
Remedy: DEALERS WILL INSTALL A REVISED PCV SYSTEM WITH WATER HEATED VACUUM SOURCE.
Aug 29, 1996
THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .
Remedy: OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.
Apr 22, 1996
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE00039 · Front Suspension Stabilizer Bar Link
Opened Sep 20, 2000 · Closed Nov 30, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE99068 · Accelerator Pedal
Opened Nov 1, 1999 · Closed Mar 9, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE97010 · Electrical Fire In Center Console
Opened Mar 13, 1997 · Closed Sep 4, 1997
Status: closed (inferred from source dates) · Electrical System
THIS INVESTIGATION REVEALED THAT CONSOLE FIRES IN THE SUBJECT VEHICLES MOST OFTEN OCCURRED WHILE VEHICLES EQUIPPED WITH THE LAMP OUTAGE MODULE (LOM), WHICH IS PART OF THE MESSAGE CENTER, WERE TOWING A TRAILER AND WHICH HAD BEEN MODIFIED BY ADDING AN AFTERMARKET TRAILER WIRING HARNESS INTO THE VEHICLE'S TAILLIGHT CIRCUITS.THE OWNER'S MANUAL STATES NEVER AND MORE THAN OTHER TRAILER LIGHT BULB TO ONE CIRCUIT HOWEVER TRAILERS FREQUENTLY CONTAIN SEVERAL BULBS.THE RESULTING EXCESS CURRENT PASSING THROUGH THE LOM COULD CAUSE IT TO OVERHEAT RESULTING IN A FIRE.PROPER AFTERMARKET INSTALLATION OF TRAILER WIRING REQUIRES THE USE OF A BYPASS MODULE, WHICH OBTAINS POWER FOR THE TRAILER LIGHTS DIRECTLY FROM THE BATTERY RATHER THAN FROM THE VEHICLE'S TAIL LIGHT AND STOP LAMP CIRCUITS, OR THE USE OF THE MANUFACTURER'S WIRING HARNESS.IN A LETTER DATED SEPTEMBER 2, 1997, FORD NOTIFIED ODI THAT IT INTENDS TO TAKE ACTION TO PRECLUDE FURTHER INCIDENTS INCLUDING ISSUING A TECHNICAL SERVICE BULLETIN TO ITS DEALERS, NOTIFYING TRAILER RENTAL ASSOCIATIONS AND AGENCIES WHERE KNOWN, AND ADVISING OWNERS BY LETTER OF THE PROPER METHOD FOR CONNECTION OF TRAILER TOW WIRING ON THE SUBJECT VEHICLES.THERE WAS NO DEFECT TREND IN THE SUBJECT VEHICLES IDENTIFIED AS A RESULT OF THIS INVESTIGATION, AND FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT WARRANTED TO CONTINUE THE INVESTIGATION.
Illustration