VEHICLE WAS GOING 30-35MPH AND FLIPPED OVER DRIVER'S SEAT BELT WOULDN'T UNLOCK, LEAVING CONSUMER IN A UPSIDE DOWN POSITION. CONSUMER USED A SCREW DRIVER TO UNLATCH THE SEAT BELT. DEALER AND MANUFACTURER WERE NOTIFIED. SEAT BELT PART# TRW TC077. *AK THE AIR BAG ALSO FAILED DURING THE ACCIDENT. THE CAUSE FOR LOSING CONTROL OF THE…
Read full complaint
VEHICLE WAS GOING 30-35MPH AND FLIPPED OVER DRIVER'S SEAT BELT WOULDN'T UNLOCK, LEAVING CONSUMER IN A UPSIDE DOWN POSITION. CONSUMER USED A SCREW DRIVER TO UNLATCH THE SEAT BELT. DEALER AND MANUFACTURER WERE NOTIFIED. SEAT BELT PART# TRW TC077. *AK THE AIR BAG ALSO FAILED DURING THE ACCIDENT. THE CAUSE FOR LOSING CONTROL OF THE VEHICLE WAS DUE TO THE TIRE WHICH ROLLED OFF FROM THE SAFETY RIM. *YH
NHTSA ODI #8005352
Mileage unknown · Jan 29, 2002
Seat BeltsCrash
VEHICLE WAS INVOLVED IN A COLLISION IN WHICH VEHICLE ROLLED OVER, AND PASSENGER SEAT BELT BUCKLE RELEASED FROM LOCKING MECHANISM. PLEASE GIVE ANY FURTHER DETAILS. *AK
NHTSA ODI #8003077
Mileage unknown · Jan 8, 2002
Seat Belts
BOTH REAR RESTRAINTS DO NOT RETRACT, LEAVING OCCUPANTS UNRESTRAINED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8001745
Mileage unknown · Jan 7, 2002
Seat Belts
DRIVER'S SIDE SEAT BELT BUCKLE WOULD NOT STAY LATCHED, AND PLASTIC ON PASSENGER SIDE SEAT BELT IS CRACKING. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION CONCERNING THIS MATTER.*AK
NHTSA ODI #8001625
Mileage unknown · Dec 17, 2001
Air BagsSeat BeltsCrashInjury
THE CONSUMER WAS TRAVELING WHEN THE VEHICLE WAS STRUCK IN THE REAR BY ANOTHER VEHICLE, CAUSING THE VEHICLE TO SPIN AROUND AND ROLL. DURING THE ACCIDENT, THE DRIVER DOOR CAME OPEN AND THE DRIVER SEAT BELT CAME LOOSE. AS A RESULT, DRIVER WAS THROWN OUT OF THE VEHICLE. THE PASSENGER'S SEAT BELT ALSO BECAME LOOSE. THE DRIVER DIED IN…
Read full complaint
THE CONSUMER WAS TRAVELING WHEN THE VEHICLE WAS STRUCK IN THE REAR BY ANOTHER VEHICLE, CAUSING THE VEHICLE TO SPIN AROUND AND ROLL. DURING THE ACCIDENT, THE DRIVER DOOR CAME OPEN AND THE DRIVER SEAT BELT CAME LOOSE. AS A RESULT, DRIVER WAS THROWN OUT OF THE VEHICLE. THE PASSENGER'S SEAT BELT ALSO BECAME LOOSE. THE DRIVER DIED INSTANTLY. THE PASSENGER SUFFERED SERIOUS INJURIES. THE AIR BAGS ALSO FAILED TO DEPLOY.(SISTER ON BEHALF OF DECEASED BROTHER) *YH
NHTSA ODI #563868
Mileage unknown · Oct 23, 2001
Seat Belts
CONSUMER STATES THAT REAR SEAT BELT BUCKLES ARE TIGHT TOGETHER AND THAT THE RELEASE BUTTONS ARE LOCATED AT THE TOPS OF THE BUCKLES MAKING THEM VERY DIFFICULT TO UNLATCH. *JADA
NHTSA ODI #563782
Mileage unknown · Oct 10, 2001
Seat Belts
REAR PASSENGER SEAT BELT LATCH WAS PLACED INTO CENTER POSITION RECEPTACLE, AND WAS UNABLE TO GET IT RELEASED. HAD TO CUT BELT TO FREE THE PASSEANGER. DEALER / MANUFACTURER WERE NOT NOTIFIED AT THIS TIME. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #897539
Mileage unknown · Oct 1, 2001
Air BagsSeat BeltsCrashInjury
ON 09/23/01 MY 24YR. OLD SONINLAW WAS KILLED WHEN HE LOST CONTROL AND HIT A MEIDIAN AND TREE WAS ON TWO TIRES THEN WENT 30FT THRU THE AIR BEFORE THE EXPLORER HE WAS DRIVING ROLLED AND THREW HIM OUT THE DRIVER WINDOW. HE WAS WEARING SEAT BELT WHICH HE HAD HAD TROUBLE WITH SINCE PURCHASE FAILED AND HE WAS EJECTED ALSO HIS BROTHER…
Read full complaint
ON 09/23/01 MY 24YR. OLD SONINLAW WAS KILLED WHEN HE LOST CONTROL AND HIT A MEIDIAN AND TREE WAS ON TWO TIRES THEN WENT 30FT THRU THE AIR BEFORE THE EXPLORER HE WAS DRIVING ROLLED AND THREW HIM OUT THE DRIVER WINDOW. HE WAS WEARING SEAT BELT WHICH HE HAD HAD TROUBLE WITH SINCE PURCHASE FAILED AND HE WAS EJECTED ALSO HIS BROTHER IN PASSENGER SIDE COULDNT GET HIS BELT TO LATCH BUT HE WAS LUCKY AND WALKED AWAY. THE TRUCK WAS ALSO EQUIPPED WITH AIRBAGS ON BOTH SIDES WHICH DIDNT DEPLOY EITHER. MY SON IN LAW DIED THAT NIGHT WHEN HE WAS EJECTED AND THE TRUCK LANDED ON HALF OF HIS FACE. HE LEFT BEHIND A WIFE AND 2SONS AND A 1 MONTH OLD DAUGHTER. THESE EXPLORERS ARE DEATH TRAPS PLEASE DO NOT PURCHASE ONE.*AK
NHTSA ODI #752765
Mileage unknown · Jul 10, 2001
Seat Belts
DRIVER'S SIDE REAR SEAT BELT LOCKED UP, AND WOULD NOT RELEASE FROM LOCKING MECHANISM . SEAT BELT HAD TO BE CUT TO RELEASE CHILD FROM THE SEAT. PLEASE GIVE ANY FURTHER DETAILS.*AK
NHTSA ODI #892341
Mileage unknown · Jan 9, 2001
Seat BeltsSuspensionCrash
ON DEC. 13, 2000, MY 22 YEAR OLD SON TOTALLED THIS VEHICLE AFTER HITTING A PATCH OF "BLACK ICE" WHILE TRAVELING AT A SPEED OF APPROXIMATELY 45-50 MPH. THE VEHICLE ROLLED ACCORDING TO AN EYEWITNESS 4 TIMES AND LANDED ON ITS ROOF. MY SON WAS, THANK GOD, WEARING HIS SEATBELT! HE WAS ABLE TO RELEASE HIS SEATBELT AND CRAWLED…
Read full complaint
ON DEC. 13, 2000, MY 22 YEAR OLD SON TOTALLED THIS VEHICLE AFTER HITTING A PATCH OF "BLACK ICE" WHILE TRAVELING AT A SPEED OF APPROXIMATELY 45-50 MPH. THE VEHICLE ROLLED ACCORDING TO AN EYEWITNESS 4 TIMES AND LANDED ON ITS ROOF. MY SON WAS, THANK GOD, WEARING HIS SEATBELT! HE WAS ABLE TO RELEASE HIS SEATBELT AND CRAWLED THROUGH THE DRIVER'S WINDOW WHICH HAD BEEN BROKEN OUT. HE ESCAPED WITHOUT ANY INJURIES! MY CONCERN IS SO MUCH EMPHASIS HAS BEEN PLACED ON THE ROLLOVER POSSIBILITIES WHEN A TIRE BLOWS, WHY NOT THE POSSIBILITY OF FLIPPING WHEN HITTING ICE? IS ANYTHING BEING INVESTIGATED TO CORRECT THE TOP HEAVINESS OF THE VEHICLE, ESPECIALLY THE 2-DOOR MODELS. MORE EMPHASIS NEEDS TO BE PLACED ON THE NECESSITY OF WEARING SEATBELTS TO SURVIVE A ROLLOVER.. *AK
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES. THE LIFTGATE ASSIST GAS CYLINDER BRACKET ON THE RIGHT HAND BODYSIDE OUTER PANEL WAS INCORRECTLY WELDED.
Consequence & remedy
Consequence: THE GAS CYLINDER BRACKET MAY NOT PROPERLY SUPPORT THE LIFTGATE INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REINFORCE THE BRACKET ATTACHMENT WITH TWO POP RIVETS.
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH 5.0L ENGINES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, IDAHO, IOWA, MAINE, MICHIGAN (UPPER PENINSULA ONLY), MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. THESE VEHICLES, WHEN OPERATED FOR EXTENDED PERIODS OF TIME AT HIGHWAY SPEEDS AND TEMPERATURES BELOW -20 DEGREES FARENHEIT, DO NOT RETURN TO IDLE DUE TO ICE IN THE THROTTLE BODY.
Consequence & remedy
Consequence: ALTHOUGH THE VEHICLE CAN BE CONTROLLED BY EITHER APPLYING THE SERVICE BRAKES OR SHIFTING THE TRANSMISSION TO NEUTRAL, INCREASED BRAKE PEDAL EFFORTS OR SOME INCREASE IN STOPPING DISTANCE CAN RESULT.
Remedy: DEALERS WILL INSTALL A REVISED PCV SYSTEM WITH WATER HEATED VACUUM SOURCE.
THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .
Remedy: OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
PE00039 · Front Suspension Stabilizer Bar Link
Opened Sep 20, 2000 · Closed Nov 30, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE99068 · Accelerator Pedal
Opened Nov 1, 1999 · Closed Mar 9, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE97010 · Electrical Fire In Center Console
Opened Mar 13, 1997 · Closed Sep 4, 1997
Status: closed (inferred from source dates) · Electrical System
THIS INVESTIGATION REVEALED THAT CONSOLE FIRES IN THE SUBJECT VEHICLES MOST OFTEN OCCURRED WHILE VEHICLES EQUIPPED WITH THE LAMP OUTAGE MODULE (LOM), WHICH IS PART OF THE MESSAGE CENTER, WERE TOWING A TRAILER AND WHICH HAD BEEN MODIFIED BY ADDING AN AFTERMARKET TRAILER WIRING HARNESS INTO THE VEHICLE'S TAILLIGHT CIRCUITS.THE OWNER'S MANUAL STATES NEVER AND MORE THAN OTHER TRAILER LIGHT BULB TO ONE CIRCUIT HOWEVER TRAILERS FREQUENTLY CONTAIN SEVERAL BULBS.THE RESULTING EXCESS CURRENT PASSING THROUGH THE LOM COULD CAUSE IT TO OVERHEAT RESULTING IN A FIRE.PROPER AFTERMARKET INSTALLATION OF TRAILER WIRING REQUIRES THE USE OF A BYPASS MODULE, WHICH OBTAINS POWER FOR THE TRAILER LIGHTS DIRECTLY FROM THE BATTERY RATHER THAN FROM THE VEHICLE'S TAIL LIGHT AND STOP LAMP CIRCUITS, OR THE USE OF THE MANUFACTURER'S WIRING HARNESS.IN A LETTER DATED SEPTEMBER 2, 1997, FORD NOTIFIED ODI THAT IT INTENDS TO TAKE ACTION TO PRECLUDE FURTHER INCIDENTS INCLUDING ISSUING A TECHNICAL SERVICE BULLETIN TO ITS DEALERS, NOTIFYING TRAILER RENTAL ASSOCIATIONS AND AGENCIES WHERE KNOWN, AND ADVISING OWNERS BY LETTER OF THE PROPER METHOD FOR CONNECTION OF TRAILER TOW WIRING ON THE SUBJECT VEHICLES.THERE WAS NO DEFECT TREND IN THE SUBJECT VEHICLES IDENTIFIED AS A RESULT OF THIS INVESTIGATION, AND FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT WARRANTED TO CONTINUE THE INVESTIGATION.
Illustration