IllustrationRECALL 97V083000 CONCERNING REMOTE POWER MIRROR SWITCH WAS ISSUED. HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. WHILE PULLING INTO A DRIVEWAY MIRROR CONTROLS BEGAN TO SMOKE. MOMENTS LATER, FIRE WAS STREAMING FROM THE MIRROR ITSELF, CONSUMING THE ENTIRE VEHICLE. *AK
1994 Ford Explorer
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1994 Ford Explorer do not stand out strongly from the model-year median of 609.
About this comparison →How this year compares
Owner complaints by model year
Compare all Explorer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 68 of 1,207 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 331 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 238 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 158 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
109 crash reports82 fire reports98 injury reports
What owners actually said
1,207 reportsI WAS INVOLVED IN AN ACCIDENT. I REAR ENDED THE CAR IN FRONT OF ME DOING 25+ MPH. MY SEAT BELTS DID NOT LOCK UP AND MY AIR BAGS DID NOT DEPLOY. MY PASSENGER AND MYSELF WERE BOTH HURT IN THE ACCIDENT. I WOULD LIKE TO KNOW IF THERE ARE KNOWN PROBLEMS WITH THIS IN OTHER 1994 FORD EXPLORERS.*AK
1994 FORD EXPLORER XLT 4 WD THE PLASTIC FUEL TANK HAS DEVELOPED A SEVERE FUEL LEAK,,,NOT SAFE TO DRIVE, WAS A RECALL DONE ON THESE ? *JB
DOOR HANDLES ON PASSENGER SIDE INTERIOR BROKEN. TRANSMISSION SLIPPING. *AK
WHILE DRIVING ON HIGHWAY VEHICLE CAUGHT ON FIRE.*MR WHILE DRIVING THE CONSUMER NOTICED SMOKE IN HIS REAR VIEW MIRROR. THE CONSUMER PULLED OVER, EXITED THE VEHICLE, LOOKED UNDER THE CAR AND NOTICED FLAMES COMING FROM UNDER THE ENGINE. A PASSER BY AND A SAFETY CREW ATTEMPTED TO EXTINGUISH THE FIRE BUT WERE UNSUCCESSFUL. …
Read full complaint
WHILE DRIVING ON HIGHWAY VEHICLE CAUGHT ON FIRE.*MR WHILE DRIVING THE CONSUMER NOTICED SMOKE IN HIS REAR VIEW MIRROR. THE CONSUMER PULLED OVER, EXITED THE VEHICLE, LOOKED UNDER THE CAR AND NOTICED FLAMES COMING FROM UNDER THE ENGINE. A PASSER BY AND A SAFETY CREW ATTEMPTED TO EXTINGUISH THE FIRE BUT WERE UNSUCCESSFUL. THE CONSUMER REMOVED PERSONAL BELONGINGS FROM THE VEHICLE BEFORE IT BECAME TOTALLY ENGULFED IN FLAMES. *PH *NM
I ALREADY SENT A LETTER ABOUT THIS TO FORD WITH A CC: TO YOU FOLKS. MY COMPLAINT IS REGARDING THE ACCELORATION CABLE ON MY FORD EXPLORER AND YOU SHOULD HAVE THE LETTER ON FILE FROM NOVEMBER 7TH. FORD DID RESPOND (A MONTH LATER) BUT ARE NOT TAKING ANY ACTION ON IT.
CONSUMER WOULD LIKE TO KNOW WHAT EFFORTS WERE BEING MADE TO GET FORD/ FIRESTONE TIRE, AND RUBBER MANUFACTURER'S TO ISSUE REIMBURSEMENTS TO CONSUMERS WHO HAD TO PAY FOR REPLACED TIRES. MANUFACTURER REFUSED TO HONOR NHTSA RECALL # 00T005000. *AK
1994 FORD EXPLORER EXPERIENCED RAPID ACCELERATION AND LOST OF BRAKING ABILITY. *MR THE ACCELERATOR CABLE WAS REPAIRED FOR THE SECOND TIME AND THE MECHANIC PLACED A WIRE TIE ON IT TO HOLD IT IN PLACE. *SCC *JB
MY DRIVER-SIDE, REAR TIRE TREAD SEPARATED. (SEMPERIT BRAND P235/75R15 (THIS BRAND IS NOT ON YOUR DROP DOWN MENU!)) ON MY 1994 FORD EXPLORER CAUSING DAMAGE TO MY CAR (NAMELY THE REAR QUARTER PANEL.) I WAS ABLE TO CONTROL THE CAR AND THUS NOT HIT ANYTHING ELSE. THE TIRES HAD 24,000 MILES ON THEM. THIS HAPPENED DURING THE FORD…
Read full complaint
MY DRIVER-SIDE, REAR TIRE TREAD SEPARATED. (SEMPERIT BRAND P235/75R15 (THIS BRAND IS NOT ON YOUR DROP DOWN MENU!)) ON MY 1994 FORD EXPLORER CAUSING DAMAGE TO MY CAR (NAMELY THE REAR QUARTER PANEL.) I WAS ABLE TO CONTROL THE CAR AND THUS NOT HIT ANYTHING ELSE. THE TIRES HAD 24,000 MILES ON THEM. THIS HAPPENED DURING THE FORD/FIRESTONE NEWS. FORD WOULD NOT PAY TO REPLACE THE TIRES AND THE COMPANY SEMPERIT IN NOWHERE TO BE FOUND IN THE US. *AK
1994 FORD EXPLORER CAUGHT ON FIRE, JUST AFTER WIFE AND BABY GOT OUT OF VEHICLE. IT BURNED THE DRIVER SIDE DOOR, AND PART OF THE DASH. NHTSA CAMPAIGN #97V083000, I THINK IS RELEVANT, AND RESPONSIBLE FOR THIS ACCIDENT. I NOTIFED FORD OVER 3 WEEKS AGO, AND THEY KEEP TELLING ME CONSUMER AFFAIRS WILL CALL, BUT THEY NEVER HAVE YET.…
Read full complaint
1994 FORD EXPLORER CAUGHT ON FIRE, JUST AFTER WIFE AND BABY GOT OUT OF VEHICLE. IT BURNED THE DRIVER SIDE DOOR, AND PART OF THE DASH. NHTSA CAMPAIGN #97V083000, I THINK IS RELEVANT, AND RESPONSIBLE FOR THIS ACCIDENT. I NOTIFED FORD OVER 3 WEEKS AGO, AND THEY KEEP TELLING ME CONSUMER AFFAIRS WILL CALL, BUT THEY NEVER HAVE YET. *LA
Official recalls
499V310001 · Structure:body:hatchback/liftgate:support Device/strut
Nov 3, 1999
VEHICLE DESCRIPTION: ON CERTAIN SPORT UTILITY VEHICLES, THE HYDRAULIC LIFT CYLINDER BRACKET WELDS COULD FRACTURE.
Consequence & remedy
Consequence: WITH A BROKEN BRACKET WELD, THERE IS A POTENTIAL FOR THE LIFTGATE BRACKET TO GRADUALLY BEND INWARD ALLOWING THE LIFT CYLINDER BALL STUD TO DISENGAGE, UNEXPECTEDLY ALLOWING THE LIFTGATE TO FALL FROM AN OPEN POSITION.
Remedy: DEALERS WILL INSTALL LIFTGATE REINFORCEMENT BRACKETS. DEPENDING UPON THE CONDITION OF THE LIFTGATE SHEET METAL IN THE AREA OF THE BRACKET, DEALERS MAY ALSO INSTALL A LARGER REINFORCEMENT.
97V083000 · Visibility:rearview Mirrors/devices
May 5, 1997
A SHORT CIRCUIT CONDITION CAN OCCUR IN THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AS A RESULT OF A SEPARATED PART OF THE CONTACT ASSEMBLY BRIDGING THE SWITCH POSITIVE BATTERY PAD AND ADJACENT CHASSIS GROUND PAD.
Consequence & remedy
Consequence: THE CURRENT CAN OVERHEAT THE PRINTED CIRCUIT BOARD AND OTHER PLASTIC AND ELASTOMERIC COMPONENTS OF THE SWITCH ASSEMBLY RESULTING IN SMOKE OR FIRE.
Remedy: DEALERS WILL INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.
96V024001 · Service Brakes, Hydraulic:power Assist:hydraulic
Feb 5, 1996
THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY CAN DEVELOP STRESS CORROSION CRACKING AFTER BEING OPERATED FOR AN EXTENDED PERIOD OF TIME IN THE SOUTHERN CALIFORNIA LOCATION.
Consequence & remedy
Consequence: IF A CRACK OCCURS, IT COULD RESULT IN ONE OR BOTH STUDS FRACTURING. THE MASTER CYLINDER COULD THEN SEPARATE FROM THE VACUUM BOOSTER, WHEN THE BRAKES ARE APPLIED, PREVENTING THE SERVICE BRAKES FROM ACTIVATING INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE POWER BRAKE VACUUM BOOSTER ASSEMBLY.
94V169001 · Parking Brake:conventional
Sep 7, 1994
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
13EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96066 · Driver Door Electrical Fire
Opened Nov 22, 1996 · Closed May 15, 1997
Status: closed (inferred from source dates) · Electrical System
THE CONTACT ASSEMBLY FOR THE REMOTE POWER MIRROR CONTROL SWITCH MAY DEVELOP A SHORT CIRCUIT BETWEEN THE SWITCH POSITIVE PAD AND CHASSIS GROUND PAD AS A RESULT OF WATER INTRUSION.EXCESS CURRENT FLOW RESULTING FROM THE SHORT CIRCUIT CONDITION MAY OVERHEAT THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AND CAUSE A FIRE IN THE DRIVER'S DOOR.FORD HAS INDICATED THAT CURRENT IN EXCESS OF 15 AMPS CAN OVERHEAT THE CIRCUIT BOARD ENOUGH TO CAUSE A FIRE.CIRCUIT PROTECTION IS PROVIDED BY A 30 AMP FUSE.FORD IS RECALLING ALL 1993-94 4-DOOR EXPLORER VEHICLES EQUIPPED WITH THE SUBJECT ELECTRONIC OPTION COMBINATION TO INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.NO 2-DOOR EXPLORER VEHICLES WERE BUILT WITH THE SUBJECT COMPONENTS.ACCORDING TO FORD, VEHICLES BUILT PRIOR TO THE RECALL PRODUCTION RANGE WERE EQUIPPED WITH LOWER CAPACITY CIRCUIT BOARDS FOR THE SUBJECT SWITCH ASSEMBLY THAT WOULD FAIL FROM AN OPEN CIRCUIT IF A SIMILAR SHORT OCCURRED.A NEW SWITCH ASSEMBLY WITH 10 AMP FUSE PROTECTION WAS INTRODUCED BEGINNING WITH THE 1995 MODEL YEAR EXPLORER.MAZDA WILL CONDUCT A PARALLEL COMPAIGN (97V-083.002) TO REMEDY THE SUBJECT CONDITION IN APPROXIMATELY 14,000 NAVAJO VEHICLES.THE NAVAJO VEHICLES WERE AVAILABLE IN ONLY THE 2-DOOR VERSION WHICH, UNLIKE THE EXPLORER VEHICLES, DID USE THE SUBJECT OPTION COMBINATION IN THAT BODY STYLE.
EA96017 · Brake System Malfunction
Opened Jul 24, 1996 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE96016 · Wheel Lockup With Antilock Brake System
Opened Feb 28, 1996 · Closed Jul 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
ODI HAS RECEIVED OND HUNDRED SEVENTY-THREE (173) CONSUMER COMPLAINTS OF ALLEGED FAILURES OR MALFUNCTIONS IN THE BRAKING SYSTEM ON CERTAIN 1993 AND 1994 FORD EXPLORERS.THESE ALLEGED FAILURES OR MALFUNCTIONS ARE REPORTED TO HAVE CAUSED THIRTY-SIX (36) ACCIDENTS RESULTING FROM VEHICLE LOSS OF DIRECTIONAL CONTROL DURING BRAKING OR FROM THE EXTENDED DISTANCE REQUIRED TO STOP THE VEHICLE DURING BRAKING.THE COMPLAINANTS REPORT THAT THE ALLEGED FAILURES OR MALFUNCTIONS OCCURRED DURING BRAKING MOSTLY ON WET OR SLIPPERY ROADS, BUT ALSO HAVE OCCURRED ON DRY ROADS.SINCE ODI OPENED THIS PE BASED ON WHEEL LOCKUP COMPLAINTS, WE HAVE RECEIVED NUMEROUS ADDITIONAL COMPLAINTS AB OUT THE EXTENDED DISTANCE REQUIRED TO STOP THE SUBJECT VEHICLES WHEN BRAKING UNDER CERTAIN ROAD AND SPEED CONDITIONS.IN RESPONSE TO ODI'S INFORMATION REQUEST (IR) CONCERNING WHEEL LOCKUP COMPLAINTS ONT HE SUBJECT VEHICLES, FORD REPORTED RECEIVING 416 REPORTS (FIELD REPORTS, OWNER COMPLAINTS, AND SUBROGATION CLAIMS) OF WHEEEL LOCKUP ON 1993 AND 1994 FORD EXPLORERS, WITH 24 ALLEGED ACCIDENTS.IN ADDITION, FORD REPORTED RECEIVING 24,916 WARRANTY CLAIMS THAT COULD RELATE TO THE ALLEGED DEFECT OF WHEEL LOCKUP DURING BRAKING ON THE SUBJECT VEHICLES.AN ENGINEERING ANALYSIS IS WARRANTED TO DETERMINE THE SCOPE OF THESE ALLEGED BRAKING SYSTEM FAILURES OR MALFUNCTIONS ON 1993 AND 1994 FORD EXPLORERS.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available