NHTSA owner reports · September 18, 2026 snapshot.
Equipment complaints
32 reportsClear category filter114,000 miles · Oct 26, 2004
Electrical SystemEngine And Engine CoolingEquipment
1994 EXPLORER 4.0 V6 AUTOMATIC TRANSMISSION REBIULT 3 TIMES IN PAST YEAR .COUNTLESS TIMES VEHICLE HAS STALLED ACTING AS IF THE FUEL PUMP QUIT, FUEL PUMP REPLACED, COIL PACKS REPLACED, RELAYS REPLACED. ONCE ON THE HIGHWAY AT 70 MPH, ANOTHER TIME WHILE PULLING INTO TRAFFIC. USUALLY UPON START UP. AIR CONDITIONER SWITCH SHORTED OU…
Read full complaint
1994 EXPLORER 4.0 V6 AUTOMATIC TRANSMISSION REBIULT 3 TIMES IN PAST YEAR .COUNTLESS TIMES VEHICLE HAS STALLED ACTING AS IF THE FUEL PUMP QUIT, FUEL PUMP REPLACED, COIL PACKS REPLACED, RELAYS REPLACED. ONCE ON THE HIGHWAY AT 70 MPH, ANOTHER TIME WHILE PULLING INTO TRAFFIC. USUALLY UPON START UP. AIR CONDITIONER SWITCH SHORTED OUT, SAW BURNED WIRES ON SWITCH UPON REPLACEMENT. ANTIFREEZE SPEWED OUT FROM SIDE OF MOTOR, ASSUMED TO BE AROUND HEADS BUT HAS NOT BEEN TO SHOP YET.*AK
NHTSA ODI #10096436
Mileage unknown · Apr 12, 2004
Engine And Engine CoolingEquipment
I HAD THE FUEL SYSTEM ON MY 1994 FORD EXPLORER REPLACED BY PEP BOYS IN CRESTWOOD, ILLINOIS. TODAY I LEARNED THAT THEY HAD BOTCHED THE JOB TO THE POINT THAT GASOLINE WAS BEING SPRAYED ONTO THE MANIFOLD OF THE VEHICLE WHICH COULD HAVE RESULTED IN A FIRE OR AND EXPLOSION. WHY IT DIDN'T HAPPEN IS SERENDIPITY FOR ME. WHEN I CALLED…
Read full complaint
I HAD THE FUEL SYSTEM ON MY 1994 FORD EXPLORER REPLACED BY PEP BOYS IN CRESTWOOD, ILLINOIS. TODAY I LEARNED THAT THEY HAD BOTCHED THE JOB TO THE POINT THAT GASOLINE WAS BEING SPRAYED ONTO THE MANIFOLD OF THE VEHICLE WHICH COULD HAVE RESULTED IN A FIRE OR AND EXPLOSION. WHY IT DIDN'T HAPPEN IS SERENDIPITY FOR ME. WHEN I CALLED PEP BOYS THEY INFORMED ME THAT THEY DON'T INSPECT THEIR WORK. NEITHER THE TECHNICIAN, THE SUPERVISOR, OR ANY KIND OF QUALITY CONTROL MECHANISM CHECKS FOR DEFECTIVE WORK. SUCH A LACK OF CONTROL, PARTICULARLY WHEN DEALING WITH THE FUEL SYSTEM, REPRESENTS A SUBSTANTIAL THREAT TO ANYONE WHO HAS WORK DONE AT PEP BOYS.*AK
NHTSA ODI #10065971
Mileage unknown · Sep 5, 2002
Equipment
THE SPARE TIRE IS SUPPORTED UNDER THE REAR OF THE VEHICLE BY A STEEL CABLE SUPPORT SYSTEM. I WAS TRAVELING ON A FREEWAY AND HIT A BUMP. THE CABLE SUPPORTING THE SPARE TIRE BROKE. APPARENTLY THE CABLE HAD RUSTED AND BECAME WEAK. THE TIRE DROPPED ONTO THE ROAD SURFACE. THERE WAS A NUMBER OF VEHICLES DIRECTELY BEHIND ME AT THE T…
Read full complaint
THE SPARE TIRE IS SUPPORTED UNDER THE REAR OF THE VEHICLE BY A STEEL CABLE SUPPORT SYSTEM. I WAS TRAVELING ON A FREEWAY AND HIT A BUMP. THE CABLE SUPPORTING THE SPARE TIRE BROKE. APPARENTLY THE CABLE HAD RUSTED AND BECAME WEAK. THE TIRE DROPPED ONTO THE ROAD SURFACE. THERE WAS A NUMBER OF VEHICLES DIRECTELY BEHIND ME AT THE TIME. THE TIRE BOUNCED APPROXIMATELY 3 - 4 FEET IN THE AIR IN FRONT THE VEHICLE DIRECTLY BEHIND MY VEHICLE. LUCKLY ALL OF THE OTHER VEHICLES MISSED THE TIRE. THE TIRE ROLLED OFF OF THE ROAD AND INTO THE DITCH. AFTER RETURNING TO THE LOCATION OF WHERE THE TIRE DROPPED OFF THE VEHICLE, I SEARCHED THE ROAD AND DITCH, AND WAS UNABLE TO FIND THE SPARE TIRE. I BELIEVE THIS IS A SERIOUS PROBLEM AND CAN CAUSE VEHICLE DAMAGE AND PERSONAL INJURIES. AFTER REPORTING THE PROBLEM, AND ASKING ABOUT REPLACEMENT PARTS AT A LOCAL FORD SERVICE DEPARTMENT, I WAS TOLD THAT I WAS THE FIRST ONE TO INDICATE THAT THIS WAS A PROBLEM. HOWEVER WHEN BUYING A NEW SPARE TIRE AND RIM FROM A LOCAL TIRE SHOP, I WAS TOLD THAT THIS WAS A COMMON PROBLEM OF FORD EXPLORERS AND PICKUP TRUCKS.*AK
NHTSA ODI #766754
Mileage unknown · Jun 30, 2002
EquipmentFuel System, Gasoline
CONSUMER STATES 4 TIRES AND 1 SPARE WHICH ARE FIRESTONE WILDERNESS AT 15 INCH TIRE(S) (DOT # UNKNOWN) ORIGINAL EQUIPMENT ARE HIGHLY DEFECTIVE. CONSUMER REPLACED THEM DUE TO SAFETY CONCERNS, HOWEVER MANUFACTURER WILL NOT REIMBURSE OR REPLACE TIRES STATING THE CAMPAIGN WAS OVER. *TT THE FUEL PUMP …
Read full complaint
CONSUMER STATES 4 TIRES AND 1 SPARE WHICH ARE FIRESTONE WILDERNESS AT 15 INCH TIRE(S) (DOT # UNKNOWN) ORIGINAL EQUIPMENT ARE HIGHLY DEFECTIVE. CONSUMER REPLACED THEM DUE TO SAFETY CONCERNS, HOWEVER MANUFACTURER WILL NOT REIMBURSE OR REPLACE TIRES STATING THE CAMPAIGN WAS OVER. *TT THE FUEL PUMP WAS REPLACED 2 TIMES AND THE AIR CONDITION WAS REPLACED. UPDATED.*JB
NHTSA ODI #566395
Mileage unknown · May 30, 2002
Equipment
TEH SPARE TIRE FELL OFF THE VEHICLE WHILE IT WAS PARKED. THE SUPPORT CABLE RUSTED THROUGH AT THE POINT WHERE IT CONNECTS TO THE FITTING THAT SLIPS THROUGH THE SPARE TIRE PRIOR TO WINCHING IT UP TO THE UNDERSIDE OF THE VEHICLE. I CONTACTED FORD BUT THEY OFFERED NO ASSISTANCE. THIS COULD HAVE BEEN EXTREMELY SERIOUS HAD I BEEN DRIV…
Read full complaint
TEH SPARE TIRE FELL OFF THE VEHICLE WHILE IT WAS PARKED. THE SUPPORT CABLE RUSTED THROUGH AT THE POINT WHERE IT CONNECTS TO THE FITTING THAT SLIPS THROUGH THE SPARE TIRE PRIOR TO WINCHING IT UP TO THE UNDERSIDE OF THE VEHICLE. I CONTACTED FORD BUT THEY OFFERED NO ASSISTANCE. THIS COULD HAVE BEEN EXTREMELY SERIOUS HAD I BEEN DRIVING THE SUV.*AK
NHTSA ODI #762476
Mileage unknown · Aug 7, 2001
EquipmentFuel System, Other
FLOATING DEVICE LOCATED IN FUEL TANK THAT MEASURES FUEL LEVELS DEVELOPED A LEAK IN IT AND WOULD NOT WORK PROPERLY. CONSUMER PAID FOR FIRST REPAIR, FORD PAID FOR SECOND REPAI, CONSUMER WILL PAY FOR THIRD REPAIR SINCE ONE YEAR WARRANTY HAS EXPIRED, CONSUMER HAS NOT HAD THE PROBLEM REPAIRED. PLEASE PROVIDE ANY ADDITIONAL INFORM…
Read full complaint
FLOATING DEVICE LOCATED IN FUEL TANK THAT MEASURES FUEL LEVELS DEVELOPED A LEAK IN IT AND WOULD NOT WORK PROPERLY. CONSUMER PAID FOR FIRST REPAIR, FORD PAID FOR SECOND REPAI, CONSUMER WILL PAY FOR THIRD REPAIR SINCE ONE YEAR WARRANTY HAS EXPIRED, CONSUMER HAS NOT HAD THE PROBLEM REPAIRED. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK SHORTED BLOWER RESISTOR CAUSED SMOKE TO COME FROM AC VENTS. NLM
NHTSA ODI #893621
Mileage unknown · Aug 2, 2001
Equipment
SPARE TIRE WAS MISSING, AFTER ARRIVING HOME, CONSUMER NOTICED THAT CABLE HAD RUSTED. *AK *JG
NHTSA ODI #893284
Mileage unknown · Jun 28, 2001
Equipment
CABLE THAT HOLDS SPARE TIRE UP SNAPPED, AND CONSUMER'S SPARE TIRE BECAME DISENGAGED WHILE DRIVING VEHICLE. CONSUMER FEELS LUCKY THAT THERE WERE NO INJURIES. CONSUMER HAS CONTACTED DEALER. PLEASE PROVIDE ANY FURTHER INFOMATION.*AK
NHTSA ODI #891609
Mileage unknown · Apr 9, 2001
EquipmentFire
WHEN AIR CONDITIONER IS TURNED ON OUTSIDE LEAVES WOULD FALL INSIDE BLOWER MOTOR AND CATCH ON FIRE. CONSUMER'S VEHICLE EXPERIENCED HEAVY SMOKE INSIDE VEHICLE DUE TO DEFECT.*AK
NHTSA ODI #885494
Mileage unknown · Jan 10, 2001
Equipment
WHILE DRIVING SPARE TIRE CABLE BROKE, CAUSING TIRE TO FALL FROM VEHICLE. PLEASE GIVE ANY FURTHER DETAILS.*AK
NHTSA ODI #877924
NHTSA investigations
13EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96066 · Driver Door Electrical Fire
Opened Nov 22, 1996 · Closed May 15, 1997
Status: closed (inferred from source dates) · Electrical System
THE CONTACT ASSEMBLY FOR THE REMOTE POWER MIRROR CONTROL SWITCH MAY DEVELOP A SHORT CIRCUIT BETWEEN THE SWITCH POSITIVE PAD AND CHASSIS GROUND PAD AS A RESULT OF WATER INTRUSION.EXCESS CURRENT FLOW RESULTING FROM THE SHORT CIRCUIT CONDITION MAY OVERHEAT THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AND CAUSE A FIRE IN THE DRIVER'S DOOR.FORD HAS INDICATED THAT CURRENT IN EXCESS OF 15 AMPS CAN OVERHEAT THE CIRCUIT BOARD ENOUGH TO CAUSE A FIRE.CIRCUIT PROTECTION IS PROVIDED BY A 30 AMP FUSE.FORD IS RECALLING ALL 1993-94 4-DOOR EXPLORER VEHICLES EQUIPPED WITH THE SUBJECT ELECTRONIC OPTION COMBINATION TO INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.NO 2-DOOR EXPLORER VEHICLES WERE BUILT WITH THE SUBJECT COMPONENTS.ACCORDING TO FORD, VEHICLES BUILT PRIOR TO THE RECALL PRODUCTION RANGE WERE EQUIPPED WITH LOWER CAPACITY CIRCUIT BOARDS FOR THE SUBJECT SWITCH ASSEMBLY THAT WOULD FAIL FROM AN OPEN CIRCUIT IF A SIMILAR SHORT OCCURRED.A NEW SWITCH ASSEMBLY WITH 10 AMP FUSE PROTECTION WAS INTRODUCED BEGINNING WITH THE 1995 MODEL YEAR EXPLORER.MAZDA WILL CONDUCT A PARALLEL COMPAIGN (97V-083.002) TO REMEDY THE SUBJECT CONDITION IN APPROXIMATELY 14,000 NAVAJO VEHICLES.THE NAVAJO VEHICLES WERE AVAILABLE IN ONLY THE 2-DOOR VERSION WHICH, UNLIKE THE EXPLORER VEHICLES, DID USE THE SUBJECT OPTION COMBINATION IN THAT BODY STYLE.
EA96017 · Brake System Malfunction
Opened Jul 24, 1996 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE96016 · Wheel Lockup With Antilock Brake System
Opened Feb 28, 1996 · Closed Jul 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
ODI HAS RECEIVED OND HUNDRED SEVENTY-THREE (173) CONSUMER COMPLAINTS OF ALLEGED FAILURES OR MALFUNCTIONS IN THE BRAKING SYSTEM ON CERTAIN 1993 AND 1994 FORD EXPLORERS.THESE ALLEGED FAILURES OR MALFUNCTIONS ARE REPORTED TO HAVE CAUSED THIRTY-SIX (36) ACCIDENTS RESULTING FROM VEHICLE LOSS OF DIRECTIONAL CONTROL DURING BRAKING OR FROM THE EXTENDED DISTANCE REQUIRED TO STOP THE VEHICLE DURING BRAKING.THE COMPLAINANTS REPORT THAT THE ALLEGED FAILURES OR MALFUNCTIONS OCCURRED DURING BRAKING MOSTLY ON WET OR SLIPPERY ROADS, BUT ALSO HAVE OCCURRED ON DRY ROADS.SINCE ODI OPENED THIS PE BASED ON WHEEL LOCKUP COMPLAINTS, WE HAVE RECEIVED NUMEROUS ADDITIONAL COMPLAINTS AB OUT THE EXTENDED DISTANCE REQUIRED TO STOP THE SUBJECT VEHICLES WHEN BRAKING UNDER CERTAIN ROAD AND SPEED CONDITIONS.IN RESPONSE TO ODI'S INFORMATION REQUEST (IR) CONCERNING WHEEL LOCKUP COMPLAINTS ONT HE SUBJECT VEHICLES, FORD REPORTED RECEIVING 416 REPORTS (FIELD REPORTS, OWNER COMPLAINTS, AND SUBROGATION CLAIMS) OF WHEEEL LOCKUP ON 1993 AND 1994 FORD EXPLORERS, WITH 24 ALLEGED ACCIDENTS.IN ADDITION, FORD REPORTED RECEIVING 24,916 WARRANTY CLAIMS THAT COULD RELATE TO THE ALLEGED DEFECT OF WHEEL LOCKUP DURING BRAKING ON THE SUBJECT VEHICLES.AN ENGINEERING ANALYSIS IS WARRANTED TO DETERMINE THE SCOPE OF THESE ALLEGED BRAKING SYSTEM FAILURES OR MALFUNCTIONS ON 1993 AND 1994 FORD EXPLORERS.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Illustration