IllustrationWHILE BACKING INTO GARAGE THE DRIVER'S SEAT SUDDENLY AND FORCEFULLY FELL BACK. THE THICK STEEL SEAT BOLT RESPONSIBLE FRO HOLDING THE SEAT SECURELY HAD BROKEN IN HALF. *BF WHEN THE SEAT COLLAPSED THE CONSUMER LOST SOME CONTROL OF THE VEHICLE WHICH CAUSED THE DRIVER'S SIDE OF THE VEHICLE TO SCRAPE AGAINST THE GARAGE. *NM
1994 Ford Explorer
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1994 Ford Explorer do not stand out strongly from the model-year median of 609.
About this comparison →How this year compares
Owner complaints by model year
Compare all Explorer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 68 of 1,207 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 331 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 238 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 158 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
109 crash reports82 fire reports98 injury reports
What owners actually said
1,207 reportsTHE TRANSMISSION ON THE 1994 FORD EXPLORER APPEARS TO BE DEFECTIVE. THEY FAIL AFTER ONLY BETWEEN 75,000-125,000 MILES. *JB
1) SMELLED BURNING ELECTRICAL INSULATION WHILE DRIVING IN A RESIDENTIAL AREA OF IDAHO FALLS, ID. PREVIOUSLY THAT DAY, THE VEHICLE HAS BEEN DIFFICULT TO START ON ONE OCCASION. MULTIPLE VEHICLE STARTS AFTERWARDS HAD BEEN WITHOUT INCIDENT.*AK 2) PULLED OVER TO THE SIDE OF THE ROAD TO INVESTIGATE. FOUND THE ALTERNATOR OUTPUT …
Read full complaint
1) SMELLED BURNING ELECTRICAL INSULATION WHILE DRIVING IN A RESIDENTIAL AREA OF IDAHO FALLS, ID. PREVIOUSLY THAT DAY, THE VEHICLE HAS BEEN DIFFICULT TO START ON ONE OCCASION. MULTIPLE VEHICLE STARTS AFTERWARDS HAD BEEN WITHOUT INCIDENT.*AK 2) PULLED OVER TO THE SIDE OF THE ROAD TO INVESTIGATE. FOUND THE ALTERNATOR OUTPUT WIRE GLOWING RED AND THE INSULATION BURNING. IMMEDIATELY STOPPED THE ENGINE, AND REMOVED THE BATTERY CABLES. ALTERNATOR WAS TOO HOT TO TOUCH (THEREFORE > 140F). 3) REPLACED THE ALTERNATOR. REMOVED SIX INCHES OF BURNED UP ALTERNATOR OUTPUT WIRE (#6 AWG) AND THE CONNECTION LUG (#6 AWG W/ 1/4" POST). RELUGGED THE OUTPUT WIRE AND INSULATED THE LUG WITH ELECTRICAL TAPE AND HEAT SHRINK TUBING. NOTED THAT THE CONNECTION LUG HAD SHORTED TO THE ALTERNATOR FRAME BY THE EVIDENCE OF MELTED ALUMINUM FROM THE ALTERNATOR ON THE LUG. THE FACTORY INSTALLED LUG WAS NOT INSULATED BETWEEN THE LUG SHAFT AND THE ALTERNATOR CASE. IT WAS PROTECTED ON ITS EXTERNAL SIDE BY A BOOT SLIDE ON BOOT. OLD PARTS AND PICTURES ARE AVAILABLE.
1994 EXPLORER 4.0 V6 AUTOMATIC TRANSMISSION REBIULT 3 TIMES IN PAST YEAR .COUNTLESS TIMES VEHICLE HAS STALLED ACTING AS IF THE FUEL PUMP QUIT, FUEL PUMP REPLACED, COIL PACKS REPLACED, RELAYS REPLACED. ONCE ON THE HIGHWAY AT 70 MPH, ANOTHER TIME WHILE PULLING INTO TRAFFIC. USUALLY UPON START UP. AIR CONDITIONER SWITCH SHORTED OU…
Read full complaint
1994 EXPLORER 4.0 V6 AUTOMATIC TRANSMISSION REBIULT 3 TIMES IN PAST YEAR .COUNTLESS TIMES VEHICLE HAS STALLED ACTING AS IF THE FUEL PUMP QUIT, FUEL PUMP REPLACED, COIL PACKS REPLACED, RELAYS REPLACED. ONCE ON THE HIGHWAY AT 70 MPH, ANOTHER TIME WHILE PULLING INTO TRAFFIC. USUALLY UPON START UP. AIR CONDITIONER SWITCH SHORTED OUT, SAW BURNED WIRES ON SWITCH UPON REPLACEMENT. ANTIFREEZE SPEWED OUT FROM SIDE OF MOTOR, ASSUMED TO BE AROUND HEADS BUT HAS NOT BEEN TO SHOP YET.*AK
WINDSHIELD WIPERS FAILED INTERMITTENTLY. DEALER COULD NOT DUPLICATE THE PROBLEM. *AK THE POWER WINDOWS WORKED INTERMITTENTLY. *JB
WHEN APPLYING THE BRAKE AT 10-20 MPH VEHICLE VIBRATED. VEHICLE WAS TAKEN TO THE DEALER ON TWO SEPARATE OCCASIONS, AND DEALER REPLACED BOTH FRONT ROTORS/ REAR DRUMS AND FRONT PADS TWICE, BUT PROBLEM RECURRED. *AK
WHILE APPLYING THE PARKING BRAKE ON A INCLINE OR FLAT SURFACE. THE EMERGENCY BRAKE FAILED WITHOUT WARNING. THE CONSUMER DROVE THE VEHICLE TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THE BRAKE MECHANISM NEEDED REPLACEMENT. THE CONSUMER INFORMED THE MECHANIC ABOUT RECALL(94V169001). THE MECHANIC INFORMED THE…
Read full complaint
WHILE APPLYING THE PARKING BRAKE ON A INCLINE OR FLAT SURFACE. THE EMERGENCY BRAKE FAILED WITHOUT WARNING. THE CONSUMER DROVE THE VEHICLE TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THE BRAKE MECHANISM NEEDED REPLACEMENT. THE CONSUMER INFORMED THE MECHANIC ABOUT RECALL(94V169001). THE MECHANIC INFORMED THE CONSUMER THAT THE RECALL WAS NOT FOR THIS VEHICLE. *JB
ON 14 APRIL 2003 I PAID FOR SERVICE ON AN "INTERMITTENT START" PROBLEM; CHECKED THE BATTERY CHARGING SYSTEM, THE ALTERNATOR, AND TESTED THE BATTERY.PAID FOR LABOR $76.50 AND $79.95 FOR BATTERY ASSY . HERE IT IS 2004 AND THE PROBLEM WAS NOT FIXED BUT HAS GOTTEN WORSE. PURCHASED TWO NEW ALARM/ENTRY DEVICES (FOBS) ON 29 JUN 04 B…
Read full complaint
ON 14 APRIL 2003 I PAID FOR SERVICE ON AN "INTERMITTENT START" PROBLEM; CHECKED THE BATTERY CHARGING SYSTEM, THE ALTERNATOR, AND TESTED THE BATTERY.PAID FOR LABOR $76.50 AND $79.95 FOR BATTERY ASSY . HERE IT IS 2004 AND THE PROBLEM WAS NOT FIXED BUT HAS GOTTEN WORSE. PURCHASED TWO NEW ALARM/ENTRY DEVICES (FOBS) ON 29 JUN 04 BECAUSE WE WERE TOLD BY ONE OF THE MECHANICS THAT THE NEW DEVICES SHOULD SOLVE THE PROBLEM. THIS BILL CAME TO $211.10. ALREADY PAID $70.65 ON OR ABOUT APRIL 28, 2004 FOR A DIAGNOSTIC TO FIND OUT WHAT THE PROBLEM WAS AND TOLD THE REPAIR PART NEEDED COST $210. I WAS UPSET AND ONLY PAID FOR THE DIAGNOSTIC. I'M GLAD WE DIDNT PAY FOR THAT PART, BECAUSE EACH SUCCESSIVE TIME, THE SOLUTION TO THE "PROBLEM" HAS BEEN DIFFERENT AND COST ADDITIONAL MONEY. NOTHING THE MECHANICS HAVE DONE HAS RESOLVED THE PROBLEM; ONLY MADE THINGS WORSE AND THE COST HAVE TOTALED $814.67 FOR THIS PROBLEM SO FAR. THE MECHANIC SAID THE VEHICLE NOT STARTING BACK UP AFTER IT HAS BEEN TURNED OFF IS TIED IN TO THE ALARM SYSTEM. THEY HAVE REPLACED THE ANTI THEFT CONTROL MODULE ON 26 JULY 2004, $368.82. NOW THE WIRING IS NOT PERFORMING, AS IT SHOULD!!! VEHICLE IS NOT STARTING AGAIN, THE INTERIOR LIGHTS WON'T GO OUT WHEN THE VEHICLE IS TURNED OFF AFTER IT WAS "FIXED", BRAKE LIGHTS COME ON, AND CHECK ENGINE LIGHT ALSO COMES ON; SEEMS TO HAVE A WIRING/ELECTRICAL PROBLEM NOW. MR. LEE HIGGS, RED TEAM SERVICE MANAGER, HAD THE FUSE TO THE INTERIOR LIGHTS TAKEN OUT SO THE LIGHTS WONT DRAIN THE BATTERY, AT LEAST UNTIL THEY CAN GET IT BACK IN TO BE FIXED "AGAIN". THE VEHICLE HAS BEEN IN AND OUT OF THE SERVICE DEPARTMENT AND THE PROBLEMS ARE INCREASING INSTEAD OF DECREASING. WE ARE STILL WAITING FOR AN OPENING IN THE SERVICE DEPARTMENT TO PUT THE VEHICLE BACK IN THE SHOP TO GET THIS RESOLVED AGAIN! *AK
I BOUGHT MY 1994 FORD EXPLORER (4WD) IN MAY OF 1999 AND HAVE HAD NUMEROUS PROBLEMS SINCE. THE VEHICLE HAD APPROXIMATELY 50900 MILES WHEN I BOUGHT IT. IT NOW HAS 89000 MILES. I HAVE REPLACED THE BRAKE ROTORS TWICE AND REPLACED THE BRAKE PADS THREE TIMES. THE LAST TIME I COMPLETED BRAKE WORK WAS BECAUSE THE LEFT FRONT CALIPER OVER…
Read full complaint
I BOUGHT MY 1994 FORD EXPLORER (4WD) IN MAY OF 1999 AND HAVE HAD NUMEROUS PROBLEMS SINCE. THE VEHICLE HAD APPROXIMATELY 50900 MILES WHEN I BOUGHT IT. IT NOW HAS 89000 MILES. I HAVE REPLACED THE BRAKE ROTORS TWICE AND REPLACED THE BRAKE PADS THREE TIMES. THE LAST TIME I COMPLETED BRAKE WORK WAS BECAUSE THE LEFT FRONT CALIPER OVERHEATED AND FAILED. I THEN REPLACED BOTH FRONT CALIPERS. THERE IS A BAD VIBRATION PROBLEM AT SPEEDS OF 55-67 MPH. I RECENTLY PURCHASED FOUR NEW TIRES, HAD THEM BALANCED, HAD THE FRONT END ALIGNED, AND REPLACED THE SHOCKS TO FIX THIS PROBLEM. IT STILL VIBRATES AT THE ABOVE MENTIONED SPEEDS. ALSO, THE VEHICLE HAD NUMEROUS PROBLEMS WITH THE PCM (CHECK ENGINE LIGHT). I REPLACED THE PCM AS A LAST RESORT BECAUSE I HAD ALREADY REPLACED ALL THE SENSORS THAT COULD HAVE BEEN CAUSING THE PROBLEM. REPLACING THE PCM CORRECTED THE PROBLEM FOR ABOUT A YEAR, BUT NOW THE CHECK ENGINE LIGHT COMES ON AGAIN DURING INITIAL STARTING AND THEN GOES OUT AFTER DRIVING ABOUT 2-3 MILES. I ALSO HAVE A SOUND COMING FROM MY AIR VENTS WHEN THE A/C IS TURNED ON. NOW FOR MY MOST RECENT PROBLEM. THE TEMPERATURE GAUGE WAS READING HOTTER THAN NORMAL SO I OVERHAULED THE COOLING SYSTEM INCLUDING: NEW THERMOSTAT, NEW COOLING FAN (OLD ONE WAS CRACKED ALL AROUND THE HUB), NEW FAN CLUTCH, NEW RADIATOR, NEW ENGINE COOLANT TEMPERATURE SENSOR, AND NEW FLUID FLUSH AND REFILL. THE TEMPERATURE GAUGE STILL READS THE SAME. I HAVE NO IDEA WHAT TO DO NOW. ANY RECALL INFORMATION YOU COULD PROVIDE WOULD HELP. I HAVE ALL RECEIPTS FOR PARTS PURCHASED AND WORK PERFORMED.*AK
CONSUMER WAS INVOLVED WITH THE FIRESTONE RECALL OF TIRES FOR BLOW OUTS. WHILE DRIVING 60 MPH DRIVER'S SIDE TIRE BLEW OUT, RIPPING ACROSS THE MIDDLE. CONSUMER WAS ABLE TO MAINTAIN CONTROL WITHOUT ANY COLLISIONS THESE TIRES WERE MANUFACTURED BY GENERAL, SERIES GENERAL AT, /P2357515. *AK
Official recalls
499V310001 · Structure:body:hatchback/liftgate:support Device/strut
Nov 3, 1999
VEHICLE DESCRIPTION: ON CERTAIN SPORT UTILITY VEHICLES, THE HYDRAULIC LIFT CYLINDER BRACKET WELDS COULD FRACTURE.
Consequence & remedy
Consequence: WITH A BROKEN BRACKET WELD, THERE IS A POTENTIAL FOR THE LIFTGATE BRACKET TO GRADUALLY BEND INWARD ALLOWING THE LIFT CYLINDER BALL STUD TO DISENGAGE, UNEXPECTEDLY ALLOWING THE LIFTGATE TO FALL FROM AN OPEN POSITION.
Remedy: DEALERS WILL INSTALL LIFTGATE REINFORCEMENT BRACKETS. DEPENDING UPON THE CONDITION OF THE LIFTGATE SHEET METAL IN THE AREA OF THE BRACKET, DEALERS MAY ALSO INSTALL A LARGER REINFORCEMENT.
97V083000 · Visibility:rearview Mirrors/devices
May 5, 1997
A SHORT CIRCUIT CONDITION CAN OCCUR IN THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AS A RESULT OF A SEPARATED PART OF THE CONTACT ASSEMBLY BRIDGING THE SWITCH POSITIVE BATTERY PAD AND ADJACENT CHASSIS GROUND PAD.
Consequence & remedy
Consequence: THE CURRENT CAN OVERHEAT THE PRINTED CIRCUIT BOARD AND OTHER PLASTIC AND ELASTOMERIC COMPONENTS OF THE SWITCH ASSEMBLY RESULTING IN SMOKE OR FIRE.
Remedy: DEALERS WILL INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.
96V024001 · Service Brakes, Hydraulic:power Assist:hydraulic
Feb 5, 1996
THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY CAN DEVELOP STRESS CORROSION CRACKING AFTER BEING OPERATED FOR AN EXTENDED PERIOD OF TIME IN THE SOUTHERN CALIFORNIA LOCATION.
Consequence & remedy
Consequence: IF A CRACK OCCURS, IT COULD RESULT IN ONE OR BOTH STUDS FRACTURING. THE MASTER CYLINDER COULD THEN SEPARATE FROM THE VACUUM BOOSTER, WHEN THE BRAKES ARE APPLIED, PREVENTING THE SERVICE BRAKES FROM ACTIVATING INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE POWER BRAKE VACUUM BOOSTER ASSEMBLY.
94V169001 · Parking Brake:conventional
Sep 7, 1994
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
13EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96066 · Driver Door Electrical Fire
Opened Nov 22, 1996 · Closed May 15, 1997
Status: closed (inferred from source dates) · Electrical System
THE CONTACT ASSEMBLY FOR THE REMOTE POWER MIRROR CONTROL SWITCH MAY DEVELOP A SHORT CIRCUIT BETWEEN THE SWITCH POSITIVE PAD AND CHASSIS GROUND PAD AS A RESULT OF WATER INTRUSION.EXCESS CURRENT FLOW RESULTING FROM THE SHORT CIRCUIT CONDITION MAY OVERHEAT THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AND CAUSE A FIRE IN THE DRIVER'S DOOR.FORD HAS INDICATED THAT CURRENT IN EXCESS OF 15 AMPS CAN OVERHEAT THE CIRCUIT BOARD ENOUGH TO CAUSE A FIRE.CIRCUIT PROTECTION IS PROVIDED BY A 30 AMP FUSE.FORD IS RECALLING ALL 1993-94 4-DOOR EXPLORER VEHICLES EQUIPPED WITH THE SUBJECT ELECTRONIC OPTION COMBINATION TO INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.NO 2-DOOR EXPLORER VEHICLES WERE BUILT WITH THE SUBJECT COMPONENTS.ACCORDING TO FORD, VEHICLES BUILT PRIOR TO THE RECALL PRODUCTION RANGE WERE EQUIPPED WITH LOWER CAPACITY CIRCUIT BOARDS FOR THE SUBJECT SWITCH ASSEMBLY THAT WOULD FAIL FROM AN OPEN CIRCUIT IF A SIMILAR SHORT OCCURRED.A NEW SWITCH ASSEMBLY WITH 10 AMP FUSE PROTECTION WAS INTRODUCED BEGINNING WITH THE 1995 MODEL YEAR EXPLORER.MAZDA WILL CONDUCT A PARALLEL COMPAIGN (97V-083.002) TO REMEDY THE SUBJECT CONDITION IN APPROXIMATELY 14,000 NAVAJO VEHICLES.THE NAVAJO VEHICLES WERE AVAILABLE IN ONLY THE 2-DOOR VERSION WHICH, UNLIKE THE EXPLORER VEHICLES, DID USE THE SUBJECT OPTION COMBINATION IN THAT BODY STYLE.
EA96017 · Brake System Malfunction
Opened Jul 24, 1996 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE96016 · Wheel Lockup With Antilock Brake System
Opened Feb 28, 1996 · Closed Jul 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
ODI HAS RECEIVED OND HUNDRED SEVENTY-THREE (173) CONSUMER COMPLAINTS OF ALLEGED FAILURES OR MALFUNCTIONS IN THE BRAKING SYSTEM ON CERTAIN 1993 AND 1994 FORD EXPLORERS.THESE ALLEGED FAILURES OR MALFUNCTIONS ARE REPORTED TO HAVE CAUSED THIRTY-SIX (36) ACCIDENTS RESULTING FROM VEHICLE LOSS OF DIRECTIONAL CONTROL DURING BRAKING OR FROM THE EXTENDED DISTANCE REQUIRED TO STOP THE VEHICLE DURING BRAKING.THE COMPLAINANTS REPORT THAT THE ALLEGED FAILURES OR MALFUNCTIONS OCCURRED DURING BRAKING MOSTLY ON WET OR SLIPPERY ROADS, BUT ALSO HAVE OCCURRED ON DRY ROADS.SINCE ODI OPENED THIS PE BASED ON WHEEL LOCKUP COMPLAINTS, WE HAVE RECEIVED NUMEROUS ADDITIONAL COMPLAINTS AB OUT THE EXTENDED DISTANCE REQUIRED TO STOP THE SUBJECT VEHICLES WHEN BRAKING UNDER CERTAIN ROAD AND SPEED CONDITIONS.IN RESPONSE TO ODI'S INFORMATION REQUEST (IR) CONCERNING WHEEL LOCKUP COMPLAINTS ONT HE SUBJECT VEHICLES, FORD REPORTED RECEIVING 416 REPORTS (FIELD REPORTS, OWNER COMPLAINTS, AND SUBROGATION CLAIMS) OF WHEEEL LOCKUP ON 1993 AND 1994 FORD EXPLORERS, WITH 24 ALLEGED ACCIDENTS.IN ADDITION, FORD REPORTED RECEIVING 24,916 WARRANTY CLAIMS THAT COULD RELATE TO THE ALLEGED DEFECT OF WHEEL LOCKUP DURING BRAKING ON THE SUBJECT VEHICLES.AN ENGINEERING ANALYSIS IS WARRANTED TO DETERMINE THE SCOPE OF THESE ALLEGED BRAKING SYSTEM FAILURES OR MALFUNCTIONS ON 1993 AND 1994 FORD EXPLORERS.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available