NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,207 reportsMileage unknown · Aug 3, 2000
Tires
I WOULD LIKE TO KNOW WHAT YOU ARE GOING TO DO ABOUT THE SAFTEY ISSUES OF THIS TIRE. A REPORT WAS BROADCAST ON THE NEWS YESTERDAY ABOUT THE HAZARDS OF THIS TIRE WHICH CAME WITH OUR EXPLORER. IT WAS MENTIONED THAT FORD HAD TO REPLACE THE DEFECTIVE TIRES IN ALL COUNTRIES EXCEPT THE USA. I CONTACTED FORD AND THEIR COMMENT WAS THAT T…
Read full complaint
I WOULD LIKE TO KNOW WHAT YOU ARE GOING TO DO ABOUT THE SAFTEY ISSUES OF THIS TIRE. A REPORT WAS BROADCAST ON THE NEWS YESTERDAY ABOUT THE HAZARDS OF THIS TIRE WHICH CAME WITH OUR EXPLORER. IT WAS MENTIONED THAT FORD HAD TO REPLACE THE DEFECTIVE TIRES IN ALL COUNTRIES EXCEPT THE USA. I CONTACTED FORD AND THEIR COMMENT WAS THAT THEY WERE LOOKING INTO IT. I WANT A RECALL. NO SAFETY DEFECT MENTIONED.( DOT NUMBER: TIRE SIZE: P23575R14M )
NHTSA ODI #726551
Mileage unknown · Aug 3, 2000
Tires
AS I WAS DRIVING NORTHBOUND ON I25 BETWEEN ALBUQUERQUE AND SANTA FE NM, I FELT MY EXPLORER START SHAKING AND THEN THERE WAS A VERY LOUD POP AND I SAW SOMETHING FLY PAST ME. I MANAGED TO GET TO THE SIDE OF THE INTERSTATE AND GOT OUT TO SEE IF I COULD DISCOVER WHAT HAPPENED. I FOUND THE TREAD OF THE LEFT REAR TIRE HAD COME OFF. …
Read full complaint
AS I WAS DRIVING NORTHBOUND ON I25 BETWEEN ALBUQUERQUE AND SANTA FE NM, I FELT MY EXPLORER START SHAKING AND THEN THERE WAS A VERY LOUD POP AND I SAW SOMETHING FLY PAST ME. I MANAGED TO GET TO THE SIDE OF THE INTERSTATE AND GOT OUT TO SEE IF I COULD DISCOVER WHAT HAPPENED. I FOUND THE TREAD OF THE LEFT REAR TIRE HAD COME OFF. PART OF THE TREAD WAS WRAPPED AROUND THE AXLE. THE TIRE DID NOT BLOWOUT. LUCKILY I WAS NOT INJURED, ONLY VERY VERY SCARED! THE RUNNING BOARD ON THE VEHICLE WAS COMPLETELY RIPPED OFF AND GONE, BOTH LEFT DOORS ARE DAMAGED, THERE IS DAMAGE TO THE QUARTER PANEL, AND TO THE TAIL GATE. I FILED A CLAIM WITH FIRESTONE ON 5/10/00 AND SENT IN 3 ESTIMATES OF $3,000; SO FAR I SEEM TO BE GETTING THE RUNAROUND. WHEN I WAS GETTING MY ESTIMATES, I WAS TOLD THIS IS BECOMING "NORMAL" FOR FIRESTONE TIRES AND EXPLORERS AND TO COUNT MYSELF AMONG THE FEW NOT INJURED. THANK YOU. *AK( DOT NUMBER: TIRE SIZE: 23575R15 )
NHTSA ODI #726522
Mileage unknown · Aug 3, 2000
Tires
THE TREAD SEPARATED FROM THE TIRE WHILE WE WERE DRIVING ON THE HIGHWAY. WE IMMEDIATELY PURCHASED NEW FIRESTONE WILDERNESS HT TIRES AND THEN I HEARD OF THE ACCIDENTS ETC.. SO, NOW I WANT TO SEE IF THERE IS ANYWAY TO RETURN MY TIRES AND BUY A DIFFERENT BRAND. WE HAD PREVIOUS PROBLEM WITH THE ATX HAVING UNEVEN WEAR DESPITE PROPE…
Read full complaint
THE TREAD SEPARATED FROM THE TIRE WHILE WE WERE DRIVING ON THE HIGHWAY. WE IMMEDIATELY PURCHASED NEW FIRESTONE WILDERNESS HT TIRES AND THEN I HEARD OF THE ACCIDENTS ETC.. SO, NOW I WANT TO SEE IF THERE IS ANYWAY TO RETURN MY TIRES AND BUY A DIFFERENT BRAND. WE HAD PREVIOUS PROBLEM WITH THE ATX HAVING UNEVEN WEAR DESPITE PROPER MAINTENCE AND FIRESTONE JUST SAID TO ROTATE THEM IN A SPECIFIC WAY AND NOT TO WORRY AND THEN THE TIRE BLEW, NOT THE SAME TIRE WITH UNEVEN WEAR. THANK YOU. *AK( DOT NUMBER: TIRE SIZE: P235/75/15 )
NHTSA ODI #726491
Mileage unknown · Aug 1, 2000
Parking Brake
WHEN APPLYING THE EMERGENCY BRAKE, IT WILL NOT HOLD AS IT SHOULD. INSTEAD THE VEHICLE MOVES JUST LIKE STATED IN RECALL 94 V169001. *AK THE PARKING BRAKE CONTROL SELF ADJUSTING PAWL DOES NOT LINE UP PROPERLY WITH SELF ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET. *YH
NHTSA ODI #866520
Mileage unknown · Jul 28, 2000
Tires
WAS DRIVING 70MPH ON CLEAR SUNNY DAY WHEN TIRE BLEWOUT FOR NO REASON. WAS ABLE TO CONTROL & GUIDE VEHICLE TO SIDE OF ROAD. AAA CAME & CHANGED FIRESTONE TIRE. NOTICED TREAD IN MIDDLE OF TIRE HAD SEPARATED & HANGING OFF,BUT STILL ON TIRE. TOOK VEHICLE TO TIRE SHOP & HAD FIRESTONE TIRE REPLACED. SHOP KEPT TIRE & HAVE NO REPORT. WA…
Read full complaint
WAS DRIVING 70MPH ON CLEAR SUNNY DAY WHEN TIRE BLEWOUT FOR NO REASON. WAS ABLE TO CONTROL & GUIDE VEHICLE TO SIDE OF ROAD. AAA CAME & CHANGED FIRESTONE TIRE. NOTICED TREAD IN MIDDLE OF TIRE HAD SEPARATED & HANGING OFF,BUT STILL ON TIRE. TOOK VEHICLE TO TIRE SHOP & HAD FIRESTONE TIRE REPLACED. SHOP KEPT TIRE & HAVE NO REPORT. WAS ORIGINAL FIRESTONE ATX P235/75R15 ON A 1994 FORD EXPLORER. *AK
NHTSA ODI #866236
Mileage unknown · Jul 27, 2000
Tires
TRAVELING ON THE HIGHWAY ABOUT 50MPH AND DRIVING UP A HILL CONSUMER HEARD A FLAPPING NOISE. SO HE PULLED OVER, AND HE SAW A PIECE OF THE TIRE HANGING OFF OF THE TIRES. REAR LEFT DRIVER'S SIDE TIRE CAME APART. IN DECEMBER OF LAST YEAR, REAR LEFT PASSENGER TIRE SEPARATED. *AK
NHTSA ODI #866202
Mileage unknown · Jul 27, 2000
TiresCrash
WHILE DRIVING ON FREEWAY ABOUT 55MPH HEARD A LOUD NOISE, SOMETHING HIT THE CAR. PULLED OVER ON THE SHOULDER, AND NOTICED THAT DRIVER'S SIDE REAR LEFT TIRE TREAD HAD SEPARATED FROM TIRE, TIRE FLEW OFF AND DAMAGED VEHICLE.*AK
NHTSA ODI #866192
Mileage unknown · Jul 27, 2000
Tires
WAS DRIVING APPROXIMATELY 55MPH WHEN VEHICLE STARTED TO SHIMMY. FELT LIKE THE WHEELS WERE OUT OF BALANCE. DROVE A FEW MORE DAYS & WAS STILL SHIMMYING. TOOK TO TIRE DEALER & MECHANIC INDICATED THE RIGHT FRONT TIRE WAS DELAMINATED. TREAD WAS SEPARATING, BUT NOT COMPLETELY. HAD THE ORIGINIAL TIRE WITH 63,000 MILES ON IT & WAS REPL…
Read full complaint
WAS DRIVING APPROXIMATELY 55MPH WHEN VEHICLE STARTED TO SHIMMY. FELT LIKE THE WHEELS WERE OUT OF BALANCE. DROVE A FEW MORE DAYS & WAS STILL SHIMMYING. TOOK TO TIRE DEALER & MECHANIC INDICATED THE RIGHT FRONT TIRE WAS DELAMINATED. TREAD WAS SEPARATING, BUT NOT COMPLETELY. HAD THE ORIGINIAL TIRE WITH 63,000 MILES ON IT & WAS REPLACED WITH ANOTHER. FIRESTONE ATX - P235/75R15 DOT W2HL1MO. HAVE NO REPORTS OR PHOTOGRAPHS. WILL BE SENDING TIRE. *AK *SLC
NHTSA ODI #866148
Mileage unknown · Jul 26, 2000
TiresCrashInjury
I WAS TRAVELLING AT 65MPH ON THE FREEWAY WHEN THE TREAD OF THE LEFT REAR TIRE SEPARATED FROM THE TIRE. I LOST CONTROL OF THE CAR. THE CAR SWERVED ACROSS THREE LANES AND ROLLED OVER 1 AND 1/4 TIMES, LANDING ON THE DRIVER'S SIDE. THE TIRES HAD BEEN INSPECTED AND ROTATED 4 MONTHS (1500 MILES) BEFORE THE ACCIDENT. AT THAT TIME …
Read full complaint
I WAS TRAVELLING AT 65MPH ON THE FREEWAY WHEN THE TREAD OF THE LEFT REAR TIRE SEPARATED FROM THE TIRE. I LOST CONTROL OF THE CAR. THE CAR SWERVED ACROSS THREE LANES AND ROLLED OVER 1 AND 1/4 TIMES, LANDING ON THE DRIVER'S SIDE. THE TIRES HAD BEEN INSPECTED AND ROTATED 4 MONTHS (1500 MILES) BEFORE THE ACCIDENT. AT THAT TIME WE WERE ADVISED BY FIRESTONE THAT THE TIRES HAD 10,000-20,000 MILES OF USAGE LEFT. *AK( DOT NUMBER: W2HL1MO482 TIRE SIZE: P235/75R15 )
NHTSA ODI #726091
Mileage unknown · Jul 24, 2000
Seat Belts
WHILE TRAVELING 35 MPH AND AS A RESULT OF AN ACCIDENT REAR SEAT BELT THAT HAD CHILD SEAT LOCKED IN BECAME UNLOCKED. CHILD SEAT WAS LAYING FACE DOWN ON FLOOR. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #865907
NHTSA investigations
13EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96066 · Driver Door Electrical Fire
Opened Nov 22, 1996 · Closed May 15, 1997
Status: closed (inferred from source dates) · Electrical System
THE CONTACT ASSEMBLY FOR THE REMOTE POWER MIRROR CONTROL SWITCH MAY DEVELOP A SHORT CIRCUIT BETWEEN THE SWITCH POSITIVE PAD AND CHASSIS GROUND PAD AS A RESULT OF WATER INTRUSION.EXCESS CURRENT FLOW RESULTING FROM THE SHORT CIRCUIT CONDITION MAY OVERHEAT THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AND CAUSE A FIRE IN THE DRIVER'S DOOR.FORD HAS INDICATED THAT CURRENT IN EXCESS OF 15 AMPS CAN OVERHEAT THE CIRCUIT BOARD ENOUGH TO CAUSE A FIRE.CIRCUIT PROTECTION IS PROVIDED BY A 30 AMP FUSE.FORD IS RECALLING ALL 1993-94 4-DOOR EXPLORER VEHICLES EQUIPPED WITH THE SUBJECT ELECTRONIC OPTION COMBINATION TO INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.NO 2-DOOR EXPLORER VEHICLES WERE BUILT WITH THE SUBJECT COMPONENTS.ACCORDING TO FORD, VEHICLES BUILT PRIOR TO THE RECALL PRODUCTION RANGE WERE EQUIPPED WITH LOWER CAPACITY CIRCUIT BOARDS FOR THE SUBJECT SWITCH ASSEMBLY THAT WOULD FAIL FROM AN OPEN CIRCUIT IF A SIMILAR SHORT OCCURRED.A NEW SWITCH ASSEMBLY WITH 10 AMP FUSE PROTECTION WAS INTRODUCED BEGINNING WITH THE 1995 MODEL YEAR EXPLORER.MAZDA WILL CONDUCT A PARALLEL COMPAIGN (97V-083.002) TO REMEDY THE SUBJECT CONDITION IN APPROXIMATELY 14,000 NAVAJO VEHICLES.THE NAVAJO VEHICLES WERE AVAILABLE IN ONLY THE 2-DOOR VERSION WHICH, UNLIKE THE EXPLORER VEHICLES, DID USE THE SUBJECT OPTION COMBINATION IN THAT BODY STYLE.
EA96017 · Brake System Malfunction
Opened Jul 24, 1996 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE96016 · Wheel Lockup With Antilock Brake System
Opened Feb 28, 1996 · Closed Jul 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
ODI HAS RECEIVED OND HUNDRED SEVENTY-THREE (173) CONSUMER COMPLAINTS OF ALLEGED FAILURES OR MALFUNCTIONS IN THE BRAKING SYSTEM ON CERTAIN 1993 AND 1994 FORD EXPLORERS.THESE ALLEGED FAILURES OR MALFUNCTIONS ARE REPORTED TO HAVE CAUSED THIRTY-SIX (36) ACCIDENTS RESULTING FROM VEHICLE LOSS OF DIRECTIONAL CONTROL DURING BRAKING OR FROM THE EXTENDED DISTANCE REQUIRED TO STOP THE VEHICLE DURING BRAKING.THE COMPLAINANTS REPORT THAT THE ALLEGED FAILURES OR MALFUNCTIONS OCCURRED DURING BRAKING MOSTLY ON WET OR SLIPPERY ROADS, BUT ALSO HAVE OCCURRED ON DRY ROADS.SINCE ODI OPENED THIS PE BASED ON WHEEL LOCKUP COMPLAINTS, WE HAVE RECEIVED NUMEROUS ADDITIONAL COMPLAINTS AB OUT THE EXTENDED DISTANCE REQUIRED TO STOP THE SUBJECT VEHICLES WHEN BRAKING UNDER CERTAIN ROAD AND SPEED CONDITIONS.IN RESPONSE TO ODI'S INFORMATION REQUEST (IR) CONCERNING WHEEL LOCKUP COMPLAINTS ONT HE SUBJECT VEHICLES, FORD REPORTED RECEIVING 416 REPORTS (FIELD REPORTS, OWNER COMPLAINTS, AND SUBROGATION CLAIMS) OF WHEEEL LOCKUP ON 1993 AND 1994 FORD EXPLORERS, WITH 24 ALLEGED ACCIDENTS.IN ADDITION, FORD REPORTED RECEIVING 24,916 WARRANTY CLAIMS THAT COULD RELATE TO THE ALLEGED DEFECT OF WHEEL LOCKUP DURING BRAKING ON THE SUBJECT VEHICLES.AN ENGINEERING ANALYSIS IS WARRANTED TO DETERMINE THE SCOPE OF THESE ALLEGED BRAKING SYSTEM FAILURES OR MALFUNCTIONS ON 1993 AND 1994 FORD EXPLORERS.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Illustration