IllustrationEXPERIENCED EXTREME SHAKING AND VIBRATION OF FRONT END OF VEHICLE, WHICH ALSO CAUSED STEERING WHEEL TO WOBBLE BACK AND FORTH. WAS TOLD BY SEARS AUTO GARAGE THAT TREAD ON TIRES WAS SHREDDING AND ALL NEEDED TO BE REPLACED. *AK( DOT NUMBER: )
1994 Ford Explorer
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1994 Ford Explorer do not stand out strongly from the model-year median of 609.
About this comparison →How this year compares
Owner complaints by model year
Compare all Explorer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 68 of 1,207 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 331 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 238 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 158 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
109 crash reports82 fire reports98 injury reports
What owners actually said
1,207 reportsVEHICLE WILL STALL OUT INTERMITTENTLY, BUT VEHICLE WILL RESTART AFTER WAITING ABOUT 5-15 MINUTES. DEALER REPLACED MODULE PART #393437, BUT DID NOT CORRECT DEFECT. *AK
ALL FOUR TIRE FAILURES INVOLVED TREAD SEPARATION ON TRIPS ON I-10 BETWEEN TEXAS AND CALIFORNIA. REPLACEMENTS WERE MADE AT NON-FIRESTONE FACILITIES. CASES SUCH AS THIS ARE THE VERY CAUSE OF THE FIRESTONE RECALL, YET ACCORDING TO THE LATEST ANNOUNCEMENTS, THERE IS NO PROVISION FOR EITHER REPLACEMENT TIRES OR A REASONABLE ALLOWAN…
Read full complaint
ALL FOUR TIRE FAILURES INVOLVED TREAD SEPARATION ON TRIPS ON I-10 BETWEEN TEXAS AND CALIFORNIA. REPLACEMENTS WERE MADE AT NON-FIRESTONE FACILITIES. CASES SUCH AS THIS ARE THE VERY CAUSE OF THE FIRESTONE RECALL, YET ACCORDING TO THE LATEST ANNOUNCEMENTS, THERE IS NO PROVISION FOR EITHER REPLACEMENT TIRES OR A REASONABLE ALLOWANCE, SINCE THESE FAILURES WERE A FEW WEEKS PRIOR TO THE OFFICIAL RECALL DATE!( DOT NUMBER: VNHL IMO TIRE SIZE: P235/75R15 )
TWO (2) OF THE FOUR (4) ORIGINAL EQUIPMENT TIRES HAD BULGES IN SEVERAL SPOTS AROUND THEM. I HAD THEM REPLACED AT NTB (NATIONAL TIRE & BATTERY) IN LOUISVILLE, KY ON 5/18/98 WITH ONLY 36,418 MILES FOR FEAR OF MAJOR FAILURE.( DOT NUMBER: TIRE SIZE: P235/75R15 )
WHILE TRAVELING ON VACATION IN 1999, I HAD A CHUNK OF RUBBER COME OFF MY TIRE. THE TIRE DID NOT BLOW OUT. EVEN THOUGH I HAD PLENTY OF TREADWEAR LEFT, I HAD TO REPLACE THE TIRE. THE RUBBER LOOKED BAD ON ALL MY TIRES SO I REPLACED THEM ALL. I STILL HAVE THE ORIGINAL SPARE WHICH IS ALSO P235X75R15 FIRESTONE ATX. I WAS INFORMED BY …
Read full complaint
WHILE TRAVELING ON VACATION IN 1999, I HAD A CHUNK OF RUBBER COME OFF MY TIRE. THE TIRE DID NOT BLOW OUT. EVEN THOUGH I HAD PLENTY OF TREADWEAR LEFT, I HAD TO REPLACE THE TIRE. THE RUBBER LOOKED BAD ON ALL MY TIRES SO I REPLACED THEM ALL. I STILL HAVE THE ORIGINAL SPARE WHICH IS ALSO P235X75R15 FIRESTONE ATX. I WAS INFORMED BY MAIL FROM FORD THAT MY VEHICLE IS NOT AFFECTED BY RECALL. WHEN I PURCHASED MY VEHICLE IT HAD 35,300 MILES ON IT. I DO NOT BELIEVE THE TIRES WOULD HAVE BEEN REPLACED THAT QUICK, INCLUDING THE SPARE. I BELIEVE FORD MADE AN ERROR IN SAYING MY VEHICLE DID NOT COME WITH TIRES INVOLVED IN RECALL. I STILL HAVE THE SPARE TO PROVE IT. I WONDER IF FORD IS ACCIDENTLY MISINFORMING OTHER PEOPLE ABOUT THEIR TIRES NOT BEING INVOLVED IN RECALL. I ALSO FEEL THE RECALL SHOULD BE RETROACTIVE BACK TO INCLUDE 1999. I BOUGHT TIRES BECAUSE I WAS FORCED TO, NOT BECAUSE I WANTED TO. THE RUBBER ON MY TIRES LOOKED AWFUL EVEN THOUGH I HAD PLENTY OF TREADWEAR LEFT.( DOT NUMBER: TIRE SIZE: P235X75R15 )
WHILE ING AT ANY SPEED THE VEHICLE WOULD SHUT OFF INTERMITTEMTLY; AFTER FIVE MINUTE OR MORE THE VEHICLE WOULD RESTART; VEHICLE BEEN IN INDEPENDENCE REPAIRS SHOP ON THREE OCCASION AND CONDITION STILL REOCCURRING. FEEL FREE TO PROVIDE ANY FURTHER DETAILS:
DURING THE FIRST PART OF AUGUST, I HEARD ABOUT THE RECALL ON MY FIRESTONE TIRES, I IMMEDIATELY CALLED MY LOCAL FIRESTONE DEALER IN MONROE. THEY EXPLAINED THAT THEY WERE NOT DOING ANYTHING YET; HOWEVER, I COULD MAKE AN APPT. TO HAVE MY TIRES CHECKED. IT WAS 3 WEEKS BEFORE THEY COULD GET ME IN. I WAITED 3 WEEKS AND TOOK MY EXP…
Read full complaint
DURING THE FIRST PART OF AUGUST, I HEARD ABOUT THE RECALL ON MY FIRESTONE TIRES, I IMMEDIATELY CALLED MY LOCAL FIRESTONE DEALER IN MONROE. THEY EXPLAINED THAT THEY WERE NOT DOING ANYTHING YET; HOWEVER, I COULD MAKE AN APPT. TO HAVE MY TIRES CHECKED. IT WAS 3 WEEKS BEFORE THEY COULD GET ME IN. I WAITED 3 WEEKS AND TOOK MY EXPLORER IN TO HAVE THE TIRES CHECKED. THEY LOOKED AT THE INSIDE OF 1 TIRE & SAID, YES, YOUR TIRES ARE BEING RECALLED, WE WILL PUT YOU ON THE LIST TO RECEIVE NEW TIRES, WE ARE ALL OUT AT THIS TIME. THEY ALSO STATED IT WOULD BE 2-2.5 MONTHS BEFORE THE TIRES WOULD BE IN. THEY NEVER BOTHERED TO CHECK MY AIR PRESSURE OR FOR ANY DEFECTS IN THE TIRES. I AM A SINGLE PARENT WITH 2 CHILDREN. MY SON JUST CAME HOME FROM A REHAB CENTER BECAUSE HE HAS A TRAUMATIC BRAIN INJ. FROM A DRIVER WHO HIT US HEAD ON. I HAVE TO DRIVE MY SON TO FARMINGTON 1-2 TIMES A WEEK FOR DOCTOR APPTS. & THERAPY. I DRIVE ANYWHERE FROM 100 - 150 MILES PER TRIP, ON THE EXPRESSWAY. WE HAD A VACATION PLANNED FOR LABOR DAY WEEKEND TO VISIT MY PARENTS IN ARKANSAS. WE HAD TO CANCEL OUR VACATION DUE TO THE DEFECTIVE TIRES. I AM VERY UPSET THAT IT TOOK 3 WKS FOR ANYONE TO EVEN LOOK AT MY TIRES AND DURING THE APPT., THEY ONLY LOOKED AT THE NUMBER ON 1 TIRE. THEY NEVER BOTHERED TO CHECK THE TIRES. I WAS NEVER PUT ON A LIST FOR NEW TIRES UNTIL THE DAY OF MY APPT., 3 WKS AFTER I CALLED. I AM WORRIED ABOUT MY ENTIRE FAMILY, ESPECIALLY MY SON WITH A TRAUMATIC BRAIN INJURY. I HAVE NO OTHER CHOICE BUT TO DRIVE THIS VEHICLE WITH DEFECTIVE TIRES. THERE HAVE BEEN SEVERAL DEATHS AND INJURIES DUE TO THESE DEFECTIVE TIRES AND THE NUMBER CONTINUES TO INCREASE. I RECEIVED THE FORM TO REPLACE THE TIRES ON MY OWN & GET REIMBURSED. I CAN'T AFFORD TO DO THIS, I AM A SINGLE PARENT AND MY EX DOES NOT PAY HIS REQUIRED SUPPORT. I DON'T UNDERSTAND THIS, IF THERE ARE TIRES AVAILABLE FOR ME TO PURCHASE, WHY CAN'T FIRESTONE PUT THEM ON MY VEHICLE OR SEND ME TO SOMEONE WHO HAS THEM?
VERY INTERMITTENTLY WHILE DRIIVNG AT ANY SPEED VEHICLE JUST DIES. SOMETIMES IT WILL RESTART IMMEDIATELY AND SOMETIMES IT TAKES AN HOUR BEFORE IT WILL RESTART. THIS HAS BEEN AN ONGONG PROBLEM FOR OVER A YEAR. THE DEALERSHIP HAS NO IDEA WHAT IS CAUSING THIS PROBLEM. *AK
TRUCK HAS A HISTORY OF NOT STARTING AFTER BEING TURNED OFF AND SHUTS OFF WHILE DRIVING.
BRAKES FAILED CAUSED CRASH INTO DIRT BANK,SEAT BELT FAILED CAUSED INJURIES TO FACE ARMES LEGS BACK
Official recalls
499V310001 · Structure:body:hatchback/liftgate:support Device/strut
Nov 3, 1999
VEHICLE DESCRIPTION: ON CERTAIN SPORT UTILITY VEHICLES, THE HYDRAULIC LIFT CYLINDER BRACKET WELDS COULD FRACTURE.
Consequence & remedy
Consequence: WITH A BROKEN BRACKET WELD, THERE IS A POTENTIAL FOR THE LIFTGATE BRACKET TO GRADUALLY BEND INWARD ALLOWING THE LIFT CYLINDER BALL STUD TO DISENGAGE, UNEXPECTEDLY ALLOWING THE LIFTGATE TO FALL FROM AN OPEN POSITION.
Remedy: DEALERS WILL INSTALL LIFTGATE REINFORCEMENT BRACKETS. DEPENDING UPON THE CONDITION OF THE LIFTGATE SHEET METAL IN THE AREA OF THE BRACKET, DEALERS MAY ALSO INSTALL A LARGER REINFORCEMENT.
97V083000 · Visibility:rearview Mirrors/devices
May 5, 1997
A SHORT CIRCUIT CONDITION CAN OCCUR IN THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AS A RESULT OF A SEPARATED PART OF THE CONTACT ASSEMBLY BRIDGING THE SWITCH POSITIVE BATTERY PAD AND ADJACENT CHASSIS GROUND PAD.
Consequence & remedy
Consequence: THE CURRENT CAN OVERHEAT THE PRINTED CIRCUIT BOARD AND OTHER PLASTIC AND ELASTOMERIC COMPONENTS OF THE SWITCH ASSEMBLY RESULTING IN SMOKE OR FIRE.
Remedy: DEALERS WILL INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.
96V024001 · Service Brakes, Hydraulic:power Assist:hydraulic
Feb 5, 1996
THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY CAN DEVELOP STRESS CORROSION CRACKING AFTER BEING OPERATED FOR AN EXTENDED PERIOD OF TIME IN THE SOUTHERN CALIFORNIA LOCATION.
Consequence & remedy
Consequence: IF A CRACK OCCURS, IT COULD RESULT IN ONE OR BOTH STUDS FRACTURING. THE MASTER CYLINDER COULD THEN SEPARATE FROM THE VACUUM BOOSTER, WHEN THE BRAKES ARE APPLIED, PREVENTING THE SERVICE BRAKES FROM ACTIVATING INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE POWER BRAKE VACUUM BOOSTER ASSEMBLY.
94V169001 · Parking Brake:conventional
Sep 7, 1994
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
13EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96066 · Driver Door Electrical Fire
Opened Nov 22, 1996 · Closed May 15, 1997
Status: closed (inferred from source dates) · Electrical System
THE CONTACT ASSEMBLY FOR THE REMOTE POWER MIRROR CONTROL SWITCH MAY DEVELOP A SHORT CIRCUIT BETWEEN THE SWITCH POSITIVE PAD AND CHASSIS GROUND PAD AS A RESULT OF WATER INTRUSION.EXCESS CURRENT FLOW RESULTING FROM THE SHORT CIRCUIT CONDITION MAY OVERHEAT THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AND CAUSE A FIRE IN THE DRIVER'S DOOR.FORD HAS INDICATED THAT CURRENT IN EXCESS OF 15 AMPS CAN OVERHEAT THE CIRCUIT BOARD ENOUGH TO CAUSE A FIRE.CIRCUIT PROTECTION IS PROVIDED BY A 30 AMP FUSE.FORD IS RECALLING ALL 1993-94 4-DOOR EXPLORER VEHICLES EQUIPPED WITH THE SUBJECT ELECTRONIC OPTION COMBINATION TO INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.NO 2-DOOR EXPLORER VEHICLES WERE BUILT WITH THE SUBJECT COMPONENTS.ACCORDING TO FORD, VEHICLES BUILT PRIOR TO THE RECALL PRODUCTION RANGE WERE EQUIPPED WITH LOWER CAPACITY CIRCUIT BOARDS FOR THE SUBJECT SWITCH ASSEMBLY THAT WOULD FAIL FROM AN OPEN CIRCUIT IF A SIMILAR SHORT OCCURRED.A NEW SWITCH ASSEMBLY WITH 10 AMP FUSE PROTECTION WAS INTRODUCED BEGINNING WITH THE 1995 MODEL YEAR EXPLORER.MAZDA WILL CONDUCT A PARALLEL COMPAIGN (97V-083.002) TO REMEDY THE SUBJECT CONDITION IN APPROXIMATELY 14,000 NAVAJO VEHICLES.THE NAVAJO VEHICLES WERE AVAILABLE IN ONLY THE 2-DOOR VERSION WHICH, UNLIKE THE EXPLORER VEHICLES, DID USE THE SUBJECT OPTION COMBINATION IN THAT BODY STYLE.
EA96017 · Brake System Malfunction
Opened Jul 24, 1996 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE96016 · Wheel Lockup With Antilock Brake System
Opened Feb 28, 1996 · Closed Jul 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
ODI HAS RECEIVED OND HUNDRED SEVENTY-THREE (173) CONSUMER COMPLAINTS OF ALLEGED FAILURES OR MALFUNCTIONS IN THE BRAKING SYSTEM ON CERTAIN 1993 AND 1994 FORD EXPLORERS.THESE ALLEGED FAILURES OR MALFUNCTIONS ARE REPORTED TO HAVE CAUSED THIRTY-SIX (36) ACCIDENTS RESULTING FROM VEHICLE LOSS OF DIRECTIONAL CONTROL DURING BRAKING OR FROM THE EXTENDED DISTANCE REQUIRED TO STOP THE VEHICLE DURING BRAKING.THE COMPLAINANTS REPORT THAT THE ALLEGED FAILURES OR MALFUNCTIONS OCCURRED DURING BRAKING MOSTLY ON WET OR SLIPPERY ROADS, BUT ALSO HAVE OCCURRED ON DRY ROADS.SINCE ODI OPENED THIS PE BASED ON WHEEL LOCKUP COMPLAINTS, WE HAVE RECEIVED NUMEROUS ADDITIONAL COMPLAINTS AB OUT THE EXTENDED DISTANCE REQUIRED TO STOP THE SUBJECT VEHICLES WHEN BRAKING UNDER CERTAIN ROAD AND SPEED CONDITIONS.IN RESPONSE TO ODI'S INFORMATION REQUEST (IR) CONCERNING WHEEL LOCKUP COMPLAINTS ONT HE SUBJECT VEHICLES, FORD REPORTED RECEIVING 416 REPORTS (FIELD REPORTS, OWNER COMPLAINTS, AND SUBROGATION CLAIMS) OF WHEEEL LOCKUP ON 1993 AND 1994 FORD EXPLORERS, WITH 24 ALLEGED ACCIDENTS.IN ADDITION, FORD REPORTED RECEIVING 24,916 WARRANTY CLAIMS THAT COULD RELATE TO THE ALLEGED DEFECT OF WHEEL LOCKUP DURING BRAKING ON THE SUBJECT VEHICLES.AN ENGINEERING ANALYSIS IS WARRANTED TO DETERMINE THE SCOPE OF THESE ALLEGED BRAKING SYSTEM FAILURES OR MALFUNCTIONS ON 1993 AND 1994 FORD EXPLORERS.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available