NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,207 reportsMileage unknown · Jul 20, 2001
Service Brakes, Hydraulic
LEFT FRONT BRAKE CALIPER LOCKED UP ON DISC WHEN BRAKES WERE APPLIED. THIS IS THE SECOND TIME I'V EXPERIENCED THIS WITH THIS BRAKE SYSTEM. THE FIRST TIME WAS IN 10/98 WITH ONLY 1825 MILES ON THE VEHICLE. AT THAT TIME, THE RIGHT FRONT BRAKE CALIPER LOCKED UP ON THE DISC, BURNING OUT THE PADS, DESTROYING THE DISC AND CALIPER. T…
Read full complaint
LEFT FRONT BRAKE CALIPER LOCKED UP ON DISC WHEN BRAKES WERE APPLIED. THIS IS THE SECOND TIME I'V EXPERIENCED THIS WITH THIS BRAKE SYSTEM. THE FIRST TIME WAS IN 10/98 WITH ONLY 1825 MILES ON THE VEHICLE. AT THAT TIME, THE RIGHT FRONT BRAKE CALIPER LOCKED UP ON THE DISC, BURNING OUT THE PADS, DESTROYING THE DISC AND CALIPER. THE CALIPERS SHOULD NOT BE LOCKING UP LIKE THIS! ON THE CURRENT FAILURE OF THE LEFT CALIPER, THE BRAKES HAD BEEN CHECKED JUST THAT WEEK, AND THE CALIPER SLIDE RAILS CHECKED AND LUBED, WHICH SHOULD HAVE PREVENTEED THE LOCKUP. THERE'S OBVIOUSLY SOMETHING WRONG WITH THE SYSTEM (IT'S ANTI-LOCK) TO BE EXPERIENCING THESE FAILURES ON A CAREFULLY MAINTAINED, EXTREMELY LOW MILEAGE VEHICLE.*AK
NHTSA ODI #748860
Mileage unknown · Jul 18, 2001
Electrical System
THIS VEHICLE WILL STOP RUNNING, NO SPUTTERING, JUST LOSE POWER, AT ANY SPEED, AT ANY TIME DURING OPERATION. ONCE, VEHICLE EVEN RESET THE RADIO STATIONS, AS IF THE BATTERY HAD BEEN DISCONNECTED DURING SERVICE. THERE IS NEVER AN INDICATION THAT THE VEHICLE IS GOING TO QUIT. IT THEN TAKES ABOUT 1-2 MINUTES TO START. THE ENGINE…
Read full complaint
THIS VEHICLE WILL STOP RUNNING, NO SPUTTERING, JUST LOSE POWER, AT ANY SPEED, AT ANY TIME DURING OPERATION. ONCE, VEHICLE EVEN RESET THE RADIO STATIONS, AS IF THE BATTERY HAD BEEN DISCONNECTED DURING SERVICE. THERE IS NEVER AN INDICATION THAT THE VEHICLE IS GOING TO QUIT. IT THEN TAKES ABOUT 1-2 MINUTES TO START. THE ENGINE WILL TURN OVER, BUT WILL NOT START UNTIL YOU WAIT, WITH THE KEY OFF, FOR THE PROPER AMOUNT OF TIME. THE RADIO STILL WORKS, ALL ELECTRICAL COMPONENTS STILL OPERATE. THIS HAS BEEN HAPPENING SINCE I GOT THE VEHICLE. I HAVE WRITTEN TO YOU ONCE BEFORE CONCERNING THIS SUBJECT, BUT NEVER HEARD BACK. PLEASE RESPOND TO THIS COMPLAINT. I APPRECIATE AND ANTICIPATE AN ANSWER. THANK YOU. JAMIE URQUHART. *AK
NHTSA ODI #748663
Mileage unknown · Jul 5, 2001
Power Train
SPEEDOMETER/ODOMETER INACCURATE AT SPEEDS ABOVE 40 MPH. ODOMETER RECORDS 1.4 MILES PER EVERY MILE AT HIGHWAY SPEEDS AND SPEEDOMETER SHOWS ACTUAL SPEED PLUS 10-25 MPH WITH A BOUNCING NEEDLE. MANY OTHER OWNERS SEEM TO HAVE THE SAME PROBLEM AS LOCAL DEALER MENTIONED LARGE NUMBER OF INQUIRIES FOR THE SPECIFIC PART. *AK
NHTSA ODI #747890
Mileage unknown · Jul 3, 2001
Tires
THE CONSUMER WAS SEEKING REIMBURSMENT FOR DEFECTIVE FIRESTONE ATX (SIZE P235/75R15) TIRE THAT HAD FAILED AND WAS ON RECALL (00T-005). *YH
NHTSA ODI #561879
Mileage unknown · Jul 2, 2001
Parking Brake
I HAVE RECEIVED A COPY OF A RECALL #94S91 AND THE DESCRIPTION ASSOCIATED WITH THIS RECALL IS IDENTICAL WITH THE PROBLEM I HAVE HAD WITH MY VEHICLE SINCE I PURCHASED IT USED IN 6/98. I CONTACTED THE DEALER, AND MANUFACTURER, AND I WAS TOLD MY VIN # IS NOT INCLUDED IN THIS RECALL. I ASKED WHY THE RECALL LIST MY VEHICLE YEAR ,M…
Read full complaint
I HAVE RECEIVED A COPY OF A RECALL #94S91 AND THE DESCRIPTION ASSOCIATED WITH THIS RECALL IS IDENTICAL WITH THE PROBLEM I HAVE HAD WITH MY VEHICLE SINCE I PURCHASED IT USED IN 6/98. I CONTACTED THE DEALER, AND MANUFACTURER, AND I WAS TOLD MY VIN # IS NOT INCLUDED IN THIS RECALL. I ASKED WHY THE RECALL LIST MY VEHICLE YEAR ,MAKE, & MODEL AND I HAVE THE EXACT SYMTOMS LISTED BUT I WAS BEING TOLD AGAIN IT WAS NOT INCLUDED IN THE RECALL. I WAS TOLD I WOULD NEED TO HAVE THE VEHICLE FIXED AT MY OWN EXPENSE. I DON'T FEEL LIKE I SHOULD BE FORCED TO PAY FOR THIS FIX WHEN MY VEHICLE HAS THE EXACT DEFECT LISTED AND THE EXACT YEAR, MAKE, & MODEL LISTED. I CONSTANTELY HAVE TO CHECK TO SEE IF MY PARKING BRAKE IS ENGAGED BECAUSE AT LEAST HALF THE TIME IT ISN'T BECAUSE THE PEDAL WENT TO THE FLOOR WITHOUT ENGAGING THE PARKING BRAKE. I WOULD APPRECIATE A RESPONSE BACK AND ANY HELP YOU MAY BE ABLE TO OFFER IN THIS MATTER. THANKS YOU VERY MUCH. V. RON DELITERIS.*AK
NHTSA ODI #747656
Mileage unknown · Jun 28, 2001
Equipment
CABLE THAT HOLDS SPARE TIRE UP SNAPPED, AND CONSUMER'S SPARE TIRE BECAME DISENGAGED WHILE DRIVING VEHICLE. CONSUMER FEELS LUCKY THAT THERE WERE NO INJURIES. CONSUMER HAS CONTACTED DEALER. PLEASE PROVIDE ANY FURTHER INFOMATION.*AK
NHTSA ODI #891609
Mileage unknown · Jun 27, 2001
Service Brakes, Hydraulic
FRONT BRAKE PADS BROKE IN HALF ON THREE SEPARATE OCCASIONS. EACH TIME DEALER INSPECTED VEHICLE AND REPLACED PADS. PLEASE PROVIDE ADDITIONAL INFORMATION. *AK
NHTSA ODI #891421
Mileage unknown · Jun 25, 2001
Seats
DRIVER'S SEAT METAL IS FATIGUE AND TORE, CAUSING DRIVER'S SIDE SEAT TO WOBBLE AND SHAKE. CONSUMER FEELS THERE COULD BE GREAT BODILY HARM. *AK
NHTSA ODI #891160
Mileage unknown · Jun 24, 2001
Vehicle Speed Control
NOTICED THE PEDAL STICKING SEVERAL YEARS AGO, HOWEVER I THOUGHT IT WAS A PROBLEM UNIQUE TO MY CAR AND IT WASN'T SO BAD THAT I NEEDED TO SPEND A LARGE SUM OF MONEY TO FIX IT. HOWEVER, A CO-WORKER TOLD ME THAT HE HAD RECEIVED A RECALL NOTICE COVERING 97-98 EXPLORERS WITH THE SAME PROBLEM. AFTER CONTACTING THE FORD CUSTOMER RELAT…
Read full complaint
NOTICED THE PEDAL STICKING SEVERAL YEARS AGO, HOWEVER I THOUGHT IT WAS A PROBLEM UNIQUE TO MY CAR AND IT WASN'T SO BAD THAT I NEEDED TO SPEND A LARGE SUM OF MONEY TO FIX IT. HOWEVER, A CO-WORKER TOLD ME THAT HE HAD RECEIVED A RECALL NOTICE COVERING 97-98 EXPLORERS WITH THE SAME PROBLEM. AFTER CONTACTING THE FORD CUSTOMER RELATIONSHIP CENTER AND WAS BASICALLY TOLD NOTHING COULD BE DONE BECAUSE MY MODEL YEAR WASN'T LISTED IN THE RECALL. I FEEL THAT THIS PROBLEM ALSO AFFECTS MY MODEL YEAR AND THAT THE RECALL SHOULD BER EXTENDED TO COVER MY AUTO ALSO. *AK
NHTSA ODI #747317
Mileage unknown · Jun 20, 2001
Power TrainVehicle Speed Control
WHILE DRIVING 65 KM THE RPMS WILL GO UP IN RED, AND NOT GO BACK DOWN UNTIL CONSUMER SLOWS DOWN TO ABOUT 30 KM. THEN, SHE CAN FEEL TRANSMISSION KICK IN, AND RPMS GO DOWN. THIS HAS HAPPENED 3 TIMES . MECHANIC STATED TRANSMISSION NEEDED TO BE REBUILT AND UPGRADED. CONSUMER CALLED FORD, AND WAS TOLD THERE WERE A LOT OF COMPLA…
Read full complaint
WHILE DRIVING 65 KM THE RPMS WILL GO UP IN RED, AND NOT GO BACK DOWN UNTIL CONSUMER SLOWS DOWN TO ABOUT 30 KM. THEN, SHE CAN FEEL TRANSMISSION KICK IN, AND RPMS GO DOWN. THIS HAS HAPPENED 3 TIMES . MECHANIC STATED TRANSMISSION NEEDED TO BE REBUILT AND UPGRADED. CONSUMER CALLED FORD, AND WAS TOLD THERE WERE A LOT OF COMPLAINTS ON EXPLORER'S TRANSMISSIONS WITH THIS PROBLEM. *AK
NHTSA ODI #890812
NHTSA investigations
13EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96066 · Driver Door Electrical Fire
Opened Nov 22, 1996 · Closed May 15, 1997
Status: closed (inferred from source dates) · Electrical System
THE CONTACT ASSEMBLY FOR THE REMOTE POWER MIRROR CONTROL SWITCH MAY DEVELOP A SHORT CIRCUIT BETWEEN THE SWITCH POSITIVE PAD AND CHASSIS GROUND PAD AS A RESULT OF WATER INTRUSION.EXCESS CURRENT FLOW RESULTING FROM THE SHORT CIRCUIT CONDITION MAY OVERHEAT THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AND CAUSE A FIRE IN THE DRIVER'S DOOR.FORD HAS INDICATED THAT CURRENT IN EXCESS OF 15 AMPS CAN OVERHEAT THE CIRCUIT BOARD ENOUGH TO CAUSE A FIRE.CIRCUIT PROTECTION IS PROVIDED BY A 30 AMP FUSE.FORD IS RECALLING ALL 1993-94 4-DOOR EXPLORER VEHICLES EQUIPPED WITH THE SUBJECT ELECTRONIC OPTION COMBINATION TO INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.NO 2-DOOR EXPLORER VEHICLES WERE BUILT WITH THE SUBJECT COMPONENTS.ACCORDING TO FORD, VEHICLES BUILT PRIOR TO THE RECALL PRODUCTION RANGE WERE EQUIPPED WITH LOWER CAPACITY CIRCUIT BOARDS FOR THE SUBJECT SWITCH ASSEMBLY THAT WOULD FAIL FROM AN OPEN CIRCUIT IF A SIMILAR SHORT OCCURRED.A NEW SWITCH ASSEMBLY WITH 10 AMP FUSE PROTECTION WAS INTRODUCED BEGINNING WITH THE 1995 MODEL YEAR EXPLORER.MAZDA WILL CONDUCT A PARALLEL COMPAIGN (97V-083.002) TO REMEDY THE SUBJECT CONDITION IN APPROXIMATELY 14,000 NAVAJO VEHICLES.THE NAVAJO VEHICLES WERE AVAILABLE IN ONLY THE 2-DOOR VERSION WHICH, UNLIKE THE EXPLORER VEHICLES, DID USE THE SUBJECT OPTION COMBINATION IN THAT BODY STYLE.
EA96017 · Brake System Malfunction
Opened Jul 24, 1996 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE96016 · Wheel Lockup With Antilock Brake System
Opened Feb 28, 1996 · Closed Jul 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
ODI HAS RECEIVED OND HUNDRED SEVENTY-THREE (173) CONSUMER COMPLAINTS OF ALLEGED FAILURES OR MALFUNCTIONS IN THE BRAKING SYSTEM ON CERTAIN 1993 AND 1994 FORD EXPLORERS.THESE ALLEGED FAILURES OR MALFUNCTIONS ARE REPORTED TO HAVE CAUSED THIRTY-SIX (36) ACCIDENTS RESULTING FROM VEHICLE LOSS OF DIRECTIONAL CONTROL DURING BRAKING OR FROM THE EXTENDED DISTANCE REQUIRED TO STOP THE VEHICLE DURING BRAKING.THE COMPLAINANTS REPORT THAT THE ALLEGED FAILURES OR MALFUNCTIONS OCCURRED DURING BRAKING MOSTLY ON WET OR SLIPPERY ROADS, BUT ALSO HAVE OCCURRED ON DRY ROADS.SINCE ODI OPENED THIS PE BASED ON WHEEL LOCKUP COMPLAINTS, WE HAVE RECEIVED NUMEROUS ADDITIONAL COMPLAINTS AB OUT THE EXTENDED DISTANCE REQUIRED TO STOP THE SUBJECT VEHICLES WHEN BRAKING UNDER CERTAIN ROAD AND SPEED CONDITIONS.IN RESPONSE TO ODI'S INFORMATION REQUEST (IR) CONCERNING WHEEL LOCKUP COMPLAINTS ONT HE SUBJECT VEHICLES, FORD REPORTED RECEIVING 416 REPORTS (FIELD REPORTS, OWNER COMPLAINTS, AND SUBROGATION CLAIMS) OF WHEEEL LOCKUP ON 1993 AND 1994 FORD EXPLORERS, WITH 24 ALLEGED ACCIDENTS.IN ADDITION, FORD REPORTED RECEIVING 24,916 WARRANTY CLAIMS THAT COULD RELATE TO THE ALLEGED DEFECT OF WHEEL LOCKUP DURING BRAKING ON THE SUBJECT VEHICLES.AN ENGINEERING ANALYSIS IS WARRANTED TO DETERMINE THE SCOPE OF THESE ALLEGED BRAKING SYSTEM FAILURES OR MALFUNCTIONS ON 1993 AND 1994 FORD EXPLORERS.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Illustration