NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,207 reportsMileage unknown · Sep 15, 2002
Power Train
THE FIRST TIME NOTICED THIS PROBLEM I WAS TRAVELING ABOUT 65MPH, I GLANCED AT THE SPEEDOMETER WHICH SHOWED 90MPH! MY FIRST INSTINCT WAS TO LIFT OFF THE GAS PEDAL AND HIT THE BRAKE! AS I LIFTED OFF ON THE GAS, I REALIZED THE THE TRUCK WAS NOT GOING THAT FAST. SO I CONTINUED ON MY TRIP AT A SPEED THAT "FELT RIGHT" BECAUSE THE SP…
Read full complaint
THE FIRST TIME NOTICED THIS PROBLEM I WAS TRAVELING ABOUT 65MPH, I GLANCED AT THE SPEEDOMETER WHICH SHOWED 90MPH! MY FIRST INSTINCT WAS TO LIFT OFF THE GAS PEDAL AND HIT THE BRAKE! AS I LIFTED OFF ON THE GAS, I REALIZED THE THE TRUCK WAS NOT GOING THAT FAST. SO I CONTINUED ON MY TRIP AT A SPEED THAT "FELT RIGHT" BECAUSE THE SPEEDOMETER WAS MORE A DISTRACTION THAN A HELP. THE SPEEDOMETER KEPT DOING THIS FROM TIME TO TIME BUT ONLY AT FREEWAY SPEEDS. THEN AFTER A SHORT TIME IT WOULD ALWAYS ADD ABOUT 30MPH TO ANY SPEED OVER 35MPH. I CHECKED WITH FORD TO FIND OUT IF THIS HAD BEEN A PROBLEM OR SUBJECT TO ANY RECALLS AND WAS TOLD NO. AT THAT TIME HAD THE SPEEDOMETER REPAIRED AT AN INDEPENDENT SHOP (SAN DIEGO SPEEDO TACH INC. 619-235-0314). THEY TOLD ME IT WAS A COMMON PROBLEM ON FORD EXPLORERS AND FORD RANGERS AND THAT THEY REPAIRED SEVERAL A WEEK! NLM
NHTSA ODI #767209
Mileage unknown · Sep 5, 2002
Equipment
THE SPARE TIRE IS SUPPORTED UNDER THE REAR OF THE VEHICLE BY A STEEL CABLE SUPPORT SYSTEM. I WAS TRAVELING ON A FREEWAY AND HIT A BUMP. THE CABLE SUPPORTING THE SPARE TIRE BROKE. APPARENTLY THE CABLE HAD RUSTED AND BECAME WEAK. THE TIRE DROPPED ONTO THE ROAD SURFACE. THERE WAS A NUMBER OF VEHICLES DIRECTELY BEHIND ME AT THE T…
Read full complaint
THE SPARE TIRE IS SUPPORTED UNDER THE REAR OF THE VEHICLE BY A STEEL CABLE SUPPORT SYSTEM. I WAS TRAVELING ON A FREEWAY AND HIT A BUMP. THE CABLE SUPPORTING THE SPARE TIRE BROKE. APPARENTLY THE CABLE HAD RUSTED AND BECAME WEAK. THE TIRE DROPPED ONTO THE ROAD SURFACE. THERE WAS A NUMBER OF VEHICLES DIRECTELY BEHIND ME AT THE TIME. THE TIRE BOUNCED APPROXIMATELY 3 - 4 FEET IN THE AIR IN FRONT THE VEHICLE DIRECTLY BEHIND MY VEHICLE. LUCKLY ALL OF THE OTHER VEHICLES MISSED THE TIRE. THE TIRE ROLLED OFF OF THE ROAD AND INTO THE DITCH. AFTER RETURNING TO THE LOCATION OF WHERE THE TIRE DROPPED OFF THE VEHICLE, I SEARCHED THE ROAD AND DITCH, AND WAS UNABLE TO FIND THE SPARE TIRE. I BELIEVE THIS IS A SERIOUS PROBLEM AND CAN CAUSE VEHICLE DAMAGE AND PERSONAL INJURIES. AFTER REPORTING THE PROBLEM, AND ASKING ABOUT REPLACEMENT PARTS AT A LOCAL FORD SERVICE DEPARTMENT, I WAS TOLD THAT I WAS THE FIRST ONE TO INDICATE THAT THIS WAS A PROBLEM. HOWEVER WHEN BUYING A NEW SPARE TIRE AND RIM FROM A LOCAL TIRE SHOP, I WAS TOLD THAT THIS WAS A COMMON PROBLEM OF FORD EXPLORERS AND PICKUP TRUCKS.*AK
NHTSA ODI #766754
Mileage unknown · Sep 3, 2002
Electrical System
IGNITION SWITCH IS INOPERATIVE, IT WILL LOCK UP WHILE DRIVING OR DRIVER WILL NOT BE ABLE TO START VEHICLE.*AK
NHTSA ODI #8017769
Mileage unknown · Aug 26, 2002
Service Brakes, Hydraulic
WHILE BRAKING PEDAL FELT SPONGY AND STEERING WHEEL TURNED TO LEFT, THEN LOCKED UP. VEHICLE IS AT DEALERSHIP AT THIS TIME. PLEASE PROVIDE ADDITIONAL INFORMATION.*AK
NHTSA ODI #8017192
Mileage unknown · Aug 24, 2002
Service Brakes, HydraulicTires
THE FRONT TIRES HAVE SLITS IN THE SIDEWALLS OF THE TIRES. WHEN WE PURCHASED THE VEHICLE WE HAD TEST DROVE IT AND WHEN WE GOT IT ON THE HIGHWAY WE NOTICED A SHAKING IN THE FRONT END. WE TOLD THE DEALER OF THIS PROBLEM AND THEY SAID THEY WOULD CHECK INTO IT. THEY SAID THEY HAD THE PROBLEM FIXED. THE TIRES LOOKED BRAND NEW WHEN THE…
Read full complaint
THE FRONT TIRES HAVE SLITS IN THE SIDEWALLS OF THE TIRES. WHEN WE PURCHASED THE VEHICLE WE HAD TEST DROVE IT AND WHEN WE GOT IT ON THE HIGHWAY WE NOTICED A SHAKING IN THE FRONT END. WE TOLD THE DEALER OF THIS PROBLEM AND THEY SAID THEY WOULD CHECK INTO IT. THEY SAID THEY HAD THE PROBLEM FIXED. THE TIRES LOOKED BRAND NEW WHEN THE VEHICLE WAS PURCHASED. WE CONTINUED WITH THE PURCHASE AND LATER WHEN THE VEHICLE WAS TAKEN ON THE HIGHWAY IT DONE THE SAME THING. THE DEALER SAID THERE WAS NO PROBLEM. THE ONLY TIME THE VEHICLE WOULD SHAKE WAS WHEN YOU WERE DRIVING BETWEEN 55 AND 65 MPH OTHER THAN THAT IT DROVE FINE. THEN MY DRIVER SIDE TIRE DEVELOPED A LEAK THAT GOT PROGRESSIVELY WORSE UNTIL I WOULD HAVE TO PUT AIR IN IT EVERY DAY. MY HUSBAND PUT SOME OTHER TIRES ON AND WHEN THE TIRES WERE REMOVED ONE OF THEM HAD 6 WEIGHTS ON IT. THE 2 FRONT TIRES BOTH HAD LARGE CRACKS. ONCE THE NEWER TIRES WERE PUT ON THE SHAKING ON THE HIGHWAY HAS STOPPED. I SEE SO MUCH ABOUT THE BAD TIRES ON THE FORD EXPLORER, THAT IT LEADS ME TO WONDER, IS IT THE TIRES OR IS IT THE EXPLORER? I DO NOT SEE HOW THERE COULD BE SO MANY DIFFERENT TIRES THAT WOULD HAVE DEFECTS. I AM LEAD TO BELIEVE THE PROBLEM LIES WITH FORD AND NOT WITH FIRESTONE OR THE OTHER TIRE COMPANIES WHO HAVE PAID TO REPLACE THESE TIRES. THE TRED ON THE TIRES IS STILL GOOD BUT THEY ARE NOT USABLE BECAUSE OF THE CRACKS.*AK
NHTSA ODI #766157
Mileage unknown · Aug 19, 2002
Engine And Engine Cooling
WHILE TRAVELING ON HIGHWAY AND WITHOUT PRIOR WARNING VEHICLE WILL SHUT DOWN . DEALERSHIP IS AWARE OF PROBLEM.*AK
NHTSA ODI #8016652
Mileage unknown · Aug 16, 2002
Seat Belts
BOTH REAR OUTBOARD SEATBELT RETRACTORS NO LONGER WORK. VEHICLE HAS NOT BEEN EXAMINED BY DEALER.*AK
NHTSA ODI #8016524
Mileage unknown · Jul 30, 2002
Electrical SystemFuel System, GasolineService Brakes, HydraulicCrashInjury
TEXAS "SALVAGE TRUCK" HOW DID IT GET "RESOLD" IN ARIZONA!. NO SAFETY DEFECT LISTED. *AK
NHTSA ODI #764922
Mileage unknown · Jul 22, 2002
Tires
DUELER APT, REPLACEMENT EQUIPMENT ON A 1994 ,FORD, EXPLORER WITH 99000 MILES. TREAD SEPARATION ON REAR DRIVER SIDE TIRE AT 75 MPH.*AK THE TREAD OF THE TIRE SEPARATED FROM THE TIRE AND WRAPPED AROUND THE AXLE, LOCKING THE REAR WHEELS AND CAUSED CONSUMERS VEHICLE TO SPIN OUT OF CONTROL. THE TIRES HAD BEEN CHECKED TWENTY MINUTES…
Read full complaint
DUELER APT, REPLACEMENT EQUIPMENT ON A 1994 ,FORD, EXPLORER WITH 99000 MILES. TREAD SEPARATION ON REAR DRIVER SIDE TIRE AT 75 MPH.*AK THE TREAD OF THE TIRE SEPARATED FROM THE TIRE AND WRAPPED AROUND THE AXLE, LOCKING THE REAR WHEELS AND CAUSED CONSUMERS VEHICLE TO SPIN OUT OF CONTROL. THE TIRES HAD BEEN CHECKED TWENTY MINUTES PRIOR TO DEPARTURE FOR PROPER PRESSURE. THE MECHANIC INFORMED CONSUMER THAT THE TREADS WERE FINE. CONSUMER TRIED TALKING TO FIRESTONE/BRIDGESTONE DEALER. IT WAS EXPLAINED TO CONSUMER THAT THE PARTICULAR TIRE WAS MADE EXCLUSIVELY FOR SEARS AND THEY COULD NOT DEAL WITH IT. *JG
NHTSA ODI #8014406
Mileage unknown · Jul 16, 2002
Structure
STRUTS THAT HOLD TRUNK OPEN BROKE, AND HATCH DOOR CAN STAY OPEN. CONTACTED DEALER, AND DEALER WAS NOT WILLING TO DO ANYTHING. *AK
NHTSA ODI #8014039
NHTSA investigations
13EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96066 · Driver Door Electrical Fire
Opened Nov 22, 1996 · Closed May 15, 1997
Status: closed (inferred from source dates) · Electrical System
THE CONTACT ASSEMBLY FOR THE REMOTE POWER MIRROR CONTROL SWITCH MAY DEVELOP A SHORT CIRCUIT BETWEEN THE SWITCH POSITIVE PAD AND CHASSIS GROUND PAD AS A RESULT OF WATER INTRUSION.EXCESS CURRENT FLOW RESULTING FROM THE SHORT CIRCUIT CONDITION MAY OVERHEAT THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AND CAUSE A FIRE IN THE DRIVER'S DOOR.FORD HAS INDICATED THAT CURRENT IN EXCESS OF 15 AMPS CAN OVERHEAT THE CIRCUIT BOARD ENOUGH TO CAUSE A FIRE.CIRCUIT PROTECTION IS PROVIDED BY A 30 AMP FUSE.FORD IS RECALLING ALL 1993-94 4-DOOR EXPLORER VEHICLES EQUIPPED WITH THE SUBJECT ELECTRONIC OPTION COMBINATION TO INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.NO 2-DOOR EXPLORER VEHICLES WERE BUILT WITH THE SUBJECT COMPONENTS.ACCORDING TO FORD, VEHICLES BUILT PRIOR TO THE RECALL PRODUCTION RANGE WERE EQUIPPED WITH LOWER CAPACITY CIRCUIT BOARDS FOR THE SUBJECT SWITCH ASSEMBLY THAT WOULD FAIL FROM AN OPEN CIRCUIT IF A SIMILAR SHORT OCCURRED.A NEW SWITCH ASSEMBLY WITH 10 AMP FUSE PROTECTION WAS INTRODUCED BEGINNING WITH THE 1995 MODEL YEAR EXPLORER.MAZDA WILL CONDUCT A PARALLEL COMPAIGN (97V-083.002) TO REMEDY THE SUBJECT CONDITION IN APPROXIMATELY 14,000 NAVAJO VEHICLES.THE NAVAJO VEHICLES WERE AVAILABLE IN ONLY THE 2-DOOR VERSION WHICH, UNLIKE THE EXPLORER VEHICLES, DID USE THE SUBJECT OPTION COMBINATION IN THAT BODY STYLE.
EA96017 · Brake System Malfunction
Opened Jul 24, 1996 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE96016 · Wheel Lockup With Antilock Brake System
Opened Feb 28, 1996 · Closed Jul 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
ODI HAS RECEIVED OND HUNDRED SEVENTY-THREE (173) CONSUMER COMPLAINTS OF ALLEGED FAILURES OR MALFUNCTIONS IN THE BRAKING SYSTEM ON CERTAIN 1993 AND 1994 FORD EXPLORERS.THESE ALLEGED FAILURES OR MALFUNCTIONS ARE REPORTED TO HAVE CAUSED THIRTY-SIX (36) ACCIDENTS RESULTING FROM VEHICLE LOSS OF DIRECTIONAL CONTROL DURING BRAKING OR FROM THE EXTENDED DISTANCE REQUIRED TO STOP THE VEHICLE DURING BRAKING.THE COMPLAINANTS REPORT THAT THE ALLEGED FAILURES OR MALFUNCTIONS OCCURRED DURING BRAKING MOSTLY ON WET OR SLIPPERY ROADS, BUT ALSO HAVE OCCURRED ON DRY ROADS.SINCE ODI OPENED THIS PE BASED ON WHEEL LOCKUP COMPLAINTS, WE HAVE RECEIVED NUMEROUS ADDITIONAL COMPLAINTS AB OUT THE EXTENDED DISTANCE REQUIRED TO STOP THE SUBJECT VEHICLES WHEN BRAKING UNDER CERTAIN ROAD AND SPEED CONDITIONS.IN RESPONSE TO ODI'S INFORMATION REQUEST (IR) CONCERNING WHEEL LOCKUP COMPLAINTS ONT HE SUBJECT VEHICLES, FORD REPORTED RECEIVING 416 REPORTS (FIELD REPORTS, OWNER COMPLAINTS, AND SUBROGATION CLAIMS) OF WHEEEL LOCKUP ON 1993 AND 1994 FORD EXPLORERS, WITH 24 ALLEGED ACCIDENTS.IN ADDITION, FORD REPORTED RECEIVING 24,916 WARRANTY CLAIMS THAT COULD RELATE TO THE ALLEGED DEFECT OF WHEEL LOCKUP DURING BRAKING ON THE SUBJECT VEHICLES.AN ENGINEERING ANALYSIS IS WARRANTED TO DETERMINE THE SCOPE OF THESE ALLEGED BRAKING SYSTEM FAILURES OR MALFUNCTIONS ON 1993 AND 1994 FORD EXPLORERS.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Illustration