NHTSA owner reports · September 18, 2026 snapshot.
Tires complaints
331 reportsClear category filterMileage unknown · May 7, 2001
Tires
CONSUMER HAS REPLACED ALL FOUR FIRESTONE ATX RADIAL TIRES DUE TO SIDEWALL FAILURES ON TWO OCCASIONS, CONSUMER STATES TIRES FAILED DUE TO A MANUFACTURER'S DEFECT, CONSUMER REQUESTED REIMBURSEMENT FOR ALL FOUR TIRES INCLUDING THE SPARE TIRE BUT WAS DENIED BECAUSE REPLACEMENT TIRES WERE PURCHASED BEFORE THE RECALL ANNOUNCEMENT. …
Read full complaint
CONSUMER HAS REPLACED ALL FOUR FIRESTONE ATX RADIAL TIRES DUE TO SIDEWALL FAILURES ON TWO OCCASIONS, CONSUMER STATES TIRES FAILED DUE TO A MANUFACTURER'S DEFECT, CONSUMER REQUESTED REIMBURSEMENT FOR ALL FOUR TIRES INCLUDING THE SPARE TIRE BUT WAS DENIED BECAUSE REPLACEMENT TIRES WERE PURCHASED BEFORE THE RECALL ANNOUNCEMENT. *JB
NHTSA ODI #561084
Mileage unknown · May 3, 2001
Tires
PRIOR TO RECALL NOTIFICATION CONSUMER REPLACED ALL 5 FIRETSTONE (P235/75) TIRES BECAUSE HE NOTICED TIRES WERE WEARING DOWN AND NO LONGER FELT SAFE DRIVING ON THEM, CONSUMER IS REQUESTING REIMBURSEMNT. *JB
NHTSA ODI #561053
Mileage unknown · May 3, 2001
Tires
PRIOR TO RECALL NOTIFICATION CONSUMER HAS REPLACED TWO FIRESTONE ATX II (235/75R15) TIRES BECAUSE THEY WERE VIBRATING THE VEHICLE, CONSUMER SENT IN ALL NECESSARY PAPERWORK FOR REIMBURSEMENT, CONSUMER WAS ADVISED BY FIRESTONE THAT HE DID NOT FOLLOW PROPER PROCEDURE OF RECALL HANDOUT. *JB
NHTSA ODI #561033
Mileage unknown · Apr 20, 2001
Tires
CONSUMER STATES ALL FOUR FIRESTONE ATX TIRES WERE REPLACED DUE TO HIGHLY IRREGULAR WEAR PATTERN, A YEAR LATER CONSUMER FOUND OUT THAT THE TIRES THAT WERE REPLACED WERE A PART OF THE RECALL, MANUFACTURER IS NOT WILLING TO REIMBURSE CONSUMER FOR THE TIRES BECUASE THEY WERE PURCHASED BEFORE THE RECALL ANNOUNCEMENT, HOWEVER CONSUMER…
Read full complaint
CONSUMER STATES ALL FOUR FIRESTONE ATX TIRES WERE REPLACED DUE TO HIGHLY IRREGULAR WEAR PATTERN, A YEAR LATER CONSUMER FOUND OUT THAT THE TIRES THAT WERE REPLACED WERE A PART OF THE RECALL, MANUFACTURER IS NOT WILLING TO REIMBURSE CONSUMER FOR THE TIRES BECUASE THEY WERE PURCHASED BEFORE THE RECALL ANNOUNCEMENT, HOWEVER CONSUMER WAS ABLE TO GET THE SPARE TIRE REPLACED. *JB
NHTSA ODI #560865
Mileage unknown · Apr 17, 2001
Tires
THERE WERE NEW FIRESTONE TIRES ON MY EXPLORER WHEN I PURCHASED IT IN 1998. I HAD TO REPLACE THE TIRES JUST BEFORE A TRIP BECAUSE IT WAS NOTICED THAT THE TREAD HAD SEPARATED TO THE DEGREE THAT TWO OF THE TIRES WOULD NOT LONGER HOLD AIR! I REPLACED THEM WITH ANOTHER BRAND OF TIRE - THEN A FEW MONTHS LATER FIRESTONE RECALLED THE T…
Read full complaint
THERE WERE NEW FIRESTONE TIRES ON MY EXPLORER WHEN I PURCHASED IT IN 1998. I HAD TO REPLACE THE TIRES JUST BEFORE A TRIP BECAUSE IT WAS NOTICED THAT THE TREAD HAD SEPARATED TO THE DEGREE THAT TWO OF THE TIRES WOULD NOT LONGER HOLD AIR! I REPLACED THEM WITH ANOTHER BRAND OF TIRE - THEN A FEW MONTHS LATER FIRESTONE RECALLED THE TIRES I HAD (I STILL HAVE THE SPARE). I APPLIED FOR REIMBURSEMENT, HOWEVER THEY REFUSE TO PAY BECAUSE I GOT THEM REPLACED WITH A COMPETITORS TIRE AND PRIOR TO THE RECALL. THE VERY REAL ISSUE HERE IS HAD I NOT NOTICED THE PROBLEM WITH THE TIRES PRIOR TO MY CAR TRIP THINGS COULD HAVE TURNED OUT VERY DIFFERENTLY FOR ME AND MY FAMILY. I HAVE DOCUMENTATION FROM FIRESTONE, FORD, THE DEALER I PURCHASED THE CAR FROM AND THE THE DEALER WHERE I REPLACED THE FIRESTONE TIRES - BUT FIRESTONE STILL REFUSES TO ACKNOWLEDGE THAT I HAD THE FAULTY TIRES OR REIMBURSE ME FOR THEM BECAUSE THEY WERE REPLACED PRIOR TO THE RECALL. I WOULD URGE THAT THE RECALL BE WIDENED BECAUSE I DON'T THINK I CAN BE THE ONLY PERSON THAT THIS HAS HAPPENED TO. THANK YOU. *AK (TIRESIZE: PT23575R15)( DOT NUMBER: TIRE SIZE: PT23575R15 )
NHTSA ODI #744173
Mileage unknown · Apr 7, 2001
Tires
WHEN I PURCHASED MY NEW 1994 FORD EXPLORER, IT WASN'T LONG BEFORE I BEGAN TO NOTICE THAT THE FRONT END SHOOK. NO ELSE BUT ME DROVE THE EXPLORER SO I CHALK IT UP TO DRIVING A UTILITY VEHICLE. I CONTINUED TO DRIVE WITHOUT ANY UNDUE STRESS, HOWEVER, I BEGAN TO NOTICE THAT ALL THE TIRES BEGAN TO SEPARATE. I COULD SEE THE CHROME STEE…
Read full complaint
WHEN I PURCHASED MY NEW 1994 FORD EXPLORER, IT WASN'T LONG BEFORE I BEGAN TO NOTICE THAT THE FRONT END SHOOK. NO ELSE BUT ME DROVE THE EXPLORER SO I CHALK IT UP TO DRIVING A UTILITY VEHICLE. I CONTINUED TO DRIVE WITHOUT ANY UNDUE STRESS, HOWEVER, I BEGAN TO NOTICE THAT ALL THE TIRES BEGAN TO SEPARATE. I COULD SEE THE CHROME STEEL BELT BETWEEN THE TREAT AND THE SIDE WALL. I USED TO APPLY ARMORAL TO THE TIRES SO THOUGHT MAYBE THE SUN WAS CRACKING THE TIRES. AS TIME WHEN ON, THE FRONT CONTINUE TO SHAKE AS WELL AS THE INTERIOR OF MY VEH. FOR THE MOST PART I WOULD DRIVE FROM THE CENTRAL VALLEY OF CA. TO LOS ANGELES TO SEE MY FAMILY OTHERWISE MY EXPLORER GOT LITTLE MILES LOCALLY. ALL OF THE TIRES HAD TO BE EVENTUALLY REPLACED (MY COST), BUT THE FIRST TIRE BEGAN TO SEPARATE AND I TOOK IT TO REPLACE IT AT A FIRESTONE DEALER, "TIRE WORLD" IN MERCED CA. I TOLD TIRE WORLD THAT THE FRONT END WAS SHAKING AND THAT THE TIRE BEGAN TO SEPARATE. TIRE WORLD TOLD ME THAT THE ONE TIRE NEEDED TO BE REPLACED AND THAT IT COULD NOT BE PRORATED BECAUSE OF THE UNEVEN WEAR. THEY ALSO TOLD ME THAT THE FRONT END NEEDED NEW CAMS. I REPLACED THE TIRE AND HAD THE EXPLORER FRONT AND REAR ALIGNED. THE FRONT END CONTINUED TO SHAKE BUT THERE WAS NO UNUSAL WEAR TO THE NEW FRONT TIRE. HOWEVER, THE OTHER FRONT TIRE ALSO BEGAN TO SEPARATE DURING A TRIP FROM CHOWCHILLA TO LOS ANGELES. WHILE PASSING THROUGH BAKERSFIELD,CA, A LARGE PORTION OF THE OLDER FRONT TIRE FELL OFF. I HAD TO IMMEDIATELY PULL OFF THE FREEWAY AND PUT ON THE SPARE TIRE (SAME) I CONTINUED MY JOURNEY AND REPLACED THE DAMAGED/SEPARATED TIRE AT FIRESTONE DEALER, "TIRE STATION" IN WHITTIER. I REPLACED THE ONE TIRE. I KNOW HAD TWO NEW FRONT TIRES, HOWEVER THE FRONT END CONT. TO SHAKE BECAUSE THE INTERIOR CONSOLE WOULD SHAKE AS I DROVE DOWN THE ROAD. OVER TIME, THE REAR TWO TIRES WERE MORE PRONOUNCED AND BEGAN TO SEPARATE. ON 11/12/00 I RETURNED TO "TIRE WORLD" AND HAD THE OTHER TWO TIRES REPLACED. (TIRESIZE: P235/75R15)
NHTSA ODI #743678
Mileage unknown · Apr 6, 2001
Tires
PE00 048; CONSUMER WAS TRAVELING ABOUT 80MPH ON HIGHWAY AND LOST CONTROL OF VEHICLE, LANDING ON SHOULDER. NOTICED THAT THE REAR TIRE ON PASSENGER'S SIDE TREAD SEPARATED FROM VEHICLE. GOODYEAR TIRE. THERE WERE NO INJURIES.*AK
NHTSA ODI #885333
Mileage unknown · Mar 29, 2001
Tires
PRIOR TO RECALL NOTIFICATION, CONSUMER EXPERIENCED TIRE SEPARATION AND IS REQUESTING REIMBURSEMENT. *JB
NHTSA ODI #560953
Mileage unknown · Mar 26, 2001
Tires
WHILE DRIVING 65MPH HAD A BLOWOUT ON RIGHT FRONT TIRE. HAD HEARD A FLAPPING SOUND, AND THEN TIRE WENT FLAT. HAD PULLED OVER AND NOTICED TREAD HAD SEPARATED IN PIECES. REPLACED TIRE WITH ANOTHER. 1994, FORD, EXPLORER. HAD FILED A CLAIM FOR REIMBURSEMENT & HAVE NOT RECEIVED IT. *AK FIRESTONE ATX TIRE, P235/75R15. *SLC
NHTSA ODI #884161
Mileage unknown · Mar 22, 2001
Tires
THE RIGHT REAR TIRE BLEWOUT PRIOR TO RECALL NOTICFICATION , AFTER THE BLOWOUT THE CONSUMER REPLACED ALL FOUR FIRESTONE TIRES, THE MANUFACTURER IS REFUSING THE REIMBURSEMENT AMOUNT OF THE NEW TIRES BECAUSE THEY WERE PURCHASED PRIOR TO JANUARY 2000. NLM
NHTSA ODI #560471
NHTSA investigations
13EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96066 · Driver Door Electrical Fire
Opened Nov 22, 1996 · Closed May 15, 1997
Status: closed (inferred from source dates) · Electrical System
THE CONTACT ASSEMBLY FOR THE REMOTE POWER MIRROR CONTROL SWITCH MAY DEVELOP A SHORT CIRCUIT BETWEEN THE SWITCH POSITIVE PAD AND CHASSIS GROUND PAD AS A RESULT OF WATER INTRUSION.EXCESS CURRENT FLOW RESULTING FROM THE SHORT CIRCUIT CONDITION MAY OVERHEAT THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AND CAUSE A FIRE IN THE DRIVER'S DOOR.FORD HAS INDICATED THAT CURRENT IN EXCESS OF 15 AMPS CAN OVERHEAT THE CIRCUIT BOARD ENOUGH TO CAUSE A FIRE.CIRCUIT PROTECTION IS PROVIDED BY A 30 AMP FUSE.FORD IS RECALLING ALL 1993-94 4-DOOR EXPLORER VEHICLES EQUIPPED WITH THE SUBJECT ELECTRONIC OPTION COMBINATION TO INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.NO 2-DOOR EXPLORER VEHICLES WERE BUILT WITH THE SUBJECT COMPONENTS.ACCORDING TO FORD, VEHICLES BUILT PRIOR TO THE RECALL PRODUCTION RANGE WERE EQUIPPED WITH LOWER CAPACITY CIRCUIT BOARDS FOR THE SUBJECT SWITCH ASSEMBLY THAT WOULD FAIL FROM AN OPEN CIRCUIT IF A SIMILAR SHORT OCCURRED.A NEW SWITCH ASSEMBLY WITH 10 AMP FUSE PROTECTION WAS INTRODUCED BEGINNING WITH THE 1995 MODEL YEAR EXPLORER.MAZDA WILL CONDUCT A PARALLEL COMPAIGN (97V-083.002) TO REMEDY THE SUBJECT CONDITION IN APPROXIMATELY 14,000 NAVAJO VEHICLES.THE NAVAJO VEHICLES WERE AVAILABLE IN ONLY THE 2-DOOR VERSION WHICH, UNLIKE THE EXPLORER VEHICLES, DID USE THE SUBJECT OPTION COMBINATION IN THAT BODY STYLE.
EA96017 · Brake System Malfunction
Opened Jul 24, 1996 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE96016 · Wheel Lockup With Antilock Brake System
Opened Feb 28, 1996 · Closed Jul 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
ODI HAS RECEIVED OND HUNDRED SEVENTY-THREE (173) CONSUMER COMPLAINTS OF ALLEGED FAILURES OR MALFUNCTIONS IN THE BRAKING SYSTEM ON CERTAIN 1993 AND 1994 FORD EXPLORERS.THESE ALLEGED FAILURES OR MALFUNCTIONS ARE REPORTED TO HAVE CAUSED THIRTY-SIX (36) ACCIDENTS RESULTING FROM VEHICLE LOSS OF DIRECTIONAL CONTROL DURING BRAKING OR FROM THE EXTENDED DISTANCE REQUIRED TO STOP THE VEHICLE DURING BRAKING.THE COMPLAINANTS REPORT THAT THE ALLEGED FAILURES OR MALFUNCTIONS OCCURRED DURING BRAKING MOSTLY ON WET OR SLIPPERY ROADS, BUT ALSO HAVE OCCURRED ON DRY ROADS.SINCE ODI OPENED THIS PE BASED ON WHEEL LOCKUP COMPLAINTS, WE HAVE RECEIVED NUMEROUS ADDITIONAL COMPLAINTS AB OUT THE EXTENDED DISTANCE REQUIRED TO STOP THE SUBJECT VEHICLES WHEN BRAKING UNDER CERTAIN ROAD AND SPEED CONDITIONS.IN RESPONSE TO ODI'S INFORMATION REQUEST (IR) CONCERNING WHEEL LOCKUP COMPLAINTS ONT HE SUBJECT VEHICLES, FORD REPORTED RECEIVING 416 REPORTS (FIELD REPORTS, OWNER COMPLAINTS, AND SUBROGATION CLAIMS) OF WHEEEL LOCKUP ON 1993 AND 1994 FORD EXPLORERS, WITH 24 ALLEGED ACCIDENTS.IN ADDITION, FORD REPORTED RECEIVING 24,916 WARRANTY CLAIMS THAT COULD RELATE TO THE ALLEGED DEFECT OF WHEEL LOCKUP DURING BRAKING ON THE SUBJECT VEHICLES.AN ENGINEERING ANALYSIS IS WARRANTED TO DETERMINE THE SCOPE OF THESE ALLEGED BRAKING SYSTEM FAILURES OR MALFUNCTIONS ON 1993 AND 1994 FORD EXPLORERS.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Illustration