NHTSA owner reports · September 18, 2026 snapshot.
Tires complaints
331 reportsClear category filter24,000 miles · Nov 10, 2013
Tires
APRIL, 1996 I, MY EX WIFE, AND MY DAUGHTER WERE COMING BACK FROM PALMDALE, LA COUNTY, TRAVELING EAST ON 138 HIGHWAY BACK TO ONTARIO, SAN BERNARDINO COUNTY, WHERE I USED TO RESIDE. WHILE I WAS PASSING SLOW TRUCK IN TWO HIGHWAY TRYING TO GET BACK IN THE FRONT OF THE TRUCK ONE OF THE FRONT TIRES EXPLODED I LOST CONTROL OF THE 1994 …
Read full complaint
APRIL, 1996 I, MY EX WIFE, AND MY DAUGHTER WERE COMING BACK FROM PALMDALE, LA COUNTY, TRAVELING EAST ON 138 HIGHWAY BACK TO ONTARIO, SAN BERNARDINO COUNTY, WHERE I USED TO RESIDE. WHILE I WAS PASSING SLOW TRUCK IN TWO HIGHWAY TRYING TO GET BACK IN THE FRONT OF THE TRUCK ONE OF THE FRONT TIRES EXPLODED I LOST CONTROL OF THE 1994 FORD EXPLORER GOT ON THE DIRT THE CAR WAS AIRBORNE LANDED TURN GOD KNOWS HOW MANY TIMES AND LANDED ON THE SIDE. *TR
NHTSA ODI #10551694
286,000 miles · Jan 29, 2011
StructureTiresVehicle Speed ControlFire
WHILE DRIVING I TURNED ON AIR CONDITIONER AND IMMEDIATELY LIGHT SMOKE BEGAN OUT OF AIR CONDITIONING VENTS AND THEN THE NEXT MOMENT THE SMOKE WAS EXTREMELY HEAVY OUT OF THE VENTS AND THEN VISIBLE FIRE UNDERNEATH FRONT PASSENGER SIDE DASHBOARD. I IMMEDIATELY PULLED THE VEHICLE OFF THE SIDE OF THE ROAD AND EXITED, 10 MINUTES LATER …
Read full complaint
WHILE DRIVING I TURNED ON AIR CONDITIONER AND IMMEDIATELY LIGHT SMOKE BEGAN OUT OF AIR CONDITIONING VENTS AND THEN THE NEXT MOMENT THE SMOKE WAS EXTREMELY HEAVY OUT OF THE VENTS AND THEN VISIBLE FIRE UNDERNEATH FRONT PASSENGER SIDE DASHBOARD. I IMMEDIATELY PULLED THE VEHICLE OFF THE SIDE OF THE ROAD AND EXITED, 10 MINUTES LATER IT WAS FULLY ENGULFED IN FLAMES. *LN
NHTSA ODI #10379515
Mileage unknown · Feb 25, 2009
TiresCrashInjury
RECALLED FIRESTONE ATX AND WILDERNESS TIRES. **NAR** *NJ THE CONSUMER WAS TRAVELING AT 70 MPH WHEN THE LEFT REAR TIRE SUFFERED A CATASTROPHIC TREAD BELT SEPARATION. THE VEHICLE BECAME UNCONTROLLABLE AND SUBSEQUENTLY ROLLED WHICH CAUSED A FATAL HEAD INJURY TO A RESTRAINED 12 YEAR OLD OCCUPANT. IT WAS ALSO STATED THAT THE SPAR…
Read full complaint
RECALLED FIRESTONE ATX AND WILDERNESS TIRES. **NAR** *NJ THE CONSUMER WAS TRAVELING AT 70 MPH WHEN THE LEFT REAR TIRE SUFFERED A CATASTROPHIC TREAD BELT SEPARATION. THE VEHICLE BECAME UNCONTROLLABLE AND SUBSEQUENTLY ROLLED WHICH CAUSED A FATAL HEAD INJURY TO A RESTRAINED 12 YEAR OLD OCCUPANT. IT WAS ALSO STATED THAT THE SPARE TIRES WERE ALSO DEFECTIVE AND THEY TOO SHOULD BE REMOVED FROM VEHICLES. *JB
NHTSA ODI #10260108
Mileage unknown · Jul 9, 2008
Tires
WHILE DRIVING 60 MPH ON THE HIGHWAY, DRIVER'S SIDE FRONT TIRE HAD COMPLETE TREAD-SEPARATION, CAUSING DAMAGE TO THE FRONT END OF THE VEHICLE, LEFT SIDE OF VEHICLE, AND FLATTENING THE REAR LEFT TIRE. ALTHOUGH THE DRIVER'S SIDE FRONT TIRE HAD COMPLETE TREAD SEPARATION, IT REMAINS INFLATED. THE DEFECTIVE TIRE, AS WELL AS ALL TIRES…
Read full complaint
WHILE DRIVING 60 MPH ON THE HIGHWAY, DRIVER'S SIDE FRONT TIRE HAD COMPLETE TREAD-SEPARATION, CAUSING DAMAGE TO THE FRONT END OF THE VEHICLE, LEFT SIDE OF VEHICLE, AND FLATTENING THE REAR LEFT TIRE. ALTHOUGH THE DRIVER'S SIDE FRONT TIRE HAD COMPLETE TREAD SEPARATION, IT REMAINS INFLATED. THE DEFECTIVE TIRE, AS WELL AS ALL TIRES ON THE VEHICLE, HAD PLENTY OF TREAD LEFT, PASSING BOTH THE PENNY AND QUARTER TEST, WERE PROPERLY INFLATED, AND SHOW NO CRACKING OR WEARING. ALL THE TIRES WERE PURCHASED AT THE SAME TIME AND ARE TOYO RADIAL OPEN COUNTRY P235/75R15. A STEVENS COUNTY POLICE OFFICER WITNESSED THE TREAD SEPARATION AND STOPPED TO HELP. *TR
NHTSA ODI #10233642
Mileage unknown · May 10, 2007
Tires
I RECEIVED A LETTER FROM BRIDGESTONE FIRESTONE NORTH AMERICA TIRE ABOUT A NOTICE REGARDING THE SAFETY OF TIRES. THE 1994 FORD EXPLORER ORIGINALLY CAME WITH P235/75R 15 RADIAL ATX. TODAY I TRIED TO RETURN THE TIRE, ORIGINAL SPARE, FOR A FREE REPLACEMENT AS STATED IN THE LETTER. HOWEVER I WAS TOLD BY AN AUTHORIZED FIRESTONE DEALER…
Read full complaint
I RECEIVED A LETTER FROM BRIDGESTONE FIRESTONE NORTH AMERICA TIRE ABOUT A NOTICE REGARDING THE SAFETY OF TIRES. THE 1994 FORD EXPLORER ORIGINALLY CAME WITH P235/75R 15 RADIAL ATX. TODAY I TRIED TO RETURN THE TIRE, ORIGINAL SPARE, FOR A FREE REPLACEMENT AS STATED IN THE LETTER. HOWEVER I WAS TOLD BY AN AUTHORIZED FIRESTONE DEALER AT HAYWOOD MALL GREENVILLE SC THAT THE RECALL HAD BEEN TERMINATED. THE LETTER FROM BRIDGESTONE FIRESTONE NORTH AMERICA DID NOT INDICATE AN END DATE. IN FACT THIS LETTER INDICATED THE COMPANY WAS TRYING TO ROOT OUT THE LAST REMAINING TIRE SPARES. THE DEALER REFUSED TO HONOR THE RECALL. AK
NHTSA ODI #10190394
Mileage unknown · Apr 3, 2007
Tires
1994 FORD EXPLORER BRIDGESTONE FIRESTONE TIRES DEFECT, TIRES RECALLED, CONSUMER HAD TIRES REPLACED AT HIS EXPENSE AND WOULD LIKE TO GET REIMBURSEMENT FROM MANUFACTURER. *MC *JB
NHTSA ODI #10186884
Mileage unknown · Dec 22, 2006
Tires
TL* - THE CONTACT RECEIVED A RECALL LETTER FOR FIRESTONE TIRES ON HIS 1994 FORD EXPLORER. THE LETTER STATED AN AUTHORIZED DEALER WOULD REPLACE THE TIRES FREE OF CHARGE. HE CALLED THE NUMBER ON THE LETTER TO FIND AN AUTHORIZED DEALER. AFTER CONTACTING THE AUTHORIZED DEALER HE WAS TOLD THEY WOULD REPLACE THE TIRES. THE CONTACT…
Read full complaint
TL* - THE CONTACT RECEIVED A RECALL LETTER FOR FIRESTONE TIRES ON HIS 1994 FORD EXPLORER. THE LETTER STATED AN AUTHORIZED DEALER WOULD REPLACE THE TIRES FREE OF CHARGE. HE CALLED THE NUMBER ON THE LETTER TO FIND AN AUTHORIZED DEALER. AFTER CONTACTING THE AUTHORIZED DEALER HE WAS TOLD THEY WOULD REPLACE THE TIRES. THE CONTACT HAD TO PAY FOR THE TIRES AND THE DEALER KEPT THE TWO TIRES HE REPLACED. THE TIRES ARE RADIAL ATX 235S.
NHTSA ODI #10176828
Mileage unknown · Nov 16, 2006
Tires
1994 EXPLORER TIRE TREAD HAS CRACKS ON ALL FOUR TIRES. *TS *JB
NHTSA ODI #10174319
179,000 miles · Nov 14, 2006
Tires
DT*: THE CONTACT STATED RECALL LETTER # 01X001000 FOR THE TIRES: TREAD/BELT WAS RECEIVED FROM BRIDGESTONE/FIRESTONE FOR THE TIRES ON THE 1994 FORD EXPLORER. THE PAPERWORK WAS RETURNED TO THE MANUFACTURER FOR THE REFUND, BUT THE REFUND WAS DENIED.
NHTSA ODI #10173447
39,000 miles · Oct 17, 2006
Tires
WHEN I BOUGHT MY FORD EXPLORER USED IN 1997 WITH 39,000 MILES ON IT THE TIRES WERE BLOATED OUT OF SHAPE AND THE VEHICAL SHOOK VIOLENTLY AT ANY SPEED ABOVE 35 MPH. I REPLACED THE TIRES BECAUSE THEY WERE EXTREMELY DANGEROUS. THEN THE TIRES WERE RE-CALLED. I CONTACTED FIRESTONE AND THEY TOLD ME THEY WOULD NOT REIMBURSE ME FOR THE T…
Read full complaint
WHEN I BOUGHT MY FORD EXPLORER USED IN 1997 WITH 39,000 MILES ON IT THE TIRES WERE BLOATED OUT OF SHAPE AND THE VEHICAL SHOOK VIOLENTLY AT ANY SPEED ABOVE 35 MPH. I REPLACED THE TIRES BECAUSE THEY WERE EXTREMELY DANGEROUS. THEN THE TIRES WERE RE-CALLED. I CONTACTED FIRESTONE AND THEY TOLD ME THEY WOULD NOT REIMBURSE ME FOR THE TIRES BECAUSE I DID NOT SAVE THEM AFTER THEY WERE REMOVED AND I COULD NOT PROVE I EVER HAD THEM. NOW I HAVE A RECALL FOR THE SPARE TIRE (WHICH IS THE ORIGIONAL FIRESTONE ATX DEFECTIVE TIRE. I CONTACTED FIRESTONE BY EMAIL WITH THIS FACT AND FIRESTONE IS IGNORING ME. PLEASE LET ME KNOW WHAT I NEED TO DO NOW THAT I HAVE THE PROOF THAT FIRESTONE DEMANDED THAT THEY SOLD ME DEFECTIVE TIRES. THANKS, JOHN ULRICH. *NM
NHTSA ODI #10171031
NHTSA investigations
13EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96066 · Driver Door Electrical Fire
Opened Nov 22, 1996 · Closed May 15, 1997
Status: closed (inferred from source dates) · Electrical System
THE CONTACT ASSEMBLY FOR THE REMOTE POWER MIRROR CONTROL SWITCH MAY DEVELOP A SHORT CIRCUIT BETWEEN THE SWITCH POSITIVE PAD AND CHASSIS GROUND PAD AS A RESULT OF WATER INTRUSION.EXCESS CURRENT FLOW RESULTING FROM THE SHORT CIRCUIT CONDITION MAY OVERHEAT THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AND CAUSE A FIRE IN THE DRIVER'S DOOR.FORD HAS INDICATED THAT CURRENT IN EXCESS OF 15 AMPS CAN OVERHEAT THE CIRCUIT BOARD ENOUGH TO CAUSE A FIRE.CIRCUIT PROTECTION IS PROVIDED BY A 30 AMP FUSE.FORD IS RECALLING ALL 1993-94 4-DOOR EXPLORER VEHICLES EQUIPPED WITH THE SUBJECT ELECTRONIC OPTION COMBINATION TO INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.NO 2-DOOR EXPLORER VEHICLES WERE BUILT WITH THE SUBJECT COMPONENTS.ACCORDING TO FORD, VEHICLES BUILT PRIOR TO THE RECALL PRODUCTION RANGE WERE EQUIPPED WITH LOWER CAPACITY CIRCUIT BOARDS FOR THE SUBJECT SWITCH ASSEMBLY THAT WOULD FAIL FROM AN OPEN CIRCUIT IF A SIMILAR SHORT OCCURRED.A NEW SWITCH ASSEMBLY WITH 10 AMP FUSE PROTECTION WAS INTRODUCED BEGINNING WITH THE 1995 MODEL YEAR EXPLORER.MAZDA WILL CONDUCT A PARALLEL COMPAIGN (97V-083.002) TO REMEDY THE SUBJECT CONDITION IN APPROXIMATELY 14,000 NAVAJO VEHICLES.THE NAVAJO VEHICLES WERE AVAILABLE IN ONLY THE 2-DOOR VERSION WHICH, UNLIKE THE EXPLORER VEHICLES, DID USE THE SUBJECT OPTION COMBINATION IN THAT BODY STYLE.
EA96017 · Brake System Malfunction
Opened Jul 24, 1996 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE96016 · Wheel Lockup With Antilock Brake System
Opened Feb 28, 1996 · Closed Jul 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
ODI HAS RECEIVED OND HUNDRED SEVENTY-THREE (173) CONSUMER COMPLAINTS OF ALLEGED FAILURES OR MALFUNCTIONS IN THE BRAKING SYSTEM ON CERTAIN 1993 AND 1994 FORD EXPLORERS.THESE ALLEGED FAILURES OR MALFUNCTIONS ARE REPORTED TO HAVE CAUSED THIRTY-SIX (36) ACCIDENTS RESULTING FROM VEHICLE LOSS OF DIRECTIONAL CONTROL DURING BRAKING OR FROM THE EXTENDED DISTANCE REQUIRED TO STOP THE VEHICLE DURING BRAKING.THE COMPLAINANTS REPORT THAT THE ALLEGED FAILURES OR MALFUNCTIONS OCCURRED DURING BRAKING MOSTLY ON WET OR SLIPPERY ROADS, BUT ALSO HAVE OCCURRED ON DRY ROADS.SINCE ODI OPENED THIS PE BASED ON WHEEL LOCKUP COMPLAINTS, WE HAVE RECEIVED NUMEROUS ADDITIONAL COMPLAINTS AB OUT THE EXTENDED DISTANCE REQUIRED TO STOP THE SUBJECT VEHICLES WHEN BRAKING UNDER CERTAIN ROAD AND SPEED CONDITIONS.IN RESPONSE TO ODI'S INFORMATION REQUEST (IR) CONCERNING WHEEL LOCKUP COMPLAINTS ONT HE SUBJECT VEHICLES, FORD REPORTED RECEIVING 416 REPORTS (FIELD REPORTS, OWNER COMPLAINTS, AND SUBROGATION CLAIMS) OF WHEEEL LOCKUP ON 1993 AND 1994 FORD EXPLORERS, WITH 24 ALLEGED ACCIDENTS.IN ADDITION, FORD REPORTED RECEIVING 24,916 WARRANTY CLAIMS THAT COULD RELATE TO THE ALLEGED DEFECT OF WHEEL LOCKUP DURING BRAKING ON THE SUBJECT VEHICLES.AN ENGINEERING ANALYSIS IS WARRANTED TO DETERMINE THE SCOPE OF THESE ALLEGED BRAKING SYSTEM FAILURES OR MALFUNCTIONS ON 1993 AND 1994 FORD EXPLORERS.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Illustration