NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
86 reportsClear category filter180,000 miles · Jul 1, 2018
Power Train
PURCHASED VEHICLE TRANSMISSION OUT,CAME WITH REBUILT TRANSMISSION,INSTALLED,LASTED ABOUT 1 YEAR.KEPT BLOWING FRONT SEALS.ALWAYS HEATED UP GOING UPHILL.NEXT TRANSMISSION,SAME STORY.SERVICED REGULAR,WITH FILTER CHANGE.CURRENT TRANSMISSION IN TRANS. SHOP,BURNT UP,NEW CLUTCHES,BANDS,SEALS,YOU NAME IT.IT STILL WILL NOT SHIFT CORRECTY…
Read full complaint
PURCHASED VEHICLE TRANSMISSION OUT,CAME WITH REBUILT TRANSMISSION,INSTALLED,LASTED ABOUT 1 YEAR.KEPT BLOWING FRONT SEALS.ALWAYS HEATED UP GOING UPHILL.NEXT TRANSMISSION,SAME STORY.SERVICED REGULAR,WITH FILTER CHANGE.CURRENT TRANSMISSION IN TRANS. SHOP,BURNT UP,NEW CLUTCHES,BANDS,SEALS,YOU NAME IT.IT STILL WILL NOT SHIFT CORRECTY DUE TO SERVO PISTON FAILURE,THAT ALSO NEEDS FIXED.A4LD TRANSMISSION IN TOO SMALL FOR THE EXPLORER VEHICLE.I LIKE THE VEHICLE IN GENERAL,EVEN INSTALLED MANUAL LOCKOUTS TO HELP THIS SIDUATION.THIS VEHICLE HAS HAD GOOD CARE,BUT TO NO AVAIL.I BELIEVE THAT THE FORD MOTOR COMPANY SHOULD BE HELD ACCOUNTABLE FOR PRESENTING THE AMERICAN CONSUMER WITH SUCH BAD DRIVETRAIN SIDUATIION,THAT I AM SURE THAT THEY BOTH KNEW ABOUT,AND JUST DID NOT CARE.IT LEFT ME,A SERVICE CONNECTED DISABLED VETERAN,ON THE SHOULDER OF THE HIGHWAY,MANY TIMES.EVEN ON MY WAY TO THE VA HOSPITAL.REGUARDS
NHTSA ODI #11104957
99,999 miles · Oct 17, 2007
Power TrainSteeringSuspension
I WAS BROWSING FOR A USED CAR AND CAME ON AN ADD SELLING CARS I HAD NO VEHICLE I ASKED IF THEY CAN PICK ME UP ON THE OTHER SIDE OF THE CLINTON FERRY. THEY SAID YES THEY WILL PICK ME UP. SO CHECKED OUT THEIR INVENTORY. I PICKED A 1994 FORD EXPLORER LITTLE DAMAGE TO THE BODY, TIRES NEEDED CHANGING, THE FRONT WINDSHIELD HAS D…
Read full complaint
I WAS BROWSING FOR A USED CAR AND CAME ON AN ADD SELLING CARS I HAD NO VEHICLE I ASKED IF THEY CAN PICK ME UP ON THE OTHER SIDE OF THE CLINTON FERRY. THEY SAID YES THEY WILL PICK ME UP. SO CHECKED OUT THEIR INVENTORY. I PICKED A 1994 FORD EXPLORER LITTLE DAMAGE TO THE BODY, TIRES NEEDED CHANGING, THE FRONT WINDSHIELD HAS DAMAGE, AND REAR VIEW MIRROR WAS GONE. I ACCEPTED THESE AND ASKED FOR A TEST RIDE PROCEEDED OFF THE LOT THERE WAS NO GAS MAKING A TEST DRIVE SHORT. IT WAS AS IF THEY RUSHED ME THROUGH THE DEAL NOTHING WAS SAID ABOUT THE PROBLEMS. RETURNING HOME IS WHEN I BEGAN RUNNING INTO PROBLEMS THAT WERE SAFETY ISSUES. THE RPMS HAD GONE TO THE LIMITS OF SAFE OPERATION EXCEEDING 6,000 RPMS AND NOT SHIFTING TO A HIRE GEAR MAKING THE MOTOR SCREEN NEARLY EXPLODING THE MOTOR THIS IS CONSISTENT EVERY TIME YOU OPERATE. SO DROVE HOME WITH THIS PROBLEM. I ACCELERATED AND THEN LET OFF THE GAS AND IT THEN SHIFTED UP. I GAVE IT THE GAS IT SCREAMED AND I LET OFF THE GAS AND IT SHIFTED INTO THE HIGHER GEAR I ALSO HAVE STEERING PROBLEMS IT PULLS TO THE LEFT PULLING ME INTO ON GOING TRAFFIC, SHIMMIES AND THE TIE RODS CONNECTED TO THE STEERING HAD SOME PLAY IN THEM. SO WHEN I TURNED LEFT OR RIGHT I HAD NO STEERING UNTIL IT GOT TO CERTAIN POINT WHERE IT STEERED. THE VEHICLE FLOATS LIKE A BOAT A STRUT PROBLEM. NOW WHEN I WENT TO ESTIMATES FOR THE REPAIRS ITS PARTS AND LABOR CAME TOO ABOUT THE SAME AMOUNT I PAID FOR THE TRUCK APPROXIMATELY 4,400.00. SO NOW I HAVE THIS TRUCK I REFUSE TO DRIVE. I TOLD THEM TO COME AND GET IT AND NO WAY WAS I GOING TO DRIVE AN UNSAFE TRUCK SO IT SITS IN MY DRIVEWAY. I REFUSE TO PAY THEM ANY MONEY. THEY HAVEN'T CALLED ME, NOR MADE ANY DEAL.
NHTSA ODI #10206124
21,782 miles · Mar 28, 2006
Power TrainCrashInjury
VEHICLE'S AUTOMATIC TRANSMISSION ENGAGED AT 2500 RPM DURING A CA. STATE SMOG INSPECTION . RESULTED IN TECHNICIAN BEING PINNED AND CRUSHED TO VEHICLE PARKED IN FRONT . TECH WAS AMBULANCED TO HOSPITAL WITH SEVERE LOWER LEG AND ANKLE INJURIES TRANSMISSION WAS REBUILT AT OTHER SHOP AFTER SAID FAILURE. *JB
NHTSA ODI #10153957
7,300 miles · Feb 17, 2006
Electrical SystemPower TrainSuspension
(1) PURCHASE OF A NEW 2002 FORD EXPLORER; (2) DEFECTIVE VEHICLE FROM THE ONSET. ONGOING PROBLEMS WITH SERIOUS "SAFETY" ISSUES. (3) HAVE REPEATED TAKEN THE VEHICLE INTO THE DEALERSHIP, BUT THE PROBLEMS HAVE NOT BEEN RECTIFIED. *NM
NHTSA ODI #10150527
Mileage unknown · Nov 22, 2004
Power Train
THE TRANSMISSION ON THE 1994 FORD EXPLORER APPEARS TO BE DEFECTIVE. THEY FAIL AFTER ONLY BETWEEN 75,000-125,000 MILES. *JB
NHTSA ODI #10100330
114,000 miles · Oct 26, 2004
Electrical SystemEngine And Engine CoolingEquipment
1994 EXPLORER 4.0 V6 AUTOMATIC TRANSMISSION REBIULT 3 TIMES IN PAST YEAR .COUNTLESS TIMES VEHICLE HAS STALLED ACTING AS IF THE FUEL PUMP QUIT, FUEL PUMP REPLACED, COIL PACKS REPLACED, RELAYS REPLACED. ONCE ON THE HIGHWAY AT 70 MPH, ANOTHER TIME WHILE PULLING INTO TRAFFIC. USUALLY UPON START UP. AIR CONDITIONER SWITCH SHORTED OU…
Read full complaint
1994 EXPLORER 4.0 V6 AUTOMATIC TRANSMISSION REBIULT 3 TIMES IN PAST YEAR .COUNTLESS TIMES VEHICLE HAS STALLED ACTING AS IF THE FUEL PUMP QUIT, FUEL PUMP REPLACED, COIL PACKS REPLACED, RELAYS REPLACED. ONCE ON THE HIGHWAY AT 70 MPH, ANOTHER TIME WHILE PULLING INTO TRAFFIC. USUALLY UPON START UP. AIR CONDITIONER SWITCH SHORTED OUT, SAW BURNED WIRES ON SWITCH UPON REPLACEMENT. ANTIFREEZE SPEWED OUT FROM SIDE OF MOTOR, ASSUMED TO BE AROUND HEADS BUT HAS NOT BEEN TO SHOP YET.*AK
NHTSA ODI #10096436
Mileage unknown · Jun 17, 2004
Power TrainCrashInjury
WHILE VEHICLE WAS IDLING IT POPPED INTO REVERSE AND ROLLED INTO A PARKED VEHICLE. TRANSMISSION SLIPPED INTO REVERSE AND CAUSED THIS MISHAP. VEHICLE IS CURRENTLY PARKED, AND CONSUMER IS AFRAID TO DRIVE IT. *AK
NHTSA ODI #10079441
88,000 miles · Jan 5, 2004
Power TrainStructure
DOOR HANDLES ON PASSENGER SIDE INTERIOR BROKEN. TRANSMISSION SLIPPING. *AK
NHTSA ODI #10052417
75,000 miles · Aug 13, 2003
Fuel System, OtherPower TrainVisibility
GASOLINE GUAGE WORKS INTERMITTENTLY OR NOT AT ALL, 4 WHEEL DRIVE DOES NOT WORK, PASSENGER WINDOW IN FRONT SIDE DOES NOT WORK. *AK
NHTSA ODI #10032776
Mileage unknown · Jul 10, 2003
Power Train
THE VEHICLE WAS TAKEN FOR INSPECTION TO AN INDEPENDENT REPAIR SHOP. CONSUMER NOTICED, AFTER RECEIVING THE VEHICLE THAT IT WAS NOT DRIVING RIGHT. CONSUMER PULLED OVER, AND PUT VEHICLE IN PARK. AFTER A FEW MINUTES, CONSUMER STARTED THE VEHICLE AND TRIED TO PUT THE VEHICLE INTO THE REVERSE. THE SHIFTER WENT PASSED ALL THE GEA…
Read full complaint
THE VEHICLE WAS TAKEN FOR INSPECTION TO AN INDEPENDENT REPAIR SHOP. CONSUMER NOTICED, AFTER RECEIVING THE VEHICLE THAT IT WAS NOT DRIVING RIGHT. CONSUMER PULLED OVER, AND PUT VEHICLE IN PARK. AFTER A FEW MINUTES, CONSUMER STARTED THE VEHICLE AND TRIED TO PUT THE VEHICLE INTO THE REVERSE. THE SHIFTER WENT PASSED ALL THE GEARS AND WOULD NOT MOVE. *AK
NHTSA ODI #10026945
NHTSA investigations
13EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96066 · Driver Door Electrical Fire
Opened Nov 22, 1996 · Closed May 15, 1997
Status: closed (inferred from source dates) · Electrical System
THE CONTACT ASSEMBLY FOR THE REMOTE POWER MIRROR CONTROL SWITCH MAY DEVELOP A SHORT CIRCUIT BETWEEN THE SWITCH POSITIVE PAD AND CHASSIS GROUND PAD AS A RESULT OF WATER INTRUSION.EXCESS CURRENT FLOW RESULTING FROM THE SHORT CIRCUIT CONDITION MAY OVERHEAT THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AND CAUSE A FIRE IN THE DRIVER'S DOOR.FORD HAS INDICATED THAT CURRENT IN EXCESS OF 15 AMPS CAN OVERHEAT THE CIRCUIT BOARD ENOUGH TO CAUSE A FIRE.CIRCUIT PROTECTION IS PROVIDED BY A 30 AMP FUSE.FORD IS RECALLING ALL 1993-94 4-DOOR EXPLORER VEHICLES EQUIPPED WITH THE SUBJECT ELECTRONIC OPTION COMBINATION TO INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.NO 2-DOOR EXPLORER VEHICLES WERE BUILT WITH THE SUBJECT COMPONENTS.ACCORDING TO FORD, VEHICLES BUILT PRIOR TO THE RECALL PRODUCTION RANGE WERE EQUIPPED WITH LOWER CAPACITY CIRCUIT BOARDS FOR THE SUBJECT SWITCH ASSEMBLY THAT WOULD FAIL FROM AN OPEN CIRCUIT IF A SIMILAR SHORT OCCURRED.A NEW SWITCH ASSEMBLY WITH 10 AMP FUSE PROTECTION WAS INTRODUCED BEGINNING WITH THE 1995 MODEL YEAR EXPLORER.MAZDA WILL CONDUCT A PARALLEL COMPAIGN (97V-083.002) TO REMEDY THE SUBJECT CONDITION IN APPROXIMATELY 14,000 NAVAJO VEHICLES.THE NAVAJO VEHICLES WERE AVAILABLE IN ONLY THE 2-DOOR VERSION WHICH, UNLIKE THE EXPLORER VEHICLES, DID USE THE SUBJECT OPTION COMBINATION IN THAT BODY STYLE.
EA96017 · Brake System Malfunction
Opened Jul 24, 1996 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE96016 · Wheel Lockup With Antilock Brake System
Opened Feb 28, 1996 · Closed Jul 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
ODI HAS RECEIVED OND HUNDRED SEVENTY-THREE (173) CONSUMER COMPLAINTS OF ALLEGED FAILURES OR MALFUNCTIONS IN THE BRAKING SYSTEM ON CERTAIN 1993 AND 1994 FORD EXPLORERS.THESE ALLEGED FAILURES OR MALFUNCTIONS ARE REPORTED TO HAVE CAUSED THIRTY-SIX (36) ACCIDENTS RESULTING FROM VEHICLE LOSS OF DIRECTIONAL CONTROL DURING BRAKING OR FROM THE EXTENDED DISTANCE REQUIRED TO STOP THE VEHICLE DURING BRAKING.THE COMPLAINANTS REPORT THAT THE ALLEGED FAILURES OR MALFUNCTIONS OCCURRED DURING BRAKING MOSTLY ON WET OR SLIPPERY ROADS, BUT ALSO HAVE OCCURRED ON DRY ROADS.SINCE ODI OPENED THIS PE BASED ON WHEEL LOCKUP COMPLAINTS, WE HAVE RECEIVED NUMEROUS ADDITIONAL COMPLAINTS AB OUT THE EXTENDED DISTANCE REQUIRED TO STOP THE SUBJECT VEHICLES WHEN BRAKING UNDER CERTAIN ROAD AND SPEED CONDITIONS.IN RESPONSE TO ODI'S INFORMATION REQUEST (IR) CONCERNING WHEEL LOCKUP COMPLAINTS ONT HE SUBJECT VEHICLES, FORD REPORTED RECEIVING 416 REPORTS (FIELD REPORTS, OWNER COMPLAINTS, AND SUBROGATION CLAIMS) OF WHEEEL LOCKUP ON 1993 AND 1994 FORD EXPLORERS, WITH 24 ALLEGED ACCIDENTS.IN ADDITION, FORD REPORTED RECEIVING 24,916 WARRANTY CLAIMS THAT COULD RELATE TO THE ALLEGED DEFECT OF WHEEL LOCKUP DURING BRAKING ON THE SUBJECT VEHICLES.AN ENGINEERING ANALYSIS IS WARRANTED TO DETERMINE THE SCOPE OF THESE ALLEGED BRAKING SYSTEM FAILURES OR MALFUNCTIONS ON 1993 AND 1994 FORD EXPLORERS.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Illustration