2024 Ford Expedition

I own a 2024 Ford Expedition XLT. The vehicle repeatedly loses multiple federally mandated safety systems including Blind Spot Monitoring, Cross-Traffic Alert, Automatic Emergency Braking, Forward Collision Warning, and camera systems. Alerts include: ‘Cross-Traffic System Fault,’ ‘Blind Spot System Fault,’ ‘Pre-Collision Assist Not Available,’ ‘Front Camera Fault,’ and ‘Check Parking Sensors.’ Ford has acknowledged this as a known issue with a fix delayed until June. My dealer (Morries Ford, Buffalo MN) is charging $225 each time the defect recurs just to clear errors. This is a safety defect that places my family at risk. Ford is refusing to cover the full repair cost and the dealer is charging for temporary resets.

I purchased this 2024 Ford Expedition brand new from a Ford certified dealer (Conklin Cars, Newton , Kansas). Upon driving off the lot for the first time to a gas station across the street from the dealer, at restart all the sensor gave warnings. Sensors that gave warning include: Blind spots sensors, back-up sensors, Froward impact, lane departure, automatic braking, rear cross traffic, and the cruise display. I took it back to the dealership and the reset the system and upon starting the vehicle after parked, all the sensors stopped working again. I then took the Ford Expedition back to the certified dealer (Conklin Cars, Newton , Kansas) and they game me sheets of paper, Last one give after 4 visits to dealer [XXX]) stating that Ford knows of the an issues, which appear to be right off the factory line. This has been over a year and there have been several close calls for me and my family without these sensors, which is standard in most cars these days. Me and my family expect these sensors to work on the vehicles we drive, rather basic or premium. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I would like to report the seats. I bought my vehicle new. The seats has caused me to have medical issues. It has also caused one other person issues too, so it was not just me. I have never had any sort of back or leg issues before getting this vehicle. I now have severe Sciatica Nerve problems. Which, I have seen the Doctor for. It flares up so bad while I am driving my right leg goes into extreme pain then it goes numb. Which is not helpful since this is the foot I use the gas and brake with. This is my only transportation, so I do not have another vehicle to drive. I have had my son drive this vehicle when we went on a trip. I sat in the middle row captain chair and it was the same issue. This trip was when my daughter in-law (Which is an RN) starting having the same issues as myself.

The 2024 Ford expedition brakes was not working at the time of the accident, we later found that there was a recall on the brakes. PMA companies is the TPA for the Victaulic Companies, please see accident description below: Insured driver states she Pulled in driveway and was trying to park vehicle. Driver hit the brakes all the way down and the vehicle did not stop. Vehicle went through drivers fence and struck a tree causing damages to vehicle. Caused damages to neighbors fence.

The contact owns a 2024 Ford Expedition. The contact stated that while driving at various speeds, the message "Drive Assist Unavailable" was displayed. The contact stated that when the vehicle was turned off and restarted, the system was functional. The contact had taken the vehicle to a local dealer, who checked the 12-Volt battery and found that the battery was operational and there were no other electrical issues. The contact stated that later, while starting the vehicle, the message "Loss of Power Steering Assist" was displayed, and the steering wheel was difficult to turn to the left or the right. The vehicle was turned off and restarted, and regained power steering functionality; however, the failure reoccurred. The contact attempted to reset the electrical system by disconnecting the battery terminals. The contact stated that loss of power steering reoccurred with the loss of the Lane Keep Assist feature. The contact had taken the vehicle back to the same dealer who diagnosed the vehicle and checked the wiring harness and coated the terminal connectors with a gel for better connectivity. The vehicle was repaired; however, the failures reoccurred. Additionally, the contact stated that the “Driving Modes” light was illuminated. The contact stated that while attempting to switch modes to Snow or Sport, or another option, the light illuminated with the message that each selected mode was unavailable. The contact stated that the vehicle would be taken back to the dealer for the failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 36,000.

The fuel line/fuel pump was leaking. Smelled fumes from the gasoline. Fuel was leaking over the fuel tank from the top of the tank. The vehicle was drivable when fuel was leaking. Very concerned that their could have been a fire due to the fuel leak. Took the vehicle to the Ford service department where it was purchased. Service shop stated that during inspection they noticed that something chewed through the fuel line/fuel pump. Comments made by the service advisors stated that they have seen squirrels/rodents attracted to the soy based ingredients of the parts/wiring. The repair would not be covered under warranty due to "outside influence". The manufacturer is installing a similar part and not covering under warranty. No warning lights; no warning messages. If the same type of soy based part is being installed, what is going to prevent the same thing from happening. Ford is not offering different types of parts and they do not have a way to prevent additional damage. No shield/tape/covering is being offered. Numerous instances of this referenced online due to soy based parts and Ford knowingly installing these parts without a fix or prevention. Consumer is responsible for all repairs. No warranty.

I am the owner of a 2024 Ford Expedition, purchased new in March 2024. I am writing to formally report multiple instances of complete brake failure, which pose a significant safety risk. The most recent incident occurred on [XXX], at approximately [XXX], while I was driving northbound on [XXX] in Cupertino, California, with my wife and two grandchildren (ages [XXX] and [XXX]) in the vehicle. As I approached the [XXX] exit, I began decelerating. While applying continuous pressure on the brake pedal during the descent of the off-ramp, the brake pedal suddenly went soft and sank to the floor. The vehicle failed to slow down and began accelerating downhill, due to gravity, toward the intersection at [XXX] , where the light was red. This total loss of braking control lasted for approximately 5 to 10 seconds and nearly resulted in a serious collision. I was only able to regain control by releasing and reapplying the brake pedal and shifting the transmission into Park, at which point the brakes resumed normal function. A similar brake failure occurred earlier in 2024 under comparable driving conditions. At that time, I believed it to be an isolated mechanical glitch, and therefor did not take it to the dealer. I brought the vehicle to Frontier Ford in Santa Clara the following day ([XXX]) for immediate inspection. Despite ongoing efforts by the dealership and Ford engineering, the issue has not been duplicated or resolved. As of this writing, the vehicle remains at the dealership. I am filing this complaint so that the matter may be officially documented and thoroughly investigated as a potential systemic safety defect affecting this model. I urge you to investigate this issue promptly to help prevent similar incidents and ensure the safety of other drivers and passengers. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)