2017 Ford Expedition

Near total loss of brakes. Pulled in to a parking spot and brakes very squishy, upon returning brake light was on. No indication of brake fluid on ground. Added approximately 25oz of fluid topping off reservoir, upon returning home (1.5mi) the pedal travel was much longer than normal, and no fluid remaining in reservoir again. Replaced master cylinder and power booster. Upon removing the power booster was full of oil.

While driving down the highway, the low brake fluid light sounded and the brake light came on . we slowly loss brakes while driving down the HWy. We added brake fluid, which there was no brake fluid in there at all .When we added the fluid, we pump the brakes and they tighten . Shortly after adding more fluid , the fluid and brakes were gone and white smoke came out of the tail pipe. We never could see exactly where it was leaking at. We added about a quart and a half of fluid . After adding the more fluid, we managed to get it up to the dealership where it was purchased . We explain to what was going on and he knew of the situation because he said it was a recall last year on the master cylinder if I’m saying it, right. I told him that we never received a recall letter but we left the vehicle and he did research by our Vin number, and said we were not part of the recall, but I read a recall number 22S14 about the break failure in expeditions. We called the local number attached to the recall and they once again told us that our vehicle was not part of the recall because I guess it was not out of the Kentucky plant . We are having the same issue with our brakes, but it’s not covered in the current recall. My vehicle is currently in the shop and waiting to be repaired. Can someone research and see if our vehicle can be part of the recall now and be repaired under the/a recall. thank you.

The recall has not been fixed. Winner Ford, Dover DE 19901, still does have the part for the Brake master cylinder. The other recall for the fan and blower has been fixed BUT it went bad last year 2021 and I had it repaired using at Winner Ford, Dover DE 19901 and paid $100 deducted using my extended warranty. I inquired today October 17, 2022 at Winner Ford Service department, Dover DE 19901 to have the $100 refunded. I feel that it should be refunded especially since there is still no remedy and it could go bad again.

My brake fluid is low warning light came on and I checked it and my brake fluid was completely empty there was no apparent leaking from anywhere within eye sight. I refilled it and a week later the same thing happened. Then I get a letter in the mail saying there is a recall about leaking break fluid and no dealer ship in my area has any availability within a reasonable amount of time. I have two kids and work full time I cannot go without a vehicle and I do not feel save driving it my breaks stopped working due to the leaking fluid which is FORDS fault.

At the present I have a vehicle that can not be driven. The low brake fluid alarm and light came. So I stopped purchase some brake fluid and fill the master cylinder up. Not 5 minutes later the alarm goes off and low brake fluid light is on. Now I have no or little brakes. Brake Pedal goes straight to the floor. Too dangerous to drive. My vehicle is now in my drive way after another bottle of brake fluid and slowly driving home. Don't know where the fluid is going Don't see any on the ground. I was told my vehicle vin # was not included in the recall.

Recall on 2017 Ford Expedition - Brake master cylinder. I have had 2 appointments canceled by Ford because they do not have the part in. Am I supposed to wait untill I have an accident because all the brake fluid leaked out. The PIN number on my driver's side door is not working. The driver's door opens after touching one number.

On 8/15/22 I was driving when all of a sudden my brake pedal went all the way to the floor, the braking system dash light chimed and lit up a warning, and the dash read low brake fluid. I pulled over with almost zero brakes, was able to add a bottle of brake fluid. I was able to limp the car home and when I got there again no brake fluid and all warning lights on again. We added another bottle of brake fluid and let the car sit. After an hour we went back and started the car and got the same warnings. We popped the hood and again zero brake fluid, even though we have added 2 bottles. There was nothing visibly leaking. We were able to get the car a mechanic that verified there is a leak in the master cylinder and it needs to be replaced along with the brake booster. The vehicle is available for inspection. There is a recall on this model truck for the same problem but I was told my vehicle was built 10 days past the date allowed in the recall. Having this happen with no warning was extremely dangerous given that I had almost no braking power. It was a challenge moving the car off the road and back home. I had no indication anything was wrong prior to 8/15/22 until the pedal went to the floor that day. Vehicle has only been inspected by my mechanic.