NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
92 reportsClear category filter70,000 miles · Jul 20, 2022
Electrical SystemFire
While driving out of parking lot during a very warm day (100 degrees), A/C blower was on high as normal: 1. A/C blower suddenly stopped working. 2. A smell of something burning became evident inside car 3. Suddenly smoke started coming out of passenger side defroster and A/C vent 4. After passenger exited vehicle, I went to …
Read full complaint
While driving out of parking lot during a very warm day (100 degrees), A/C blower was on high as normal: 1. A/C blower suddenly stopped working. 2. A smell of something burning became evident inside car 3. Suddenly smoke started coming out of passenger side defroster and A/C vent 4. After passenger exited vehicle, I went to look under passenger glove compartment and discovered a small fire under dash. Tried to douse flames with water bottles, but with no effect. 5. Opened glove compartment box and flames came out of opening immediately. 6. Witnessed a small size soup can and melting plastic fall on passenger floor of dripping fire 7. Fire spread suddenly up into dash and windshield and then cabin 8. Called 911 and fire department arrived within 3-4 minutes. 9. Fire became an inferno and car burnt to the ground
NHTSA ODI #11474960
Mileage unknown · Jul 15, 2022
Electrical SystemUnknown Or Other
Our car experienced a failed Throttle Body Assembly. While driving our car, the engine would lose power, and the car would start to violently shake. The wrench light would come on the dash. We would have to pull over whether we were on the highway or a city street. Once we turned the car off and back on the wrench light would di…
Read full complaint
Our car experienced a failed Throttle Body Assembly. While driving our car, the engine would lose power, and the car would start to violently shake. The wrench light would come on the dash. We would have to pull over whether we were on the highway or a city street. Once we turned the car off and back on the wrench light would disappear. We took the car to our mechanic who could not figure out the issue due to no codes. The Ford dealership told us the same thing as our mechanic - without a code(s) it would take a lot of time and money to figure out the problem. Finally after several (at least 5 time) scary occurrences of this issue, the engine light came on and gave a code. We fixed the issue on June 23, 2022.
NHTSA ODI #11474113
Mileage unknown · Feb 12, 2022
Electrical System
Phone and Bluetooth are inoperable, as well as usb and auxiliary are inoperable. This presents a danger as the APIM controls a number of functions on the vehicle that could also become safety threat such as relying on the back up camera which has also presented intermittent issues.
NHTSA ODI #11451625
Mileage unknown · Dec 2, 2021
Electrical SystemUnknown Or Other
Backup camera displays video while drive forward. Almost like having a tv in front seat. Dealer can not recreate. Happened intermittently. Also goes blank and fuzzy intermittently which there is recall for on 2019 and 2020 models.
NHTSA ODI #11442445
Mileage unknown · Sep 2, 2021
Electrical SystemEquipmentFire
Shortly after the car was started and while still parked, a foul smell was detected and black smoke observed coming from the air vents. The vehicle was then turned off however within minutes of safely exiting all passengers from the vehicle, flames came out towards the passenger seat from underneath the glove box. An unsuccessfu…
Read full complaint
Shortly after the car was started and while still parked, a foul smell was detected and black smoke observed coming from the air vents. The vehicle was then turned off however within minutes of safely exiting all passengers from the vehicle, flames came out towards the passenger seat from underneath the glove box. An unsuccessful attempt was made to smother the flames with large wet towels before being successfully put out with the fire extinguisher. 911 was called and the fire department suspected the cause of the fire was the HVAC motor blower. The battery was disconnected and the car towed to the dealership where it has been for the past week. As of yesterday, according to the dealer, the source of the fire is thought to be a short circuit in the HVAC motor blower. The insurance is awaiting the fire report at this point.
NHTSA ODI #11431444
70,000 miles · Feb 13, 2020
Electrical SystemSteering
VEHICLE WAS 18 MONTHS OLD, MANUFACTURED IN JULY 2017, ISSUE AROSE IS DECEMBER 2019. THE POWER STEERING WENT OUT. WE WERE TOLD IT WAS DUE TO A CORRODED POSITIVE BATTERY CABLE. WE BOUGHT A WARRANTY BUT THE REPAIRS WERE NOT COVERED BY THE WARRANTY BECAUSE IT IS CONSIDERED A "MAINTENANCE ISSUE." THE REPAIRS COST ABOUT $1,000.
NHTSA ODI #11308995
54,000 miles · Oct 17, 2019
Electrical SystemPower Train
CAR WILL DOWNSHIFT TO 1ST GEAR, ENGINE RPM WILL GO TO 8000, AND LOSS OF POWER. THIS IS A MAJOR CONCERN WITH WINTER COMING ON, WHEN ONE TRAVELS ON ICE OR SNOW AND CAR DECIDES TO DOWNSHIFT, GUESS WHAT, ONE WILL WRECK!! HAS BEEN TO TWO DEALERSHIPS FOR A TOTAL OF 23 DAYS AND THEY CANT FIND ANYTHING. NO CODES ARE STORED. ALSO F…
Read full complaint
CAR WILL DOWNSHIFT TO 1ST GEAR, ENGINE RPM WILL GO TO 8000, AND LOSS OF POWER. THIS IS A MAJOR CONCERN WITH WINTER COMING ON, WHEN ONE TRAVELS ON ICE OR SNOW AND CAR DECIDES TO DOWNSHIFT, GUESS WHAT, ONE WILL WRECK!! HAS BEEN TO TWO DEALERSHIPS FOR A TOTAL OF 23 DAYS AND THEY CANT FIND ANYTHING. NO CODES ARE STORED. ALSO FROM TIME TO TIME WHEN STARTING ALL ELECTRICAL POWER WILL COME ON BUT NO START. TAKE KEY OUT WAIT A FEW MINUTES THEN KEY WORKS.
NHTSA ODI #11269089
27,000 miles · Sep 10, 2019
Electrical SystemFuel/propulsion SystemFire
09-10-19 MY 2017 FORD EXPEDITION HAS SHUT DOWN MULTIPLE TIMES WHILE DRIVING DOWN THE ROAD. THE DASHBOARD LIGHTS GO BLACK AND ALL POWER IS LOST, ENGINE, POWER STEERING ETC. I HAD THE VEHICLE TOWED TO THE DEALER ON 09-08-19. WHILE IT WAS BEING TOWED, THE ENGINE COMPARTMENT CAUGHT ON FIRE AND THE TOW TRUCK DRIVER HAD TO PUT OUT TH…
Read full complaint
09-10-19 MY 2017 FORD EXPEDITION HAS SHUT DOWN MULTIPLE TIMES WHILE DRIVING DOWN THE ROAD. THE DASHBOARD LIGHTS GO BLACK AND ALL POWER IS LOST, ENGINE, POWER STEERING ETC. I HAD THE VEHICLE TOWED TO THE DEALER ON 09-08-19. WHILE IT WAS BEING TOWED, THE ENGINE COMPARTMENT CAUGHT ON FIRE AND THE TOW TRUCK DRIVER HAD TO PUT OUT THE FIRE WITH AN EXTINGUISHER. FORTUNATELY, I DECIDED TO HAVE THE VEHICLE TOWED AS THIS ENTIRE EXPERIENCE IS A LIFE SAFETY MATTER.
NHTSA ODI #11254347
40,000 miles · May 22, 2019
Electrical System
TL* THE CONTACT OWNS A 2017 FORD EXPEDITION. THE CONTACT STATED THAT THE ELECTRONIC TOUCH SCREEN MONITOR FAILED TO OPERATE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.
NHTSA ODI #11209174
50,100 miles · Mar 6, 2019
Electrical SystemUnknown Or OtherVisibility/wiper
REAR WIDOW DEFROSTER TERMINAL FELL OFF OF RIGHT SIDE OF REAR GLASS, CREST FORD OF FLATROCK MICHIGAN REPLACED REAR GLASS ON 12/26/2017 UNDER WARRANTY. ON 01/28/2019 THE REAR WINDOW DEFROSTER TERMINAL FELL OF THE RIGHT SIDE OF THAT REAR GLASS AFTER13 MONTHS OF USE, AT THAT TIME I WAS OVER MY 36,000 MILE WARRANTY AND CONTACTED CRES…
Read full complaint
REAR WIDOW DEFROSTER TERMINAL FELL OFF OF RIGHT SIDE OF REAR GLASS, CREST FORD OF FLATROCK MICHIGAN REPLACED REAR GLASS ON 12/26/2017 UNDER WARRANTY. ON 01/28/2019 THE REAR WINDOW DEFROSTER TERMINAL FELL OF THE RIGHT SIDE OF THAT REAR GLASS AFTER13 MONTHS OF USE, AT THAT TIME I WAS OVER MY 36,000 MILE WARRANTY AND CONTACTED CREST FORD LOOKING FOR SOME HELP WITH THIS ISSUE. CREST FORD CONTACTED ME ABOUT A WEEK LATER AND STATED FORD MOTOR WOULD NOT COVER THE REPAIR. ON 03/01/2019 I APPEALED THIS DIRECTLY TO THE FORD MOTOR CO. CUSTOMER SERVICE AND WAS TOLD THEY WOULD NOT REPLACE THE GLASS AGAIN. ON 03/05/2015 I HAD A LOCAL GLASS SHOP REPLACE THE REAR WINDOW AT A COST OF $262.00. I FEEL THAT THIS IS A SAFETY ISSUE AND WANT TO KNOW IF THIS IS COMMON WITH THIS VEHICLE AND IS THERE ANY COMPLAINTS ABOUT THIS WITH FORD VEHICLES. ALSO I WOULD LIKE FORD MOTOR COMPANY TO REIMBURSE ME THE $262.00 DOLLARS I SPENT ON THE NEW REAR GLASS. WAS DRIVING VEHICLE BOTH TIMES WHEN THE TERMINAL FELL OFF THE GLASS, FIRST TIME THE DEFROSTER HAD JUST TURNED OFF AND THE SECOND TIME IT WAS ON.
NHTSA ODI #11184563
Official recalls
4Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
Apr 11, 2025
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence & remedy
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Aug 26, 2022
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Expedition and Lincoln Navigator vehicles. The front blower motor located behind the glove box may fail.
Consequence & remedy
Consequence: Front blower motor failure can increase the risk of a vehicle interior fire.
Remedy: Dealers will replace the front blower motor assembly, free of charge. Owner notification letters were mailed August 4, 2023. Remedy parts are expected to become available in the second quarter of 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S56.
Additional source detail variants (2)
Visibility:defroster/defogger/hvac System:fan/motor
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Expedition and Lincoln Navigator vehicles. The front blower motor located behind the glove box may fail.
Consequence: Front blower motor failure can increase the risk of a vehicle interior fire.
Remedy: Dealers will replace the front blower motor assembly, free of charge. Owner notification letters were mailed August 4, 2023. Remedy parts are expected to become available in the second quarter of 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S56.
Electrical System:wiring:interior/under Dash
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Expedition and Lincoln Navigator vehicles. The front blower motor located behind the glove box may fail.
Consequence: Front blower motor failure can increase the risk of a vehicle interior fire.
Remedy: Dealers will replace the front blower motor assembly, free of charge. Owner notification letters were mailed August 4, 2023. Remedy parts are expected to become available in the second quarter of 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S56.
Mar 11, 2022
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence & remedy
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Expedition, Lincoln Navigator, and 2016-2018 F-150 vehicles equipped with 3.5L Ecoboost engines. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A loss of brake fluid may result in a change in brake pedal travel, increased pedal effort and reduced front brake function, requiring greater effort and distance to stop the vehicle. These conditions can increase the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. An interim owner notification letter notifying customers of the safety defect were mailed on April 29, 2022. Owner notification letters were mailed April 29, 2022. This recall is an expansion of NHTSA recall number 20V-332. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S11.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration