IllustrationRight Rear Rancho Strut failed. Available till I return it. Could have lost control of vehicle. Confirmed by mechanic. Inspected by mechanic. No warnings at all. Discovered issue Feb 2026. Installed June 2021.
2008 Ford Expedition
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2008 Ford Expedition do not stand out strongly from the model-year median of 155.
About this comparison →How this year compares
Owner complaints by model year
Compare all Expedition years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
240–25K
2425–50K
2350–75K
2275–100K
14100–150K
10150K+
117 reports with mileage · 29 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
24 crash reports2 fire reports10 injury reports
Suspension complaints
6 reportsPAINT IS CHIPING FROM THE HOOD AND FROM THE TRUNK DOOR. THE OTHER PROBLEM IS THAT IT VIBRATES AT HIGH SPEEDS. IT DRIVES VERY SMOOTH, BUT ONCE I HIT ABOVE 70MPH ON THE HIGHWAY IT STARTS TO FEEL SHAKY. I CAN FEEL THE VIBRATION ON THE STEERING WHEEL.
AIR SHOCKS AND PUMP NEED REPLACING. VERY EXPENSIVE ALMOST FOUR THOUSAND. VEHICLE ONLY HAS 100, 000 MILES. VEHICLE IS VERY UNSTABLE.
WE PURCHASED THIS 2008 EXPEDITION LAST FALL WITH THE INTENSION OF TOWING A TRAILER ACROSS COUNTRY BECAUSE THEY CAME WITH HIGH REVIEWS AND COMFORT. WE FIRST NOTICED THE DRIFTING WHEN WE PICKED UP THE TRAILER. THE TRAILER FULLY LOADED IS ABOUT 6,200 POUNDS. WE HAVE A STABILIZER HITCH THAT WE USED TO TOW WITH. WE TOOK THE SUV I…
Read full complaint
WE PURCHASED THIS 2008 EXPEDITION LAST FALL WITH THE INTENSION OF TOWING A TRAILER ACROSS COUNTRY BECAUSE THEY CAME WITH HIGH REVIEWS AND COMFORT. WE FIRST NOTICED THE DRIFTING WHEN WE PICKED UP THE TRAILER. THE TRAILER FULLY LOADED IS ABOUT 6,200 POUNDS. WE HAVE A STABILIZER HITCH THAT WE USED TO TOW WITH. WE TOOK THE SUV INTO A DEALER TO HAVE IT CHECKED OUT. A MECHANIC SUGGESTED THAT THEY CHECK THE CAMBER'S. THE DEALER SAID ALL WAS FINE. WE TOOK IT ON A 7,000 MILE TRIP TOWING THE TRAILER AND IMMEDIATELY DISCOVERED THAT THE TOWING ABILITY WAS DANGEROUS. THE STEERING WHEEL WAS DIFFICULT TO CONTROL. IN ALL CASES, NO WIND OR WITH EVER THE SLIGHTEST WIND, THE VEHICLE WOULD DRIFT FROM SIDE TO SIDE AND THE TRAILER WOULD WOBBLE BACK AND FORTH MAKING IT EXHAUSTING TO STEER. WITH HIGH GUSTS IT WAS ALMOST IMPOSSIBLE TO STEER EVEN AT 45 MPH, IT WOULD DRIFT FROM SIDE TO SIDE MAKING IT EXTREMELY HARD TO CONTROL, AND THE TRAILER FISH-TAILING BEHIND US. IT WAS VERY DANGEROUS. WE COULD NOT GO OVER 55-60 MPH ON A WIND FREE DAY AND FEEL ANYWHERE SAFE. WE TOOK IT INTO THE SAME DEALER WHEN WE GOT BACK HOME AND THEY SAID THAT THEY DIDN'T SEE ANYTHING WRONG. WE TOOK IT INTO ANOTHER DEALER AND THEY ALSO TOOK IT FOR A TEST DRIVE AND SAID THEY COULD NOT SEE ANY PROBLEMS. THERE IS SOMETHING TERRIBLY WRONG WITH THIS SUSPENSION AND STEERING SYSTEM AND THE DEALERS CANNOT PUT A FINGER ON IT. THE STEERING WHEEL HAS A TENDENCY TO CAUSE THE SUV TO DRIFT WHILE DRIVING EVEN WITHOUT THE TRAILER. IT FEELS LOOSE. IT ALSO AT TIMES, HAS A KNOCK IN IT LIKE SOMETHING IS EITHER SNAPPING BACK IN OR SNAPPING OUT OF POSITION. WE ARE AT A LOSS AND DON'T KNOW WHERE TO TURN FOR HELP. WE LOVE THIS SUV OTHER THAN THESE DRIVING PROBLEMS THAT ARE DANGEROUS. *TR
THE COMPRESSOR FOR THE AIR SUSPENSION QUIT CAUSING THE AIR SUSPENSION TO FAIL. THIS MAKES THE VEHICLE UNDRIVEABLE. THIS IS A KNOWN DEFECT THAT HAS OTHER AFTERMARKET PARTS MANUFACTURERS MAKING RETROFIT KITS. *TR
INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) 2008 FORD EXPEDITION EL LIMITED 4 X 4. MY VEHICLE (AND MANY OTHERS FROM WHAT I HAVE READ ONLINE) TOWS HORRIBLY, WEAVES ALMOST UNCONTROLLABLY WHEN GETTING PASSED WHILE TOWING AND EVEN WHEN CLEAN, WILL ABRUPTLY TRY TO CHANGE LANES AND SW…
Read full complaint
INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) 2008 FORD EXPEDITION EL LIMITED 4 X 4. MY VEHICLE (AND MANY OTHERS FROM WHAT I HAVE READ ONLINE) TOWS HORRIBLY, WEAVES ALMOST UNCONTROLLABLY WHEN GETTING PASSED WHILE TOWING AND EVEN WHEN CLEAN, WILL ABRUPTLY TRY TO CHANGE LANES AND SWERVE ALL BY IT'S SELF WHEN IN A GUSTY CROSS WIND OR WHEN BEING PASSED BY OTHER VEHICLES. THERE WAS ANOTHER HUGE ROLL OVER ACCIDENT A FEW DAYS AGO WITH AN EXPEDITION WHILE TOWING AND AT LEAST THIS TIME NO ONE WAS KILLED. I HAVE HAD MY EL BACK TO THE DEALER AND THEY SAY IT'S FINE, BUT IT'S NOT. MY LAST TWO SUVS (DODGE) WERE AS SOLID AS A ROCK BUT THE EXPEDITION IS VERY DANGEROUS AND NEEDS TO BE INVESTIGATED. [XXX] *TR
Official recalls
308V166000 · Tires:pressure Monitoring And Regulating Systems
Apr 11, 2008
FORD IS RECALLING 158 MY 2008 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES EQUIPPED WITH A TIRE PRESSURE MONITORING SYSTEM (TPMS) AND THE LIMO BUILDERS PACKAGE FOR FAILING TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, Z"TIRE PRESSURE MONITORING SYSTEMS." THE TIRE PRESSURE WAS INCREASED FROM 35 PSI TO 40 PSI WITHOUT A COMMENSURATE UPDATE TO THE TPMS CALIBRATIONS.
Consequence & remedy
Consequence: THE TPMS INDICATOR LIGHT WILL NOT ILLUMINATE WHEN A TIRE PRESSURE IS IS 25% BELOW THE 40 PSI VALUE STATED ON THE TIRE PLACARD LABEL OCCURS.
Remedy: DEALERS WILL RECONFIGURE THE TPMS THRESHOLDS TO THE APPROPRIATE PRESSURES. THE RECALL BEGAN ON APRIL 23, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
08V058000 · Latches/locks/linkages:doors:latch
Feb 5, 2008
FORD IS RECALLING 123,632 MY 2007-2008 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES. THE DOOR HANDLE HOUSING EMBOSSMENT RETAINING THE BOTTOM OF THE INTERIOR DOOR HANDLE SPRING ON ALL SIDE DOORS MAY FRACTURE DURING NORMAL CUSTOMER USAGE. THIS CAN RESULT IN INSUFFICIENT SPRING FORCE TO RETURN THE HANDLE TO THE FULLY CLOSED POSITION. THE HANDLE MAY BE LOOSE CAUSING A RATTLE OR NOISE AND THE HANDLE MAY NOT RETURN TO THE FULLY CLOSED POSITION. THIS CONDITION MAY ALSO PROVIDE A DELAYED RESISTANCE WHEN ACTUATING THE HANDLE PRIOR TO OPENING THE DOOR.
Consequence & remedy
Consequence: IN THE EVENT OF A SIDE IMPACT CRASH, THE INTERIOR DOOR HANDLE MAY CAUSE THE DOOR LATCH TO OPEN INCREASING THE RISK OF INJURY TO A VEHICLE OCCUPANT.
Remedy: DEALERS WILL REPLACE THE INTERIOR HANDLE SPRING ON ALL SIDE DOORS. THE RECALL BEGAN ON MARCH 5, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
07V541000 · Air Bags:frontal:driver Side:inflator Module
Nov 21, 2007
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS SPECIFIED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE DRIVER AIR BAG MODULE MAY NOT HAVE BEEN PROPERLY ASSEMBLED.
Consequence & remedy
Consequence: THIS CONDITION MAY PREVENT THE DRIVER AIR BAG FROM PROPERLY DEPLOYING AND REDUCE OCCUPANT PROTECTION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE YOUR DRIVER AIR BAG MODULE FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 20, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO