2018 Ford Escape

The contact owns a 2018 Ford Escape. The contact stated that the vehicle was leaking fluid. The contact stated that the coolant level was very low, and the engine hot message was displayed. The vehicle was taken to the local dealer, who was unable to identify the source of the leak. A dye was placed in the cooling system, and the contact was informed not to add coolant. While driving at an undisclosed speed, the contact became aware that there was not enough coolant in the coolant reservoir. The driver added coolant. The vehicle was taken back to the local dealer, where it was diagnosed that there was damage to the undercarriage and that air pockets needed to be released from the system. The vehicle was repaired, but the failure persisted. The contact became aware of a fluid leak. The vehicle was taken back to the local dealer, where it was diagnosed and determined that the water pump, timing belt, and cooling lines needed to be flushed; additionally, the thermostat needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred to the NHTSA Hotline for assistance. The failure mileage was unknown.

Engine light came on. I took it to repair shop, they inspected and told me there is a Coolant leak in the Combustion Chamber and I, eventually will have to replace they engine.Therefore, in the County I currently live in, the vehicle will not pass required Emission Test and I will not be able to renew registration. The car is 2018 Ford Escape with only 46,413 miles with perfect service record.

The contact owns a 2018 Ford Escape. The contact stated while driving at an undisclosed speed, the temperature gauge indicated that the vehicle was overheating, after which the vehicle entered LIMP Mode and lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, who determined that coolant intrusion had damaged the engine. The contact was informed that a replacement engine was required. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion). The manufacturer was notified of the failure, and a case was opened. The failure mileage was 89,000.

The contact owns a 2018 Ford Escape. The contact stated while attempting to start the vehicle, there was a rattling sound coming from the vehicle. The vehicle was taken to a local dealer who diagnosed and determined that the coolant level was low. The contact was informed that the head gasket was leaking coolant into cylinder #1. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.

The contact owns a 2018 Ford Escape. The contact stated that while operating the vehicle, the check engine warning light remained illuminated, and the vehicle lost motive power and stalled. The vehicle was towed to the local dealer who diagnosed the vehicle and determined that coolant was present inside the engine and had caused severe engine damage. The contact was advised that the engine needed to be replaced. The vehicle was not yet repaired. The contact stated that the engine was previously replaced for similar failure. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The failure mileage was 28,000.

The contact owns a 2018 Ford Escape. The contact stated that while driving at various speeds, the check engine warning light illuminated. The contact inspected the coolant reservoir and became aware that it was empty. The contact refilled the coolant; however, after attempting to drive the vehicle, the check engine warning light illuminated again. The vehicle was taken to an independent mechanic who determined that the coolant gasket was leaking. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 107,000.

I received my car back from All Star Ford on [XXX] with a rebuilt transmission installed. Since the repairs were under warranty I only had to pay $100 out of pocket. The following week I took the car in to have an oil change. The car seemed to run fairly well until [XXX]. The car started to make a strange rattling noise and a notification popped up saying that I needed to get an oil change soon. I thought this to be pretty strange as I had just got an oil change in April 2024 after I received the car back. I decided to take the car to get an oil change on [XXX] in which comments were noted that there was a major oil leak present and transmission fluid leaking as well. The following day on [XXX], as I was out and about, the car started to make the rattling noise louder as I started the car. I shifted the car in reverse to back out of a parking spot and then when I shifted into drive the car would not accelerate. I shifted into park and attempted to start the car again and it shut off and would not move. I had the car towed to All Star Ford same day and dropped the keys in the drop box because they were closed. I called again on [XXX] and was informed that the system had shut down at the shop and they could not get the approval from Ford Corporation to fix the issue. He stated that the mechanic diagnosed that the plate between the transmission and the engine was cracked and needed to be replaced. He estimated that he would be able to get the approval by 07/05/2024 and order the other parts since the shop had majority of the parts to replace again. He informed me that the repairs were still under warranty. I called on 07/10/2024 to check the progress of the repairs and Frank informed me that they are currently working on vehicle and will update me. I called on 07/12/2024 and left Frank a message for follow-up. Frank called me back and stated that there are more issues with the car which includes fixing additional items such as the torque. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S

The contact owns a 2018 Ford Escape. The contact stated that while her husband was driving at undisclosed speeds, the vehicle shuddered abnormally. The contact stated that during the failure, there was a cloud of white smoke coming from the exhaust pipes. The contact stated that the instrument panel indicated that the engine was overheating. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the coolant and engine oil were mixing, due to coolant intrusion, causing engine failure. The dealer was unable to specify the location of the leak. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and it was confirmed that the VIN was not under recall or Warranty. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 61,000.

Engine due to coolant intrusion to cylinders. Car hesitates to go, stalls out, hard to start TSB was released for this issue. The car is at a Ford dealer and now needs a full engine replacement The engine light came on at 102000 miles issues started at 56000 reported to the dealer but never fixed 2 ford dealers didn't follow TSB issues 19-2375 to do repairs while under warranty. Now over 100000, they want me to pay for repair after it has been reported to them for the last 50000 miles, and a TSB released matches the issues I reported