2016 Ford Escape

The contact owns a 2016 Ford Escape. The contact stated that while stopped on several occasions, the vehicle was idling rough. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that there was a misfire in cylinder #1. The vehicle was not repaired. The contact stated that an undisclosed DTC code was reset however, approximately a week later the code reappeared. The engine then started overheating and coolant was added to the coolant reservoir was administered. The manufacturer was notified of the failure. The failure mileage was approximately 120,000.

The contact owns a 2016 Ford Escape. The contact stated that while driving at an undisclosed speed, the vehicle intermittently hesitated while accelerating. The check engine warning light was illuminated. The vehicle was taken to the dealer, who determined that the engine block was cracked, and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 150,000.

Ford is aware of a design flaw with the 2.0 Ecoboost engines. It impacts Escapes, Fusions, Edges, and some Lincoln vehicles. They issued TSB # 22-2229 about this. According to Ford, the only fix is to replace the engine. The engine block has a design flaw that causes the head gasket to blow and cause severe coolant leakage into either cylinder 2 or 3. Ford says to replace the Long block. My vehicle had less than 70k miles on it and started having issues just a month or so after the warranty expired. An engine should last much longer than this. Now our vehicle may be worth $500 instead of about $9,000. Ford knows this is an issue and there is significant information on the Internet about this. Ford should have been forced to recall these engines. From a safety standpoint, our engine fails to start at times. The cylinder is so full of coolant at times, the engine won't turn over for a while. We have to keep bumping the starter to get it to finally turn over. We purchased this vehicle new from a Ford dealership. The vehicle is otherwise in excellent condition and has had the oil changed every 4,000 miles, much less miles than required by Ford.

My car overheated when I pulled over I noticed my engine coolant low. I had a mechanic add more fluids then a day later car shuts off why I was going 65 on a highway . I was pushing down on the gas peddle but my car would not go. It was barely moving no matter how far I pushed gas peddle. I finally found a somewhat area to pull over . I almost died or was seriously injuried in a few close call accidents this day. Had someone look at it from a garage in town he said it was a fuse and a cylinder misfire. No engine light no issues then my car over heated again no warning just shut down but the car still on Emmy lights didn’t work my turn signals didn’t work . Then my car stopped dead in a busy roadway over heated smoking . Now I’m time I need an engine replacement Let me add my car only has 60000 miles on it and is in great maintained condition I am a single mother of 3 young kids and take care of my mom. Not employed due to a bad relationship and trying to get back on my feet and now this . Coolest leaks into cylinder causing over heating and catastrophic engine damage , so upset over this and ford won’t even diagnose my car with out a 200 dollar charge to start with . It’s pathetic

65,000 miles, coolant intrusion into #1 cylinder confirmed by Ford service center. First signs were Check Engine Light, rough idle. Replaced all spark plugs and coils. Check engine light returned the following day with loss of coolant in tank. Engine runs rough and overheats with coolant loss and continued intrusion into engine, endangering occupants

Throttle body and motor was replaced twice due to engine keep stalling issues on the roads intermittently. Had faced life threatening occasions multiple times because the car engine stalled while car was driving on the roads. I brought the car to the local Ford service center several times and got the DTC P2112 code each visit. Ford service center approved the throttle body replacement on 2/10/2020 (car mileage 26688) but the same issue came back a few months later. P2112 was detected again on 4/30/2023 (mileage 40215) It was not very frequent but it happened once per month or every other month. I brought this car once again to the same local Focal service center and they diagnosed the throttle body and motor to be defect again (mileage 46476) and replaced it on 10/15/2024.