NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,974 reports75,000 miles · Sep 3, 2014
Power TrainVehicle Speed Control
TWO DAYS AGO, I WAS DRIVING ON THE HIGHWAY AND SUDDENLY, MY GEARS STARTED SLIPPING. I WAS DRIVING 45 MPH AND THEN MY CAR DECELERATED TO THE POINT WHERE I COULD NO LONGER ACCELERATE. THIS MADE IT VERY DIFFICULT TO GET BACK HOME AND I FEARED THAT I WOULD BE AT RISK FOR A CRASH. IMMEDIATELY THE NEXT MORNING, I BROUGHT MY CAR TO A…
Read full complaint
TWO DAYS AGO, I WAS DRIVING ON THE HIGHWAY AND SUDDENLY, MY GEARS STARTED SLIPPING. I WAS DRIVING 45 MPH AND THEN MY CAR DECELERATED TO THE POINT WHERE I COULD NO LONGER ACCELERATE. THIS MADE IT VERY DIFFICULT TO GET BACK HOME AND I FEARED THAT I WOULD BE AT RISK FOR A CRASH. IMMEDIATELY THE NEXT MORNING, I BROUGHT MY CAR TO A FORD DEALER AND THEY DIAGNOSED THE PROBLEM TO BE WITH THE TRANSMISSION. MY OPTIONS WERE TO FIX ONE BAND OR THE ENTIRE TRANSMISSION. UPON DOING RESEARCH ABOUT THIS ISSUE, I FOUND THAT MANY OTHER FORD CUSTOMERS HAD EXPERIENCED THE SAME PROBLEMS WITH THEIR 2008 FORD ESCAPE'S TRANSMISSION. *TR
NHTSA ODI #10630525
93,000 miles · Sep 2, 2014
Air BagsEngineSteering
TL* THE CONTACT OWNS A 2008 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THE AIR BAG AND CHECK ENGINE WARNING LIGHTS ILLUMINATED CONTINUOUSLY. IN ADDITION, THE VEHICLE BEGAN SHAKING. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTS…
Read full complaint
TL* THE CONTACT OWNS A 2008 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THE AIR BAG AND CHECK ENGINE WARNING LIGHTS ILLUMINATED CONTINUOUSLY. IN ADDITION, THE VEHICLE BEGAN SHAKING. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V284000 (STEERING) AND AFTER THE RECALL REPAIR, THE FAILURES OCCURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 93,000.
NHTSA ODI #10630210
22,000 miles · Aug 29, 2014
Electronic Stability Control (esc)Service Brakes
WHILE DRIVING MY FRONT WHEEL DRIVE FORD ESCAPE ON A TRIP THE ABS AND STABILITY CONTROL LIGHTS BOTH CAME ON. THIS DID NOT INITIALLY CAUSE ANY PROBLEMS WITH NORMAL BRAKING WHILE DRIVING IN DRY CONDITIONS. AT THE END OF THE TRIP THE ABS SYSTEM ACTIVATED ON EVERY STOP, SIGNIFICANTLY REDUCING STOPPING DISTANCE ON DRY GROUND. MY INVES…
Read full complaint
WHILE DRIVING MY FRONT WHEEL DRIVE FORD ESCAPE ON A TRIP THE ABS AND STABILITY CONTROL LIGHTS BOTH CAME ON. THIS DID NOT INITIALLY CAUSE ANY PROBLEMS WITH NORMAL BRAKING WHILE DRIVING IN DRY CONDITIONS. AT THE END OF THE TRIP THE ABS SYSTEM ACTIVATED ON EVERY STOP, SIGNIFICANTLY REDUCING STOPPING DISTANCE ON DRY GROUND. MY INVESTIGATION FOUND THE FOLLOWING: RUSTING OF THE DRIVESHAFT SURFACE APPARENTLY CAUSED OUTWARD PRESSURE ON THE INSIDE OF THE FRONT RIGHT ABS TONE RING RESULTING IN IT SEPARATING IN ONE SPOT. THIS PROBABLY CREATED A ERROR IN THE MONITORING BY THAT ABS SENSOR RESULTING IN THE LIGHTS COMING ON. THE RING MAY HAVE HELD FAST TO THE RUST UNDER THE REMAINDER OF THE RING DURING MOST OF MY TRIP CAUSING NO OTHER PROBLEMS. NEAR THE END OF MY TRIP THE CRACKED RING APPEARS TO HAVE SHAKEN FREE, SLIPPING ON THE ROTATING DRIVESHAFT SURFACE. THIS MAY HAVE MADE THE SENSOR THINK THE WHEEL WAS NOT TURNING AND APPLIED THE ABS TO THAT WHEEL EACH TIME THE BRAKES WERE APPLIED. THE DANGER THEN BECAME INCREASED STOPPING DISTANCE ON DRY GROUND AND UNKNOWN PERFORMANCE ON SLIPPERY SURFACES. IN CHECKING AROUND, THIS APPEARS TO BE A COMMON PROBLEM AND THE OTHER RING WILL CRACK EVENTUALLY DUE TO SIMILAR RUSTING. REPAIRING THIS REQUIRES THE RING TO BE REPLACED AND POSSIBLY THE DRIVESHAFT SECTION IT IS MOUNTED ON. *TR
NHTSA ODI #10629467
150,000 miles · Aug 28, 2014
Power Train
WHILE ACCELERATING TO GET ONTO THE HIGHWAY, I NOTICED THE ENGINE WAS REVVING BUT OUR SPEED WASN'T INCREASING AND IT SEEMED AS THOUGH IT WASN'T GOING INTO GEAR. FINALLY ONCE IT DID SHIFT THE WRENCH INDICATOR LIGHT CAME ON. AFTER TAKING IT TO THE REPAIR SHOP TO HAVE IT EVALUATED I WAS TOLD THAT THE BANDS FOR 2ND AND 4TH GEAR WERE …
Read full complaint
WHILE ACCELERATING TO GET ONTO THE HIGHWAY, I NOTICED THE ENGINE WAS REVVING BUT OUR SPEED WASN'T INCREASING AND IT SEEMED AS THOUGH IT WASN'T GOING INTO GEAR. FINALLY ONCE IT DID SHIFT THE WRENCH INDICATOR LIGHT CAME ON. AFTER TAKING IT TO THE REPAIR SHOP TO HAVE IT EVALUATED I WAS TOLD THAT THE BANDS FOR 2ND AND 4TH GEAR WERE BUSTED AND I'D NEED A NEW OR REBUILT TRANSMISSION INSTALLED. I WON'T EVER BUY ANOTHER FORD AFTER SEEING ALL OF THE OTHER REPORTS ON THIS AND KNOWING THAT THEY AREN'T ISSUING A RECALL TO FIX THIS PROBLEM. THIS CAN BE REAL DANGEROUS IF SOMEONE IS COMING AT YOU AND YOU CAN'T GET OUT OF THE WAY FAST ENOUGH! I'M TAKING THE LOSS AND TRADING IT IN ON SOMETHING MORE RELIABLE. *TR
NHTSA ODI #10629136
133,000 miles · Aug 27, 2014
Service Brakes
TL* THE CONTACT OWNS A 2008 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE ABS LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10628729
100,000 miles · Aug 25, 2014
Steering
POWER STEERING WOULD FAIL OFTEN. AT FIRST IT WOULD NOT WORK RIGHT AFTER VEHICLE WAS STARTED. AFTER SHUTTING DOWN AND RESTARTING IT WOULD OFTEN KICK BACK IN AND WORK. IT PROGRESSIVELY GOT WORSE AND ABOUT 2 WEEKS AFTER INITIAL INCIDENT IT WOULD OFTEN FAIL WHILE TRAVELING ON THE HIGHWAY AT SPEEDS UP TO 70 MPH. THIS IS MY WIFE'S…
Read full complaint
POWER STEERING WOULD FAIL OFTEN. AT FIRST IT WOULD NOT WORK RIGHT AFTER VEHICLE WAS STARTED. AFTER SHUTTING DOWN AND RESTARTING IT WOULD OFTEN KICK BACK IN AND WORK. IT PROGRESSIVELY GOT WORSE AND ABOUT 2 WEEKS AFTER INITIAL INCIDENT IT WOULD OFTEN FAIL WHILE TRAVELING ON THE HIGHWAY AT SPEEDS UP TO 70 MPH. THIS IS MY WIFE'S PRIMARY VEHICLE AND IF SOMETHING WERE TO HAPPEN AND THE POWER STEERING FAILED AT THOSE SPEEDS SHE WOULD NOT HAVE THE STRENGTH TO PROPERLY MANEUVER THE VEHICLE OUT OF DANGER. *TR
NHTSA ODI #10627997
77,320 miles · Aug 13, 2014
Vehicle Speed Control
I WAS DECELERATING TO A RED LIGHT, WHEN MY ACCELERATOR DEPRESSED AND STUCK TO THE FLOOR ON IT'S OWN, I HAD TO SHUT THE IGNITION OFF AND COAST INTO THE GAS STATION TO GET THE VEHICLE TO COME TOO A STOP. I TOOK IT TO ANDY MOHR FORD AND WAS TOLD IT NEEDS A NEW ELECTRONIC THROTTLE BODY, WHICH IS A 600.00 REPAIR. I BOUGHT MY ESCAPE…
Read full complaint
I WAS DECELERATING TO A RED LIGHT, WHEN MY ACCELERATOR DEPRESSED AND STUCK TO THE FLOOR ON IT'S OWN, I HAD TO SHUT THE IGNITION OFF AND COAST INTO THE GAS STATION TO GET THE VEHICLE TO COME TOO A STOP. I TOOK IT TO ANDY MOHR FORD AND WAS TOLD IT NEEDS A NEW ELECTRONIC THROTTLE BODY, WHICH IS A 600.00 REPAIR. I BOUGHT MY ESCAPE USED SO THERE IS NO WARRANTY NOR COULD I AFFORD THIS REPAIR. I RESEARCHED THE ISSUE AND FOUND A RECALL FOR THE ELECTRONIC THROTTLE BODY, BUT WAS TOLD BY ANDY MOHR, THE RECALL DOESN'T APPLY TO MY SPECIFIC BUILD. I THEN CONTACTED FORD CORPORATE AND OPENED A CLAIM WITH THEM, I WAS TOLD THEY WOULD TAKE CARE OF IT ( BECAUSE IT'S A MANUFACTURES DEFECT AND A SAFETY ISSUE )AND WAS REFERRED BACK TO ANDY MOHR THIS TIME I SPOKE WITH THE CUSTOMER SERVICE MANAGER AND TOLD THE SANE THING, THAT BECAUSE I DON'T HAVE A WARRANTY,, THE REPAIR ISN'T COVETED AND I'M THEREFORE RESPONSIBLE FOR THE COST OF REPAIR. THIS CAN'T BE RIGHT OR LEGAL, THIS PROBLEM POSES A SAFETY RISK TO MYSELF AND MY FAMILY AS WELL AS MY FELLOW DRIVERS I COULD POTENTIALLY HURT OR KILL WHEN THIS ACCELERATOR DECIDES TO DEPRESS AND STICK AGAIN. *TR
NHTSA ODI #10622080
626,998 miles · Aug 13, 2014
Steering
WHILE DRIVING 2008 FORD ESCAPE ELECTRICAL STEERING WOULD QUIT WORKING WHILE DRIVING DOWN THE ROAD AND GO INTO MANUAL STEERING MODE. IF THE VEHICLE WAS STOPPED AND RESTARTED THE ELECTRICAL STEERING WOULD WORK. CHECKED TO SEE IF THE VEHICLE HAD A RECALL FOR THE STEERING PROBLEM ONLINE AND THE VEHICLE DID. RECEIVED RECALL NOTICE F…
Read full complaint
WHILE DRIVING 2008 FORD ESCAPE ELECTRICAL STEERING WOULD QUIT WORKING WHILE DRIVING DOWN THE ROAD AND GO INTO MANUAL STEERING MODE. IF THE VEHICLE WAS STOPPED AND RESTARTED THE ELECTRICAL STEERING WOULD WORK. CHECKED TO SEE IF THE VEHICLE HAD A RECALL FOR THE STEERING PROBLEM ONLINE AND THE VEHICLE DID. RECEIVED RECALL NOTICE FOR 2008 FORD ESCAPE ELECTRICAL STEERING FAILURE RECAL # 14S05. TOOK THE 2008 IN FOR REPAIRS AT ED KOEHN FORD DEALERSHIP IN WAYLAND, MICHIGAN FOR REPAIRS. MECHANIC STATED THAT STEERING HAD TO BE REPROGRAMMED. NOW AFTER THE FIX (PROGRAMING) VEHICLE STEERING WHEEL SHAKES WHILE NOT IN MOTION WHILE PARKED. UNABLE TO USE VEHICLE. FORD STATES THAT VEHICLE HAS BEEN FIXED AS FAR AS THEY ARE CONCERNED. DEALERSHIP CONTACTED FORD SPECIAL SERVICES FOR THE SHAKING STEERING (WHILE THE VEHICLE IS SITTING MOTIONLESS) AND DEALERSHIP ADVISED THAT THIS WOULD NOT BE COVERED UNDER THE RECALL. THE STEERING WHEEL DID NOT SHAKE UNTIL FORD MADE THE REPAIR FOR THE RECALL. I HAVE CONTACTED FORD CUSTOMER SERVICE TWICE (1-800-392-3673) WHICH STILL ADVISES IT IS NOT RELATED TO THE RECALL. CASE #5055156-F5P7BQ. THE RECALL STATES THAT ALTERNATIVELY, THE DEALER MAY HAVE TO REPLACE THE TORQUE SENSOR OR THE STEERING COLUMN. IN THIS CASE, SINCE THE REPROGRAMMING DID NOT WORK THE STEERING COLUMN SHOULD HAVE BEEN CHANGED. THE VEHICLE WAS NOT PROPERLY REPAIRED. IT APPEARS TO BE A CHEAP FIX BY FORD AT MY EXPENSE. NOW FORD WANTS $950 TO MAKE THE REPAIR WHICH SHOULD HAVE BEEN COVERED AT NO COST UNDER THE RECALL. *TR
NHTSA ODI #10622017
Mileage unknown · Aug 13, 2014
Steering
2008 FORD ESCAPE. CONSUMER WRITES IN REGARDS TO POWER STEERING SYSTEM RECALL NOTICE. *SMD THE CONSUMER STATED IT WAS DIFFICULT TO MAKE AN APPOINTMENT. SHE CALLED THREE DEALERSHIPS, AND THEY ALL HAD SOME TYPE OF ISSUE. RECALL # 14V284000.
NHTSA ODI #10621660
11,000 miles · Aug 12, 2014
Vehicle Speed Control
THIS MORNING DRIVING TO WORK, AGAIN....MY GAS PEDAL STUCK...WAS GOING 50 TO 1 MPH IN A SECOND. I HAVE HAD MY 2008 FORD ESCAPE BACK TO THE DEALER THREE DIFFERENT TIMES SINCE I PURCHASED IT IN 2009 AND THEY STATED...THEY COULD NOT "REPLICATE" THE ISSUE. I HAVE JUST LEARNED ON 8/12/14 THERE IS A RECALL ON THE THROTTLE AND I HOPE TH…
Read full complaint
THIS MORNING DRIVING TO WORK, AGAIN....MY GAS PEDAL STUCK...WAS GOING 50 TO 1 MPH IN A SECOND. I HAVE HAD MY 2008 FORD ESCAPE BACK TO THE DEALER THREE DIFFERENT TIMES SINCE I PURCHASED IT IN 2009 AND THEY STATED...THEY COULD NOT "REPLICATE" THE ISSUE. I HAVE JUST LEARNED ON 8/12/14 THERE IS A RECALL ON THE THROTTLE AND I HOPE THEY HONOR THE RECALL. THIS HAS BEEN A VERY SCARY SITUATION OVER THE YEARS, WHERE MY LIFE WAS PUT IN DANGER AND ALL I HAVE BEEN TOLD IS THAT THEY CANNOT "REPLICATE" THE ISSUE WHEN THE VEHICLE WAS IN EACH TIME SOON AFTER IT HAPPENED. I AM CALLING MY LOCAL FORD DEALER NOW! *TR
NHTSA ODI #10621618
Official recalls
3Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
May 29, 2014
Ford Motor Company (Ford) is recalling certain model year 2008-2011 Ford Escape and Mercury Mariner vehicles manufactured August 18, 2006, through September 11, 2010. The affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. As a result, the system could remove the Electric Power Steering (EPS) assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will update the software for the power steering control module (PSCM) and the instrument cluster module, free of charge. If a vehicle shows a history of a loss of the torque sensor signal or fault codes relating to the PSCM when the vehicle is brought in for the recall remedy, the affected components will be replaced, free of charge. The recall began on July 18, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S05.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP15001 · Loss Of Power Steering While Driving
Opened Apr 1, 2015 · Closed Jun 14, 2018
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equipped with electric power assisted steering (NHTSA 14V-284, Ford 14S05). Ford's DIR described the defect condition as a poor signal to noise ratio [SNR] in the torque sensor within the Electric Power Assisted Steering (EPAS) system [which] does not allow the PSCM to determine the driver's steering input. When the system detects this fault condition, it transitions the EPAS system to the fail-safe/manual steering mode.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Ford's remedy instructs dealers to check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTCs) to determine the proper repair procedure. If no DTCs are present, dealers are to update the PSCM and instrument cluster module software. The updated PSCM software changes the torque sensor fault strategy so that the SNR condition does not result in a loss of power steering assist while driving.In addition, audible and visual warnings are provided for torque sensor faults.If DTCs indicating faults in the torque sensor, PSCM or Power Steering Motor (motor) are present in the initial recall inspection, the dealer performs the following repairs: 1) replaces the torque sensor for torque sensor faults (DTC B2278); or 2) replaces the steering column for faults related to the PSCM (DTC B1342) or motor (DTC B2277).Continued in attachment pages
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
Illustration