Steering. Review the 1,127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 329 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 175 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

59 crash reports6 fire reports36 injury reports

Steering complaints

1,127 reports

Clear category filter

101,500 miles · Apr 2, 2014

Steering

I WAS DRIVING IN TOWN AND ALL OF A SUDDEN MY POWER STEERING LOCKED UP AND WOULD NOT RELEASE. USUALLY IF YOU PUT THE CAR IN PARK, SHUT IT OFF, LET IT SIT FORE AWHILE THEN START IT BACK UP IT WELL EVENTUALLY RELEASE. HOWEVER, IT HAPPENS REGULARLY AND IS A DANGEROUS THING TO HAVE HAPPEN SUDDENLY. *TR

NHTSA ODI #10576998

86,000 miles · Apr 2, 2014

Steering

Read full complaint

I WAS ATTEMPTING TO LEAVE A GAS STATION WHEN THE POWER STEERING FAILED. TURNED THE VEHICLE OFF FOR ABOUT 10 SECONDS, THEN ON AGAIN. STILL NO POWER STEERING. WITH GREAT DIFFICULTY AND WITH NO POWER STEERING, BACKED AWAY FROM THE GAS PUMP TO AN OUT-OF-THE-WAY AREA. TURNED THE VEHICLE OFF THEN ON AGAIN. POWER STEERING RETURNED. I CHECKED ONLINE TO FIND THAT OTHER FORD/ESCAPE OWNERS HAVE EXPERIENCED THE SAME THING. IT ALSO HAPPENED AGAIN TWO WEEKS LATER AT ANOTHER LOCATION. *TR

NHTSA ODI #10576582

75,000 miles · Apr 1, 2014

SteeringCrash

POWER STEERING STOPPED WORKING WHILE TURNING CORNER--CAR HIT MAIL BOX @ 10MPH. POWER STEERING GOES OUT ANYTIME. *TR

NHTSA ODI #10576548

79,000 miles · Apr 1, 2014

Electrical SystemSteering

WHEN I START THE IGNITION EN VARIOUS OCCASIONS I DON'T HAVE POWER STEERING I HAVE TO TURN THE IGNITION ON AND OFF MULTIPLE TIMES UNTIL I REGAIN POWER STEERING. WHILE I'M DRIVING MY STEERING WHEEL STARTS TREMBLING AND SHAKING. WHEN THAT OCCURS AND I COME TO A STOP I LOOSE MY POWER STEERING. I HAVE TO TURN THE IGNITION ON AND OFF …

Read full complaint

NHTSA ODI #10576379

146,000 miles · Apr 1, 2014

Steering

WHILE DRIVING AT HIGHWAY SPEEDS THE STEERING WHEEL BEGAN TO PULL AND SHAKE TO THE LEFT AND RIGHT. THE POWER STEERING ALSO SHUTS OFF ENTIRELY WHILE DRIVING, AND RANDOMLY WHEN STARTING THE CAR. THE CAR IS INCREDIBLY DIFFICULT TO STEER WHEN THIS OCCURS, MAKING IT ALMOST IMPOSSIBLE FOR ME TO DRIVE. SHUTTING OFF AND RESTARTING THE…

Read full complaint

NHTSA ODI #10576290

122,000 miles · Mar 31, 2014

Steering

Read full complaint

THIS IS THE FOURTH TIME THAT THE POWERING STEERING HAS GONE OUT ON MY ESCAPE. I HAVE REPORTED THE OTHER INCIDENTS AS WELL. JUST IMPATIENTLY WAITING FOR FORD TO RECALL THIS ISSUE THAT IS LIFE THREATENING!! THESE LAST TWO TIMES HAVE BEEN AT A LOW RATE OF SPEED THANK GOODNESS! ITS REALLY SCARY WHEN THE STEERING GOES OUT WHILE DRIVING. I REALLY LIKE MY VEHICLE BUT I THINK I AM GOING TO TRADE IT SO DRIVING WILL BE LESS STRESSFUL FOR ME, EVEN THOUGH I HAVE INVESTED THOUSANDS OF DOLLARS IN THIS VEHICLE. FORD SUCKS AND NEEDS TO HELP SAVE LIVES... I WILL NOT BUY FORD AGAIN, THIS NEGLECT REALLY MAKES ME ANGRY! *TR

NHTSA ODI #10576005

82,000 miles · Mar 26, 2014

Steering

Read full complaint

TL* THE CONTACT OWNS A 2008 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE POWER STEERING ASSIST SUDDENLY MALFUNCTIONED AS THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN. THE CONTACT STOPPED THE VEHICLE AND TURNED THE ENGINE OFF. AFTER RESTARTING THE ENGINE THE VEHICLE OPERATED NORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE STEERING COLUMN WAS FAULTY AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. NO ADDITIONAL INFORMATION WAS AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 82,000.

NHTSA ODI #10574947

107,000 miles · Mar 26, 2014

Steering

MY ESCAPE HAD A FAULTY POWER STEERING SENSOR OR STEERING COLUMN THAT WOULD ALLOW THE POWER STEERING TO STOP WORKING AT UNKNOWN TIMES. THIS HAPPENED SEVERAL TIMES WHILE DRIVING AND AFFECTED THE WAY THE CAR WOULD STEER. I HAD TO REPLACE THIS AT THE FORD DEALERSHIP AT A COST OF $1,200 TO ME. THIS SHOULD BE A RECALL ITEM THAT FOR…

Read full complaint

NHTSA ODI #10574916

90,000 miles · Mar 26, 2014

Steering

Read full complaint

WHILE DRIVING IN REGULAR TRAFFIC, I NOTICED THAT MY STEERING WHEEL WOULD SHUDDER WHEN STOPPED. AFTER PARKING, SHUTTING OFF CAR, AND THEN RETURNING, MY CAR HAD LOST ITS POWER STEERING. IT HAS INTERMITTENTLY RETURNED AFTER TURNING CAR. OFF/ON, BUT IT IS HAPPENING MORE OFTEN. QUICK INTERNET SEARCH LISTED VERY SIMILAR ISSUES AND SYMPTOMS. ALL POINTING TOWARDS THE ELECTRONIC STEERING ASSEMBLY. WHICH LOOKS LIKE IT COSTS NEARLY $1400 TO FIX USUALLY. I FIND THIS EXTREMELY DANGEROUS AND WILL NOT BE HAVING MY WIFE OR CHILD IN THIS VEHICLE. *TR

NHTSA ODI #10574851

126,000 miles · Mar 26, 2014

Steering

Read full complaint

WITHOUT WARNING, THE POWER STEERING ON MY 2008 FORD ESCAPE SIMPLY WENT OUT. I HAD NO ISSUES OR INDICATION THAT THE STEERING WAS ABOUT TO FAIL AND SUDDENLY, THE POWER STEERING SIMPLY STOPPED WORKING. FORTUNATELY, THIS LOSS OF POWER STEERING DIDN'T RESULT IN A CRASH IN MY CASE. I QUICKLY SCHEDULED AN INSPECTION AT THE FORD DEALERSHIP AND THEY CONFIRMED THAT THE POWER STEERING HAD IN FACT FAILED. IN RESEARCHING THIS ISSUE ON THE INTERNET, I HAVE FOUND SCORES OF OTHER PEOPLE WITH THE SAME ISSUE. I DISCOVERED THAT FORD HAD CHANGED FROM A HYDRAULIC POWER STEERING SYSTEM TO AN ELECTRIC SYSTEM STARTING IN 2008. CLEARLY THIS SYSTEM IS DEFECTIVE AND SHOULD BE LOOKED INTO IMMEDIATELY. I WAS LUCKY NOT TO HAVE HAD AN ACCIDENT BUT ONE DAY SOME ONE WILL BE KILLED WHEN THIS SYSTEM FAILS AGAIN. DON'T LET THIS TURN INTO ANOTHER ISSUE LIKE IS CURRENTLY HAPPENING WITH GM IGNITIONS AND LIVES ARE LOST. *TR

NHTSA ODI #10574849

Official recalls

15V606000 · Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:floor Shift

Sep 29, 2015

Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.

Consequence & remedy

Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.

Additional source detail variants (2)

Power Train:automatic Transmission:lever And Linkage:floor Shift

Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.

Power Train:automatic Transmission:gear Position Indication (prndl)

14V526000 · Hybrid Propulsion System

Sep 3, 2014

Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.

Consequence & remedy

Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.

14V284000 · Steering:electric Power Assist System

May 29, 2014

Ford Motor Company (Ford) is recalling certain model year 2008-2011 Ford Escape and Mercury Mariner vehicles manufactured August 18, 2006, through September 11, 2010. The affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. As a result, the system could remove the Electric Power Steering (EPS) assist.

Consequence & remedy

Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will update the software for the power steering control module (PSCM) and the instrument cluster module, free of charge. If a vehicle shows a history of a loss of the torque sensor signal or fault codes relating to the PSCM when the vehicle is brought in for the recall remedy, the affected components will be replaced, free of charge. The recall began on July 18, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S05.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP15001 · Loss Of Power Steering While Driving

Opened Apr 1, 2015 · Closed Jun 14, 2018

Status: closed (inferred from source dates) · Steering:electric Power Assist System

On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equipped with electric power assisted steering (NHTSA 14V-284, Ford 14S05). Ford's DIR described the defect condition as a poor signal to noise ratio [SNR] in the torque sensor within the Electric Power Assisted Steering (EPAS) system [which] does not allow the PSCM to determine the driver's steering input. When the system detects this fault condition, it transitions the EPAS system to the fail-safe/manual steering mode.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Ford's remedy instructs dealers to check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTCs) to determine the proper repair procedure. If no DTCs are present, dealers are to update the PSCM and instrument cluster module software. The updated PSCM software changes the torque sensor fault strategy so that the SNR condition does not result in a loss of power steering assist while driving.In addition, audible and visual warnings are provided for torque sensor faults.If DTCs indicating faults in the torque sensor, PSCM or Power Steering Motor (motor) are present in the initial recall inspection, the dealer performs the following repairs: 1) replaces the torque sensor for torque sensor faults (DTC B2278); or 2) replaces the steering column for faults related to the PSCM (DTC B1342) or motor (DTC B2277).Continued in attachment pages

DP12006 · Electronic Throttle Body Malfunction

Opened Oct 2, 2012 · Closed Feb 21, 2013

Status: closed (inferred from source dates) · Engine

In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.

PE08060 · Tire Valve Cracking

Opened Oct 14, 2008 · Closed Apr 9, 2009

Status: closed (inferred from source dates) · Tires:valve

ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO

Go deeper into Ford Escape problems

Ford Escape transmission problems →Ford Escape electrical problems →