NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
11 reportsClear category filterMileage unknown · Feb 28, 2025
Fuel/propulsion SystemPower TrainUnknown Or Other
My 2007 Ford Escape Hybrid (mileage currently 180,000 but the issue started around 150,000 miles) will occasionally (varies from once a week to once every 3 months) not respond properly when I'm accelerating from a stop. When this happens, I can push the accelerator all the way to the floor, but the car will accelerate very slow…
Read full complaint
My 2007 Ford Escape Hybrid (mileage currently 180,000 but the issue started around 150,000 miles) will occasionally (varies from once a week to once every 3 months) not respond properly when I'm accelerating from a stop. When this happens, I can push the accelerator all the way to the floor, but the car will accelerate very slowly for the first 5 seconds or so, and then start accelerating normally again. When this issue first began, it nearly resulted in multiple crashes when I was pulling out into traffic, but now I leave lots of extra space when pulling into traffic in case this happens. I've taken the car to an independent mechanic to try to diagnose the issue and they were unable to observe it since it doesn't happen frequently or predictably enough. There were not any warning lamps, messages, or other symptoms of the problem prior to the issue starting.
NHTSA ODI #11645558
Mileage unknown · Dec 7, 2024
Fuel/propulsion SystemPower Train
While driving, a red triangle to safely stop came up and the vehicle engine shut down. I could not accelerate since the engine was shut down, I could only coast and brake. After the vehicle has been cooling down for 20 min, I’m able to restart the vehicle and drive again until the same issue occurs again. No light on dashboard. …
Read full complaint
While driving, a red triangle to safely stop came up and the vehicle engine shut down. I could not accelerate since the engine was shut down, I could only coast and brake. After the vehicle has been cooling down for 20 min, I’m able to restart the vehicle and drive again until the same issue occurs again. No light on dashboard. Very dangerous issue as it often happens when driving on the freeway for a while. You have no way to accelerate the vehicle and need to slowly pull over on a busy freeway, endangering others and yourself. The issue has not been reproduced by a dealer or independent service center. No, the vehicle has not been inspected by anyone. Please note that this is a known recall for this vehicle but my VIN is NOT included in the recall. Please see the details of the recall below: NHTSA CAMPAIGN ID: 14V526000 Report Date: SEP 03, 2014 Vehicles Affected: 70,209 Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash. What You Should Do: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
NHTSA ODI #11629431
Mileage unknown · Dec 19, 2021
Fuel/propulsion SystemService Brakes
On 12/10/21 the accelerator stuck. I had to pull off the road, because I was losing power. But what if it got stuck at a high rate of speed? How would I stop, other than the hand brake and pray that it works. It had happened another time that week, but I thought it was a fluke as the car only has 85000 miles on it. I bought i…
Read full complaint
On 12/10/21 the accelerator stuck. I had to pull off the road, because I was losing power. But what if it got stuck at a high rate of speed? How would I stop, other than the hand brake and pray that it works. It had happened another time that week, but I thought it was a fluke as the car only has 85000 miles on it. I bought it in Sept 2021. It happened again on the 11th. Had my family member look at it and they lubricated the accelerator and a cable in the engine compartment. It has not done it since. Here is the VIN # [XXX]. 12/18/21 Drove to church. No problem with anything. No lights on.... the dash. Family member left to go home for the afternoon and stated that they almost hit a herd of deer, because the brakes went straight to the floor. They drove back for the evening program, with the same problem. I drove home about 35 miles an hour, and the brake pedal goes straight to the floor. No noise of any kind, no warning, no puddles where the car was parked at church or at home. The brake light is on now. What in the world. This could be fatal... both of these issues. FORD just told me there are no recalls, and then sent me to a survey. They need to look into these issues....Poor customer service in my opinion and could be a fatal situation. Last week was unable to get in for an appointment within a 50 mile radius to get that problem looked at. NOT able to be seen till after the new year.... INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA ODI #11444360
Mileage unknown · Feb 10, 2016
Fuel/propulsion System
GAS PEDAL IS STUCK
NHTSA ODI #10825430
70,000 miles · Dec 27, 2015
Fuel/propulsion System
SENSOR LIGHT KEEPS COMING ON NEAR THE GAS CAP
NHTSA ODI #10816317
105,000 miles · Nov 25, 2015
Fuel/propulsion SystemVehicle Speed Control
THE GAS PEDAL WOULD STICK INTERMITTENTLY, AND MORE PRESSURE NEEDED TO BE APPLIED TO THE PEDAL IN ORDER TO GET THE CAR TO ACCELERATE. AT ONE POINT THE GAS PEDAL COMPLETELY STUCK, AND I WAS NOT ABLE TO ACCELERATE THE CAR AT ALL ON THE HIGHWAY, FORCING ME TO PULL THE CAR OVER TO THE SIDE OF THE ROAD AND TURN IT OFF TO BE TOWED. A M…
Read full complaint
THE GAS PEDAL WOULD STICK INTERMITTENTLY, AND MORE PRESSURE NEEDED TO BE APPLIED TO THE PEDAL IN ORDER TO GET THE CAR TO ACCELERATE. AT ONE POINT THE GAS PEDAL COMPLETELY STUCK, AND I WAS NOT ABLE TO ACCELERATE THE CAR AT ALL ON THE HIGHWAY, FORCING ME TO PULL THE CAR OVER TO THE SIDE OF THE ROAD AND TURN IT OFF TO BE TOWED. A MECHANIC WAS ABLE TO CONFIRM THIS ISSUE IS CAUSED BY A MALFUNCTION IN THE THROTTLE BODY. FORD PREVIOUSLY RECALLED THROTTLE BODY'S IN ESCAPES FROM 2009-2012, BUT MY CAR IS 2007 AND DOES NOT APPLY. HOWEVER, BECAUSE IT IS EXPERIENCING THE SAME MALFUNCTION, AND HAS SERIOUS SAFETY IMPLICATION, I BELIEVE THE 2007 FORD ESCAPE MODEL SHOULD BE ADDED TO FORDS CURRENT CONSUMER SATISFACTION PROGRAM 13N03.
NHTSA ODI #10806815
Mileage unknown · Mar 27, 2015
Fuel/propulsion System
TL*THE CONTACT OWNS A 2007 FORD EDGE. THE CONTACT RECEIVED NHTSA CAMPAIGN NUMBER: 14V682000 (FUEL SYSTEM,GASOLINE) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD …
Read full complaint
TL*THE CONTACT OWNS A 2007 FORD EDGE. THE CONTACT RECEIVED NHTSA CAMPAIGN NUMBER: 14V682000 (FUEL SYSTEM,GASOLINE) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
NHTSA ODI #10702099
76,000 miles · Dec 30, 2014
Fuel/propulsion SystemCrash
MY DAUGHTER, JULIE MAYO, WAS DRIVING ON HWY 280 IN BIRMINGHAM, AL WHEN SHE APPROACHED A STOPPED VEHICLE ON THE HIGHWAY. SHE WAS UNABLE TO STOP THE FORD ESCAPE TO AVOID THE CRASH EVEN AFTER APPLYING BRAKES. A SUBSEQUENT INSPECTION BY A CERTIFIED MECHANIC AT JOE HUDSON'S INDICATED THE THROTTLE WAS STUCK AND THE ENGINE WAS RUNNING…
Read full complaint
MY DAUGHTER, JULIE MAYO, WAS DRIVING ON HWY 280 IN BIRMINGHAM, AL WHEN SHE APPROACHED A STOPPED VEHICLE ON THE HIGHWAY. SHE WAS UNABLE TO STOP THE FORD ESCAPE TO AVOID THE CRASH EVEN AFTER APPLYING BRAKES. A SUBSEQUENT INSPECTION BY A CERTIFIED MECHANIC AT JOE HUDSON'S INDICATED THE THROTTLE WAS STUCK AND THE ENGINE WAS RUNNING AT 4000 RPM FOLLOWING THE COLLISION. DAMAGES TO THE ESCAPE WERE ESTIMATED AT $5700 INCLUDING FRAME DAMAGE, THEREFORE THE VEHICLE WAS DECLARED A TOTAL LOSS BY STATE FARM. THE CURRENT FORD ESCAPE RECALL NOTICE FOR THIS PROBLEM DOES NOT EXTEND TO INCLUDE 2007 MODELS. IT SHOULD.
NHTSA ODI #10668950
52,000 miles · Jul 30, 2012
Fuel/propulsion System
WHEN THE TEMPERATURE OUTSIDE IS BELOW 32 DEGREES, THE GAS PEDAL STICKS. THIS OCCURS WHEN YOU ATTEMPT TO ACCELERATE. THIS IS DANGEROUS IF YOU ARE PULLING OUT INTO TRAFFIC. ONCE THE PEDAL STICKS, SOMETIMES IF YOU STOMP ON IT, IT WILL RELEASE. THEY HAVE RECALLED 2001-2004 ESCAPE FOR THIS ISSUE. FORD IS NOT ACKNOWLEDGING THIS I…
Read full complaint
WHEN THE TEMPERATURE OUTSIDE IS BELOW 32 DEGREES, THE GAS PEDAL STICKS. THIS OCCURS WHEN YOU ATTEMPT TO ACCELERATE. THIS IS DANGEROUS IF YOU ARE PULLING OUT INTO TRAFFIC. ONCE THE PEDAL STICKS, SOMETIMES IF YOU STOMP ON IT, IT WILL RELEASE. THEY HAVE RECALLED 2001-2004 ESCAPE FOR THIS ISSUE. FORD IS NOT ACKNOWLEDGING THIS ISSUE FOR THE 2007 ESCAPE. *TR
NHTSA ODI #10468333
51,574 miles · Jul 27, 2012
Fuel/propulsion SystemVehicle Speed Control
IN COLD WEATHER FOR THE FIRST 2 OR 3 STOPS THE GAS PEDAL WOULD NOT MASH DOWN. IT STUCK UP. IT WOULD BE OK AFTER THAT. NEVER A PROBLEM IN SUMMER. FORD CHECKED IT AND COULD NOT FIND A PROBLEM. I CONTACTED FORD AND THEY DID NOT HAVE AN ANSWER TO THE PROBLEM. I FELT LIKE I WAS NOT THE ONLY ONE WITH THIS PROBLEM. FINALLY IN AP…
Read full complaint
IN COLD WEATHER FOR THE FIRST 2 OR 3 STOPS THE GAS PEDAL WOULD NOT MASH DOWN. IT STUCK UP. IT WOULD BE OK AFTER THAT. NEVER A PROBLEM IN SUMMER. FORD CHECKED IT AND COULD NOT FIND A PROBLEM. I CONTACTED FORD AND THEY DID NOT HAVE AN ANSWER TO THE PROBLEM. I FELT LIKE I WAS NOT THE ONLY ONE WITH THIS PROBLEM. FINALLY IN APRIL OF THIS YEAR IT STUCK AND I HAD TO HAVE THE THROTTLE REPLACED, A $383.79 COST TO ME. I CONTACTED FORD AND TOLD THEM I THOUGHT THEY SHOULD PAY FOR THE REPAIR SINCE IT WAS A SAFETY ISSUE. THEY EVIDENTIALLY THOUGHT NOT BECAUSE THEY WOULD NOT TAKE CARE OF IT. WHEN YOU STOP AND START OFF AND THE PEDAL STICKS AND YOU ARE IN THE MIDDLE OF AN INTERSECTION AND YOUR CAR WON'T MOVE, THAT IS A SAFETY ISSUE. MY SON WAS DRIVING IN TEXAS AND STOPPED BEHIND ANOTHER CAR AT A RED LIGHT AND STARTED TO EASE UP WHEN THE PEDAL STUCK. HE PATTED IT A TIME OR TWO AND IT JERKED FORWARD AND ALMOST HIT THE CAR IN FRONT OF US. THIS HAPPENED THE WHOLE TIME I HAD THE CAR UNTIL APRIL OF THIS YEAR AND AFTER 2 OR 3 STOPS, WHEN IT WARMED UP, IT WAS OK. *TR
NHTSA ODI #10468017
Official recalls
2Sep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence & remedy
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Consequence: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Sep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
Consequence & remedy
Consequence: If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
Illustration