THE POWER STEERING FAILED AS I PULLED MY ESCAPE FROM A PARKING SPACE ON A CITY STREET; I COULD GO FORWARD OR BACK BUT ONLY TURN THE STEERING WHEEL WITH GREAT EFFORT. I DROVE HOME WITH GREAT DIFFICULTY, BARELY ABLE TO TURN THE WHEEL FOR THE TURNS I HAD TO MAKE -- IT WAS A VERY DANGEROUS SITUATION. I CHECKED THE NHSTA WEBSITE AND…
Read full complaint
THE POWER STEERING FAILED AS I PULLED MY ESCAPE FROM A PARKING SPACE ON A CITY STREET; I COULD GO FORWARD OR BACK BUT ONLY TURN THE STEERING WHEEL WITH GREAT EFFORT. I DROVE HOME WITH GREAT DIFFICULTY, BARELY ABLE TO TURN THE WHEEL FOR THE TURNS I HAD TO MAKE -- IT WAS A VERY DANGEROUS SITUATION. I CHECKED THE NHSTA WEBSITE AND LEARNED THAT FORD HAS ISSUED A RECALL FOR MODEL YEAR 2008-2011 ESCAPES MADE IN THE KANSAS CITY, MO. FACTORY DUE TO POWER STEERING FAILURE AND THAT NHTSA HAS AN OPEN INVESTIGATION INTO THE ISSUE. THE DEALERSHIP MANAGER TOWED IT THE NEXT MORNING AND TOLD ME THAT IT WOULD COST $2100 TO REPLACE THE POWER STEERING COLUMN AND HOUSING. WHEN I ASKED WHY IT WASN'T COVERED UNDER THE THE RECALL WHEN IT MET ALL THE CRITERIA, HE SAID BECAUSE IT'S A HYBRID - THE RECALL ONLY APPLIES TO NON-HYBRIDS. HOWEVER, THE MANAGER SAID HE WOULD TRY TO GET IT COVERED. HE WAS ABLE TO GET FORD TO COVER TWO-THIRDS OF THE COST; I STILL HAD TO PAY $500. THE MANAGER WAS GREAT, FORD WAS NOT. I'M EXTREMELY UPSET BY FORD'S POSITION THAT HYBRIDS AREN'T COVERED UNDER THE RECALL WHEN THE PROBLEM IS EXACTLY THE SAME AND THE CAR MET ALL THE CRITERIA. IT WAS A TERRIBLE WAY TO TREAT A LIFE LONG FORD OWNER. THINGS WOULD HAVE BEEN EVEN WORSE IF IT WEREN'T FOR THE MANAGER WHO WAS VERY CUSTOMER-ORIENTED.
NHTSA ODI #10939124
79,000 miles · Mar 31, 2016
Steering
THIS COMPLAINT IS CLOSELY RELATED TO A 2014 RECALL RELATIVE TO ELECTRIC POWER STEERING ASSIST ON FORD ESCAPE AND MERCURY MARINER VEHICLES, HOWEVER FORD STATES MY VIN WAS NOT COVERED UNDER THE RECALL. REF: NHTSA ACTION#DP15001, NHTSA 14V-284, FORD 14S05. PROBLEM: ON A NEARLY-DAILY BASIS, THE POWER STEERING ASSIST (WHICH IS ALL…
Read full complaint
THIS COMPLAINT IS CLOSELY RELATED TO A 2014 RECALL RELATIVE TO ELECTRIC POWER STEERING ASSIST ON FORD ESCAPE AND MERCURY MARINER VEHICLES, HOWEVER FORD STATES MY VIN WAS NOT COVERED UNDER THE RECALL. REF: NHTSA ACTION#DP15001, NHTSA 14V-284, FORD 14S05. PROBLEM: ON A NEARLY-DAILY BASIS, THE POWER STEERING ASSIST (WHICH IS ALL-ELECTRIC ON THIS VEHICLE) "DROPS OUT" BRIEFLY - TYPICALLY FOR 1-3 SECONDS - OFTEN DURING A TURN. THE VEHICLE STEERING HAS A STRONG TENDENCY TO "CENTER" SO FOR A DRIVER WITHOUT UPPER BODY STRENGTH THIS COULD EASILY CAUSE LOSS OF CONTROL. ON TWO OCCASIONS THE POWER STEERING ASSIST HAS STOPPED AND REMAINED INACTIVE AFTER RE-STARTING, WHICH REQUIRED ME TO VISIT A REPAIR SHOP TO HAVE THE SOFTWARE RESET - A 5 MINUTE PROCESS PERFORMED WITH A PROGRAMMED IPAD. FORD'S RECALL CENTER AND CUSTOMER RELATIONSHIP CENTER TOOK THE CASE #, BUT WANT ME TO VISIT A DEALER AND PAY FOR A DIAGNOSIS. ISSUE HAS OCCURRED BOTH TURNING AND NOT TURNING; LOW SPEED AND HIGHWAY SPEED, COLD AND WARM WEATHER.
NHTSA ODI #10852799
50,000 miles · Feb 7, 2014
Steering
THE STEERING WHEEL LOSES POWER WHILE THE VEHICLE IS IN MOTION. THE VEHICLE NEEDS TO BE TURNED OFF AND RESTARTED AGAIN TO FIX THE PROBLEM. THIS PROBLEM OFTEN HAPPENS IN COLD WEATHER AND USUALLY IN THE MORNING. THE STEERING WHEEL ALSO MAKES A WEIRD SOUND BEFORE IT LOSES POWER. I HAVE FRIENDS WHO HAVE THE SAME VEHICLE BUT OF DIFFER…
Read full complaint
THE STEERING WHEEL LOSES POWER WHILE THE VEHICLE IS IN MOTION. THE VEHICLE NEEDS TO BE TURNED OFF AND RESTARTED AGAIN TO FIX THE PROBLEM. THIS PROBLEM OFTEN HAPPENS IN COLD WEATHER AND USUALLY IN THE MORNING. THE STEERING WHEEL ALSO MAKES A WEIRD SOUND BEFORE IT LOSES POWER. I HAVE FRIENDS WHO HAVE THE SAME VEHICLE BUT OF DIFFERENT YEAR AND THEY HAD TO REPLACE THE WHOLE STEERING COLUMN. *TR
NHTSA ODI #10563329
25,000 miles · Jul 30, 2013
SteeringWheels
AT 40-45 MPH HEAR WHEEL BEARING NOISE. DEALER CONFIRMED AND BOTH RIGHT FRONT BEARINGS (MAIN AND CARRIER) REPLACED BY FORD DEALER. STILL HAD NOISE AFTER REPLACEMENT. DEALER CONFIRMED THAT THE CARRIER BEARING JUST REPLACED WAS BAD. REPLACED CARRIER BEARING AGAIN BUT STILL HAVING SAME NOISE. DEALER STATED THERE HAVE BEEN MANY …
Read full complaint
AT 40-45 MPH HEAR WHEEL BEARING NOISE. DEALER CONFIRMED AND BOTH RIGHT FRONT BEARINGS (MAIN AND CARRIER) REPLACED BY FORD DEALER. STILL HAD NOISE AFTER REPLACEMENT. DEALER CONFIRMED THAT THE CARRIER BEARING JUST REPLACED WAS BAD. REPLACED CARRIER BEARING AGAIN BUT STILL HAVING SAME NOISE. DEALER STATED THERE HAVE BEEN MANY WHEEL BEARING PROBLEMS, AND THAT FAULTY BEARINGS ARE COMING TO FORD FROM VENDOR. PROBLEM AS YET NOT RESOLVED. SEEMS FORD IS UNABLE TO IDENTIFY WHICH BEARINGS ARE BAD WITHOUT INSTALLING THEM. I AM CONCERNED WITH POTENTIAL WHEEL LOCK UP AT SPEEDS, ESPECIALLY A FRONT WHEEL. *TR
NHTSA ODI #10532623
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP15001 · Loss Of Power Steering While Driving
Opened Apr 1, 2015 · Closed Jun 14, 2018
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equipped with electric power assisted steering (NHTSA 14V-284, Ford 14S05). Ford's DIR described the defect condition as a poor signal to noise ratio [SNR] in the torque sensor within the Electric Power Assisted Steering (EPAS) system [which] does not allow the PSCM to determine the driver's steering input. When the system detects this fault condition, it transitions the EPAS system to the fail-safe/manual steering mode.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Ford's remedy instructs dealers to check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTCs) to determine the proper repair procedure. If no DTCs are present, dealers are to update the PSCM and instrument cluster module software. The updated PSCM software changes the torque sensor fault strategy so that the SNR condition does not result in a loss of power steering assist while driving.In addition, audible and visual warnings are provided for torque sensor faults.If DTCs indicating faults in the torque sensor, PSCM or Power Steering Motor (motor) are present in the initial recall inspection, the dealer performs the following repairs: 1) replaces the torque sensor for torque sensor faults (DTC B2278); or 2) replaces the steering column for faults related to the PSCM (DTC B1342) or motor (DTC B2277).Continued in attachment pages
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
2011 Ford Escape Hybrid Problems, Complaints & Recalls | Skip That Year
Illustration