Service Brakes. Review the 129 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 110 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

13 crash reports1 fire reports1 injury reports

Vehicle Speed Control complaints

25 reports

Clear category filter

38,200 miles · Jun 11, 2012

EngineFuel/propulsion SystemVehicle Speed Control

TRAVELING ON FREEWAY AT APPROXIMATELY 70 MPH. WITHOUT WARNING, ENGINE COMPLETELY SHUT DOWN. CHIME SOUNDED AND WARNING MESSAGE APPEARED ON DASHBOARD SAYING "STOP SAFELY NOW." RED TRIANGLE WITH EXCLAMATION POINT IN CENTER APPEARED ON DASH. I WAS INFORMED BY FORD SERVICE DEPARTMENT DURING REPAIRS THAT THIS IS A KNOWN FAILURE PROBLE…

Read full complaint

NHTSA ODI #10461261

30 miles · Apr 14, 2012

Electronic Stability Control (esc)Engine And Engine CoolingVehicle Speed Control

Read full complaint

WHILE DRIVING I NOTICED A LACK OF POWER AND GOT THE MESSAGE "STOP SAFELY NOW". AS THE MANUAL STATED I PULLED OVER, WAITED A FEW MINUTES. THE CAR STARTED UP AGAIN BUT THE EVENT KEPT HAPPENING ALL THE WAY HOME. I BROUGHT THE CAR TO A DEALER WHO MADE A REPAIR COSTING 642 DOLLARS. THE CAR RAN FINE FOR A MONTH BUT WHEN ON A MAJOR HIGHWAY I HAD THE SAME EXPERIENCE EXCEPT IT WAS MORE DIFFICULT TO DEAL WITH THE LOSS OF POWER IN BUSY TRAFFIC. I WAS IN THE PASSING LANE TO ALLOW ANOTHER CAR ENTER THE HIGHWAY FROM AN ON RAMP WHEN IT HAPPENED AND I WAS LUCKY TO BE ABLE TO CROSS THREE LANES OF TRAFFIC TO BRING THE CAR TO REST. AGAIN, IT HAPPENED ALL THE WAY HOME CAUSING ME TO FINALLY DRIVE IN THE BREAKDOWN LANE WITH FLASHERS ON. I WENT ONLINE AND LEARNED THAT THIS IS AN ONGOING PROBLEM WITH FORD HYBRIDS. MY QUESTION IS WHY NO RECALL ON SUCH AN EXPENSIVE AND DANGEROUS PROBLEM? *TR

NHTSA ODI #10455257

68,000 miles · Apr 11, 2012

Electrical SystemEngine And Engine CoolingVehicle Speed Control

Read full complaint

VEH SHOWS A CAUTION SIGN (EXCLAMATION IN TRIANGLE) WITH A WARNING (PULL VEHICLE OVER SAFELY AND TURN OFF ENGINE). VEH LOSES ALL ACCELERATION AND I MUST PULL OVER IMMEDIATELY TO AVOID AN ACCIDENT. HAPPENS EVERY TIME WE DRIVE ON THE FREEWAY ONLY, NEVER ON A SIDE STREET OR IN STOP AND GO. I PULL VEHICLE OVER AND TURN OFF ENGINE FOR APPROX 2 OR 3 MINUTES, AND IT STARTS RIGHT UP. SOME TIMES IT WILL HAPPEN MULTIPLE TIMES WITHIN A 20 TO 30 MINUTE TIME PERIOD, SOMETIMES ONLY ONCE IN SEVERAL HOURS OF DRIVING. DEALER HAS NO IDEA WHY AND REQUIRES A TOW IMMEDIATELY WHEN IT HAPPENS TO DETERMINE CAUSE. CANNOT TOW WHEN ON THE WAY TO DR, OUT OF TOWN, OR OTHER. *TR

NHTSA ODI #10454894

111,397 miles · Feb 3, 2012

Electrical SystemPower TrainVehicle Speed Control

WHILE DRIVING ON THE FREEWAY AT 65 MPH THE POWER CUT OUT AND A WARNING WAS DISPLAYED ON THE DASH TO PULL OVER SAFELY. I WAS ABLE TO RESTART THE CAR AND CONTINUE DRIVING, BUT IT HAPPENED AGAIN. I HAD TO HAVE THE CAR TOWED TO FORD. THE FORD DEALER HAD TO REPLACE THE THROTTLE BODY AND MOTOR ASSEMBLY. THIS IS VERY DANGEROUS. *K…

Read full complaint

NHTSA ODI #10446391

21,478 miles · Feb 20, 2010

Fuel System, GasolineVehicle Speed Control

Read full complaint

WAS DRIVING 2008 ESCAPE HYBRID ON HIGHWAY YESTERDAY @ 55MPH, ATTEMPTED TO PASS SLOWER VEHICLE BY SWITCHING LANES AND ACCELERATING. ACCELERATOR STUCK AND CAR CONTINUED TO ACCELERATE DESPITE MY ATTEMPTS TO STOP IT. I HAD TO DRIVE OFF THE ROAD WHILE SLAMMING ON THE BRAKES TO STOP THE VEHICLE. VEHICLE REACHED SPEED OF 80 + MPH BEFORE ACCELERATOR BECAME UNSTUCK. HEARD A "POP" SIMILAR TO THE SOUND OF A CAR HOOD POPPING OPEN ONCE ACCELERATOR BECAME UNSTUCK. CAR WAS THEN DRIVABLE, BUT I DID NOT DRIVE OVER 35 MPH AFTER THAT OUT OF FEAR THAT CAR WOULD AGAIN BECOME UNCONTROLLABLE. HAD VEHICLE TOWED TO FORD DEALERSHIP OUT OF FEAR OF DRIVING IT. CURRENTLY BEING EXAMINED BY DEALERSHIP AND PROBLEM HAS NOT YET BEEN DIAGNOSED. *TR

NHTSA ODI #10312333

Official recalls

No recalls in this snapshot.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

DP15001 · Loss Of Power Steering While Driving

Opened Apr 1, 2015 · Closed Jun 14, 2018

Status: closed (inferred from source dates) · Steering:electric Power Assist System

On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equipped with electric power assisted steering (NHTSA 14V-284, Ford 14S05). Ford's DIR described the defect condition as a poor signal to noise ratio [SNR] in the torque sensor within the Electric Power Assisted Steering (EPAS) system [which] does not allow the PSCM to determine the driver's steering input. When the system detects this fault condition, it transitions the EPAS system to the fail-safe/manual steering mode.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Ford's remedy instructs dealers to check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTCs) to determine the proper repair procedure. If no DTCs are present, dealers are to update the PSCM and instrument cluster module software. The updated PSCM software changes the torque sensor fault strategy so that the SNR condition does not result in a loss of power steering assist while driving.In addition, audible and visual warnings are provided for torque sensor faults.If DTCs indicating faults in the torque sensor, PSCM or Power Steering Motor (motor) are present in the initial recall inspection, the dealer performs the following repairs: 1) replaces the torque sensor for torque sensor faults (DTC B2278); or 2) replaces the steering column for faults related to the PSCM (DTC B1342) or motor (DTC B2277).Continued in attachment pages

DP12006 · Electronic Throttle Body Malfunction

Opened Oct 2, 2012 · Closed Feb 21, 2013

Status: closed (inferred from source dates) · Engine

In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.