2008 Ford Escape Hybrid

WHILE EXITING A STATE ROUTE ON A OFF RAMP I WAS APPLYING BRAKES ON A TURN. THE BRAKE LIGHT, ABS LIGHT, CHECK BRAKES WARNING CAME ON AND I LOST ALL OF MY BRAKES. FAULT CODES THAT ARE SETTING ARE U2023,C1526,C1477. FORD IS AWARE OF THIS PROBLEM AND TO REPAIR IT YOU MUST REPLACE THE MASTER CYLINDER $850 AND ABS PUMP ASSEMBLY $3500. *TR

IT WAS THURSDAY, OCTOBER 17, 2013. THE AMBIENT AIR TEMPERATURE WAS ABOUT 62 DEGREES. IT WAS SUNNY. THE STREETS WERE DRY. I WAS DRIVING SOUTH FROM AUSTIN TO NEW BRAUNFELS, TEXAS ON I-35 AT APPROXIMATELY 7:15 A.M. I HAD THE SPEED CONTROL SET FOR 55 M.P.H. AS I WAS LEAVING SAN MARCOS, AN ALARM TONE SOUNDED, AND THE DASH BOARD DISPLAY SHOWED "STOP SAFELY NOW" AND THE ENGINE SHUT OFF. I WAS ABLE TO MOVE TO THE SHOULDER USING BATTERY POWER ONLY AT LESS THAN 20 MILES AN HOUR, CAUSING ISSUES WITH OTHER TRAFFIC ON THE INTERSTATE, WITH MANY OF THE OTHER DRIVERS ANXIOUS TO GET TO WORK. I STOPPED THE CAR, AND WHEN IT WAS SAFE TO DO SO, EXITED THE VEHICLE AND DID A PERIMETER SCAN FOR ISSUES. NONE WERE DETECTED. I OPENED THE HOOD AND CHECKED FOR UNTOWARD ISSUES. THERE WAS NO SMOKE. THE ENGINE WASN'T OVERLY HOT. OIL WAS FULL TO THE APPROPRIATE MARK. THE VEHICLE HAD BEEN SERVICED BY THE DEALERSHIP WHO SOLD THE VEHICLE TO ME ABOUT 1790 MILES PRIOR TO THIS INCIDENT, AND A FULL DIAGNOSTIC WAS PERFORMED WITHOUT ANY ISSUES DETECTED. AFTER COMPLETING THIS CHECK, I RESTARTED THE CAR AND DROVE FOR ANOTHER 20 OR SO MILES WHEN THE ALARM AND DISPLAY REPEATED AS ABOVE. AGAIN THERE WERE NO ISSUES. I RESTARTED THE VEHICLE AFTER ABOUT THREE MINUTES AND WAS ABLE TO COMPLETE THE 75 MILE COMMUTE. THE RETURN TRIP HAD NO ISSUES. SINCE THE VEHICLE SHUT DOWN COMPLETELY WITHOUT WARNING IN FAST-MOVING TRAFFIC, THIS IS A CATASTROPHIC FAILURE. INFORMATION FROM THE INTERNET INDICATES THAT FORD HAS HAD THIS ISSUE SINCE THE FIRST ESCAPE HYBRIDS WERE ON THE ROAD, AND THERE APPEARS TO BE NO DEFINITIVE PROBLEM OR CORRECTION. I REQUEST THAT THE NHTSA EXAMINE THIS TO DETERMINE IF A RECALL SHOULD BE PERFORMED BEFORE SOMEONE IS KILLED BECAUSE OF A FAULTY ALARM THAT SHUTS THE VEHICLE DOWN COMPLETELY WITHOUT WARNING. *TR

FAILURE OF THE ELECTRONIC WATER PUMP FOR THE HYBRID SYSTEM CAUSES THE IMMEDIATE SHUTDOWN OF THE VEHICLE LEAVING DRIVER NO POWER TO MOVE TO A SAFE AREA. THERE IS NO WARNING BUT JUST AN IMMEDIATE ELECTRICAL SHUTOFF UNTIL DRIVER CAN MOVE TO THE SHOULDER AND RESTART THE VEHICLE. THIS OCCURRED TWICE AND LEFT US IN VERY DANGEROUS SITUATIONS BEFORE I HAD THE CAR REPAIRED. FORD WOULD NOT REPLACE THE PART CLAIMING IT IS NOT COVERED UNDER THEIR HYBRID WARRANTY ALTHOUGH THE PART IS INTEGRAL TO THE HYBRID SYSTEM. PART SHOULD BE RECALLED BEFORE FATALITIES OCCUR. *TR

WHILE DRIVING DOWN THE ROAD AT HIGHWAY SPEED ON A SUMMER NIGHT AT AROUND 9:00 PM, THE CAR'S ENGINE SUDDENLY STOPPED, A RED WARNING TRIANGLE LIGHT CAME ON, AND THE DASH MESSAGE SCREEN SAID, "STOP SAFELY NOW." I PULLED THE CAR TO THE SIDE OF THE ROAD, TURNED IT OFF, AND WAS ABLE TO RESUME DRIVING AFTER A FEW MINUTES. ON 5 SEPARATE TRIPS SUBSEQUENTLY, THIS SUDDEN LOSS OF ENGINE POWER HAS HAPPENED, OFTEN IN HEAVY TRAFFIC WHERE PULLING TO THE SIDE OF THE ROAD WAS VERY DIFFICULT AND DANGEROUS. THE FAILURE OFTEN HAPPENS MULTIPLE TIMES ON THE SAME TRIP. EACH TIME THE FAILURE HAS HAPPENED HAS BEEN IN THE SUMMER AND IN THE LATE AFTERNOON OR EVENING. EACH TIME THE CAR CAN BE RESTARTED ONCE PULLED TO THE SIDE OF THE ROAD AND TURNED OFF. *TR

ON 4 SEPARATE OCCASIONS, ALL OCCURRING AT HIGHWAY SPEED AFTER AT LEAST 40 MINUTES OF DRIVING ON A HOT DAY, THE CAR'S ENGINE SUDDENLY CUT OFF, CAUSING THE VEHICLE TO LOSE SPEED RAPIDLY. A RED TRIANGLE WARNING LIGHT APPEARED ON THE DASHBOARD WITH THE FOLLOWING WORDS: "PULL OVER SAFELY NOW AND TURN OFF ENGINE". ALL 4 TIMES I WAS DRIVING AROUND 65 MPH ON AN INTERSTATE. ALL 4 TIMES THE CAR STARTED AGAIN NORMALLY AFTER A FEW MINUTES. AFTER THE 3RD INCIDENT, I STARTED THE CAR AGAIN SOON, AND IT STALLED AGAIN AFTER 10 MORE MINUTES OF HIGHWAY DRIVING. FIRST INCIDENT LATE JULY 2012, THEN LATE AUGUST 2012, AND TWICE ON JUNE 19, 2013. THIS IS A TERRIFYING EXPERIENCE, AND I WAS EXTREMELY LUCKY NOT TO BE REAR ENDED. THE DEALER CLAIMS IT CANNOT DUPLICATE PROBLEM OR SEE ANY CODES IN DIAGNOSTIC COMPUTER, REFUSES TO PURSUE. HELP!!!! *TR

FORD ESCAPE HYBRID (FEH) "STOP VEHICLE SAFELY" RED TRIANGLE WARNING AND IMMEDIATE ENGINE SHUTDOWN DUE TO THE WELL-KNOWN DEFECT IN THE BOSCH OEM MOTOR ELECTRONICS COOLING SYSTEM (MECS) PUMP IN THE 2005-2008 MODEL YEARS. SEE FORD TSB 08-24-5. IF THE NHTSA DID EVEN A CURSORY SEARCH ON THE INTERNET THEY WOULD SEE MANY, MANY HUNDREDS OF POSTINGS AND RELATED ACCIDENTS OR NEAR-MISSES. THIS IS A VERY SERIOUS SAFETY PROBLEM BECAUSE FAILURE IS ONLY TRIGGERED BY DRIVING AT HIGHWAY SPEEDS OR DRIVING UP STEEP HILLS AND THE SHUTDOWN IS IMMEDIATE (NO PRIOR WARNING), CAUSING SUDDEN AND SIGNIFICANT DROP IN SPEED AND FRANTIC ACTIONS BY THE DRIVER TO ABRUPTLY STEER THE UNPOWERED CAR TO THE SHOULDER. THERE ARE NO EXTERNAL INDICATORS TO WARN OTHER VEHICLES OF THE SUDDEN SLOWDOWN AND LANE CHANGE AND THE DRIVER DARE NOT USE THE BRAKES TO SIGNAL OTHERS BECAUSE TO HIT THE BRAKES WITH THE ENGINE SHUT DOWN AND THE VEHICLE ALREADY QUICKLY SLOWING TO A STOP WOULD CAUSE THE FEH TO ABRUPTLY STOP IN THE MIDDLE OF HIGHWAY. ALTHOUGH THIS PART IS UNIQUE TO THE HYBRID VERSIONS OF ESCAPES, FORD REFUSES TO CLASSIFY IT AS A UNIQUE HYBRID COMPONENT (WHICH WOULD BE COVERED BY THE 8 YR 100,000 MI WARRANTY) AND ROUTINELY CHARGES $800 TO REPLACE IT. IN MY CASE FAILURES HAPPENED FOUR TIMES IN THE LAST YEAR, ALWAYS ON INTERSTATE HIGHWAYS. TWO OF THE FAILURES NEARLY CAUSED MULTIPLE CAR PILEUPS BECAUSE THE INTERSTATE WAS FULL OF CARS AND SEMIS WHEN THE ENGINE CUT OUT. I AM FRANKLY SHOCKED THAT THE NHTSA DIDN'T REQUIRE A RECALL YEARS AGO FOR A WELL-KNOWN AND COMMON DEFECT THAT WITHOUT WARNING CAUSES FEH'S TO ABRUPTLY AND SIGNIFICANTLY SLOW DOWN SPECIFICALLY AT HIGH SPEEDS OR STEEP HILL CLIMBS, FORCING THE DRIVER TO ABRUPTLY CHANGE LANES TO GET TO THE SHOULDER. SEVERAL CLASS ACTION LAWSUITS ARE BEING PREPARED. ISN'T IT TIME THE NHTSA ADDRESSED THIS VERY SERIOUS DEFECT? *TR

MY 17 YEAR OLD DAUGHTER WAS DRIVING HOME APPROX 5:30 PM ON A BUSY FOUR LANE ROAD FROM AN ERRAND AND THE "STOP SAFELY NOW" LIGHT CAME ON. AT THAT POINT SHE COULD NOT GET OVER DUE TO TRAFFIC AND THE ENGINE SHUT OFF IN THE MIDDLE OF THE ROAD. SHE WAS ABLE TO COAST DOWN A HILL INTO A TURN LANE NEARLY HITTING AN ONCOMING CAR AND STOP THE CAR. WE ARRIVED ON THE SCENE AND WAS ABLE TO RESTART THE CAR AND BRING IT HOME. WE TOOK IT TO THE DEALER WHERE THEY WANTED TO REPLACE THE COOLANT MOTOR TO THE BATTERY WHICH WAS DEFECTIVE AND CAUSING THE HYBRID BATTERY TO OVERHEAT THEREBY SHUTTING DOWN THE ENGINE COMPLETELY. THIS IS TO PREVENT THE HYBRID BATTERY FROM OVERHEATING. I DO UNDERSTAND THE NEED FOR THIS TO ELIMINATE THE POSSIBILITY OF A FIRE, BUT THESE SHOULD BE REPLACED EVERY 50,000 MILES TO STOP THE ENGINE FROM SHUTTING OFF . WE WERE GETTING READY TO DRIVE ON A 600 MILE TRIP IN THIS CAR AND WOULD HAVE BEEN STRANDED ON THE HIGHWAY. THE WAY THE WARRANTY IS WRITTEN, IT IS NOT COVERED. AFTER RESEARCHING THE PROBLEM, THIS HAPPENS MORE FREQUENTLY ESPECIALLY AFTER 50,000 MILES. PLEASE INVESTIGATE AND PROVIDE A RECALL AND/OR FIX TO THIS PROBLEM ON THESE CARS. *TR

DURING A 300 MILE TRIP, THE FEH "STOP SAFELY NOW" WARNING CAME ON AND CAR SHUT DOWN. WE WERE ON A BUSY LA HIGHWAY AT THE TIME. WE WERE ABLE TO GET IT OFF THE HIGHWAY, READ UP ON THAT WARNING SYMBOL AND RESTARTED CAR WITHOUT ANOTHER INCIDENT THEN. 25 DAYS LATER, DRIVING THE CAR ON 45 MINUTE TRIP, 'STOP SAFELY NOW' LIGHT CAME ON REPEATEDLY. HAD TO PULL OVER SEVERAL TIMES, WAIT A FEW MINUTES AND RESTART CAR. AGAIN THIS WAS HIGHWAY DRIVING IN HEAVY TRAFFIC. THIS WAS VERY DANGEROUS SITUATION AND NO CAR SHOULD JUST SHUT DOWN WHILE YOU'RE DRIVING. *TR