2008 Ford Escape Hybrid

RECEIVED THE RED MASTER VEHICLE ELECTRICAL HAZARD WARNING LAMP, IMMEDIATELY FOLLOWED BY ENGINE SHUTTING DOWN WHILE ON HIGHWAY. CAUSE WAS A FAILURE OF THE MECS PUMP FORD PN 5M6Z-8C419-A. AFTER IT HAPPENED I RESEARCHED AND FOUND OTHER REPORTS ISSUED FOR SAME ISSUE. SEE 10597458,10604791,10596349,10592073,10588181,10588170,10568053,10567619,10567234,10566464,10565177,10560868,10557567,10554859,10548328,10547463,10537539,10533928,10531556,10525970,10523932,10523371,10521436,10521116,10516178,10514445,10513916,10511202,10505543,10504308,10500579,10500159,10461261,10462036,10462214,10463235,10468355,10474060,10475192,10476583,10477359,10485797,10490135,10460373,10459919,10459596,10459518,10458744,10457505,10457488,10456830,10456625,10455257,10455049,10454894,10453205,10448469,10448468,10409310,10409374,10410388,10411980,10412392,10416615,10419367,10430477,10326667,10329839,10348540,10349760,10352951,10360029,10361122,10393862,10393924,10399209. *TR

MECS COOLANT PUMP DEFECT CAUSES LOSS OF ENGINE POWER AT HIGHWAY SPEEDS RESULTING IN AN EXTREMELY UNSAFE CONDITION. FORD IS AWARE OF THE DEFECT IN THIS "HYBRID UNIQUE" COMPONENT BUT REFUSES TO COVER IT UNDER THEIR HYBRID COMPONENT WARRANTY. IN MY CASE I WAS DRIVING AT 55MPH ON A PUBLIC HIGHWAY WHEN THE DASH ILLUMINATED A RED TRIANGLE WITH THE MESSAGE "STOP SAFELY NOW". I HAD TO SCRAMBLE TO GET TO THE RIGHT SHOULDER AND CREATE A DANGEROUS CONDITION BY CUTTING OFF THE DRIVERS AROUND ME. I HAD TO PAY OUT OF POCKET FOR A REDESIGNED MECS PUMP REPLACEMENT AND HAVE NOT EXPERIENCED THE ISSUE SINCE. PENDING LAWSUIT, MACDONALD V. FORD MOTOR CO., CASE NUMBER 3:13-CV-02988, IN THE U.S. DISTRICT COURT FOR THE NORTHERN DISTRICT OF CALIFORNIA. *TR

STARTING IN MAY OF 2014, MY CAR'S PERFORMANCE HAS BEEN UNTRUSTWORTHINESS. SOME DAYS THERE'S NO PROBLEM-- I PUSH ON THE GAS PEDAL AND THE CAR MOVES ACCORDINGLY. AT A STOP SIGN, I CAN GO. WHILE MOVING AT 50 MPH ON THE FREEWAY, I CAN EASILY ACCELERATE AND MOVE AROUND A MONSTER SIZE 18 WHEELER. BUT ON THE DAYS WHEN I PRESS THE GAS PEDAL AND THE CAR DOESN'T RESPOND, I SWEAT. HERE'S A DESCRIPTION: FOOT ON THE GAS PEDAL, NO RESPONSE... SO I PRESS DOWN FURTHER, WITHOUT ANY ACCELERATION OF THE CAR. FINALLY, NOW FREAKED OUT THAT THE CAR IS NOT MOVING (AND THAT ANOTHER CAR IS RIGHT ON MY TAIL) I PRESS THE PEDAL TO THE FLOOR-- WITH NO IMMEDIATE REACTION. THEN-- BAM-- SURPRISE! IT WORKS AND THE SUDDEN SURGE SENDS ME FLYING BEYOND INTENTION AND I MUST PRESS ON THE BRAKES TO SLOW. AT STOP SIGNS THIS HAPPENS AND PEOPLE BEHIND ME GET FRUSTRATED, PROBABLY THINKING I'M ON DRUGS OR SOMETHING. BUT REALLY, IT'S NOT ME; IT'S MY FORD ESCAPE HYBRID 2008. THE RATE OF INCIDENCE HAS GRADUALLY INCREASED FROM MAY TO THE CURRENT DATE OF JULY, AND CONSEQUENTLY, I AM AFRAID TO DRIVE THIS CAR. *TR

AS WE WERE DRIVING, A "HAZARD" LIGHT COME ON THE DASH, THE ENGINE SHUT COMPLETELY OFF, AND A MESSAGE, "STOP CAR SAFELY," ALSO APPEARED ON THE DASH. WE DID SO, AND TURNED OFF THE CAR AND TURNED IT BACK ON. CAR DROVE FINE FOR ABOUT 5 MINUTES AND THE SAME THING HAPPENED. WE DID THIS FOR ABOUT AN HOUR OR SO TO GET HOME. HAD WE BEEN ON A BUSY INTERSTATE. A SUDDEN ENGINE SHUT OFF COULD HAVE BEEN VERY DANGEROUS. WE TOOK THE CAR TO THE DEALERSHIP AND WERE INFORMED THAT THE ELECTRIC BATTERY HAD OVERHEATED BECAUSE THE WATER PUMP WAS NOT WORKING. I HAVE COME ACROSS SIMILAR COMPLAINTS WHILE LOOKING INTO MY SITUATION. SOME EXAMPLES: HTTP://REPAIRPAL.COM/COOLANT-PUMP-ON-HYBRID-MAY-FAIL-AND-CAUSE-CELENGINE-SHUTDOWN-562. *TR

I WAS DRIVING MY 2008 FORD ESCAPE HYBRID AT ABOUT 65MPH IN THE LEFTMOST LANE SHORTLY AFTER MERGING FROM I83 SOUTH ONTO I395 (BALTIMORE BELTWAY) WHEN, WITH NO ADVANCE WARNING WHATSOEVER, THE GAS PEDAL STOPPED RESPONDING AT THE SAME TIME AS THE TRIANGLE WITH AN EXCLAMATION POINT AND THE "STOP SAFELY NOW" (AS IF I HAD ANY CHOICE) MESSAGE APPEARED. BY THE GRACE OF GOD I WAS ABLE TO COAST ACROSS 5 LANES OF TRAFFIC TO THE BREAKDOWN LANE. I WAS ANXIOUS TO GET HOME TO FEED THE DOGS, AND MY HUSBAND WAS OUT OF TOWN, SO RATHER THAN CALL A TOW TRUCK I RESTARTED THE CAR AND KEPT GOING IN THE RIGHT-HAND LANE FOR ANOTHER 3 OR 4 MILES UNTIL THE SAME THING HAPPENED AGAIN. IT TOOK ANOTHER 2 HOURS (WITH AN 15-20 ADDITIONAL STALLING EPISODES) UNTIL BEFORE I WAS ABLE TO MAKE IT HOME TO ANNAPOLIS. THROUGH THE INTERNET (AND MY HUSBAND CRAWLING UNDER THE CAR) WE HAVE CONFIRMED THAT THE SOURCE OF THE PROBLEM IS A WELL-DOCUMENTED FAULTY OEM HYBRID DRIVE TRAIN MECS COOLANT WATER PUMP. SEEMS TO ME THAT THIS IS A CATASTROPHIC FAILURE THAT IS EVERY BIT AS SERIOUS AS THE GM IGNITION SWITCH PROBLEM, AND A FATAL ACCIDENT WAITING TO HAPPEN. IT IS UNCONSCIONABLE THAT FORD HAS NOT ISSUED A RECALL ON THIS ISSUE, AND UNCONSCIONABLE THAT NHTSA HAS NOT FORCED FORD TO DO SO. *TR

CAR GOES LIMP. FORD HAS TSB 08-24-05. MECP FAILS. POOR DESIGN. HAS GONE LIMP ON ME ~8 TIMES. EACH TIME CAR DRIFTS TO A STOP REGARDLESS OF LOCATION, SPEED, ETC...(EG, CAN BE GOING 75MPH ON HIGHWAY) AND IT GOES LIMP. CANNOT MOVE AFTERWARDS FOR MINUTES. MANY CASES OF THIS HAPPENING HAVE BEEN REPORTED. TSB 08-24-5 STATES THAT SOME 2005-2008 ESCAPE HYBRID AND 2006-2008 MARINER HYBRID VEHICLES MAY EXHIBIT A RED TRIANGLE LIGHT AND CODES INDICATING A TRANSAXLE OVERTEMP. THIS CONDITION MAY RESULT IN REDUCED POWER AS THE SYSTEM ACTIVATES FAIL SAFE OPERATION. CODES P1A0E, P1A0F, P0A3C, P0A3E, P0A7A, P0A7C AND P1A0D MAY ALSO BE SET. *TR

CAR ENGINE TURNED OFF AT 70 MPH. I WAS ABLE TO DRIVE THE CAR TO THE SHOULDER OF THE ROAD. PRIOR TO THE ENGINE SHUT-OFF, ONLY THE "WRENCH INDICATOR" WAS ON; IT COMES ON OCCASIONALLY. SERVICE CENTERS CAN NEVER DIAGNOSE THE ISSUE ONCE THE CAR HAS TURNED OFF. WARNING LIGHT ON DASH SAID "SAFETY MODE" AT THE TIME OF ENGINE SHUT-OFF. I WAS ABLE TO RESTART THE CAR AFTER ABOUT TWO MINUTES. DASH WARNING INDICATORS TURNED OFF. GOT BACK ON THE INTERSTATE ONLY FOR THE CAR ENGINE TO TURN-OFF AGAIN AT THE BASE OF AN OFF-RAMP ABOUT FOUR MILES FARTHER UP THE ROAD. I WAS DRIVING THE CAR AT 55-60 MPH BEFORE THE SECOND INCIDENT. I WAS ABLE TO PULL INTO THE FORD DEALERSHIP. *TR

SINCE THE FIRST TIME I EXPERIENCED A BRAKING FAILURE INCIDENT I HAVE DONE A LOT OF RESEARCH&VISITS TO MECHANICS TO RETRIEVE CODES THROWN FROM THE CAR OFF DIAGNOSTIC MACHINES. REPLACING THE HCU CARRIES A PREMIUM PRICE TAG OF $5K-7K. PRIOR TO THE FIRST ACCIDENT,THERE IS NO OBVIOUS WAY THAT I COULD HAVE DAMAGED THE HCU WITH MY VERY NORMAL DRIVING HABITS (I.E.NO HISTORY OF TOWING, NO LONG DOWNHILL BRAKING)&THE HCU IS NOT A COMPONENT SUSCEPTIBLE TO WEAR TO THE POINT OF EARLY FAILURE. I BELIEVE THAT THE ESCAPE HYBRIDS BRAKING SYSTEM IS DEFECTIVE BY DESIGN (HENCE THE TSB)&FAULT LIES WITH FORD.I CONSIDER THIS BRAKE FAILURE VERY SERIOUS&A PROBLEM THAT FORD HAD NEVER BOTHERED TO NOTIFY ME ABOUT OR RECALL.MY ATTEMPTS TO GET FORD'S ATTENTION ON THIS MATTER HAVE BEEN FRUITLESS.TO SUMMARIZE NHTSA IS NOT CONCERNED B/C NOBODY HAS GOTTEN KILLED BY THESE DEFECTIVE BRAKES. FORD CLAIMS NO RESPONSIBILITY FOR THIS VERY SERIOUS&SIGNIFICANTLY DANGEROUS DESIGN FLAW.AFTER SEVERAL EPISODES OF BRAKE FAILURE I FOUND TSB 05-8-5 (8/5/05 NHTSA ID#10017553:ESCAPEHYBRIDVEHICLES EXHIBIT THE YELLOW ABS&RED E- BRAKE WARNING LAMPS ILLUMINATING AFTER THE ENGINE IS STARTED,&AN INCREASE INBRAKE PEDALEFFORT)FORD CLAIMS NO RESPONSIBILITY TO DEAL W/THE PROBLEM.ITS NOT SAFE TO DRIVE W/O THE REPAIR,IT HAD NO VALUE BEING BROKEN,&I DID NOT HAVE THE CONSCIENCE TO SELL THE VEHICLE W/A DANGEROUS PROBLEM.FORDS FAILURE TO PROACTIVELY ADDRESS THIS SAFETY ISSUE IS RATHER APPALLING.FORD ABANDONED ME W/A$7,000 BILL TO REPAIR A PROBLEM THAT IS SOLELY RELATED TO THEIR POOR DESIGN.FIRST ACCIDENT DESCRIPTION:ABS WARNING LIGHT&SERVICE ENGINE LIGHT ILLUMINATED ON CLUSTER."SERVICE BRAKE SYSTEM"&"REGENERATIVE BRAKING DISABLED" ILLUMINATED ON MESSAGE BOARD. ON THE HIGHWAY IN RUSH HOUR TRAFFIC,UPON EXTREME BRAKING, BRAKES FAILED TO STOP THE VEHICLE IN TIME TO AVOID A REAR-END COLLISION WITH THE VEHICLE STOPPED IN FRONT OF ME. *TR

MULTIPLE INCIDENTS OF THE VEHICLE SHUTTING DOWN OCCURRED ON 3/8/2014 BEGINNING WHILE TRAVELLING ALONG A 2-LANE HIGHWAY (CA-74 AROUND IDYLLWILD AREA) AT APPROXIMATELY 10:30 P.M. VEHICLE DISPLAYED RED TRIANGLE ICON WITH EXCLAMATION POINT INSIDE THE TRIANGLE AND WORDS IN RED "STOP SAFELY NOW", AT WHICH POINT POWER TO THE ENGINE WAS DISABLED ALTHOUGH POWER STEERING APPEARED TO STILL BE ACTIVE. I THEN PULLED OVER AT A TURN-OUT (LUCKILY ONE WAS NEARBY SINCE I WAS GOING UPHILL AND LOSING SPEED QUICKLY). I PROCEEDED TO TURN THE IGNITION TO THE OFF POSITION AND WITHIN MINUTES RE-STARTED WITHOUT FURTHER INCIDENT UNTIL APPROXIMATELY MIDNIGHT AT WHICH POINT I WAS TRAVELLING ALONG A MAJOR FREEWAY IN SAN DIEGO I-15 SOUTHBOUND AT A SPEED OF 65-70 MPH. AT THIS POINT THE VEHICLE BECAME DISABLED AFTER DISPLAYING THE RED ICON AND WORDS DESCRIBED ABOVE. THIS HAPPENED AGAIN 4 SEPARATE TIMES. THESE 4 INCIDENTS OCCURRED WITHIN A 6 MILE STRETCH OF EACH OTHER AND WITHIN A 20 MINUTE WINDOW. THERE WAS NO OTHER INDICATION THAT ANYTHING WAS WRONG WITH THE VEHICLE - NO SYSTEM NOTICE OF OVERHEATING, FAULTY ELECTRICAL, ETC. *TR