NUMEROUS INTERMITTENT BRAKE/SYSTEM ISSUES. INCLUDING GRABBING DURING TRANSITION FROM REGENERATIVE TO NORMAL BRAKING DURING WET/FROZEN CONDITIONS(CAUSING POOR CONTROL/SLIDING ON SLIPPERY ROADS). FIRST DEALER, NO TROUBLE FOUND, SECOND DEALER REPLACED FRONT TONE RING, DID NOT CORRECT, TOLD TO WAIT MAYBE A BULLETIN WILL BE ISSUED. D…
Read full complaint
NUMEROUS INTERMITTENT BRAKE/SYSTEM ISSUES. INCLUDING GRABBING DURING TRANSITION FROM REGENERATIVE TO NORMAL BRAKING DURING WET/FROZEN CONDITIONS(CAUSING POOR CONTROL/SLIDING ON SLIPPERY ROADS). FIRST DEALER, NO TROUBLE FOUND, SECOND DEALER REPLACED FRONT TONE RING, DID NOT CORRECT, TOLD TO WAIT MAYBE A BULLETIN WILL BE ISSUED. DEALER RETAINED PART. INTERMITTENT BRAKE ABS/TRACTION CONTROL/4X4 WARNING MESSAGES (VEHICLE MAY FAIL TO ACCELERATE DURING FAILURE AND OR UNEXPECTEDLY JUMP SIDE TO SIDE DURING NORMAL ACCELERATION). DEALER REPLACED REAR ROTATION SENSOR. DEALER RETAINED PART CLUNKING, LURCHING AND LOSS OF BRAKING DURING TRANSITION FROM REGENERATIVE TO NORMAL BRAKING (CAUSES DRIVER TO DEPRESS PEDAL HARDER THEN WHEN BRAKING RESTORES VEHICLE STOPS ABRUPTLY). NOT CHECKED BY DEALER. *TR
NHTSA ODI #10348066
45,100 miles · Jul 22, 2010
Service Brakes, Hydraulic
BRAKES SERVICED ON 07/12/10 CERTIFIED OK. ABS LIGHT ON 07/21/10. SHEEHY FORD; SPRINGFIELD, VA SERVICE MANAGER STATES, "NOT OUR FAULT YOUR FAULT!" SUV HAS EXTENDED SERVICE WARRANTY AND VIP MEMBER. BRAKES CERTIFIED AS SAFE ARE UNSAFE. *TR
NHTSA ODI #10344793
72,200 miles · Jun 2, 2010
Service Brakes, Hydraulic
THE BRAKES SUDDENLY DID NOT WORK WHILE PULLING OUT OF THE PARKING LOT. ABS LIGHT AND PARKING LIGHTS CAME ON AND SERVICE BRAKE WARNING. DIAGNOSTIC DETERMINE THAT HCU(HYDRAULIC CONTROL UNIT) AND ANTI-LOCK BRAKING FAILED. *TR
NHTSA ODI #10334345
90,000 miles · Feb 23, 2010
Service Brakes, Hydraulic
WHILE DRIVING ON INTERSTATE 95 IN NORTHERN VIRGINIA, MY FAMILY AND I WE'RE CRUISING AT HIGHWAY SPEEDS UNTIL TRAFFIC CAME TO A SUDDEN HALT. MY WIFE SUCCESSFULLY APPLIED THE BRAKES IN OUR 2007 FORD ESCAPE HYBRID AND WE CAME TO A STOP. HOWEVER, FOLLOWING THAT STOP, THE BRAKES NO LONGER FUNCTIONED. WE HAD MANAGED TO SUCCESSFULLY …
Read full complaint
WHILE DRIVING ON INTERSTATE 95 IN NORTHERN VIRGINIA, MY FAMILY AND I WE'RE CRUISING AT HIGHWAY SPEEDS UNTIL TRAFFIC CAME TO A SUDDEN HALT. MY WIFE SUCCESSFULLY APPLIED THE BRAKES IN OUR 2007 FORD ESCAPE HYBRID AND WE CAME TO A STOP. HOWEVER, FOLLOWING THAT STOP, THE BRAKES NO LONGER FUNCTIONED. WE HAD MANAGED TO SUCCESSFULLY NEGOTIATE THE VEHICLE OFF THE ROAD AND CALLED FOR A TOW TRUCK. THE ONLY FACTOR THAT LED TO THE STOPPING OF THE VEHICLE WAS DOWNSHIFTING AND USE OF THE EMERGENCY BRAKE. THANKFUL WE WERE SAFE, BUT FRUSTRATED BECAUSE WE HAD BEEN AT THE FORD DEALERSHIP THAT MORNING TO HAVE A SERVICE LIGHT AND WEAK BRAKING POWER INVESTIGATED. THE TECHNICIAN TOLD ME THAT THE SERVICE LIGHT COULD BE A COMPUTER MALFUNCTION (TO BE REMEDIED BY A "RE BOOT" OF THE SYSTEM) OR A FAILURE OF THE ELECTRONIC CONTROL MODULE. HE ASSURED ME THE VEHICLE WAS SAFE TO DRIVE. IN THE END, BOTH THE ELECTRONIC CONTROL MODULE AND HYDRAULIC CONTROL MODULE FAILED, RESULTING IN THE INCIDENT ON I-95. *TR CONSUMER STATED HE GOT RID OF THE VEHICLE AFTER THE BRAKE FAILURE. UPDATED 6/8/18*JB
NHTSA ODI #10312977
3,000 miles · Feb 3, 2010
Service Brakes, Hydraulic
FULL BRAKE FAILURE ON A BRAND NEW FORD ESCAPE HYBRID. BRAKES FAILED AT 3,000 MILES ON THE CAR ON MY WAY TO WORK. DEALER FOUND AND FIXED A "COMPUTER" SYSTEM DEFECT THAT CAUSED THE BRAKING SYSTEM TO FAIL COMPLETELY. SCATTERED SIMILAR REPORTS ON THE INTERNET ON THE FORD ESCAPE. IF IT HADN'T BEEN SIX AM ON A QUIET STREET I WOULD HAV…
Read full complaint
FULL BRAKE FAILURE ON A BRAND NEW FORD ESCAPE HYBRID. BRAKES FAILED AT 3,000 MILES ON THE CAR ON MY WAY TO WORK. DEALER FOUND AND FIXED A "COMPUTER" SYSTEM DEFECT THAT CAUSED THE BRAKING SYSTEM TO FAIL COMPLETELY. SCATTERED SIMILAR REPORTS ON THE INTERNET ON THE FORD ESCAPE. IF IT HADN'T BEEN SIX AM ON A QUIET STREET I WOULD HAVE CRASHED THE CAR. THERE WAS NO BRAKING POWER WHATSOEVER. BRAKE LIGHT WARNING DID FLASH.*TR
NHTSA ODI #10304207
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
2007 Ford Escape Hybrid Problems, Complaints & Recalls | Skip That Year
Illustration