NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
15 reportsClear category filter102,000 miles · Apr 29, 2015
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2007 FORD ESCAPE HYBRID. WHILE DRIVING AT 20 MPH AND APPROACHING A STOP SIGN, THE BRAKES FAILED TO RESPOND. THE VEHICLE WAS TOWED TO THE DEALER, WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC UNIT FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 102,0…
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD ESCAPE HYBRID. WHILE DRIVING AT 20 MPH AND APPROACHING A STOP SIGN, THE BRAKES FAILED TO RESPOND. THE VEHICLE WAS TOWED TO THE DEALER, WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC UNIT FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 102,000. UPDATED 7/9/15*CN
NHTSA ODI #10713585
86,600 miles · Jul 2, 2014
Electrical SystemService Brakes, Hydraulic
TL* THE CONTACT OWNS A 2007 FORD ESCAPE HYBRID. THE CONTACT STATED THAT THE ABS AND BRAKE LIGHT INDICATORS ILLUMINATED INTERMITTENTLY. THE DEALER STATED THAT THERE WAS INTERNAL ABS CONTROL MODULE AND HCU FAILURE. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 86,600.
NHTSA ODI #10607723
64,150 miles · Jul 16, 2013
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
WHILE BACKING OUT OF A PARKING SPACE, THE RIGHT FRONT WHEEL SEPARATED FROM THE VEHICLE. UPON CLOSER INSPECTION, IT APPEARED THAT THE BOLT SHEARED, DISLOCATING THE WHEEL FROM THE DRIVETRAIN. THIS WAS LATER CONFIRMED AT THE REPAIR CENTER--THE BOLT HAD SHEARED AND HAD TO BE DRILLED OUT. THE FRONT LOWER CONTROL ARM BOLTS (FORWARD…
Read full complaint
WHILE BACKING OUT OF A PARKING SPACE, THE RIGHT FRONT WHEEL SEPARATED FROM THE VEHICLE. UPON CLOSER INSPECTION, IT APPEARED THAT THE BOLT SHEARED, DISLOCATING THE WHEEL FROM THE DRIVETRAIN. THIS WAS LATER CONFIRMED AT THE REPAIR CENTER--THE BOLT HAD SHEARED AND HAD TO BE DRILLED OUT. THE FRONT LOWER CONTROL ARM BOLTS (FORWARD BOLT) REMOVED AND THREADS HAD TO BE REPAIRED. THE RIGHT FRONT AXLE ALSO HAD TO BE REPLACED. THIS VEHICLE IS ONLY 6.5 YEARS OLD, AND IS NOT DRIVEN OFF ROAD. FORD DOES NOT ACKNOWLEDGE THIS AS AN ISSUE. AS NOTED ELSEWHERE ON THIS SITE, WE ALSO HAVE HAD ISSUES WITH BRAKE SQUEALING, AS WELL AS THE WATER PUMP ISSUE. *TR
NHTSA ODI #10525152
79,000 miles · Apr 24, 2012
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 2007 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING SERVICED BY A DEALER, THE DEALER STATED THAT THE MASTER CYLINDER NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 79,000. THE VIN WAS UNKNOWN.
NHTSA ODI #10456368
87,080 miles · Mar 1, 2012
Service Brakes, Hydraulic
I WAS LEAVING THE PARKING LOT AT MY OFFICE AND "SERVICE BRAKE SYSTEM" "SERVICE 4X4" AND ABS LIGHT ALL COME ON. IT APPEARS TO BE SPLIT TONE RING - A WELL KNOWN ISSUE WITH FORD ESCAPE HYBRID IF YOU SEARCH WITH GOOGLE. *TR
NHTSA ODI #10450012
96,493 miles · May 5, 2011
Service Brakes, Hydraulic
TOTAL BRAKE FAILURE. ABS AND BRAKE WARNING LIGHTS CAME ON, FOLLOWED BY TOTAL BRAKE FAILURE. OCCURRED FOLLOWING SERVICE AT FORD DEALERSHIP. THE PROBLEM FIRST OCCURRED TO MECHANICS SERVICING THE VEHICLE. I WAS NOT TOLD THAT A BRAKE FAILURE HAD OCCURRED TO THE VEHICLE. *TR
NHTSA ODI #10399223
57,000 miles · Dec 26, 2010
Service Brakes, Hydraulic
2007 FORD ESCAPE HYBRID. THE CAR SKID AS I APPLY BRAKES. IT IS VERY DANGEROUS. *TR
NHTSA ODI #10372461
47,600 miles · Dec 23, 2010
Service Brakes, Hydraulic
WHILE DRIVING THE "SERVICE BRAKE SYSTEM" LIGHT CAME ON. ABS LIGHT ALSO CAME ON AND THE BRAKE PEDAL DID NOT RESPOND NORMALLY AND CAR PULLED HARD TO THE LEFT WHEN BRAKING. WHEN CAN WAS TURNED OFF AND BACK ON THE ABS LIGHT WAS OFF BUT THE PROBLEM HAS RECURRED 2 MORE TIMES. CAR WAS TAKEN TO THE DEALERSHIP AND WAS DIAGNOSED WITH FAUL…
Read full complaint
WHILE DRIVING THE "SERVICE BRAKE SYSTEM" LIGHT CAME ON. ABS LIGHT ALSO CAME ON AND THE BRAKE PEDAL DID NOT RESPOND NORMALLY AND CAR PULLED HARD TO THE LEFT WHEN BRAKING. WHEN CAN WAS TURNED OFF AND BACK ON THE ABS LIGHT WAS OFF BUT THE PROBLEM HAS RECURRED 2 MORE TIMES. CAR WAS TAKEN TO THE DEALERSHIP AND WAS DIAGNOSED WITH FAULTY MASTER BRAKE CYLINDER SENSOR. *LN
NHTSA ODI #10372187
34,000 miles · Nov 16, 2010
Service Brakes, Hydraulic
TL. THE CONTACT 2007 FORD ESCAPE HYBRID. THE CONTACT STATED WHILE DRIVING 5 MPH THE CONTACT NOTICE THE ABS AND SERVICE BRAKE WAS ON. THE CONTACT DROVE THE VEHICLE TO THE DEALER AND THE DEALER NOTICE THE HYDRAULIC CONTROL UNIT HAD BROKEN. THE DEALER NOR THE CONTACT COULD NOT DETERMINE WHAT CAUSED THE HYDRAULIC CONTROL UNIT TO …
Read full complaint
TL. THE CONTACT 2007 FORD ESCAPE HYBRID. THE CONTACT STATED WHILE DRIVING 5 MPH THE CONTACT NOTICE THE ABS AND SERVICE BRAKE WAS ON. THE CONTACT DROVE THE VEHICLE TO THE DEALER AND THE DEALER NOTICE THE HYDRAULIC CONTROL UNIT HAD BROKEN. THE DEALER NOR THE CONTACT COULD NOT DETERMINE WHAT CAUSED THE HYDRAULIC CONTROL UNIT TO BRAKE. THE CONTACT HAS NOT CALLED THE MANUFACTURER REGARDING THE BRAKE UNIT. THE CONTACT NOTICE NUMEROUS COMPLAINTS REGARDING THE HYDRAULIC CONTROL UNIT FOR THIS YEAR MAKE AND MODEL AND STATED THIS MALFUNCTION COULD CAUSE A CRASH. THE FAILURE MILEAGE WAS 34,000. JO
NHTSA ODI #10366379
55,000 miles · Sep 16, 2010
Electrical SystemService Brakes, Hydraulic
AT 41,000 MILES, THE SERVICE BRAKE SYSTEM LIGHT CAME ON AND REQUIRED AN ABS TONE RING TO BE REPLACED. THIS IS NOW LOOKING TO BE QUITE THE COMMON PART TO BREAK AFTER THE WARRANTY EXPIRES. THE SERVICE BRAKE SYSTEM LIGHT WOULD COME ON IN FREQUENTLY, BUT WOULD NEVER GENERATE A DIAGNOSTIC CODE. AT ~55000 MILES, THE SERVICE BRAKE S…
Read full complaint
AT 41,000 MILES, THE SERVICE BRAKE SYSTEM LIGHT CAME ON AND REQUIRED AN ABS TONE RING TO BE REPLACED. THIS IS NOW LOOKING TO BE QUITE THE COMMON PART TO BREAK AFTER THE WARRANTY EXPIRES. THE SERVICE BRAKE SYSTEM LIGHT WOULD COME ON IN FREQUENTLY, BUT WOULD NEVER GENERATE A DIAGNOSTIC CODE. AT ~55000 MILES, THE SERVICE BRAKE SYSTEM LIGHT TURNED ON AND WHEN I DEPRESSED MY BRAKE PEDAL, IT WENT TO THE FLOOR AND WAS ONLY ABLE TO STOP THE CAR BY DOWNSHIFTING AND USING THE EMERGENCY BRAKE. LUCKILY I WAS ONLY DRIVING ~25 MPH ON AN EMPTY ROAD, BUT MY YOUNG CHILDREN WERE IN THE CAR. I TURNED THE CAR OFF, AND BACK ON AND TESTED THE BRAKES ON A SHORT FLAT SECTION OF THE ROAD AND THEY WORKED. I PROCEEDED THE 1/4 MILE TO MY HOUSE AND AFTER STOPPING AT A RED LIGHT AND 2 STOP SIGNS, THE BRAKES FAILED PULLING INTO MY DRIVEWAY BEING STOPPED BY MY OTHER CAR!!! THE FORD DEALER HAD THE CAR AND PULLED A DIAGNOSTIC CODE WHICH HAD THEM REPLACE AN ACTUATOR IN THE D-PILLAR. THEY ASSURED ME THAT THIS SOLVED THE ISSUE. MY WIFE LEFT TO TAKE THE KIDS TO SCHOOL AND THE SERVICE BRAKE SYSTEM LIGHT TURNED ON AND THE BRAKES FAILED AS SHE PULLED INTO THE DRIVEWAY. WE HAD THE VEHICLE TOWED TO FORD AND THEY HAVE BEEN UNABLE TO FIND ANYTHING WRONG OR GET THE BRAKES TO FAIL. NO CODES WERE GENERATED. THE GENERAL MANAGER OF THE DEALERSHIP CLAIMED HE HAD NEVER HEARD OF BRAKES FAILING ON FORD HYBRIDS. *TR
NHTSA ODI #10355987
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
Illustration