WHEN THE VEHICLE IS WARMED UP AND DECELERATING BELOW 40MPH THEY GASOLINE ENGINE WILL SHUT OFF AS THE REGENERATIVE BRAKING CHARGES THE HYBRID HIGH VOLTAGE BATTERY. ON A RARE OCCASION DURING THIS BRAKING, THE GASOLINE ENGINE WILL TURN BACK ON GIVING A BRIEF SURGE WHICH REQUIRES PRESSING THE BRAKE HARDER. IT HAS DONE THIS SINCE I…
Read full complaint
WHEN THE VEHICLE IS WARMED UP AND DECELERATING BELOW 40MPH THEY GASOLINE ENGINE WILL SHUT OFF AS THE REGENERATIVE BRAKING CHARGES THE HYBRID HIGH VOLTAGE BATTERY. ON A RARE OCCASION DURING THIS BRAKING, THE GASOLINE ENGINE WILL TURN BACK ON GIVING A BRIEF SURGE WHICH REQUIRES PRESSING THE BRAKE HARDER. IT HAS DONE THIS SINCE I BOUGHT THE VEHICLE. *TR
NHTSA ODI #10633774
75,000 miles · May 29, 2014
Electrical SystemEngine
TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE WATER PUMP FOR THE HYBRID BATTERY FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAI…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE WATER PUMP FOR THE HYBRID BATTERY FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 75,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10594930
99,000 miles · May 3, 2014
Electrical SystemEngine
0 *TR
NHTSA ODI #10586342
140,000 miles · Sep 11, 2013
Electrical SystemEngineHybrid Propulsion System
TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE LOST POWER AND STALLED. THE CONTACT ALSO MENTIONED THAT A RED TRIANGLE ILLUMINATED WITH A MESSAGE TO STOP SAFETY. THE VEHICLE WAS TAKEN TO THE DEALER AND THE MECHANIC DIAGNOSED THAT THE SERVICE HARNESS NEEDED TO BE …
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE LOST POWER AND STALLED. THE CONTACT ALSO MENTIONED THAT A RED TRIANGLE ILLUMINATED WITH A MESSAGE TO STOP SAFETY. THE VEHICLE WAS TAKEN TO THE DEALER AND THE MECHANIC DIAGNOSED THAT THE SERVICE HARNESS NEEDED TO BE INSTALLED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000. ACCORDING TO THE SERVICE BULLETIN, THE PROGRAM INVOLVED INSTALLING A SERVICE HARNESS IN THE HIGH-VOLTAGE TRACTION BATTERY AND REPROGRAMMING THE BATTERY CONTROL MODULE. UPDATED 11/06/13 UPDATED 11/29/13*LJ
NHTSA ODI #10543050
115,790 miles · Nov 26, 2012
Electrical SystemEngineVehicle Speed Control
DRIVING AT NIGHT ON FOUR-LANE US HIGHWAY AT 50 MPH WHEN ENGINE SUDDENLY STALLED. WARNING LAMP CAME ON WITH STOP SAFELY NOW MESSAGE. SCARY IN TRAFFIC BUT WAS ABLE TO PULL OVER ONTO SHOULDER WITHOUT CAUSING AN ACCIDENT. AAA TOWED TO FORD DEALERSHIP WHICH DIAGNOSED STUCK OPEN CIRCUIT IN THROTTLE BODY. REPLACED PART 5M6Z*9E926*C…
Read full complaint
DRIVING AT NIGHT ON FOUR-LANE US HIGHWAY AT 50 MPH WHEN ENGINE SUDDENLY STALLED. WARNING LAMP CAME ON WITH STOP SAFELY NOW MESSAGE. SCARY IN TRAFFIC BUT WAS ABLE TO PULL OVER ONTO SHOULDER WITHOUT CAUSING AN ACCIDENT. AAA TOWED TO FORD DEALERSHIP WHICH DIAGNOSED STUCK OPEN CIRCUIT IN THROTTLE BODY. REPLACED PART 5M6Z*9E926*CA THROTTLE BODY AND MOTOR ASY. PART $376.70 LABOR $262.50 SHOP FEE $2.50 SALES TAX $48.13 TOTAL $ 689.83 VERY EXPENSIVE BUT LUCKY TO NOT HAVE BEEN HURT. *TR
NHTSA ODI #10486140
81,939 miles · Nov 26, 2012
Engine
TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, HE NOTICED A TICKING AND BANGING SOUND COMING FROM THE ENGINE. THE CONTACT MERGED TO THE SHOULDER OF THE ROAD AND HAD THE VEHICLE TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE ENGINE NEEDED TO …
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, HE NOTICED A TICKING AND BANGING SOUND COMING FROM THE ENGINE. THE CONTACT MERGED TO THE SHOULDER OF THE ROAD AND HAD THE VEHICLE TOWED TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE ENGINE NEEDED TO BE REPLACED BECAUSE THE NUMBER ONE PISTON WAS HITTING THE VALVE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 81,939.
NHTSA ODI #10486007
92,040 miles · Jul 3, 2012
EnginePower Train
WHILE TRAVELING IN THE HIGH SPEED LANE AT APPROXIMATELY 2 AM, THE VEHICLE LOST ENGINE POWER WITHOUT ANY NOTICE AS THE ENGINE SHUT OFF AND THE POWER WAS REDUCED TO MINIMAL POWER GIVEN BY THE ELECTRIC MOTOR. THIS CAUSED AN INABILITY TO MAINTAIN SPEED ON A VERY DANGEROUS OVERPASS CURVE OF THE FREEWAY AND NEARLY CAUSED TWO VEHICLES …
Read full complaint
WHILE TRAVELING IN THE HIGH SPEED LANE AT APPROXIMATELY 2 AM, THE VEHICLE LOST ENGINE POWER WITHOUT ANY NOTICE AS THE ENGINE SHUT OFF AND THE POWER WAS REDUCED TO MINIMAL POWER GIVEN BY THE ELECTRIC MOTOR. THIS CAUSED AN INABILITY TO MAINTAIN SPEED ON A VERY DANGEROUS OVERPASS CURVE OF THE FREEWAY AND NEARLY CAUSED TWO VEHICLES IN THE IMMEDIATE PROXIMITY TO COLLIDE WITH MY VEHICLE AS SPEED RAPIDLY DROPPED AND THE VEHICLE SAID TO "PULL OVER ANDS SHUT OFF VEHICLE SAFELY". THIS PART OF THE FREEWAY HAD NO PULL OVER SPOT NOR DID IT HAVE AN AREA TO REALLY SAFELY PULL OFF THE FREEWAY. THIS IS THE SECOND TIME THE CAR HAS DONE THIS AT HIGH SPEED WITHIN TWO WEEKS. IT HAS DONE THIS APPROXIMATELY 1-0 TIMES AT LOW SPEEDS ON CITY STREETS. THE CAR IS ABLE TO BE DRIVEN AFTER SHUTTING OFF THE POWER, LETTING IT SIT, AND THEN RESTARTING THE SYSTEM. THERE IS AN ACCOMPANYING OVERHEATING THAT OCCURTS AS A RESULT OF THE ENGINE SHUTTING OFF, CAUSING THE ENGINE TO BE UNABLE TO BE EASILY RESTARTED AT THAT POINT. THIS EVENT GIVES NO WARNING OR INDICATION IT WILL HAPPEN AND IS A VERY DANGEROUS SITUATION FOR ANY DRIVER TO BE THRUST INTO. IF IT HAD BEEN RUSH HOUR TRAFFIC, I AM CERTAIN THERE WOULD HAVE BEEN ACCIDENTS AND VEHICLE COLLISIONS AS A RESULT. *JS
NHTSA ODI #10464035
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
2005 Ford Escape Hybrid Problems, Complaints & Recalls | Skip That Year
Illustration