2005 Ford Escape Hybrid

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. WHILE DRIVING 35 MPH, THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT DROVE TO LITHIA FORD LINCOLN OF ROSEBURG (1650 NE STEPHENS ST, ROSEBURG, OR 97470, (541) 537-4643) WHERE IT WAS DIAGNOSED THAT TWO HYBRID FANS NEEDED TO BE REPLACED. THE CONTACT CLAIMED THAT A RECALL WAS ISSUED FOR THIS YEAR, MAKE, AND MODEL VEHICLE; HOWEVER, UPON INVESTIGATION, NO RECALLS COULD BE FOUND. THE MANUFACTURER WAS NOTIFIED AND WERE CURRENTLY ORDERING THE PARTS FOR THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000.

OVER THE PAST 3 YEARS I HAVE HAD THE ISSUE OF 'STOP SAFELY NOW' ON MULTIPLE OCCASIONS. THESE ISSUES DIDN'T START UNTIL THE MEC PUMP WAS REPLACED UNDER A RECALL. AFTER THAT MY 2005 ESCAPE HYBRID WILL SHUT DOWN WHILE DRIVING OR NOT START OR CUT OUT THE HYBRID POWER AND RUN ON ENGINE ONLY. I TOOK IT TO THE LOCAL FORD DEALERSHIP WHERE WE HAVE GOTTEN ALL OTHER SERVICE DONE THREE TIMES FOR THESE ISSUES. THEY HAVEN'T BEEN ABLE TO TELL ME ANYTHING, STATING ONLY THAT THERE ARE NO CODES, SO NO IDEA WHERE TO LOOK. I COULDN'T UNDERSTAND HOW THE COMPUTER CAN KNOW TO TELL ME TO STOP DRIVING THE CAR, YET NOT RECORD A DTC. IT HAPPENED AGAIN ON THE FIRST WARM DAY OF THE SUMMER - DROVE ACROSS TOWN, PARKED IT, CAME BACK 20 MINUTES LATER AND IT WOULDN'T START, SHOWING 'STOP SAFELY NOW'. I LEFT IT UNTIL THE NEXT MORNING AND IT STARTED RIGHT UP AND I DROVE IT HOME. I WENT OUT AND BOUGHT SCANXL AND USED MY LAPTOP TO SCAN THE CAR. I FOUND P1A10, P1A14, P0A0A, AND P0A95. IF I CAN BUY SOME CONSUMER PROGRAM AND FIND THIS INFO, WAY IS FORD TELLING THERE ARE NO CODES? FORD ALSO REPLACED THE BATTERY FANS TWO YEARS AGO, STATING THEY WERE COVERED UNDER SOME RECALL OR WARRANTY. SEARCHING THE INTERNET GETS ME 100'S OF COMMENTS ON THIS STOP SAFELY ISSUE WITH DOZENS OF POSSIBLE CAUSES DEPENDING ON THE YEAR AND MODEL. MY SCAN TOOL SHOWS A BATTERY VOLTAGE OF 665 VOLTS, THOUGH IT'S SUPPOSED TO BE A 300 VOLT BATTERY. THE HYBRID EVAPORATOR TEMP CAN RANGE BETWEEN 220 AND 310 DEGREES F WHEN IT'S RUNNING OK. THAT CAN'T BE NORMAL. I HAVE NO IDEA WHAT'S GOING ON AND CAN'T GET ANY HELP FROM THE FORD DEALER.

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING AND THE "STOP SAFELY" WARNING INDICATOR FLASHED. THE VEHICLE WAS UNABLE TO BE DRIVEN DUE TO THE FAILURE. MANTECA FORD (555 N MAIN ST, MANTECA, CA 95336, (209) 239-3561) WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE NEEDED TO BE DIAGNOSED IN ORDER TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

I WAS ABOUT 115 MILES INTO A 130 MILE TRIP, DOING 70 MPH ON THE INTERSTATE, WHEN OUT OF NO WHERE MY VEHICLE JERKED VERY HARD AND THEN STARTED MAKING LOUD SOUNDS LIKE PARTS FALLING OUT. ALL OF THE CARS BEHIDE ME HAD TO SLAM ON BREAKS AND AVOID HITTING ME. NO LIGHTS OR WARNINGS HAD COME ON UNTIL AFTER THIS HAPPENED. I STEERED THE CAR OFF OF THE INTERSTATE AND DOWN THE RAMP INTO A STORE PARKING LOT. THE CAR WAS NOT RUNNING HOT. LOOKED UNDER CAR AND OIL WAS COMING OUT ALL OVER THE GROUND. A MAN LOOKED AND SAID IT LOOKED LIKE THE COOLANT SYSTEM MESSED UP AND IT THROUGH A ROD IN THE MOTOR BLOCK. I GOT THE CAR ONE MONTH AGO AND IT WAS DOING GREAT. BY LOOKING UP ON TYPE CAR THERE IS OTHERS HAVING PROBLEMS LIKE THIS AND RECALLS ON THE COOLANT SYSTEM. BUT NO ONE ON MY VIN. RECALL 14V526000

WHILE DRIVING, RECEIVED A "STOP SAFELY NOW" WARNING LIGHT AND THE ENGINE SHUTDOWN. SECOND TIME IN THREE WEEKS SUCH INCIDENT OCCURRED AND THIS IS AFTER SUPPOSED "SAFETY RECALL" WORK DONE ON THE VEHICLE A FEW MONTHS BACK. PREVIOUS TO THE RECALL, THE CAR ACTUALLY SHUTDOWN NUMEROUS TIMES WHILE TRAVELING AT HIGH RATES OF SPEED ON MAJOR INTERSTATE HIGHWAYS. AFTER THE LIGHT COMES ON, THE GAS PEDAL IS NO LONGER RESPONSIVE AND YOU HAVE TO HOPE YOU CAN COAST OFF THE SIDE OF THE ROAD. ONCE YOU STOP SAFELY AND TURN OFF THE CAR, AFTER WAITING 5-10 MINUTES, THE CAR USUALLY COMES BACK ON, WHICH LEADS ME TO BELIEVE IT IS DUE TO SOME SORT OF OVERTEMP CONDITION.

TL* THE CONTACT OWNS A 2005 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE BECAME EXTREMELY HOT, THE ENGINE STALLED, AND AN UNKNOWN WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE JOLTED WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V256000 (HYBRID PROPULSION SYSTEM). THE APPROXIMATE FAILURE MILEAGE WAS 141,418.

RIGHT REAR WELL CORRODED EXTENSIVELY. 4 INCH HOLE EXPOSING HIGH VOLTAGE BATTERY IN TRUNK TO WATER, SALT, SNOW. DEALER STATES THAT VEHICLE IS UNSAFE TO DRIVE DUE TO RISK OF COLLAPSE OF STRUTS AND RISK OF EXPLOSION/FIRE FROM HIGH VOLTAGE BATTERY EXPOSURE. QUOTES MORE THAN $4000 TO REPAIR THIS VEHICLE WITH ONLY 59,510 MILES. REAR BUMPER AND REAR SUSPENSION BOTH COMPROMISED. REAR BUMPER HAS NO SUPPORT ON RIGHT SIDE RISKING PASSENGER INJURY IN ACCIDENT. REAR SHOCK STRUT COLLAPSING. REQUEST INVESTIGATION AND RECALL ACTION. *TR