Power Train. Review the 183 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

12 crash reports1 fire reports12 injury reports

Wheels complaints

4 reports

Clear category filter

Mileage unknown · Sep 12, 2025

Power TrainUnknown Or OtherWheels

Read full complaint

Gear change struggles and shudders during 2nd to 4th gear (18-39 mph) when pressing the gas pedal. Driving in sport mode does help but not for long. This problem disappears when cruise control is activated. Went to workshop and had to replace the torque converter. Several owners report similar problems. I bought this car with a mileage of 103,000 miles and it seems to already have some jerking during gear changes but not as bad. It got worse around 120,000 miles. The safety was not of a concern, but the driving dynamics was concerning since the whole vehicle was shaking during gear changes. I checked the NHTSA website and it this vehicle did not have any recalls so far. Another slightly minor but inconvenient issue is the TPMS sensor malfunction. Most of the time the sensors seem to be working perfectly but every time I drive above 50 mph for at least half an hour the dashboard shows TPMS sensor malfunctioning. After I turned off the engine for at least 15 to 30 minutes and I turn on the engine again. The problem seems to disappear temporarily

NHTSA ODI #11686987

Mileage unknown · Apr 13, 2023

Wheels

Swollen 2-part Lug Nuts

NHTSA ODI #11516930

601 miles · Jan 13, 2021

SteeringSuspensionWheels

Read full complaint

I NOTICED A KNOCKING IN THE LEFT FRONT END. IT WAS DIFFICULT TO STEER, VERY LOUD RUMBLING NOISE LIKE GEARS CLASHING. LUCKILY I WAS ONLY GOING 25 MPH WHEN IT HAPPENED AND A MILE AWAY FROM HOME. WHEN I ALMOST STOPPED COULDN'T STEER AT ALL. PURCHASED OCTOBER 27, 2020, IT IS CURRENTLY JANUARY 13, 2021 AND HAS 601 MILES ON IT. IT HAS BEEN IN THE SHOP FOR 3 DAYS. FORD DEALERSHIP VERIFIED THAT IS WAS A FACTORY WELD FAILURE. THE PIECE THAT BROKE OFF MADE A NOTCH IN THE TIRE WHICH WILL BE SHOWN IN THE PHOTOS. I DO NOT FEEL SAFE DRIVING THE VEHICLE WITH A MAJOR WELD FAILURE HAPPENING AT ONLY 601 MILES AND NOW I WORRY ABOUT THE OTHER WELDS ON THE FRAME.

NHTSA ODI #11387924

7,000 miles · Oct 10, 2020

Wheels

PERILLI SCORPION TIRE WITH ONLY 7,000 MILES ON IT EXPLODED WHILE DRIVING ON A HIGHWAY GOING 80 MILES AN HOUR. NOTHING WAS IN THE ROAD, DID NOT HIT OR RUN OVER ANYTHING. NO OTHER DAMAGE TO CAR INCLUDING RIM.

NHTSA ODI #11363668

Official recalls

25V442000 · Back Over Prevention:software

Jun 27, 2025

Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

Consequence & remedy

Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

21V011000 · Power Train:driveline:driveshaft

Jan 15, 2021

Ford Motor Company (Ford) is recalling certain 2020-2021 Edge, 2020 Lincoln Nautilus and Ford Escape and 2021 Lincoln Corsair and Ford Bronco Sport vehicles. An inadequate amount of lubricant in the rear drive unit may cause seizure of the rear drive axle.

Consequence & remedy

Consequence: If the rear drive unit seizes, there may be a loss of drive and/or a loss of vehicle control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will check the rear drive unit lubricant level. Axles found to have lubricant at the minimum level will be filled to the full level. Axles found to be below the minimum lubricant fill level will be replaced, free of charge. This recall began March 12, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S02.

20V575000 · Back Over Prevention: Sensing System: Camera

Sep 23, 2020

Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence & remedy

Consequence: Reduced rearward visibility can increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.

20V550000 · Power Train:automatic Transmission

Sep 10, 2020

Ford Motor Company (Ford) is recalling certain 2019-2020 Edge, Transit Connect and Lincoln MKX and 2020 Escape and Lincoln Corsair vehicles. The start/stop accumulator endcap may have missing or loose bolts.

Consequence & remedy

Consequence: Missing or loose bolts on the start stop accumulator endcap could result in a transmission fluid leak and may progress to a loss of transmission function. A transmission fluid leak in the presence of an ignition source may increase the risk of fire.

Remedy: Ford will notify owners, and dealers will replace the start/stop accumulator, free of charge. The recall began September 23, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S49.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ21002 · Rearview Camera Fmvss 111 Noncompliance

Opened Aug 3, 2021 · No close date supplied

Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera

On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.