2019 Ford Edge

The contact owns a 2019 Ford Edge. The contact stated that the check engine warning light was illuminated. The contact used a vehicle scanner to scan the vehicle. The contact retrieved DTC: P0446 (Evaporative Emission Control System (EVAP) vent control circuit malfunction). Additionally, the contact stated that the infotainment system was frozen and was inoperable, and there was rust underneath the hood because the vehicle was not equipped with a hood shroud. The dealer was notified of the failure, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a case was opened. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 64,000.

The contact owns a 2019 Ford Edge. The contact stated that while opening the liftgate to place groceries inside the vehicle, the liftgate attempted to close, and in the process,s the liftgate quickly closed, knocking the contact to the ground. No warning lights were illuminated. The contact was not injured, and no medical attention was needed. The local dealer was not contacted, and the vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 55,124.

2019 Ford Edge Titanium Rear Lift Gate Glass Shatters. The rear lift gate glass of a 2019 Ford Edge Titanium shattered by simply and normally closing the driver side door without warning or symptoms. There was no impact of any object with the lift gate glass. Rear glass defogging heat was not on at the time. This rendered the vehicle unsafe to drive and cost the owner roughly $1000 to repair. It was not inspected by the manufacturer, but repairs were made by an authorized Ford Dealer. Local news channel ran a news story piece on similar occurrences, so it is believed this is not a random occurrence.

Engine: Severe surging at low power settings, especially during engine warm-up. This surging is not related to air conditioner compressor cycling on/off, or turbo lag. Body: Rear hatch "kick to open" feature often activates suddenly without warning and without a deliberate kick motion by operator. This feature cannot be disabled; only the actuator can be disabled using instrument panel menus. This creates a condition where any inadvertent "open" command using any device will unlatch, but not open, the hatch. This can lead to loss of internal security and/or driving with an unlatched hatch. Thank You

The contact owns a 2019 Ford Edge. The contact stated that the driver's side door was making an abnormal squeaking sound. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the door needed to be replaced. The dealer informed the contact that rainwater had entered the door and the door’s structure was deteriorating. The vehicle was not repaired. The manufacturer was contacted and opened a case and referred the contact to the NHTSA Hotline. The failure mileage was approximately 40,000.

The contact owns a 2019 Ford Edge. The contact stated while entering the vehicle, she became aware that the driver's side door was squeaky and difficult to open. The vehicle was taken to the dealer, who diagnosed a failure with the driver's side door check arm attachment point. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Action Number: PE23013 (Structure). The manufacturer was notified of the failure but referred the contact to the NHTSA hotline for assistance. The failure mileage was 50,000.

The contact owns a 2019 Ford Edge. The contact stated that the trunk door inadvertently closed on the driver and was difficult to raise up. There were no warning lights illuminated. There were no reported injuries. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 15,900.

VEHICLE HAD REAR LIFT GATE ISSUES JULY 2020. THE LIFT GATE BECAME TOTALLY INOP AT THAT TIME AND SPENT A LENGTHY TIME IN THE SHOP. THIS ISSUE HAS BEEN OCCURRING INTERMITTENTLY SINCE THEN. I WENT SHOPPING THIS MORNING AND LIFT GATE WORKED OK WHEN LOADING BUT BECAME INOP WHEN I GOT HOME AND I HAD TO FOLD THE REAR SEATS DOWN FOR ACCESS TO GROCERY BAGS.THE ODD THING IS THE SYSTEM STARTS TO WORK NORMALLY AFTER SITTING FOR A SHORT TIME. I'M CONCERNED THAT IF THIS IS AN ON GOING ISSUE WITH THESE VEHICLES WHAT IF IN AN EMERGENCY THE LIFT GATE BECAME INOP?