TL* THE CONTACT OWNS A 2011 FORD EDGE. THE CONTACT STATED THAT THE AUTOMATIC DOOR SYSTEM WAS DEFECTIVE AND WOULD INDICATE THAT THE DOOR WAS OPEN WHEN IT WAS ACTUALLY CLOSED. THE AUTOMATIC DOOR LOCK SYSTEM FAILED TO ENGAGE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE DOOR MODULE NEEDED TO BE REPLACE…
Read full complaint
TL* THE CONTACT OWNS A 2011 FORD EDGE. THE CONTACT STATED THAT THE AUTOMATIC DOOR SYSTEM WAS DEFECTIVE AND WOULD INDICATE THAT THE DOOR WAS OPEN WHEN IT WAS ACTUALLY CLOSED. THE AUTOMATIC DOOR LOCK SYSTEM FAILED TO ENGAGE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE DOOR MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 45,000 AND CURRENT MILEAGE WAS 47,000.
NHTSA ODI #10605984
60,000 miles · Jun 22, 2014
Electrical SystemStructure
DRIVER DOOR SAYS IT'S OPEN WHEN IT'S NOT. *TR
NHTSA ODI #10605075
45,000 miles · Jun 16, 2014
Electrical SystemStructure
DRIVER'S DOOR LATCH REPORTS DOOR IS AJAR, WHICH PREVENTS CAR FROM LOCKING DOORS WHEN CAR IS MOVING. OTHER SIDE EFFECTS - CAN'T USE TOUCH-LOCK FEATURES, LIGHTS ARE STAYING ON AFTER CAR IS LOCKED ETC. *TR
NHTSA ODI #10598633
21,288 miles · Jun 8, 2014
Electrical SystemStructure
DRIVER DOOR AJAR LIGHT COMES ON WHEN DOOR IS CLOSED AS WELL AS WHILE VEHICLE IS MOVING. INTERIOR AS WELL AS PUDDLE LIGHTS COME ON. FREQUENT SLAMMING IF DOOR TO TRIGGER SENSOR DOES NOT WORK. UNABLE TO TURN LIGHTS OFF. PROHIBITS DOORS FROM LOCKING WHILE VEHICLE IS IN MOTION. SERIOUS SAFETY CONCERN. *TR
NHTSA ODI #10596938
19,000 miles · May 22, 2014
Structure
DOOR IS AJAR WARNING DOES NOT CLEAR EVEN AFTER REPEATED CLOSING OF DOORS. THIS CAUSES INTERIOR LIGHTS TO STAY ON AND DOORS NOT TO AUTOMATICALLY LOCK WHEN DRIVING. *TR
NHTSA ODI #10593460
75,000 miles · May 20, 2014
Electrical SystemStructure
DOOR AJAR STAYS ON AFTER DOOR CLOSED. *TR
NHTSA ODI #10592819
20,000 miles · May 20, 2014
Latches/locks/linkagesStructure
VEHICLE DOES NOT RECOGNIZE THAT THE DRIVER SIDE DOOR IS CLOSED. THE DOOR AJAR LIGHT STAYS ON, CAUSING THE INTERIOR LIGHT TO STAY ON, AND PREVENTING THE DOORS FROM LOCKING WHILE TRAVELING. THE DEALERSHIP SERVICE DEPARTMENT STATED THIS IS A COMMON PROBLEM THAT REQUIRES THE LATCH BE REPLACED. *TR
NHTSA ODI #10592681
46,000 miles · May 17, 2014
Electrical SystemExterior LightingStructure
FIRST DOOR AJAR WARNING WOULD COME ON,WHEN YOU CLOSED DOOR IT WOULD GO AWAY.NOW IT JUST STAY ON, THE LIGHTS SAY ON AND THE BELLS CHIMES. I SEE THEIRS A LOT OF COMPLAINTS ON THE INTERNET. PLEASE HELP!!! THIS IS NOT IN MY BUDGET!! THANKS *JS
NHTSA ODI #10592180
Mileage unknown · May 17, 2014
Structure
THE FRONT DOOR AJAR SENSOR OR LATCH HAS BEEN OFF AND ON NOT WORKING. THE LIGHT DOOR AJAR LIGHT COMES ON YOU HAVE TO EITHER SLAM THE DOOR OR OPEN AND SHUT IT OVER AND OVER AGAIN NOW TO GET THE DOOR AJAR LIGHT TO GO OFF AND THE INTERIOR LIGHTS TO SHUT OFF. WHILE THE DOOR AJAR IS ON THE DOORS WILL NOT LOCK WHILE DRIVING. THE OTH…
Read full complaint
THE FRONT DOOR AJAR SENSOR OR LATCH HAS BEEN OFF AND ON NOT WORKING. THE LIGHT DOOR AJAR LIGHT COMES ON YOU HAVE TO EITHER SLAM THE DOOR OR OPEN AND SHUT IT OVER AND OVER AGAIN NOW TO GET THE DOOR AJAR LIGHT TO GO OFF AND THE INTERIOR LIGHTS TO SHUT OFF. WHILE THE DOOR AJAR IS ON THE DOORS WILL NOT LOCK WHILE DRIVING. THE OTHER PROBLEM IS THE INTERIOR LIGHTS WILL NOT GO OFF AFTER PARKING THE CAR WHICH I AM AFRAID WILL END UP KILLING THE BATTERY. WHY HAS THERE NOT BEEN A RECALL ON THIS? THERE IS A DANGER WITH THE LOCKS NOT BEING ABLE TO LOCK AND THE RISK OF A BATTERY DYING. *JS
NHTSA ODI #10592140
Mileage unknown · May 16, 2014
Latches/locks/linkagesStructure
IT SEEMS THE DOOR LATCH IS DEFECTIVE AS MANY EDGE OWNERS HAVE HAD THIS ISSUE. THE "DOOR AJAR" LIGHT COMES ON & YOU HAVE TO OPEN & CLOSE THE DOOR TO RESOLVE IT. AFTER SEVERAL OCCURENCES, IT DOES NOT GO OFF BY SIMPLY OPENING & CLOSING THE DOOR. *TR
FORD IS RECALLING CERTAIN MODEL YEAR 2011 FORD F-150, F-250, F-350, F-450, F-550, EDGE, AND LINCOLN MKX TRUCKS MANUFACTURED FROM OCTOBER 25, 2010, THROUGH NOVEMBER 20, 2010. THESE VEHICLES WERE INSPECTED USING INTEGRATED DIAGNOSTIC SYSTEM (IDS) THAT HAD A CUSTOM SOFTWARE ROUTINE TO READ THE SUSPECT BODY CONTROL MODULE (BCM) SERIAL NUMBER. BASED ON THE SERIAL NUMBER THE BCM WAS EITHER NOT AFFECTED OR REPLACED. THE CUSTOM SOFTWARE ROUTINE WAS NOT READING THE CORRECT SET OF CHARACTERS, AND WAS NOT ABLE TO IDENTIFY A BCM THAT REQUIRED REPLACEMENT AFFECTED BCMS MAY HAVE THE POTENTIAL FOR AN INTERNAL SHORT.
Consequence & remedy
Consequence: IF AN ELECTRICAL SHORT DEVELOPS, AN OVERHEATING CONDITION MAY OCCUR WHICH COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALER WILL INSPECT THE BODY CONTROL MODULE AND IF NECESSARY REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 7, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-150, F-250, F-350, F-450, F-550, EDGE AND LINCOLN MKX VEHICLES. DURING A SIX-DAY PRODUCTION PERIOD, THE SUPPLIER OF THE BODY CONTROL MODULE MANUFACTURED MODULES THAT MAY HAVE THE POTENTIAL FOR AN INTERNAL SHORT.
Consequence & remedy
Consequence: IF AN ELECTRICAL SHORT DEVELOPS, AN OVERHEATING CONDITION MAY OCCUR WHICH CAN RESULT IN AN UNATTENDED VEHICLE FIRE.
Remedy: DEALER WILL REPLACE THE BODY CONTROL MODULE IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
FORD IS RECALLING CERTAIN MODEL YEAR 2011 EDGE AND LINCOLN MKX VEHICLES MANUFACTURED FROM JULY 1, 2010, THROUGH OCTOBER 8, 2010. THESE VEHICLES WERE SHIPPED WITH INCORRECTLY CONFIGURED ELECTRONIC MODULE SETTINGS THAT DISABLE THE LOCKING FUNCTION OF THE LIFTGATE. ACCORDINGLY, THE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE LIFTGATE LOCK MAY BE DISABLED AND THE DRIVER MAY NOT BE ABLE TO LOCK THE LIFTGATE USING INTERIOR LOCK SWITCHES OR REMOTE KEY FOB BUTTONS.
Remedy: FORD WILL NOTIFY OWNERS AND DEALERS WILL HAVE THE AFFECTED CONTROL MODULES UPDATED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 1, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Additional source detail variants (3)
Interior Lighting
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Latches/locks/linkages
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
2011 Ford Edge Problems, Complaints & Recalls | Skip That Year
Illustration